Complaints & Recalls
Official Safety Recalls - Important!
12 RecallsThese are official manufacturer recalls ordered by NHTSA for safety defects. If you own this vehicle, contact your dealer immediately for free repairs.
Kia America, Inc.
Safety Issue:
Kia America, Inc. (Kia) is recalling certain 2016-2022 Sorento, 2021-2022 Sorento Hybrid (HEV), 2022-2023 Sorento Plug-In Hybrid (PHEV), and 2017-2022 Sportage vehicles equipped with a tow hitch harness installed as original equipment, or purchased as an accessory through a Kia dealership. Debris and moisture accumulation on the tow hitch harness module printed circuit board (PCB) may cause an electrical short, which can result in a fire.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Mfg Campaign: SC249
Recall Date: Sep 19, 2022
Kia Motors America
Safety Issue:
Kia Motors America (Kia) is recalling certain 2011-2017 Optima, 2012-2017 Sorento and 2011-2018 Sportage vehicles that previously received an engine replacement under recall number 17V-224, warranty, or the Knock Sensor Detection System (KSDS) Product Improvement Campaign. The high pressure fuel pipe that connects to the fuel pump outlet may have been damaged, misaligned or improperly torqued during the engine replacement procedure, possibly causing a fuel leak.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Mfg Campaign: SC172
Recall Date: Dec 19, 2018
Kia Motors America
Safety Issue:
Kia Motors America (Kia) is recalling certain 2017 Sorento vehicles equipped with 3.3L engines. The engine crankshaft may have been improperly heat treated and may fail.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Mfg Campaign: SC153
Recall Date: Sep 21, 2017
Kia Motors America
Safety Issue:
Kia Motors America (Kia) is recalling certain model year 2016-2017 Sorento vehicles manufactured October 27, 2014, to August 25, 2016, and 2017 Sportage vehicles manufactured December 10, 2015, to August 26, 2016. The affected vehicles are equipped with an accessory trailer hitch wiring harness that, due to a malfunction of the tow hitch module, may result in the trailer brake lights being constantly illuminated. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, " Lamps, Reflective Devices, and Associated Equipment."
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Mfg Campaign: SC142
Recall Date: Nov 30, 2016
Consumer Complaints
894 ComplaintsKia America, Inc.
Defect Description:
UNKNOWN OR OTHER
Potential Consequences:
Driving on the highway at 65mph uphill, engine started making horrible noise and started to fail. Pulled over on shoulder and had to have it towed. Kia is denying warranty because I cannot provide service records. Whether or not they will right this wrong it is a major safety issue when you have complete engine failure with no warning. The engine in my vehicle (3.3 v6 Lambda)completely failed without tripping any warning devices that are equipped on the vehicle. There is a Defect that causes the engine to burn too much oil and there is a defect where the vehicle fails to warn of potential safety issues. There was total engine failure with no warnings. No Service Message No Check Engine Light No Low Oil Pressure Light No Knock Sensor Code No Limp Mode activation. In the service technician's report it even says "no codes set in the ecm" This could have caused a fatal accident and I don't see how this is acceptable.
Corrective Action:
Driving on the highway at 65mph uphill, engine started making horrible noise and started to fail. Pulled over on shoulder and had to have it towed. Kia is denying warranty because I cannot provide service records. Whether or not they will right this wrong it is a major safety issue when you have complete engine failure with no warning. The engine in my vehicle (3.3 v6 Lambda)completely failed without tripping any warning devices that are equipped on the vehicle. There is a Defect that causes the engine to burn too much oil and there is a defect where the vehicle fails to warn of potential safety issues. There was total engine failure with no warnings. No Service Message No Check Engine Light No Low Oil Pressure Light No Knock Sensor Code No Limp Mode activation. In the service technician's report it even says "no codes set in the ecm" This could have caused a fatal accident and I don't see how this is acceptable.
Additional Notes:
Driving on the highway at 65mph uphill, engine started making horrible noise and started to fail. Pulled over on shoulder and had to have it towed. Kia is denying warranty because I cannot provide service records. Whether or not they will right this wrong it is a major safety issue when you have complete engine failure with no warning. The engine in my vehicle (3.3 v6 Lambda)completely failed without tripping any warning devices that are equipped on the vehicle. There is a Defect that causes the engine to burn too much oil and there is a defect where the vehicle fails to warn of potential safety issues. There was total engine failure with no warnings. No Service Message No Check Engine Light No Low Oil Pressure Light No Knock Sensor Code No Limp Mode activation. In the service technician's report it even says "no codes set in the ecm" This could have caused a fatal accident and I don't see how this is acceptable.
Mfg Campaign: 11448028
Recall Date: Jan 19, 2022
Kia America, Inc.
Defect Description:
ELECTRICAL SYSTEM
Potential Consequences:
Left low beam bulb went out. The right side was rendered inoperable. Had no operational low beam, just parking and high beam lights. Safety issue, generated a dangerous and lot of irate drivers in on coming vehicle’s, with inability to lower the high beams. Once the left low beam bulb was replaced right side became operable full low beam was operating. Don’t know if this a fluke with this vehicle or engineering problem. Created a high stress situation!
Corrective Action:
Left low beam bulb went out. The right side was rendered inoperable. Had no operational low beam, just parking and high beam lights. Safety issue, generated a dangerous and lot of irate drivers in on coming vehicle’s, with inability to lower the high beams. Once the left low beam bulb was replaced right side became operable full low beam was operating. Don’t know if this a fluke with this vehicle or engineering problem. Created a high stress situation!
Additional Notes:
Left low beam bulb went out. The right side was rendered inoperable. Had no operational low beam, just parking and high beam lights. Safety issue, generated a dangerous and lot of irate drivers in on coming vehicle’s, with inability to lower the high beams. Once the left low beam bulb was replaced right side became operable full low beam was operating. Don’t know if this a fluke with this vehicle or engineering problem. Created a high stress situation!
Mfg Campaign: 11447745
Recall Date: Jan 17, 2022
Kia America, Inc.
Defect Description:
EXTERIOR LIGHTING
Potential Consequences:
Left low beam bulb went out. The right side was rendered inoperable. Had no operational low beam, just parking and high beam lights. Safety issue, generated a dangerous and lot of irate drivers in on coming vehicle’s, with inability to lower the high beams. Once the left low beam bulb was replaced right side became operable full low beam was operating. Don’t know if this a fluke with this vehicle or engineering problem. Created a high stress situation!
Corrective Action:
Left low beam bulb went out. The right side was rendered inoperable. Had no operational low beam, just parking and high beam lights. Safety issue, generated a dangerous and lot of irate drivers in on coming vehicle’s, with inability to lower the high beams. Once the left low beam bulb was replaced right side became operable full low beam was operating. Don’t know if this a fluke with this vehicle or engineering problem. Created a high stress situation!
Additional Notes:
Left low beam bulb went out. The right side was rendered inoperable. Had no operational low beam, just parking and high beam lights. Safety issue, generated a dangerous and lot of irate drivers in on coming vehicle’s, with inability to lower the high beams. Once the left low beam bulb was replaced right side became operable full low beam was operating. Don’t know if this a fluke with this vehicle or engineering problem. Created a high stress situation!
Mfg Campaign: 11447745
Recall Date: Jan 17, 2022
Kia America, Inc.
Defect Description:
STEERING
Potential Consequences:
I am the owner of the 2017 KIA Sorento, which I purchased new. When I first contacted the NHTSA, I stated within the last few months that after driving the vehicle the highway or expressway for an extended period (approximately 60 mins to 90 mins), the steering wheel would bind when turning on the road to change lanes or maintain the vehicle on the road. This binding occurs in the turning position without warning. I'm concerned the steering will lock, which will result in a bad accident. I initially took the car to the dealership (Gunther KIA), where I purchased the vehicle. The service adviser told him because the steering wheel has electronic components, the problem could occur when the battery needed replacement. I agreed to have the battery replaced; however, the binding of the steering wheel re-occurred. After the second failure, I returned the car to the dealership's service dept. At the advice of their technicians, they performed a software update on the vehicle. Unfortunately, a couple of days after the second repair, the same failure recurred for the third time. Once again, I took the car back to the dealership, where a case was filed and opened; however, the dealership could not diagnose or duplicate the failure after a few days in their possession. At one point, the master adviser (Randy Rosario) at the dealership told me that he had the same experience with his own Sorrento. And he learned to deal with it and said I should learn to deal with it because the dealership would not give me a new vehicle. I replied by stating that I didn't want a new car; I wanted my car fixed because I feared for my safety and the safety of my family and grandchildren. The adviser also mentioned that a recall should happen, but the manufacturer has never issued one. The manufacturer had yet to be notified of the failure. As a result, the vehicle was not repaired. The failure mileage was 43,490 Fortunately, during the week of January 10th, 2022, I once again called the dealers
Corrective Action:
I am the owner of the 2017 KIA Sorento, which I purchased new. When I first contacted the NHTSA, I stated within the last few months that after driving the vehicle the highway or expressway for an extended period (approximately 60 mins to 90 mins), the steering wheel would bind when turning on the road to change lanes or maintain the vehicle on the road. This binding occurs in the turning position without warning. I'm concerned the steering will lock, which will result in a bad accident. I initially took the car to the dealership (Gunther KIA), where I purchased the vehicle. The service adviser told him because the steering wheel has electronic components, the problem could occur when the battery needed replacement. I agreed to have the battery replaced; however, the binding of the steering wheel re-occurred. After the second failure, I returned the car to the dealership's service dept. At the advice of their technicians, they performed a software update on the vehicle. Unfortunately, a couple of days after the second repair, the same failure recurred for the third time. Once again, I took the car back to the dealership, where a case was filed and opened; however, the dealership could not diagnose or duplicate the failure after a few days in their possession. At one point, the master adviser (Randy Rosario) at the dealership told me that he had the same experience with his own Sorrento. And he learned to deal with it and said I should learn to deal with it because the dealership would not give me a new vehicle. I replied by stating that I didn't want a new car; I wanted my car fixed because I feared for my safety and the safety of my family and grandchildren. The adviser also mentioned that a recall should happen, but the manufacturer has never issued one. The manufacturer had yet to be notified of the failure. As a result, the vehicle was not repaired. The failure mileage was 43,490 Fortunately, during the week of January 10th, 2022, I once again called the dealers
Additional Notes:
I am the owner of the 2017 KIA Sorento, which I purchased new. When I first contacted the NHTSA, I stated within the last few months that after driving the vehicle the highway or expressway for an extended period (approximately 60 mins to 90 mins), the steering wheel would bind when turning on the road to change lanes or maintain the vehicle on the road. This binding occurs in the turning position without warning. I'm concerned the steering will lock, which will result in a bad accident. I initially took the car to the dealership (Gunther KIA), where I purchased the vehicle. The service adviser told him because the steering wheel has electronic components, the problem could occur when the battery needed replacement. I agreed to have the battery replaced; however, the binding of the steering wheel re-occurred. After the second failure, I returned the car to the dealership's service dept. At the advice of their technicians, they performed a software update on the vehicle. Unfortunately, a couple of days after the second repair, the same failure recurred for the third time. Once again, I took the car back to the dealership, where a case was filed and opened; however, the dealership could not diagnose or duplicate the failure after a few days in their possession. At one point, the master adviser (Randy Rosario) at the dealership told me that he had the same experience with his own Sorrento. And he learned to deal with it and said I should learn to deal with it because the dealership would not give me a new vehicle. I replied by stating that I didn't want a new car; I wanted my car fixed because I feared for my safety and the safety of my family and grandchildren. The adviser also mentioned that a recall should happen, but the manufacturer has never issued one. The manufacturer had yet to be notified of the failure. As a result, the vehicle was not repaired. The failure mileage was 43,490 Fortunately, during the week of January 10th, 2022, I once again called the dealers
Mfg Campaign: 11447778
Recall Date: Jan 17, 2022
Kia America, Inc.
Defect Description:
POWER TRAIN
Potential Consequences:
THIS IS A EARLY 2017 BOUGHT IN AUGUST 2016 ON DECEMBER 22 2021, MY DAUGHTER AND TWO YOUNG GRANDSONS WERE TRAVELING WEST BOUND ON I68 JUST PAST CUMBERLAND MD. HER CAR LOST POWER AND SHE CALLED ME IMMEDIATELY AND I HEARD THE ENGINE RATTLING. I TOLD HER IMMEDIATELY TO PULL OVER AND TURN THE ENGINE OFF, I ASK HER IF SHE HAD A LOW OIL PRESSURE OR LOW OIL LIGHT SHE DIDN'T UNTIL ALL THE OIL LEAKED OUT. SHE HAD THE VEHICLE TOWED TO A KIA DEALER IN CUMBERLAND, MD WHERE HE TOOK A PICTURE OF A POP CAN SIZE HOLE IN THE BLOCK. SO YOU HAVE THE SAME PROBLEMS IN SOME 2017s. SHE HAS 115000. MILES ON THE VEHICLE. IF YOU ARE WONDERING WHY SHE CALLED ME, SHE WAS ON THE WAY TO MY HOME AND I WORKED AT TMMWV TEST CELLS AND LISTENED TO MANY ENGINES.
Corrective Action:
THIS IS A EARLY 2017 BOUGHT IN AUGUST 2016 ON DECEMBER 22 2021, MY DAUGHTER AND TWO YOUNG GRANDSONS WERE TRAVELING WEST BOUND ON I68 JUST PAST CUMBERLAND MD. HER CAR LOST POWER AND SHE CALLED ME IMMEDIATELY AND I HEARD THE ENGINE RATTLING. I TOLD HER IMMEDIATELY TO PULL OVER AND TURN THE ENGINE OFF, I ASK HER IF SHE HAD A LOW OIL PRESSURE OR LOW OIL LIGHT SHE DIDN'T UNTIL ALL THE OIL LEAKED OUT. SHE HAD THE VEHICLE TOWED TO A KIA DEALER IN CUMBERLAND, MD WHERE HE TOOK A PICTURE OF A POP CAN SIZE HOLE IN THE BLOCK. SO YOU HAVE THE SAME PROBLEMS IN SOME 2017s. SHE HAS 115000. MILES ON THE VEHICLE. IF YOU ARE WONDERING WHY SHE CALLED ME, SHE WAS ON THE WAY TO MY HOME AND I WORKED AT TMMWV TEST CELLS AND LISTENED TO MANY ENGINES.
Additional Notes:
THIS IS A EARLY 2017 BOUGHT IN AUGUST 2016 ON DECEMBER 22 2021, MY DAUGHTER AND TWO YOUNG GRANDSONS WERE TRAVELING WEST BOUND ON I68 JUST PAST CUMBERLAND MD. HER CAR LOST POWER AND SHE CALLED ME IMMEDIATELY AND I HEARD THE ENGINE RATTLING. I TOLD HER IMMEDIATELY TO PULL OVER AND TURN THE ENGINE OFF, I ASK HER IF SHE HAD A LOW OIL PRESSURE OR LOW OIL LIGHT SHE DIDN'T UNTIL ALL THE OIL LEAKED OUT. SHE HAD THE VEHICLE TOWED TO A KIA DEALER IN CUMBERLAND, MD WHERE HE TOOK A PICTURE OF A POP CAN SIZE HOLE IN THE BLOCK. SO YOU HAVE THE SAME PROBLEMS IN SOME 2017s. SHE HAS 115000. MILES ON THE VEHICLE. IF YOU ARE WONDERING WHY SHE CALLED ME, SHE WAS ON THE WAY TO MY HOME AND I WORKED AT TMMWV TEST CELLS AND LISTENED TO MANY ENGINES.
Mfg Campaign: 11447357
Recall Date: Jan 13, 2022
Kia America, Inc.
Defect Description:
ENGINE
Potential Consequences:
THIS IS A EARLY 2017 BOUGHT IN AUGUST 2016 ON DECEMBER 22 2021, MY DAUGHTER AND TWO YOUNG GRANDSONS WERE TRAVELING WEST BOUND ON I68 JUST PAST CUMBERLAND MD. HER CAR LOST POWER AND SHE CALLED ME IMMEDIATELY AND I HEARD THE ENGINE RATTLING. I TOLD HER IMMEDIATELY TO PULL OVER AND TURN THE ENGINE OFF, I ASK HER IF SHE HAD A LOW OIL PRESSURE OR LOW OIL LIGHT SHE DIDN'T UNTIL ALL THE OIL LEAKED OUT. SHE HAD THE VEHICLE TOWED TO A KIA DEALER IN CUMBERLAND, MD WHERE HE TOOK A PICTURE OF A POP CAN SIZE HOLE IN THE BLOCK. SO YOU HAVE THE SAME PROBLEMS IN SOME 2017s. SHE HAS 115000. MILES ON THE VEHICLE. IF YOU ARE WONDERING WHY SHE CALLED ME, SHE WAS ON THE WAY TO MY HOME AND I WORKED AT TMMWV TEST CELLS AND LISTENED TO MANY ENGINES.
Corrective Action:
THIS IS A EARLY 2017 BOUGHT IN AUGUST 2016 ON DECEMBER 22 2021, MY DAUGHTER AND TWO YOUNG GRANDSONS WERE TRAVELING WEST BOUND ON I68 JUST PAST CUMBERLAND MD. HER CAR LOST POWER AND SHE CALLED ME IMMEDIATELY AND I HEARD THE ENGINE RATTLING. I TOLD HER IMMEDIATELY TO PULL OVER AND TURN THE ENGINE OFF, I ASK HER IF SHE HAD A LOW OIL PRESSURE OR LOW OIL LIGHT SHE DIDN'T UNTIL ALL THE OIL LEAKED OUT. SHE HAD THE VEHICLE TOWED TO A KIA DEALER IN CUMBERLAND, MD WHERE HE TOOK A PICTURE OF A POP CAN SIZE HOLE IN THE BLOCK. SO YOU HAVE THE SAME PROBLEMS IN SOME 2017s. SHE HAS 115000. MILES ON THE VEHICLE. IF YOU ARE WONDERING WHY SHE CALLED ME, SHE WAS ON THE WAY TO MY HOME AND I WORKED AT TMMWV TEST CELLS AND LISTENED TO MANY ENGINES.
Additional Notes:
THIS IS A EARLY 2017 BOUGHT IN AUGUST 2016 ON DECEMBER 22 2021, MY DAUGHTER AND TWO YOUNG GRANDSONS WERE TRAVELING WEST BOUND ON I68 JUST PAST CUMBERLAND MD. HER CAR LOST POWER AND SHE CALLED ME IMMEDIATELY AND I HEARD THE ENGINE RATTLING. I TOLD HER IMMEDIATELY TO PULL OVER AND TURN THE ENGINE OFF, I ASK HER IF SHE HAD A LOW OIL PRESSURE OR LOW OIL LIGHT SHE DIDN'T UNTIL ALL THE OIL LEAKED OUT. SHE HAD THE VEHICLE TOWED TO A KIA DEALER IN CUMBERLAND, MD WHERE HE TOOK A PICTURE OF A POP CAN SIZE HOLE IN THE BLOCK. SO YOU HAVE THE SAME PROBLEMS IN SOME 2017s. SHE HAS 115000. MILES ON THE VEHICLE. IF YOU ARE WONDERING WHY SHE CALLED ME, SHE WAS ON THE WAY TO MY HOME AND I WORKED AT TMMWV TEST CELLS AND LISTENED TO MANY ENGINES.
Mfg Campaign: 11447357
Recall Date: Jan 13, 2022
Kia America, Inc.
Defect Description:
ENGINE
Potential Consequences:
MY DAUGHTER WAS DRIVING ON THE HIGHWAY AND THE CAR STALLED SCARING EVERYONE IN THE VEHICLE. WHEN I TOOK IT TO THE DEALER THEY SAID THERE IS A MISFIRE AND MOST LIKELY THE PISTON RING IS BAD AND ENGINE NEEDS TO REPLACED . THE VEHICLE WAS CONSUMING ALOT OF OIL PRIOR TO ENGINE FAILURE .
Corrective Action:
MY DAUGHTER WAS DRIVING ON THE HIGHWAY AND THE CAR STALLED SCARING EVERYONE IN THE VEHICLE. WHEN I TOOK IT TO THE DEALER THEY SAID THERE IS A MISFIRE AND MOST LIKELY THE PISTON RING IS BAD AND ENGINE NEEDS TO REPLACED . THE VEHICLE WAS CONSUMING ALOT OF OIL PRIOR TO ENGINE FAILURE .
Additional Notes:
MY DAUGHTER WAS DRIVING ON THE HIGHWAY AND THE CAR STALLED SCARING EVERYONE IN THE VEHICLE. WHEN I TOOK IT TO THE DEALER THEY SAID THERE IS A MISFIRE AND MOST LIKELY THE PISTON RING IS BAD AND ENGINE NEEDS TO REPLACED . THE VEHICLE WAS CONSUMING ALOT OF OIL PRIOR TO ENGINE FAILURE .
Mfg Campaign: 11447431
Recall Date: Jan 13, 2022
Kia America, Inc.
Defect Description:
ENGINE
Potential Consequences:
I WAS LEAVING MY COUSINS APARTMENT COMPLEX WHEN THE VEHICLE STALLED. I ATTEMPTED TO TRY TO START THE VEHICLE AGAIN BUT IT WOULD NOT TURN OVER. ALL THE LIGHTS IN THE VEHICLE WERE ON AND THE RADIO WAS STILL PLAYING SO IT DID NOT APPEAR TO BE THE BATTERY. I ATTEMPTED TO TRY AND START THE VEHICLE AGAIN AND NOTICED GRAY SMOKE COMING FROM UNDER THE HOOD. I THEN BEGAN TO SMELL SOMETHING BURNING, SO I EXITED THE VEHICLE AND POPPED THE HOOD. I THEN NOTICED A FIRE COMING FROM THE ENGINE BEHIND THE AIR FILTER COMPONET. ABOUT 10 SECONDS LATER I HEARD A POP AND TOOK OFF RUNNING TO A SAFER LOCATION AND CALLED 911. THE FIRE THEN BEGAN TO GROW BIGGER AND THE WHOLE FRONT OF THE VEHICLE WAS IN FLAMES. THE FIRE DEPARTMENT RESPONDED AND PUT THE FIRE OUT. THERE WERE NO WARNING LIGHTS THAT CAME ON. IF I HAD NOT EXITED THE VEHICLE WHEN I DID I PROBABLY WOULD HAVE BEEN SEVERLY BURNT AS THE WHOLE FRONT WINDSHIELD SHATTERED AND THE DASH WAS MELTED AND FRONT SEATS WERE BURNT.
Corrective Action:
I WAS LEAVING MY COUSINS APARTMENT COMPLEX WHEN THE VEHICLE STALLED. I ATTEMPTED TO TRY TO START THE VEHICLE AGAIN BUT IT WOULD NOT TURN OVER. ALL THE LIGHTS IN THE VEHICLE WERE ON AND THE RADIO WAS STILL PLAYING SO IT DID NOT APPEAR TO BE THE BATTERY. I ATTEMPTED TO TRY AND START THE VEHICLE AGAIN AND NOTICED GRAY SMOKE COMING FROM UNDER THE HOOD. I THEN BEGAN TO SMELL SOMETHING BURNING, SO I EXITED THE VEHICLE AND POPPED THE HOOD. I THEN NOTICED A FIRE COMING FROM THE ENGINE BEHIND THE AIR FILTER COMPONET. ABOUT 10 SECONDS LATER I HEARD A POP AND TOOK OFF RUNNING TO A SAFER LOCATION AND CALLED 911. THE FIRE THEN BEGAN TO GROW BIGGER AND THE WHOLE FRONT OF THE VEHICLE WAS IN FLAMES. THE FIRE DEPARTMENT RESPONDED AND PUT THE FIRE OUT. THERE WERE NO WARNING LIGHTS THAT CAME ON. IF I HAD NOT EXITED THE VEHICLE WHEN I DID I PROBABLY WOULD HAVE BEEN SEVERLY BURNT AS THE WHOLE FRONT WINDSHIELD SHATTERED AND THE DASH WAS MELTED AND FRONT SEATS WERE BURNT.
Additional Notes:
I WAS LEAVING MY COUSINS APARTMENT COMPLEX WHEN THE VEHICLE STALLED. I ATTEMPTED TO TRY TO START THE VEHICLE AGAIN BUT IT WOULD NOT TURN OVER. ALL THE LIGHTS IN THE VEHICLE WERE ON AND THE RADIO WAS STILL PLAYING SO IT DID NOT APPEAR TO BE THE BATTERY. I ATTEMPTED TO TRY AND START THE VEHICLE AGAIN AND NOTICED GRAY SMOKE COMING FROM UNDER THE HOOD. I THEN BEGAN TO SMELL SOMETHING BURNING, SO I EXITED THE VEHICLE AND POPPED THE HOOD. I THEN NOTICED A FIRE COMING FROM THE ENGINE BEHIND THE AIR FILTER COMPONET. ABOUT 10 SECONDS LATER I HEARD A POP AND TOOK OFF RUNNING TO A SAFER LOCATION AND CALLED 911. THE FIRE THEN BEGAN TO GROW BIGGER AND THE WHOLE FRONT OF THE VEHICLE WAS IN FLAMES. THE FIRE DEPARTMENT RESPONDED AND PUT THE FIRE OUT. THERE WERE NO WARNING LIGHTS THAT CAME ON. IF I HAD NOT EXITED THE VEHICLE WHEN I DID I PROBABLY WOULD HAVE BEEN SEVERLY BURNT AS THE WHOLE FRONT WINDSHIELD SHATTERED AND THE DASH WAS MELTED AND FRONT SEATS WERE BURNT.
Mfg Campaign: 11446409
Recall Date: Jan 5, 2022
Kia America, Inc.
Defect Description:
FUEL/PROPULSION SYSTEM
Potential Consequences:
I WAS LEAVING MY COUSINS APARTMENT COMPLEX WHEN THE VEHICLE STALLED. I ATTEMPTED TO TRY TO START THE VEHICLE AGAIN BUT IT WOULD NOT TURN OVER. ALL THE LIGHTS IN THE VEHICLE WERE ON AND THE RADIO WAS STILL PLAYING SO IT DID NOT APPEAR TO BE THE BATTERY. I ATTEMPTED TO TRY AND START THE VEHICLE AGAIN AND NOTICED GRAY SMOKE COMING FROM UNDER THE HOOD. I THEN BEGAN TO SMELL SOMETHING BURNING, SO I EXITED THE VEHICLE AND POPPED THE HOOD. I THEN NOTICED A FIRE COMING FROM THE ENGINE BEHIND THE AIR FILTER COMPONET. ABOUT 10 SECONDS LATER I HEARD A POP AND TOOK OFF RUNNING TO A SAFER LOCATION AND CALLED 911. THE FIRE THEN BEGAN TO GROW BIGGER AND THE WHOLE FRONT OF THE VEHICLE WAS IN FLAMES. THE FIRE DEPARTMENT RESPONDED AND PUT THE FIRE OUT. THERE WERE NO WARNING LIGHTS THAT CAME ON. IF I HAD NOT EXITED THE VEHICLE WHEN I DID I PROBABLY WOULD HAVE BEEN SEVERLY BURNT AS THE WHOLE FRONT WINDSHIELD SHATTERED AND THE DASH WAS MELTED AND FRONT SEATS WERE BURNT.
Corrective Action:
I WAS LEAVING MY COUSINS APARTMENT COMPLEX WHEN THE VEHICLE STALLED. I ATTEMPTED TO TRY TO START THE VEHICLE AGAIN BUT IT WOULD NOT TURN OVER. ALL THE LIGHTS IN THE VEHICLE WERE ON AND THE RADIO WAS STILL PLAYING SO IT DID NOT APPEAR TO BE THE BATTERY. I ATTEMPTED TO TRY AND START THE VEHICLE AGAIN AND NOTICED GRAY SMOKE COMING FROM UNDER THE HOOD. I THEN BEGAN TO SMELL SOMETHING BURNING, SO I EXITED THE VEHICLE AND POPPED THE HOOD. I THEN NOTICED A FIRE COMING FROM THE ENGINE BEHIND THE AIR FILTER COMPONET. ABOUT 10 SECONDS LATER I HEARD A POP AND TOOK OFF RUNNING TO A SAFER LOCATION AND CALLED 911. THE FIRE THEN BEGAN TO GROW BIGGER AND THE WHOLE FRONT OF THE VEHICLE WAS IN FLAMES. THE FIRE DEPARTMENT RESPONDED AND PUT THE FIRE OUT. THERE WERE NO WARNING LIGHTS THAT CAME ON. IF I HAD NOT EXITED THE VEHICLE WHEN I DID I PROBABLY WOULD HAVE BEEN SEVERLY BURNT AS THE WHOLE FRONT WINDSHIELD SHATTERED AND THE DASH WAS MELTED AND FRONT SEATS WERE BURNT.
Additional Notes:
I WAS LEAVING MY COUSINS APARTMENT COMPLEX WHEN THE VEHICLE STALLED. I ATTEMPTED TO TRY TO START THE VEHICLE AGAIN BUT IT WOULD NOT TURN OVER. ALL THE LIGHTS IN THE VEHICLE WERE ON AND THE RADIO WAS STILL PLAYING SO IT DID NOT APPEAR TO BE THE BATTERY. I ATTEMPTED TO TRY AND START THE VEHICLE AGAIN AND NOTICED GRAY SMOKE COMING FROM UNDER THE HOOD. I THEN BEGAN TO SMELL SOMETHING BURNING, SO I EXITED THE VEHICLE AND POPPED THE HOOD. I THEN NOTICED A FIRE COMING FROM THE ENGINE BEHIND THE AIR FILTER COMPONET. ABOUT 10 SECONDS LATER I HEARD A POP AND TOOK OFF RUNNING TO A SAFER LOCATION AND CALLED 911. THE FIRE THEN BEGAN TO GROW BIGGER AND THE WHOLE FRONT OF THE VEHICLE WAS IN FLAMES. THE FIRE DEPARTMENT RESPONDED AND PUT THE FIRE OUT. THERE WERE NO WARNING LIGHTS THAT CAME ON. IF I HAD NOT EXITED THE VEHICLE WHEN I DID I PROBABLY WOULD HAVE BEEN SEVERLY BURNT AS THE WHOLE FRONT WINDSHIELD SHATTERED AND THE DASH WAS MELTED AND FRONT SEATS WERE BURNT.
Mfg Campaign: 11446409
Recall Date: Jan 5, 2022
Kia America, Inc.
Defect Description:
ELECTRICAL SYSTEM
Potential Consequences:
I WAS LEAVING MY COUSINS APARTMENT COMPLEX WHEN THE VEHICLE STALLED. I ATTEMPTED TO TRY TO START THE VEHICLE AGAIN BUT IT WOULD NOT TURN OVER. ALL THE LIGHTS IN THE VEHICLE WERE ON AND THE RADIO WAS STILL PLAYING SO IT DID NOT APPEAR TO BE THE BATTERY. I ATTEMPTED TO TRY AND START THE VEHICLE AGAIN AND NOTICED GRAY SMOKE COMING FROM UNDER THE HOOD. I THEN BEGAN TO SMELL SOMETHING BURNING, SO I EXITED THE VEHICLE AND POPPED THE HOOD. I THEN NOTICED A FIRE COMING FROM THE ENGINE BEHIND THE AIR FILTER COMPONET. ABOUT 10 SECONDS LATER I HEARD A POP AND TOOK OFF RUNNING TO A SAFER LOCATION AND CALLED 911. THE FIRE THEN BEGAN TO GROW BIGGER AND THE WHOLE FRONT OF THE VEHICLE WAS IN FLAMES. THE FIRE DEPARTMENT RESPONDED AND PUT THE FIRE OUT. THERE WERE NO WARNING LIGHTS THAT CAME ON. IF I HAD NOT EXITED THE VEHICLE WHEN I DID I PROBABLY WOULD HAVE BEEN SEVERLY BURNT AS THE WHOLE FRONT WINDSHIELD SHATTERED AND THE DASH WAS MELTED AND FRONT SEATS WERE BURNT.
Corrective Action:
I WAS LEAVING MY COUSINS APARTMENT COMPLEX WHEN THE VEHICLE STALLED. I ATTEMPTED TO TRY TO START THE VEHICLE AGAIN BUT IT WOULD NOT TURN OVER. ALL THE LIGHTS IN THE VEHICLE WERE ON AND THE RADIO WAS STILL PLAYING SO IT DID NOT APPEAR TO BE THE BATTERY. I ATTEMPTED TO TRY AND START THE VEHICLE AGAIN AND NOTICED GRAY SMOKE COMING FROM UNDER THE HOOD. I THEN BEGAN TO SMELL SOMETHING BURNING, SO I EXITED THE VEHICLE AND POPPED THE HOOD. I THEN NOTICED A FIRE COMING FROM THE ENGINE BEHIND THE AIR FILTER COMPONET. ABOUT 10 SECONDS LATER I HEARD A POP AND TOOK OFF RUNNING TO A SAFER LOCATION AND CALLED 911. THE FIRE THEN BEGAN TO GROW BIGGER AND THE WHOLE FRONT OF THE VEHICLE WAS IN FLAMES. THE FIRE DEPARTMENT RESPONDED AND PUT THE FIRE OUT. THERE WERE NO WARNING LIGHTS THAT CAME ON. IF I HAD NOT EXITED THE VEHICLE WHEN I DID I PROBABLY WOULD HAVE BEEN SEVERLY BURNT AS THE WHOLE FRONT WINDSHIELD SHATTERED AND THE DASH WAS MELTED AND FRONT SEATS WERE BURNT.
Additional Notes:
I WAS LEAVING MY COUSINS APARTMENT COMPLEX WHEN THE VEHICLE STALLED. I ATTEMPTED TO TRY TO START THE VEHICLE AGAIN BUT IT WOULD NOT TURN OVER. ALL THE LIGHTS IN THE VEHICLE WERE ON AND THE RADIO WAS STILL PLAYING SO IT DID NOT APPEAR TO BE THE BATTERY. I ATTEMPTED TO TRY AND START THE VEHICLE AGAIN AND NOTICED GRAY SMOKE COMING FROM UNDER THE HOOD. I THEN BEGAN TO SMELL SOMETHING BURNING, SO I EXITED THE VEHICLE AND POPPED THE HOOD. I THEN NOTICED A FIRE COMING FROM THE ENGINE BEHIND THE AIR FILTER COMPONET. ABOUT 10 SECONDS LATER I HEARD A POP AND TOOK OFF RUNNING TO A SAFER LOCATION AND CALLED 911. THE FIRE THEN BEGAN TO GROW BIGGER AND THE WHOLE FRONT OF THE VEHICLE WAS IN FLAMES. THE FIRE DEPARTMENT RESPONDED AND PUT THE FIRE OUT. THERE WERE NO WARNING LIGHTS THAT CAME ON. IF I HAD NOT EXITED THE VEHICLE WHEN I DID I PROBABLY WOULD HAVE BEEN SEVERLY BURNT AS THE WHOLE FRONT WINDSHIELD SHATTERED AND THE DASH WAS MELTED AND FRONT SEATS WERE BURNT.
Mfg Campaign: 11446409
Recall Date: Jan 5, 2022
Kia America, Inc.
Defect Description:
POWER TRAIN
Potential Consequences:
My car was fine, then all of a sudden (after an oil change) it started knocking really loudly. I pulled over and the noise stopped- so I got back in the car a drive home. When I pulled into the driveway, I heard the noise again- knocking. I popped the hood and had daughter press the gas, sure enough- knocking again. I told husband and we parked it, he towed it to the dealership the next day. They said that because my car did not get the "campaign" update- ROD KNOCKING SENSOR- that the extended warranty was null and void. I asked to place a complaint at how the whole situation was handled- they said they mailed us letters, but they must have been the most non-descriptive letters in history. It's not safe- they know about this problem and they are not doing anything about it- they are doing the bare minimum, that is how people get hurt. We owe more to repair this vehicle than it is worth, and there is no "Goodwill" assistance on a car that wasn't "kept". I kept my car within it's normal limits, it's not right how the company chose to notify. They have all my contact info- I am the original owner. Thank goodness my teen daughter wasn't driving.
Corrective Action:
My car was fine, then all of a sudden (after an oil change) it started knocking really loudly. I pulled over and the noise stopped- so I got back in the car a drive home. When I pulled into the driveway, I heard the noise again- knocking. I popped the hood and had daughter press the gas, sure enough- knocking again. I told husband and we parked it, he towed it to the dealership the next day. They said that because my car did not get the "campaign" update- ROD KNOCKING SENSOR- that the extended warranty was null and void. I asked to place a complaint at how the whole situation was handled- they said they mailed us letters, but they must have been the most non-descriptive letters in history. It's not safe- they know about this problem and they are not doing anything about it- they are doing the bare minimum, that is how people get hurt. We owe more to repair this vehicle than it is worth, and there is no "Goodwill" assistance on a car that wasn't "kept". I kept my car within it's normal limits, it's not right how the company chose to notify. They have all my contact info- I am the original owner. Thank goodness my teen daughter wasn't driving.
Additional Notes:
My car was fine, then all of a sudden (after an oil change) it started knocking really loudly. I pulled over and the noise stopped- so I got back in the car a drive home. When I pulled into the driveway, I heard the noise again- knocking. I popped the hood and had daughter press the gas, sure enough- knocking again. I told husband and we parked it, he towed it to the dealership the next day. They said that because my car did not get the "campaign" update- ROD KNOCKING SENSOR- that the extended warranty was null and void. I asked to place a complaint at how the whole situation was handled- they said they mailed us letters, but they must have been the most non-descriptive letters in history. It's not safe- they know about this problem and they are not doing anything about it- they are doing the bare minimum, that is how people get hurt. We owe more to repair this vehicle than it is worth, and there is no "Goodwill" assistance on a car that wasn't "kept". I kept my car within it's normal limits, it's not right how the company chose to notify. They have all my contact info- I am the original owner. Thank goodness my teen daughter wasn't driving.
Mfg Campaign: 11446050
Recall Date: Jan 3, 2022
Kia America, Inc.
Defect Description:
ENGINE
Potential Consequences:
My car was fine, then all of a sudden (after an oil change) it started knocking really loudly. I pulled over and the noise stopped- so I got back in the car a drive home. When I pulled into the driveway, I heard the noise again- knocking. I popped the hood and had daughter press the gas, sure enough- knocking again. I told husband and we parked it, he towed it to the dealership the next day. They said that because my car did not get the "campaign" update- ROD KNOCKING SENSOR- that the extended warranty was null and void. I asked to place a complaint at how the whole situation was handled- they said they mailed us letters, but they must have been the most non-descriptive letters in history. It's not safe- they know about this problem and they are not doing anything about it- they are doing the bare minimum, that is how people get hurt. We owe more to repair this vehicle than it is worth, and there is no "Goodwill" assistance on a car that wasn't "kept". I kept my car within it's normal limits, it's not right how the company chose to notify. They have all my contact info- I am the original owner. Thank goodness my teen daughter wasn't driving.
Corrective Action:
My car was fine, then all of a sudden (after an oil change) it started knocking really loudly. I pulled over and the noise stopped- so I got back in the car a drive home. When I pulled into the driveway, I heard the noise again- knocking. I popped the hood and had daughter press the gas, sure enough- knocking again. I told husband and we parked it, he towed it to the dealership the next day. They said that because my car did not get the "campaign" update- ROD KNOCKING SENSOR- that the extended warranty was null and void. I asked to place a complaint at how the whole situation was handled- they said they mailed us letters, but they must have been the most non-descriptive letters in history. It's not safe- they know about this problem and they are not doing anything about it- they are doing the bare minimum, that is how people get hurt. We owe more to repair this vehicle than it is worth, and there is no "Goodwill" assistance on a car that wasn't "kept". I kept my car within it's normal limits, it's not right how the company chose to notify. They have all my contact info- I am the original owner. Thank goodness my teen daughter wasn't driving.
Additional Notes:
My car was fine, then all of a sudden (after an oil change) it started knocking really loudly. I pulled over and the noise stopped- so I got back in the car a drive home. When I pulled into the driveway, I heard the noise again- knocking. I popped the hood and had daughter press the gas, sure enough- knocking again. I told husband and we parked it, he towed it to the dealership the next day. They said that because my car did not get the "campaign" update- ROD KNOCKING SENSOR- that the extended warranty was null and void. I asked to place a complaint at how the whole situation was handled- they said they mailed us letters, but they must have been the most non-descriptive letters in history. It's not safe- they know about this problem and they are not doing anything about it- they are doing the bare minimum, that is how people get hurt. We owe more to repair this vehicle than it is worth, and there is no "Goodwill" assistance on a car that wasn't "kept". I kept my car within it's normal limits, it's not right how the company chose to notify. They have all my contact info- I am the original owner. Thank goodness my teen daughter wasn't driving.
Mfg Campaign: 11446050
Recall Date: Jan 3, 2022
Kia America, Inc.
Defect Description:
UNKNOWN OR OTHER
Potential Consequences:
My car was fine, then all of a sudden (after an oil change) it started knocking really loudly. I pulled over and the noise stopped- so I got back in the car a drive home. When I pulled into the driveway, I heard the noise again- knocking. I popped the hood and had daughter press the gas, sure enough- knocking again. I told husband and we parked it, he towed it to the dealership the next day. They said that because my car did not get the "campaign" update- ROD KNOCKING SENSOR- that the extended warranty was null and void. I asked to place a complaint at how the whole situation was handled- they said they mailed us letters, but they must have been the most non-descriptive letters in history. It's not safe- they know about this problem and they are not doing anything about it- they are doing the bare minimum, that is how people get hurt. We owe more to repair this vehicle than it is worth, and there is no "Goodwill" assistance on a car that wasn't "kept". I kept my car within it's normal limits, it's not right how the company chose to notify. They have all my contact info- I am the original owner. Thank goodness my teen daughter wasn't driving.
Corrective Action:
My car was fine, then all of a sudden (after an oil change) it started knocking really loudly. I pulled over and the noise stopped- so I got back in the car a drive home. When I pulled into the driveway, I heard the noise again- knocking. I popped the hood and had daughter press the gas, sure enough- knocking again. I told husband and we parked it, he towed it to the dealership the next day. They said that because my car did not get the "campaign" update- ROD KNOCKING SENSOR- that the extended warranty was null and void. I asked to place a complaint at how the whole situation was handled- they said they mailed us letters, but they must have been the most non-descriptive letters in history. It's not safe- they know about this problem and they are not doing anything about it- they are doing the bare minimum, that is how people get hurt. We owe more to repair this vehicle than it is worth, and there is no "Goodwill" assistance on a car that wasn't "kept". I kept my car within it's normal limits, it's not right how the company chose to notify. They have all my contact info- I am the original owner. Thank goodness my teen daughter wasn't driving.
Additional Notes:
My car was fine, then all of a sudden (after an oil change) it started knocking really loudly. I pulled over and the noise stopped- so I got back in the car a drive home. When I pulled into the driveway, I heard the noise again- knocking. I popped the hood and had daughter press the gas, sure enough- knocking again. I told husband and we parked it, he towed it to the dealership the next day. They said that because my car did not get the "campaign" update- ROD KNOCKING SENSOR- that the extended warranty was null and void. I asked to place a complaint at how the whole situation was handled- they said they mailed us letters, but they must have been the most non-descriptive letters in history. It's not safe- they know about this problem and they are not doing anything about it- they are doing the bare minimum, that is how people get hurt. We owe more to repair this vehicle than it is worth, and there is no "Goodwill" assistance on a car that wasn't "kept". I kept my car within it's normal limits, it's not right how the company chose to notify. They have all my contact info- I am the original owner. Thank goodness my teen daughter wasn't driving.
Mfg Campaign: 11446050
Recall Date: Jan 3, 2022
Kia America, Inc.
Defect Description:
UNKNOWN OR OTHER
Potential Consequences:
The contact owns a 2017 Kia Sorento. The contact stated that while driving approximately 20 mph when the vehicle began to lag in acceleration when attempting to go uphill. The driver noticed a spark within the instrument panel directly behind the steering wheel. The driver then immediately pulled over and both the driver and the passenger (the contact) exited the vehicle. The vehicle then caught fire. The fire department showed and distinguished the fire. A report was made. There were no injuries. The vehicle was towed and deemed totaled. The dealer was not contacted. The manufacturer was contacted and made aware of the failure. A case was opened regarding the matter. The approximate failure mileage was unknown
Corrective Action:
The contact owns a 2017 Kia Sorento. The contact stated that while driving approximately 20 mph when the vehicle began to lag in acceleration when attempting to go uphill. The driver noticed a spark within the instrument panel directly behind the steering wheel. The driver then immediately pulled over and both the driver and the passenger (the contact) exited the vehicle. The vehicle then caught fire. The fire department showed and distinguished the fire. A report was made. There were no injuries. The vehicle was towed and deemed totaled. The dealer was not contacted. The manufacturer was contacted and made aware of the failure. A case was opened regarding the matter. The approximate failure mileage was unknown
Additional Notes:
The contact owns a 2017 Kia Sorento. The contact stated that while driving approximately 20 mph when the vehicle began to lag in acceleration when attempting to go uphill. The driver noticed a spark within the instrument panel directly behind the steering wheel. The driver then immediately pulled over and both the driver and the passenger (the contact) exited the vehicle. The vehicle then caught fire. The fire department showed and distinguished the fire. A report was made. There were no injuries. The vehicle was towed and deemed totaled. The dealer was not contacted. The manufacturer was contacted and made aware of the failure. A case was opened regarding the matter. The approximate failure mileage was unknown
Mfg Campaign: 11445485
Recall Date: Dec 29, 2021
Kia America, Inc.
Defect Description:
WHEELS
Potential Consequences:
All four tires cupped on vehicle
Corrective Action:
All four tires cupped on vehicle
Additional Notes:
All four tires cupped on vehicle
Mfg Campaign: 11445279
Recall Date: Dec 28, 2021
Kia America, Inc.
Defect Description:
ENGINE
Potential Consequences:
The oil pressure switch sensor is going bad. Common problem with the 3.3 Lambda V6 engine. The oil light comes on when the vehicle is at idle. I now have an oil leak which is another symptom of the sensor going bad. Costly repair, sensor located deep in the engine between the two cylinder banks. This is a fire hazard with oil pooling on top of the engine if not repaired.
Corrective Action:
The oil pressure switch sensor is going bad. Common problem with the 3.3 Lambda V6 engine. The oil light comes on when the vehicle is at idle. I now have an oil leak which is another symptom of the sensor going bad. Costly repair, sensor located deep in the engine between the two cylinder banks. This is a fire hazard with oil pooling on top of the engine if not repaired.
Additional Notes:
The oil pressure switch sensor is going bad. Common problem with the 3.3 Lambda V6 engine. The oil light comes on when the vehicle is at idle. I now have an oil leak which is another symptom of the sensor going bad. Costly repair, sensor located deep in the engine between the two cylinder banks. This is a fire hazard with oil pooling on top of the engine if not repaired.
Mfg Campaign: 11444455
Recall Date: Dec 20, 2021
Kia America, Inc.
Defect Description:
STEERING
Potential Consequences:
While driving 40mph+, steering appears to "stick" and driver has to make a more forceful jerk with the steering wheel to "unstick" the steering. Driver ends up over compensating for stuck steering and is jerking the car on the road. Steering appears to not "stick" as much when going under 40mph. Steering sticks more often going around bends or small turns on the open road.
Corrective Action:
While driving 40mph+, steering appears to "stick" and driver has to make a more forceful jerk with the steering wheel to "unstick" the steering. Driver ends up over compensating for stuck steering and is jerking the car on the road. Steering appears to not "stick" as much when going under 40mph. Steering sticks more often going around bends or small turns on the open road.
Additional Notes:
While driving 40mph+, steering appears to "stick" and driver has to make a more forceful jerk with the steering wheel to "unstick" the steering. Driver ends up over compensating for stuck steering and is jerking the car on the road. Steering appears to not "stick" as much when going under 40mph. Steering sticks more often going around bends or small turns on the open road.
Mfg Campaign: 11443335
Recall Date: Dec 10, 2021
Kia America, Inc.
Defect Description:
UNKNOWN OR OTHER
Potential Consequences:
Steering began sticking at about 55K miles. Got worse over time. Causing difficulty with accurate lane changes or straight steering. Car has electric motor assisted power steering. Found multiple similar cases on line where solution was to replace entire steering column assy. Took car in to dealer (Peoria Kia, Peoria AZ) 15Oct2021. Dealer said had to replace entire column assy- steering. Was covered by 3rd party extended warranty on car, 2 months later, steering stopped working completely. We were able to get the car to the side of the street and stop. Had car towed back to Peoria Kia. They now report broken steering gear, which appears to be related to previous repair. Solution pending back ordered parts. Work order for first repair attached.
Corrective Action:
Steering began sticking at about 55K miles. Got worse over time. Causing difficulty with accurate lane changes or straight steering. Car has electric motor assisted power steering. Found multiple similar cases on line where solution was to replace entire steering column assy. Took car in to dealer (Peoria Kia, Peoria AZ) 15Oct2021. Dealer said had to replace entire column assy- steering. Was covered by 3rd party extended warranty on car, 2 months later, steering stopped working completely. We were able to get the car to the side of the street and stop. Had car towed back to Peoria Kia. They now report broken steering gear, which appears to be related to previous repair. Solution pending back ordered parts. Work order for first repair attached.
Additional Notes:
Steering began sticking at about 55K miles. Got worse over time. Causing difficulty with accurate lane changes or straight steering. Car has electric motor assisted power steering. Found multiple similar cases on line where solution was to replace entire steering column assy. Took car in to dealer (Peoria Kia, Peoria AZ) 15Oct2021. Dealer said had to replace entire column assy- steering. Was covered by 3rd party extended warranty on car, 2 months later, steering stopped working completely. We were able to get the car to the side of the street and stop. Had car towed back to Peoria Kia. They now report broken steering gear, which appears to be related to previous repair. Solution pending back ordered parts. Work order for first repair attached.
Mfg Campaign: 11442847
Recall Date: Dec 6, 2021
Kia America, Inc.
Defect Description:
UNKNOWN OR OTHER
Potential Consequences:
The horn on my Kia became very faint causing a safety risk as it was so quiet, that it was no longer a viable safety tool. At 57,711 miles. On 5/13/21 I paid a local certified mechanic to replace the horn. (I was informed there were actually 2 horns). My vehicle was purchased 10/8/16. Since it was under warranty, in June 2021, I provided KIA the receipt to get reimbursed for the horn replacement. After 5 months of my persistent communication with KIA, they denied reimbursement. Early on one of the KIA emails asked for proof of payment (which I provided) and it also stated reimbursements can take up to 60 days. I have the defective horns in my possession.
Corrective Action:
The horn on my Kia became very faint causing a safety risk as it was so quiet, that it was no longer a viable safety tool. At 57,711 miles. On 5/13/21 I paid a local certified mechanic to replace the horn. (I was informed there were actually 2 horns). My vehicle was purchased 10/8/16. Since it was under warranty, in June 2021, I provided KIA the receipt to get reimbursed for the horn replacement. After 5 months of my persistent communication with KIA, they denied reimbursement. Early on one of the KIA emails asked for proof of payment (which I provided) and it also stated reimbursements can take up to 60 days. I have the defective horns in my possession.
Additional Notes:
The horn on my Kia became very faint causing a safety risk as it was so quiet, that it was no longer a viable safety tool. At 57,711 miles. On 5/13/21 I paid a local certified mechanic to replace the horn. (I was informed there were actually 2 horns). My vehicle was purchased 10/8/16. Since it was under warranty, in June 2021, I provided KIA the receipt to get reimbursed for the horn replacement. After 5 months of my persistent communication with KIA, they denied reimbursement. Early on one of the KIA emails asked for proof of payment (which I provided) and it also stated reimbursements can take up to 60 days. I have the defective horns in my possession.
Mfg Campaign: 11442104
Recall Date: Nov 30, 2021
Kia America, Inc.
Defect Description:
STEERING
Potential Consequences:
The contact owns a 2017 KIA Sorento, which he purchased new. The contact stated within the last few months that after driving the vehicle the highway or expressway for an extended period (approximately 60 mins to 90 mins), the steering wheel would bind when turning on the road to change lanes or maintain the vehicle on the road. This binding occurs in the turning position without warning. The contact had initially taken the car to the dealership (Gunther KIA), where he purchased the vehicle as new. The service adviser told him because the steering wheel has electronic components, the problem could occur when the battery needed replacement. The contact agreed to have the battery replaced; however, the binding of the steering wheel re-occurred. After the second failure, the vehicle was returned to the dealership’s service dept. They performed a software update on the car. Unfortunately, a couple of days after the second repair, the same failure recurred for the third time. The contact had taken the vehicle back to the dealership, where a case was filed and opened; however, after a few days in their possession, the dealership could not diagnose or duplicate the failure. At one point, the master adviser at the dealership told the contact that he himself had the same experience with his own Sorrento. And he learned to deal with it and said to the contact (car owner) should learn to deal with it because the dealership would not give him a new vehicle. The contact replied by stating that he didn’t want a new car; he wanted his car fixed because he fears for his family’s, and grandchildren’s safety. The adviser also mentioned that a recall should happen, but the manufacturer has never issued one. The manufacturer had yet to be notified of the failure. As a result, the vehicle was not repaired. The failure mileage was 43,490.
Corrective Action:
The contact owns a 2017 KIA Sorento, which he purchased new. The contact stated within the last few months that after driving the vehicle the highway or expressway for an extended period (approximately 60 mins to 90 mins), the steering wheel would bind when turning on the road to change lanes or maintain the vehicle on the road. This binding occurs in the turning position without warning. The contact had initially taken the car to the dealership (Gunther KIA), where he purchased the vehicle as new. The service adviser told him because the steering wheel has electronic components, the problem could occur when the battery needed replacement. The contact agreed to have the battery replaced; however, the binding of the steering wheel re-occurred. After the second failure, the vehicle was returned to the dealership’s service dept. They performed a software update on the car. Unfortunately, a couple of days after the second repair, the same failure recurred for the third time. The contact had taken the vehicle back to the dealership, where a case was filed and opened; however, after a few days in their possession, the dealership could not diagnose or duplicate the failure. At one point, the master adviser at the dealership told the contact that he himself had the same experience with his own Sorrento. And he learned to deal with it and said to the contact (car owner) should learn to deal with it because the dealership would not give him a new vehicle. The contact replied by stating that he didn’t want a new car; he wanted his car fixed because he fears for his family’s, and grandchildren’s safety. The adviser also mentioned that a recall should happen, but the manufacturer has never issued one. The manufacturer had yet to be notified of the failure. As a result, the vehicle was not repaired. The failure mileage was 43,490.
Additional Notes:
The contact owns a 2017 KIA Sorento, which he purchased new. The contact stated within the last few months that after driving the vehicle the highway or expressway for an extended period (approximately 60 mins to 90 mins), the steering wheel would bind when turning on the road to change lanes or maintain the vehicle on the road. This binding occurs in the turning position without warning. The contact had initially taken the car to the dealership (Gunther KIA), where he purchased the vehicle as new. The service adviser told him because the steering wheel has electronic components, the problem could occur when the battery needed replacement. The contact agreed to have the battery replaced; however, the binding of the steering wheel re-occurred. After the second failure, the vehicle was returned to the dealership’s service dept. They performed a software update on the car. Unfortunately, a couple of days after the second repair, the same failure recurred for the third time. The contact had taken the vehicle back to the dealership, where a case was filed and opened; however, after a few days in their possession, the dealership could not diagnose or duplicate the failure. At one point, the master adviser at the dealership told the contact that he himself had the same experience with his own Sorrento. And he learned to deal with it and said to the contact (car owner) should learn to deal with it because the dealership would not give him a new vehicle. The contact replied by stating that he didn’t want a new car; he wanted his car fixed because he fears for his family’s, and grandchildren’s safety. The adviser also mentioned that a recall should happen, but the manufacturer has never issued one. The manufacturer had yet to be notified of the failure. As a result, the vehicle was not repaired. The failure mileage was 43,490.
Mfg Campaign: 11439212
Recall Date: Nov 3, 2021
Need Legal Help?
Featured Attorneys
Barry Edzant
Edzant Price LLC
Valencia, CA • 36 yrs
Focus: Lemon Law, Personal Injury