Complaints & Recalls
Official Safety Recalls - Important!
10 RecallsThese are official manufacturer recalls ordered by NHTSA for safety defects. If you own this vehicle, contact your dealer immediately for free repairs.
Prime-time Specialty Vehicles
Safety Issue:
Prime-Time Specialty Vehicles (Prime-Time) is recalling certain 2014-2019 Paratransit vehicles equipped with 3.6L engines. The transmission shifter cable may separate and disconnect from the transmission, causing the vehicle to not perform shifts intended by the driver and the gear shift lever position not matching the actual transmission gear.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Mfg Campaign: W00
Chrysler (fca Us Llc)
Safety Issue:
Chrysler (FCA US LLC) is recalling certain 2014-2019 Ram ProMaster vehicles equipped 3.6L engines. The transmission shifter cable may separate and disconnect from the transmission, causing the vehicle to not perform shifts intended by the driver and the gear shift lever position not matching the actual transmission gear.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Mfg Campaign: W00
Recall Date: Jan 23, 2020
Chrysler (fca Us Llc)
Safety Issue:
Chrysler (FCA US LLC) is recalling certain 2015-2018 Ram ProMaster vehicles equipped with 3.0L diesel or 3.6L gasoline engines and air conditioning (A/C). The engine cooling fan may seize which can cause the cooling fan motor to overheat.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Mfg Campaign: VB2
Recall Date: Nov 15, 2019
Unicell Body Company Inc.
Safety Issue:
Unicell Body Company Inc. (Unicell) is recalling certain 2017-2019 Chevrolet Express and GMC Savanna, 2018-2019 Hino 155, Ford Econoline and Transit and Isuzu NPR, and 2018 Ram ProMaster-based vehicles equipped with ASA Electronics Voyager monitors used to display the back-up camera image. The affected monitors may revert back to the factory default settings which may cause the camera image to be reversed.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Recall Date: Jun 11, 2019
New England Wheels
Safety Issue:
New England Wheels (New England) is recalling certain 2014-2018 Ford Transit and 2014-2019 Ram Promaster 2500 and 3500 vehicles modified to be equipped with Freedman Go-ES Foldaway seats. When the back seat cushion is rotated from the stowed position to the upright position, the seat cushion may not remain locked into place when under load, such as in a crash or a sudden stop.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Mfg Campaign: 18E-076
Recall Date: Apr 29, 2019
Mobility Transportation Services
Safety Issue:
Mobility Transportation Services (MobilityTrans) is recalling certain 2014-2018 Ford Transit and Ram Promaster vehicles and 2014-2015 Ford Econoline vehicles modified to be equipped with Freedman GO-ES Foldaway Seats, part numbers 43705, 45467, 48923, and 75719. When the back seat cushion is rotated from the stowed position to the upright position, the seat cushion may not remain locked into place when under load, such as in a crash or a sudden stop.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Recall Date: Apr 18, 2019
Prime-time Specialty Vehicles
Safety Issue:
Prime-Time Specialty Vehicles (Prime-Time) is recalling certain 2016-2018 Ram ProMaster and Ford Transit vehicles modified to be equipped with Freedman GO-ES Foldaway Seats. When the seat back cushion is rotated from the stowed position to the upright position, the seat cushion may not remain locked into place when under load, such as in a crash or a sudden stop.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Recall Date: Mar 1, 2019
Chrysler (fca Us Llc)
Safety Issue:
Chrysler (FCA US LLC) is recalling certain 2018 Jeep Renegade, Compass and Grand Cherokee, RAM 1500 and Promaster, Fiat 500x, Dodge Journey, Challenger, Charger and Durango and Chrysler 300x vehicles, 2017-2018 Jeep Wrangler, Dodge Grand Caravan and Chrysler Town and Country vehicles and 2018-2019 Jeep Cherokee and 2018 Chrysler Pacifica and Pacifica Hybrid vehicles. The powertrain control module may be equipped with a voltage regulator chip in the circuit board that may fail, causing a stall or a no start condition.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Mfg Campaign: U87
Recall Date: Aug 9, 2018
Chrysler (fca Us Llc)
Safety Issue:
Chrysler (FCA US LLC) is recalling certain 2018 Ram ProMaster vehicles. An incorrect rivet may have been used to attach the front door impact sensor which can cause the sensor housing to fracture.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Mfg Campaign: T64
Recall Date: Nov 14, 2017
Consumer Complaints
47 ComplaintsChrysler (fca Us, Llc)
Defect Description:
ENGINE
Potential Consequences:
Hello, my 2018 Ram Promaster is exhibiting the same symptoms as recall 44A: metal debris in the transmission, which could possibly impact the parking pawl I believe. I have experienced transmission issues for the past 12 months and the Ram dealer in Carson city has identified the same metal debris as seen in recall 44A for 2019-2021 vehicles. I respectfully request that the Office of Defects Investigation consider reviewing this complaint and evaluating whether the scope of the recall should be expanded to include my vehicle. Thank you for your attention to this matter. Please let me know if any additional information or documentation would be helpful.
Corrective Action:
Hello, my 2018 Ram Promaster is exhibiting the same symptoms as recall 44A: metal debris in the transmission, which could possibly impact the parking pawl I believe. I have experienced transmission issues for the past 12 months and the Ram dealer in Carson city has identified the same metal debris as seen in recall 44A for 2019-2021 vehicles. I respectfully request that the Office of Defects Investigation consider reviewing this complaint and evaluating whether the scope of the recall should be expanded to include my vehicle. Thank you for your attention to this matter. Please let me know if any additional information or documentation would be helpful.
Additional Notes:
Hello, my 2018 Ram Promaster is exhibiting the same symptoms as recall 44A: metal debris in the transmission, which could possibly impact the parking pawl I believe. I have experienced transmission issues for the past 12 months and the Ram dealer in Carson city has identified the same metal debris as seen in recall 44A for 2019-2021 vehicles. I respectfully request that the Office of Defects Investigation consider reviewing this complaint and evaluating whether the scope of the recall should be expanded to include my vehicle. Thank you for your attention to this matter. Please let me know if any additional information or documentation would be helpful.
Mfg Campaign: 11674560
Recall Date: Jul 18, 2025
Chrysler (fca Us, Llc)
Defect Description:
POWER TRAIN
Potential Consequences:
I was Driving down the highway at 45-50 mph when the truck suddenly the engine started to rev very high approximately 5000-5500 rpm and the truck lost all Drive gears. I immediately put it in neutral and tried again to put it in drive and nothing happened. I immediately pulled over to the shoulder and shut the truck off. I waited and restarted the truck but the truck did not have any movement in any gear. I had to get it Towed to a local shop.
Corrective Action:
I was Driving down the highway at 45-50 mph when the truck suddenly the engine started to rev very high approximately 5000-5500 rpm and the truck lost all Drive gears. I immediately put it in neutral and tried again to put it in drive and nothing happened. I immediately pulled over to the shoulder and shut the truck off. I waited and restarted the truck but the truck did not have any movement in any gear. I had to get it Towed to a local shop.
Additional Notes:
I was Driving down the highway at 45-50 mph when the truck suddenly the engine started to rev very high approximately 5000-5500 rpm and the truck lost all Drive gears. I immediately put it in neutral and tried again to put it in drive and nothing happened. I immediately pulled over to the shoulder and shut the truck off. I waited and restarted the truck but the truck did not have any movement in any gear. I had to get it Towed to a local shop.
Mfg Campaign: 11646886
Recall Date: Mar 6, 2025
Chrysler (fca Us, Llc)
Defect Description:
ELECTRICAL SYSTEM:IGNITION
Potential Consequences:
The contact owns a 2018 Ram Promaster 2500. The contact stated that while the vehicle was parked, it failed to start. The contact attempted to remove the key from the ignition; however, the key was stuck for several minutes before the contact was able to remove the key. No warning light was illuminated. The vehicle was towed to an independent mechanic where it was diagnosed that the ignition warning harness needed to be replaced. The vehicle was repaired. The contact researched and found an undisclosed NHTSA recall; however, the VIN was not included. The manufacturer was not notified of the failure. The failure mileage was approximately 96,500.
Corrective Action:
The contact owns a 2018 Ram Promaster 2500. The contact stated that while the vehicle was parked, it failed to start. The contact attempted to remove the key from the ignition; however, the key was stuck for several minutes before the contact was able to remove the key. No warning light was illuminated. The vehicle was towed to an independent mechanic where it was diagnosed that the ignition warning harness needed to be replaced. The vehicle was repaired. The contact researched and found an undisclosed NHTSA recall; however, the VIN was not included. The manufacturer was not notified of the failure. The failure mileage was approximately 96,500.
Additional Notes:
The contact owns a 2018 Ram Promaster 2500. The contact stated that while the vehicle was parked, it failed to start. The contact attempted to remove the key from the ignition; however, the key was stuck for several minutes before the contact was able to remove the key. No warning light was illuminated. The vehicle was towed to an independent mechanic where it was diagnosed that the ignition warning harness needed to be replaced. The vehicle was repaired. The contact researched and found an undisclosed NHTSA recall; however, the VIN was not included. The manufacturer was not notified of the failure. The failure mileage was approximately 96,500.
Mfg Campaign: 11622586
Recall Date: Oct 29, 2024
Chrysler (fca Us, Llc)
Defect Description:
ELECTRONIC STABILITY CONTROL (ESC)
Potential Consequences:
The contact owns a 2018 Ram Promaster 1500. The contact stated that while driving at an undisclosed speed, the service Hill Holder, Electronic Stability Control and check engine warning lights illuminated. The vehicle was taken to a local dealer where it was diagnosed with codes HAF, DTC, P0740, TCC clutch performance, and metal debris found in the transmission fluid. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 85,000.
Corrective Action:
The contact owns a 2018 Ram Promaster 1500. The contact stated that while driving at an undisclosed speed, the service Hill Holder, Electronic Stability Control and check engine warning lights illuminated. The vehicle was taken to a local dealer where it was diagnosed with codes HAF, DTC, P0740, TCC clutch performance, and metal debris found in the transmission fluid. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 85,000.
Additional Notes:
The contact owns a 2018 Ram Promaster 1500. The contact stated that while driving at an undisclosed speed, the service Hill Holder, Electronic Stability Control and check engine warning lights illuminated. The vehicle was taken to a local dealer where it was diagnosed with codes HAF, DTC, P0740, TCC clutch performance, and metal debris found in the transmission fluid. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 85,000.
Mfg Campaign: 11619797
Recall Date: Oct 15, 2024
Chrysler (fca Us, Llc)
Defect Description:
ENGINE
Potential Consequences:
The contact owns a 2018 Ram Promaster 1500. The contact stated that while driving at an undisclosed speed, the service Hill Holder, Electronic Stability Control and check engine warning lights illuminated. The vehicle was taken to a local dealer where it was diagnosed with codes HAF, DTC, P0740, TCC clutch performance, and metal debris found in the transmission fluid. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 85,000.
Corrective Action:
The contact owns a 2018 Ram Promaster 1500. The contact stated that while driving at an undisclosed speed, the service Hill Holder, Electronic Stability Control and check engine warning lights illuminated. The vehicle was taken to a local dealer where it was diagnosed with codes HAF, DTC, P0740, TCC clutch performance, and metal debris found in the transmission fluid. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 85,000.
Additional Notes:
The contact owns a 2018 Ram Promaster 1500. The contact stated that while driving at an undisclosed speed, the service Hill Holder, Electronic Stability Control and check engine warning lights illuminated. The vehicle was taken to a local dealer where it was diagnosed with codes HAF, DTC, P0740, TCC clutch performance, and metal debris found in the transmission fluid. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 85,000.
Mfg Campaign: 11619797
Recall Date: Oct 15, 2024
Chrysler (fca Us, Llc)
Defect Description:
POWER TRAIN:AUTOMATIC TRANSMISSION:FLUID/LUBRICANT
Potential Consequences:
The contact owns a 2018 Ram Promaster 1500. The contact stated that while driving at an undisclosed speed, the service Hill Holder, Electronic Stability Control and check engine warning lights illuminated. The vehicle was taken to a local dealer where it was diagnosed with codes HAF, DTC, P0740, TCC clutch performance, and metal debris found in the transmission fluid. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 85,000.
Corrective Action:
The contact owns a 2018 Ram Promaster 1500. The contact stated that while driving at an undisclosed speed, the service Hill Holder, Electronic Stability Control and check engine warning lights illuminated. The vehicle was taken to a local dealer where it was diagnosed with codes HAF, DTC, P0740, TCC clutch performance, and metal debris found in the transmission fluid. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 85,000.
Additional Notes:
The contact owns a 2018 Ram Promaster 1500. The contact stated that while driving at an undisclosed speed, the service Hill Holder, Electronic Stability Control and check engine warning lights illuminated. The vehicle was taken to a local dealer where it was diagnosed with codes HAF, DTC, P0740, TCC clutch performance, and metal debris found in the transmission fluid. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 85,000.
Mfg Campaign: 11619797
Recall Date: Oct 15, 2024
Chrysler (fca Us, Llc)
Defect Description:
POWER TRAIN
Potential Consequences:
THE VEHICLE SHIFTS OUT OF PARK ON ITS OWN , IT HAS ROLLED DOWN MY DRIVE AND HIT MY MERCEDES. THIS HAS HAPPENED SEVERAL TIMES, THE STEVENS CREEK RAM DODGE DEALER IN SAN JOSE TOLD ME , THERE IS A RECALL ON THE COMPUTER CAUSING THE MALFUNTION FOR VEHICLES MFG FROM JULY 2018 TO 2022 , BUT ACCORDING TO MY VIN ITS NOT A RECALL, ONLY THE SHIFT CABLE , VIN [XXX] . HOWEVER MY DATE OF MFG IS JULY 2018 , AND SHOULD TO FALL IN THE RECALL EVENT 44A YES STEVENS CREEK DODGE CHECKED IT , THEY WILL ONLY REPALCE SHIFT CABLE NO WARNING LAMPS COME ON, BUT THE CHECK ENGINE LIGHTS STAYS ON INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Corrective Action:
THE VEHICLE SHIFTS OUT OF PARK ON ITS OWN , IT HAS ROLLED DOWN MY DRIVE AND HIT MY MERCEDES. THIS HAS HAPPENED SEVERAL TIMES, THE STEVENS CREEK RAM DODGE DEALER IN SAN JOSE TOLD ME , THERE IS A RECALL ON THE COMPUTER CAUSING THE MALFUNTION FOR VEHICLES MFG FROM JULY 2018 TO 2022 , BUT ACCORDING TO MY VIN ITS NOT A RECALL, ONLY THE SHIFT CABLE , VIN [XXX] . HOWEVER MY DATE OF MFG IS JULY 2018 , AND SHOULD TO FALL IN THE RECALL EVENT 44A YES STEVENS CREEK DODGE CHECKED IT , THEY WILL ONLY REPALCE SHIFT CABLE NO WARNING LAMPS COME ON, BUT THE CHECK ENGINE LIGHTS STAYS ON INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Additional Notes:
THE VEHICLE SHIFTS OUT OF PARK ON ITS OWN , IT HAS ROLLED DOWN MY DRIVE AND HIT MY MERCEDES. THIS HAS HAPPENED SEVERAL TIMES, THE STEVENS CREEK RAM DODGE DEALER IN SAN JOSE TOLD ME , THERE IS A RECALL ON THE COMPUTER CAUSING THE MALFUNTION FOR VEHICLES MFG FROM JULY 2018 TO 2022 , BUT ACCORDING TO MY VIN ITS NOT A RECALL, ONLY THE SHIFT CABLE , VIN [XXX] . HOWEVER MY DATE OF MFG IS JULY 2018 , AND SHOULD TO FALL IN THE RECALL EVENT 44A YES STEVENS CREEK DODGE CHECKED IT , THEY WILL ONLY REPALCE SHIFT CABLE NO WARNING LAMPS COME ON, BUT THE CHECK ENGINE LIGHTS STAYS ON INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Mfg Campaign: 11618300
Recall Date: Oct 6, 2024
Chrysler (fca Us, Llc)
Defect Description:
ENGINE
Potential Consequences:
Vehicle is experiencing misfires code P0300 and P0302. Performed the usual repairs listed: 1. Coil pack, 2. Spark Plug, 3. Injector. Inspected cam, rocker arms and lifters. All checked good. Codes still remain. After further inspection, the exhaust valve is cracked/broken on #2 cylinder. This appears to be an issue as many others are experiencing the same problem. This vehicle only has 86k miles, oil changed at scheduled intervals.
Corrective Action:
Vehicle is experiencing misfires code P0300 and P0302. Performed the usual repairs listed: 1. Coil pack, 2. Spark Plug, 3. Injector. Inspected cam, rocker arms and lifters. All checked good. Codes still remain. After further inspection, the exhaust valve is cracked/broken on #2 cylinder. This appears to be an issue as many others are experiencing the same problem. This vehicle only has 86k miles, oil changed at scheduled intervals.
Additional Notes:
Vehicle is experiencing misfires code P0300 and P0302. Performed the usual repairs listed: 1. Coil pack, 2. Spark Plug, 3. Injector. Inspected cam, rocker arms and lifters. All checked good. Codes still remain. After further inspection, the exhaust valve is cracked/broken on #2 cylinder. This appears to be an issue as many others are experiencing the same problem. This vehicle only has 86k miles, oil changed at scheduled intervals.
Mfg Campaign: 11577778
Recall Date: Mar 16, 2024
Chrysler (fca Us, Llc)
Defect Description:
UNKNOWN OR OTHER
Potential Consequences:
Service lights for ABS, HILL ASSIST, and ESC on frequently emergency brake and ABS failed locking left rear wheel causing tire to explode. repair parts are not readily available van is currently undriveable.
Corrective Action:
Service lights for ABS, HILL ASSIST, and ESC on frequently emergency brake and ABS failed locking left rear wheel causing tire to explode. repair parts are not readily available van is currently undriveable.
Additional Notes:
Service lights for ABS, HILL ASSIST, and ESC on frequently emergency brake and ABS failed locking left rear wheel causing tire to explode. repair parts are not readily available van is currently undriveable.
Mfg Campaign: 11549515
Recall Date: Oct 11, 2023
Chrysler (fca Us, Llc)
Defect Description:
ELECTRICAL SYSTEM
Potential Consequences:
As of approximately around the 15th of April 2023, we realized suddenly that our lithium battery in our 2019 Winnebago Travato was not being replaced with charging from our Volta alternator from driving or from our solar as it has always done. The KISAE DC to DC charger and the Volta system show an error message that they were/are ‘overheated’. Testing of the DC to DC charger shows that it’s receiving far over the correct voltage. Upon diagnostics at a RV dealership they found the alternator is being overcharged. The alternator must be replaced before it can be determined why the alternator is overcharging (since obviously safeguards are meant to be in place to prevent this). We discovered through online research of the NHTSA Recall ID Number 21V793 on Boldt 2021-22 and Travato 2019-22 with Volta Power Systems; Manufacturer; Winnebago Industries, Inc. Subject; Wire Harness Built Incorrectly; loss of over-current protection can cause the wires to overheat, increasing the risk of a fire. There was also another subsequent recall for Winnebago Travato 2021, Winnebago Boldt 2021, and Storyteller Overland Vans 2021 of the seemingly same exact issue again, “In the case that power connections are not properly seated severe voltage spike by intermittent connections could damage the filtering diode in the the alternator control harness (10001447) resulting in the possibility of a shorted wire, on the same circuit the order of the fuse and diode were reversed. In the case that the diode is broken in a closed condition, the sense wire could be shorted to ground resulting in an overheated wire or broken wire. The identified cause of the diode failure was excessive overvoltage spikes. When the diode failed, it failed closed and with the diode and fuse being reversed the wire continued to heat up instead of breaking the fuse. With evidence from our van I believe in a strong probability the scope of the recall should be widened to include more units, such as ours. We are proof
Corrective Action:
As of approximately around the 15th of April 2023, we realized suddenly that our lithium battery in our 2019 Winnebago Travato was not being replaced with charging from our Volta alternator from driving or from our solar as it has always done. The KISAE DC to DC charger and the Volta system show an error message that they were/are ‘overheated’. Testing of the DC to DC charger shows that it’s receiving far over the correct voltage. Upon diagnostics at a RV dealership they found the alternator is being overcharged. The alternator must be replaced before it can be determined why the alternator is overcharging (since obviously safeguards are meant to be in place to prevent this). We discovered through online research of the NHTSA Recall ID Number 21V793 on Boldt 2021-22 and Travato 2019-22 with Volta Power Systems; Manufacturer; Winnebago Industries, Inc. Subject; Wire Harness Built Incorrectly; loss of over-current protection can cause the wires to overheat, increasing the risk of a fire. There was also another subsequent recall for Winnebago Travato 2021, Winnebago Boldt 2021, and Storyteller Overland Vans 2021 of the seemingly same exact issue again, “In the case that power connections are not properly seated severe voltage spike by intermittent connections could damage the filtering diode in the the alternator control harness (10001447) resulting in the possibility of a shorted wire, on the same circuit the order of the fuse and diode were reversed. In the case that the diode is broken in a closed condition, the sense wire could be shorted to ground resulting in an overheated wire or broken wire. The identified cause of the diode failure was excessive overvoltage spikes. When the diode failed, it failed closed and with the diode and fuse being reversed the wire continued to heat up instead of breaking the fuse. With evidence from our van I believe in a strong probability the scope of the recall should be widened to include more units, such as ours. We are proof
Additional Notes:
As of approximately around the 15th of April 2023, we realized suddenly that our lithium battery in our 2019 Winnebago Travato was not being replaced with charging from our Volta alternator from driving or from our solar as it has always done. The KISAE DC to DC charger and the Volta system show an error message that they were/are ‘overheated’. Testing of the DC to DC charger shows that it’s receiving far over the correct voltage. Upon diagnostics at a RV dealership they found the alternator is being overcharged. The alternator must be replaced before it can be determined why the alternator is overcharging (since obviously safeguards are meant to be in place to prevent this). We discovered through online research of the NHTSA Recall ID Number 21V793 on Boldt 2021-22 and Travato 2019-22 with Volta Power Systems; Manufacturer; Winnebago Industries, Inc. Subject; Wire Harness Built Incorrectly; loss of over-current protection can cause the wires to overheat, increasing the risk of a fire. There was also another subsequent recall for Winnebago Travato 2021, Winnebago Boldt 2021, and Storyteller Overland Vans 2021 of the seemingly same exact issue again, “In the case that power connections are not properly seated severe voltage spike by intermittent connections could damage the filtering diode in the the alternator control harness (10001447) resulting in the possibility of a shorted wire, on the same circuit the order of the fuse and diode were reversed. In the case that the diode is broken in a closed condition, the sense wire could be shorted to ground resulting in an overheated wire or broken wire. The identified cause of the diode failure was excessive overvoltage spikes. When the diode failed, it failed closed and with the diode and fuse being reversed the wire continued to heat up instead of breaking the fuse. With evidence from our van I believe in a strong probability the scope of the recall should be widened to include more units, such as ours. We are proof
Mfg Campaign: 11520227
Recall Date: May 3, 2023
Chrysler (fca Us, Llc)
Defect Description:
UNKNOWN OR OTHER
Potential Consequences:
As of approximately around the 15th of April 2023, we realized suddenly that our lithium battery in our 2019 Winnebago Travato was not being replaced with charging from our Volta alternator from driving or from our solar as it has always done. The KISAE DC to DC charger and the Volta system show an error message that they were/are ‘overheated’. Testing of the DC to DC charger shows that it’s receiving far over the correct voltage. Upon diagnostics at a RV dealership they found the alternator is being overcharged. The alternator must be replaced before it can be determined why the alternator is overcharging (since obviously safeguards are meant to be in place to prevent this). We discovered through online research of the NHTSA Recall ID Number 21V793 on Boldt 2021-22 and Travato 2019-22 with Volta Power Systems; Manufacturer; Winnebago Industries, Inc. Subject; Wire Harness Built Incorrectly; loss of over-current protection can cause the wires to overheat, increasing the risk of a fire. There was also another subsequent recall for Winnebago Travato 2021, Winnebago Boldt 2021, and Storyteller Overland Vans 2021 of the seemingly same exact issue again, “In the case that power connections are not properly seated severe voltage spike by intermittent connections could damage the filtering diode in the the alternator control harness (10001447) resulting in the possibility of a shorted wire, on the same circuit the order of the fuse and diode were reversed. In the case that the diode is broken in a closed condition, the sense wire could be shorted to ground resulting in an overheated wire or broken wire. The identified cause of the diode failure was excessive overvoltage spikes. When the diode failed, it failed closed and with the diode and fuse being reversed the wire continued to heat up instead of breaking the fuse. With evidence from our van I believe in a strong probability the scope of the recall should be widened to include more units, such as ours. We are proof
Corrective Action:
As of approximately around the 15th of April 2023, we realized suddenly that our lithium battery in our 2019 Winnebago Travato was not being replaced with charging from our Volta alternator from driving or from our solar as it has always done. The KISAE DC to DC charger and the Volta system show an error message that they were/are ‘overheated’. Testing of the DC to DC charger shows that it’s receiving far over the correct voltage. Upon diagnostics at a RV dealership they found the alternator is being overcharged. The alternator must be replaced before it can be determined why the alternator is overcharging (since obviously safeguards are meant to be in place to prevent this). We discovered through online research of the NHTSA Recall ID Number 21V793 on Boldt 2021-22 and Travato 2019-22 with Volta Power Systems; Manufacturer; Winnebago Industries, Inc. Subject; Wire Harness Built Incorrectly; loss of over-current protection can cause the wires to overheat, increasing the risk of a fire. There was also another subsequent recall for Winnebago Travato 2021, Winnebago Boldt 2021, and Storyteller Overland Vans 2021 of the seemingly same exact issue again, “In the case that power connections are not properly seated severe voltage spike by intermittent connections could damage the filtering diode in the the alternator control harness (10001447) resulting in the possibility of a shorted wire, on the same circuit the order of the fuse and diode were reversed. In the case that the diode is broken in a closed condition, the sense wire could be shorted to ground resulting in an overheated wire or broken wire. The identified cause of the diode failure was excessive overvoltage spikes. When the diode failed, it failed closed and with the diode and fuse being reversed the wire continued to heat up instead of breaking the fuse. With evidence from our van I believe in a strong probability the scope of the recall should be widened to include more units, such as ours. We are proof
Additional Notes:
As of approximately around the 15th of April 2023, we realized suddenly that our lithium battery in our 2019 Winnebago Travato was not being replaced with charging from our Volta alternator from driving or from our solar as it has always done. The KISAE DC to DC charger and the Volta system show an error message that they were/are ‘overheated’. Testing of the DC to DC charger shows that it’s receiving far over the correct voltage. Upon diagnostics at a RV dealership they found the alternator is being overcharged. The alternator must be replaced before it can be determined why the alternator is overcharging (since obviously safeguards are meant to be in place to prevent this). We discovered through online research of the NHTSA Recall ID Number 21V793 on Boldt 2021-22 and Travato 2019-22 with Volta Power Systems; Manufacturer; Winnebago Industries, Inc. Subject; Wire Harness Built Incorrectly; loss of over-current protection can cause the wires to overheat, increasing the risk of a fire. There was also another subsequent recall for Winnebago Travato 2021, Winnebago Boldt 2021, and Storyteller Overland Vans 2021 of the seemingly same exact issue again, “In the case that power connections are not properly seated severe voltage spike by intermittent connections could damage the filtering diode in the the alternator control harness (10001447) resulting in the possibility of a shorted wire, on the same circuit the order of the fuse and diode were reversed. In the case that the diode is broken in a closed condition, the sense wire could be shorted to ground resulting in an overheated wire or broken wire. The identified cause of the diode failure was excessive overvoltage spikes. When the diode failed, it failed closed and with the diode and fuse being reversed the wire continued to heat up instead of breaking the fuse. With evidence from our van I believe in a strong probability the scope of the recall should be widened to include more units, such as ours. We are proof
Mfg Campaign: 11520227
Recall Date: May 3, 2023
Chrysler (fca Us, Llc)
Defect Description:
VISIBILITY/WIPER
Potential Consequences:
Driver's side exterior mirror design flaw/failure. Safety of self and others at risk due to lack of visibility in checking for clear rear and lateral traffic. Mirror shakes uncontrollably and or is unable to be adjusted for proper viewing of rear and lateral traffic. Many warranty claims have been submitted through dealerships as well as various online complaints having been issued. No in-dash warning lamps or messages would appear for this type issue. This issue appears to be affecting driver's side mirror only and not passenger side. Symptoms of driver's side mirror failure do exist in various stages prior to overall failure. Considerable mirror shake and inability to keep mirror adjusted due to such shake. Problem has been ongoing with some reports having detailed up to 3 changes of driver's side mirrors by dealership for single vehicle.
Corrective Action:
Driver's side exterior mirror design flaw/failure. Safety of self and others at risk due to lack of visibility in checking for clear rear and lateral traffic. Mirror shakes uncontrollably and or is unable to be adjusted for proper viewing of rear and lateral traffic. Many warranty claims have been submitted through dealerships as well as various online complaints having been issued. No in-dash warning lamps or messages would appear for this type issue. This issue appears to be affecting driver's side mirror only and not passenger side. Symptoms of driver's side mirror failure do exist in various stages prior to overall failure. Considerable mirror shake and inability to keep mirror adjusted due to such shake. Problem has been ongoing with some reports having detailed up to 3 changes of driver's side mirrors by dealership for single vehicle.
Additional Notes:
Driver's side exterior mirror design flaw/failure. Safety of self and others at risk due to lack of visibility in checking for clear rear and lateral traffic. Mirror shakes uncontrollably and or is unable to be adjusted for proper viewing of rear and lateral traffic. Many warranty claims have been submitted through dealerships as well as various online complaints having been issued. No in-dash warning lamps or messages would appear for this type issue. This issue appears to be affecting driver's side mirror only and not passenger side. Symptoms of driver's side mirror failure do exist in various stages prior to overall failure. Considerable mirror shake and inability to keep mirror adjusted due to such shake. Problem has been ongoing with some reports having detailed up to 3 changes of driver's side mirrors by dealership for single vehicle.
Mfg Campaign: 11504828
Recall Date: Jan 31, 2023
Chrysler (fca Us, Llc)
Defect Description:
TIRES
Potential Consequences:
LT225/75R16 We started experiencing very noticeable vibrations when driving at highway speeds. We brought the van to our dealer for service and they responded "Please replace at least both rear tires. Right rear seems to have ruptured internally?" "Please replace that right rear tire asap." We had the tire removed and you can see the attached photo of the inside of the tire where something has obviously failed. These tires only had about 17,000 miles of use. I still have the bad tire.
Corrective Action:
LT225/75R16 We started experiencing very noticeable vibrations when driving at highway speeds. We brought the van to our dealer for service and they responded "Please replace at least both rear tires. Right rear seems to have ruptured internally?" "Please replace that right rear tire asap." We had the tire removed and you can see the attached photo of the inside of the tire where something has obviously failed. These tires only had about 17,000 miles of use. I still have the bad tire.
Additional Notes:
LT225/75R16 We started experiencing very noticeable vibrations when driving at highway speeds. We brought the van to our dealer for service and they responded "Please replace at least both rear tires. Right rear seems to have ruptured internally?" "Please replace that right rear tire asap." We had the tire removed and you can see the attached photo of the inside of the tire where something has obviously failed. These tires only had about 17,000 miles of use. I still have the bad tire.
Mfg Campaign: 11501895
Recall Date: Jan 15, 2023
Chrysler (fca Us, Llc)
Defect Description:
STEERING
Potential Consequences:
-Vehicle shut off on highway, lost power steering Vehicle fan sounds like it's running full speed after turning off engine. Turning key off and pulling out did not shut off engine. Engine appeared to be overheating. Electric system was making lots of clicks and odd noises. Power steering pump went out in intersection. Police helped push van out of traffic.
Corrective Action:
-Vehicle shut off on highway, lost power steering Vehicle fan sounds like it's running full speed after turning off engine. Turning key off and pulling out did not shut off engine. Engine appeared to be overheating. Electric system was making lots of clicks and odd noises. Power steering pump went out in intersection. Police helped push van out of traffic.
Additional Notes:
-Vehicle shut off on highway, lost power steering Vehicle fan sounds like it's running full speed after turning off engine. Turning key off and pulling out did not shut off engine. Engine appeared to be overheating. Electric system was making lots of clicks and odd noises. Power steering pump went out in intersection. Police helped push van out of traffic.
Mfg Campaign: 11499602
Recall Date: Dec 30, 2022
Chrysler (fca Us, Llc)
Defect Description:
ELECTRICAL SYSTEM
Potential Consequences:
-Vehicle shut off on highway, lost power steering Vehicle fan sounds like it's running full speed after turning off engine. Turning key off and pulling out did not shut off engine. Engine appeared to be overheating. Electric system was making lots of clicks and odd noises. Power steering pump went out in intersection. Police helped push van out of traffic.
Corrective Action:
-Vehicle shut off on highway, lost power steering Vehicle fan sounds like it's running full speed after turning off engine. Turning key off and pulling out did not shut off engine. Engine appeared to be overheating. Electric system was making lots of clicks and odd noises. Power steering pump went out in intersection. Police helped push van out of traffic.
Additional Notes:
-Vehicle shut off on highway, lost power steering Vehicle fan sounds like it's running full speed after turning off engine. Turning key off and pulling out did not shut off engine. Engine appeared to be overheating. Electric system was making lots of clicks and odd noises. Power steering pump went out in intersection. Police helped push van out of traffic.
Mfg Campaign: 11499602
Recall Date: Dec 30, 2022
Chrysler (fca Us, Llc)
Defect Description:
ENGINE
Potential Consequences:
-Vehicle shut off on highway, lost power steering Vehicle fan sounds like it's running full speed after turning off engine. Turning key off and pulling out did not shut off engine. Engine appeared to be overheating. Electric system was making lots of clicks and odd noises. Power steering pump went out in intersection. Police helped push van out of traffic.
Corrective Action:
-Vehicle shut off on highway, lost power steering Vehicle fan sounds like it's running full speed after turning off engine. Turning key off and pulling out did not shut off engine. Engine appeared to be overheating. Electric system was making lots of clicks and odd noises. Power steering pump went out in intersection. Police helped push van out of traffic.
Additional Notes:
-Vehicle shut off on highway, lost power steering Vehicle fan sounds like it's running full speed after turning off engine. Turning key off and pulling out did not shut off engine. Engine appeared to be overheating. Electric system was making lots of clicks and odd noises. Power steering pump went out in intersection. Police helped push van out of traffic.
Mfg Campaign: 11499602
Recall Date: Dec 30, 2022
Chrysler (fca Us, Llc)
Defect Description:
SERVICE BRAKES
Potential Consequences:
During some cases of downhill driving, the Brake system warning light will come on. I believe this issue is tied to a combination of longer and steeper downhill drives when the angle indicated in road side sinage is no less than 6%. Minimal braking ton control the decent is used. Each time this occurs, I take the nearest off ramp to pull over to a stop and turn off the engine. My visual and hand-test of each wheel/tire temperature finds in my opinion, the temps to be quite nominal. On the last trip, a digital laser thermometer also indicated a good balance across the four wheels/tires, with no issues to be concerned with. Under the hood, the Master cylinder, ABS controller, Power Brake unit, brake fluid vessel and brake lines were all cool to the touch. Brake fluid in the vessel is clear and full. Each time the engine is restarted, the warning light is off and the drive can be continued with no further incident unless a similar long and relatively steep downhill is encountered. Time of day and outside temperature seem to not matter. Safety is compromised when I cannot trust that the warning light is, or is not indicating a real problem Reference RAM PROMASTER 3500, VIN [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
Corrective Action:
During some cases of downhill driving, the Brake system warning light will come on. I believe this issue is tied to a combination of longer and steeper downhill drives when the angle indicated in road side sinage is no less than 6%. Minimal braking ton control the decent is used. Each time this occurs, I take the nearest off ramp to pull over to a stop and turn off the engine. My visual and hand-test of each wheel/tire temperature finds in my opinion, the temps to be quite nominal. On the last trip, a digital laser thermometer also indicated a good balance across the four wheels/tires, with no issues to be concerned with. Under the hood, the Master cylinder, ABS controller, Power Brake unit, brake fluid vessel and brake lines were all cool to the touch. Brake fluid in the vessel is clear and full. Each time the engine is restarted, the warning light is off and the drive can be continued with no further incident unless a similar long and relatively steep downhill is encountered. Time of day and outside temperature seem to not matter. Safety is compromised when I cannot trust that the warning light is, or is not indicating a real problem Reference RAM PROMASTER 3500, VIN [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
Additional Notes:
During some cases of downhill driving, the Brake system warning light will come on. I believe this issue is tied to a combination of longer and steeper downhill drives when the angle indicated in road side sinage is no less than 6%. Minimal braking ton control the decent is used. Each time this occurs, I take the nearest off ramp to pull over to a stop and turn off the engine. My visual and hand-test of each wheel/tire temperature finds in my opinion, the temps to be quite nominal. On the last trip, a digital laser thermometer also indicated a good balance across the four wheels/tires, with no issues to be concerned with. Under the hood, the Master cylinder, ABS controller, Power Brake unit, brake fluid vessel and brake lines were all cool to the touch. Brake fluid in the vessel is clear and full. Each time the engine is restarted, the warning light is off and the drive can be continued with no further incident unless a similar long and relatively steep downhill is encountered. Time of day and outside temperature seem to not matter. Safety is compromised when I cannot trust that the warning light is, or is not indicating a real problem Reference RAM PROMASTER 3500, VIN [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
Mfg Campaign: 11483809
Recall Date: Sep 10, 2022
Chrysler (fca Us, Llc)
Defect Description:
ELECTRICAL SYSTEM
Potential Consequences:
Vehicle Electronic throttle control had a malfunction and system went into limp mode on a highway at highway speeds of 70mph. The engine destroyed itself instead of limping. Lost power and almost got hit by a semi truck and other vehicles when this happened. Ended up getting a used engine due to current remanufacture costs etc. Total cost out of pocket because the dealership lied about my warranty and what was covered and for how long was around $7,000 parts lanor etc. Limp mode is dangerous and the way it happened on a highway could have gotten me or others seriously hurt or killed. Also now there is an electrical error code P0482 which is electronic coller fan issue other rams are having. All vehices in this series that have the recalled fan should be included the 2018 has issues but no recalls but has the same components of other recalls.. doesn't make sense.
Corrective Action:
Vehicle Electronic throttle control had a malfunction and system went into limp mode on a highway at highway speeds of 70mph. The engine destroyed itself instead of limping. Lost power and almost got hit by a semi truck and other vehicles when this happened. Ended up getting a used engine due to current remanufacture costs etc. Total cost out of pocket because the dealership lied about my warranty and what was covered and for how long was around $7,000 parts lanor etc. Limp mode is dangerous and the way it happened on a highway could have gotten me or others seriously hurt or killed. Also now there is an electrical error code P0482 which is electronic coller fan issue other rams are having. All vehices in this series that have the recalled fan should be included the 2018 has issues but no recalls but has the same components of other recalls.. doesn't make sense.
Additional Notes:
Vehicle Electronic throttle control had a malfunction and system went into limp mode on a highway at highway speeds of 70mph. The engine destroyed itself instead of limping. Lost power and almost got hit by a semi truck and other vehicles when this happened. Ended up getting a used engine due to current remanufacture costs etc. Total cost out of pocket because the dealership lied about my warranty and what was covered and for how long was around $7,000 parts lanor etc. Limp mode is dangerous and the way it happened on a highway could have gotten me or others seriously hurt or killed. Also now there is an electrical error code P0482 which is electronic coller fan issue other rams are having. All vehices in this series that have the recalled fan should be included the 2018 has issues but no recalls but has the same components of other recalls.. doesn't make sense.
Mfg Campaign: 11460771
Recall Date: Apr 14, 2022
Chrysler (fca Us, Llc)
Defect Description:
ENGINE
Potential Consequences:
Vehicle Electronic throttle control had a malfunction and system went into limp mode on a highway at highway speeds of 70mph. The engine destroyed itself instead of limping. Lost power and almost got hit by a semi truck and other vehicles when this happened. Ended up getting a used engine due to current remanufacture costs etc. Total cost out of pocket because the dealership lied about my warranty and what was covered and for how long was around $7,000 parts lanor etc. Limp mode is dangerous and the way it happened on a highway could have gotten me or others seriously hurt or killed. Also now there is an electrical error code P0482 which is electronic coller fan issue other rams are having. All vehices in this series that have the recalled fan should be included the 2018 has issues but no recalls but has the same components of other recalls.. doesn't make sense.
Corrective Action:
Vehicle Electronic throttle control had a malfunction and system went into limp mode on a highway at highway speeds of 70mph. The engine destroyed itself instead of limping. Lost power and almost got hit by a semi truck and other vehicles when this happened. Ended up getting a used engine due to current remanufacture costs etc. Total cost out of pocket because the dealership lied about my warranty and what was covered and for how long was around $7,000 parts lanor etc. Limp mode is dangerous and the way it happened on a highway could have gotten me or others seriously hurt or killed. Also now there is an electrical error code P0482 which is electronic coller fan issue other rams are having. All vehices in this series that have the recalled fan should be included the 2018 has issues but no recalls but has the same components of other recalls.. doesn't make sense.
Additional Notes:
Vehicle Electronic throttle control had a malfunction and system went into limp mode on a highway at highway speeds of 70mph. The engine destroyed itself instead of limping. Lost power and almost got hit by a semi truck and other vehicles when this happened. Ended up getting a used engine due to current remanufacture costs etc. Total cost out of pocket because the dealership lied about my warranty and what was covered and for how long was around $7,000 parts lanor etc. Limp mode is dangerous and the way it happened on a highway could have gotten me or others seriously hurt or killed. Also now there is an electrical error code P0482 which is electronic coller fan issue other rams are having. All vehices in this series that have the recalled fan should be included the 2018 has issues but no recalls but has the same components of other recalls.. doesn't make sense.
Mfg Campaign: 11460771
Recall Date: Apr 14, 2022
Chrysler (fca Us, Llc)
Defect Description:
UNKNOWN OR OTHER
Potential Consequences:
Vehicle Electronic throttle control had a malfunction and system went into limp mode on a highway at highway speeds of 70mph. The engine destroyed itself instead of limping. Lost power and almost got hit by a semi truck and other vehicles when this happened. Ended up getting a used engine due to current remanufacture costs etc. Total cost out of pocket because the dealership lied about my warranty and what was covered and for how long was around $7,000 parts lanor etc. Limp mode is dangerous and the way it happened on a highway could have gotten me or others seriously hurt or killed. Also now there is an electrical error code P0482 which is electronic coller fan issue other rams are having. All vehices in this series that have the recalled fan should be included the 2018 has issues but no recalls but has the same components of other recalls.. doesn't make sense.
Corrective Action:
Vehicle Electronic throttle control had a malfunction and system went into limp mode on a highway at highway speeds of 70mph. The engine destroyed itself instead of limping. Lost power and almost got hit by a semi truck and other vehicles when this happened. Ended up getting a used engine due to current remanufacture costs etc. Total cost out of pocket because the dealership lied about my warranty and what was covered and for how long was around $7,000 parts lanor etc. Limp mode is dangerous and the way it happened on a highway could have gotten me or others seriously hurt or killed. Also now there is an electrical error code P0482 which is electronic coller fan issue other rams are having. All vehices in this series that have the recalled fan should be included the 2018 has issues but no recalls but has the same components of other recalls.. doesn't make sense.
Additional Notes:
Vehicle Electronic throttle control had a malfunction and system went into limp mode on a highway at highway speeds of 70mph. The engine destroyed itself instead of limping. Lost power and almost got hit by a semi truck and other vehicles when this happened. Ended up getting a used engine due to current remanufacture costs etc. Total cost out of pocket because the dealership lied about my warranty and what was covered and for how long was around $7,000 parts lanor etc. Limp mode is dangerous and the way it happened on a highway could have gotten me or others seriously hurt or killed. Also now there is an electrical error code P0482 which is electronic coller fan issue other rams are having. All vehices in this series that have the recalled fan should be included the 2018 has issues but no recalls but has the same components of other recalls.. doesn't make sense.
Mfg Campaign: 11460771
Recall Date: Apr 14, 2022
Need Legal Help?
Featured Attorneys
Barry Edzant
Edzant Price LLC
Valencia, CA • 36 yrs
Focus: Lemon Law, Personal Injury