Complaints & Recalls
Official Safety Recalls - Important!
23 RecallsThese are official manufacturer recalls ordered by NHTSA for safety defects. If you own this vehicle, contact your dealer immediately for free repairs.
Ford Motor Company
Safety Issue:
Ford Motor Company (Ford) is recalling certain 2016-2017 Explorer vehicles. The driver and front passenger B-Pillar door trim may detach while driving.
Potential Risk:
FREE Recall Solution:
Mfg Campaign: 25S53
Ford Motor Company
Safety Issue:
Ford Motor Company (Ford) is recalling certain 2011-2019 Explorer vehicles. The A-pillar trim retention clips may not be properly engaged, allowing the trim to detach.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Mfg Campaign: 24S02
Recall Date: Jan 19, 2024
Ford Motor Company
Safety Issue:
Ford Motor Company (Ford) is recalling certain 2013-2017 Explorer vehicles originally sold, or ever registered, in Connecticut, Delaware, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, Wisconsin, and the District of Columbia. Exposure to road salt can cause the cross-axis ball joint to corrode and seize, resulting in a fracture of the outboard section of the rear suspension toe link.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Mfg Campaign: 21S32
Recall Date: Jul 15, 2021
Ford Motor Company
Safety Issue:
Ford Motor Company (Ford) is recalling certain 2016-2019 Explorer vehicles. The retention pins could loosen and allow the roof rail covers to detach from the vehicle.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Mfg Campaign: 21S22
Recall Date: May 5, 2021
Ford Motor Company
Safety Issue:
Ford Motor Company (Ford) is recalling certain 2014-2016 Explorer, 2014-2015 Taurus and 2014 Edge vehicles equipped with 2.0L or 2.3L engines and front wheel drive. The support bracket for the front drive axle halfshaft may fail.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Mfg Campaign: 20S63
Recall Date: Nov 10, 2020
Ford Motor Company
Safety Issue:
Ford Motor Company (Ford) is recalling certain 2013-2017 Explorer vehicles originally sold, or currently registered in Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, and Wisconsin that were previously repaired under a prior recall numbers 16V-245 or 19V-435. The outboard section of a rear suspension toe link may fracture.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Mfg Campaign: 20S62
Recall Date: Oct 30, 2020
Ford Motor Company
Safety Issue:
Ford Motor Company (Ford) is recalling certain 2011-2017 Explorer vehicles. The rear suspension toe links may fracture due to stress on the rear suspension.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Mfg Campaign: 19S17
Recall Date: Jun 10, 2019
Ford Motor Company
Safety Issue:
Ford Motor Company (Ford) is recalling certain 2016 F-150 and Explorer vehicles. Loose power seat adjuster pivot bolts may cause the front seat cushions to detach and not properly restrain the seat occupant in the event of a crash.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Mfg Campaign: 17S40
Recall Date: Nov 29, 2017
Ford Motor Company
Safety Issue:
Ford Motor Company (Ford) is recalling certain Wheel Hub Bearing assemblies, part number HB5Z-1104-C, incorrectly listed as being for installation on the rear axles of 2011-2017 Ford Explorer 4X2 vehicles. These bearings assemblies were manufactured without a self retention feature, possibly resulting in the separation of the wheel or wheel end.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Recall Date: Aug 28, 2017
Ford Motor Company
Safety Issue:
Ford Motor Company (Ford) is recalling certain model year 2016 Ford Explorer and F-150 vehicles equipped with a manual recline driver's seat. The seat back frame may have insufficient welds which may not meet the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Mfg Campaign: 16C11
Recall Date: Jun 28, 2016
Ford Motor Company
Safety Issue:
Ford Motor Company (Ford) is recalling certain model year 2015-2016 Lincoln MKC vehicles manufactured November 25, 2013, to January 25, 2016, and 2016 Ford Explorer vehicles manufactured October 20, 2014, to January 28, 2016. The affected vehicles are equipped with 2.3L GTDI engines and engine block heaters. These engine block heaters have elements that may overheat while plugged in.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Mfg Campaign: 16S14
Recall Date: Mar 31, 2016
Ford Motor Company
Safety Issue:
Ford Motor Company (Ford) is recalling certain model year 2015 Ford Taurus, Lincoln MKS, and 2016 Ford Explorer vehicles manufactured on July 24, 2015. During vehicle production, the fuel tank attachment bolts may not have been properly tightened. As a result, the fuel tank straps may fracture and the fuel tank could separate from the vehicle.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Mfg Campaign: 15S26
Recall Date: Sep 28, 2015
Ford Motor Company
Safety Issue:
Ford Motor Company (Ford) is recalling certain model year 2015 Ford Taurus, Ford Flex, and Lincoln MKS vehicles manufactured May 4, 2015, to May 23, 2015, Lincoln MKT vehicles manufactured May 4, 2015, to May 21, 2015, and 2015-2016 Ford Explorer vehicles manufactured May 4, 2015, to May 23, 2015. The affected vehicles have a parking brake that may not fully engage when applied. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 135, "Light Vehicle Brake Systems."
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Mfg Campaign: 15C07
Recall Date: Jul 24, 2015
Consumer Complaints
2.8K ComplaintsFord Motor Company
Defect Description:
VISIBILITY/WIPER
Potential Consequences:
Trim around windshield becomes loose on highway and rattles against windshield and rubber seals have started coming loose
Corrective Action:
Trim around windshield becomes loose on highway and rattles against windshield and rubber seals have started coming loose
Additional Notes:
Trim around windshield becomes loose on highway and rattles against windshield and rubber seals have started coming loose
Mfg Campaign: 11595583
Recall Date: Jun 20, 2024
Ford Motor Company
Defect Description:
STRUCTURE
Potential Consequences:
The contact owns a 2016 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while the vehicle was parked, she became aware that the A-pillar trim was missing. The contact stated that a couple months later the rubber gasket on the driver’s side had flown off. The dealer was made aware of the failure but confirmed that parts were not yet available and advised the contact to call the NHTSA Hotline. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 101,000. VIN tool confirms parts not available.
Corrective Action:
The contact owns a 2016 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while the vehicle was parked, she became aware that the A-pillar trim was missing. The contact stated that a couple months later the rubber gasket on the driver’s side had flown off. The dealer was made aware of the failure but confirmed that parts were not yet available and advised the contact to call the NHTSA Hotline. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 101,000. VIN tool confirms parts not available.
Additional Notes:
The contact owns a 2016 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while the vehicle was parked, she became aware that the A-pillar trim was missing. The contact stated that a couple months later the rubber gasket on the driver’s side had flown off. The dealer was made aware of the failure but confirmed that parts were not yet available and advised the contact to call the NHTSA Hotline. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 101,000. VIN tool confirms parts not available.
Mfg Campaign: 11595077
Recall Date: Jun 18, 2024
Ford Motor Company
Defect Description:
ENGINE AND ENGINE COOLING
Potential Consequences:
The contact owns a 2016 Ford Explorer. The contact stated that while her husband was driving at an undisclosed speed, the temperature gauge started to indicate that the engine was overheating, prompting him to pull over to the shoulder of the roadway to allow the engine to cool down. No warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the water pump. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 98,000.
Corrective Action:
The contact owns a 2016 Ford Explorer. The contact stated that while her husband was driving at an undisclosed speed, the temperature gauge started to indicate that the engine was overheating, prompting him to pull over to the shoulder of the roadway to allow the engine to cool down. No warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the water pump. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 98,000.
Additional Notes:
The contact owns a 2016 Ford Explorer. The contact stated that while her husband was driving at an undisclosed speed, the temperature gauge started to indicate that the engine was overheating, prompting him to pull over to the shoulder of the roadway to allow the engine to cool down. No warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the water pump. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 98,000.
Mfg Campaign: 11594922
Recall Date: Jun 17, 2024
Ford Motor Company
Defect Description:
STRUCTURE
Potential Consequences:
The contact owns a 2016 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated while driving 65 MPH, the outer structure of the A-Pilar trim detached from the vehicle. The dealer was made aware of the failure but confirmed that parts were not yet available. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 82,500. VIN tool confirms parts not available.
Corrective Action:
The contact owns a 2016 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated while driving 65 MPH, the outer structure of the A-Pilar trim detached from the vehicle. The dealer was made aware of the failure but confirmed that parts were not yet available. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 82,500. VIN tool confirms parts not available.
Additional Notes:
The contact owns a 2016 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated while driving 65 MPH, the outer structure of the A-Pilar trim detached from the vehicle. The dealer was made aware of the failure but confirmed that parts were not yet available. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 82,500. VIN tool confirms parts not available.
Mfg Campaign: 11594359
Recall Date: Jun 14, 2024
Ford Motor Company
Defect Description:
ENGINE AND ENGINE COOLING
Potential Consequences:
The contact owns a 2016 Ford Explorer. The contact stated that while driving at an undisclosed speed, the temperature gauge indicated that the engine was overheating, prompting the contact to pull over to the shoulder of the roadway. After a visual inspection, the contact observed that the coolant reservoir was empty. The overheating warning light was illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the water pump. The vehicle was repaired. The manufacturer was not notified of the failure. The failure mileage was 78,000.
Corrective Action:
The contact owns a 2016 Ford Explorer. The contact stated that while driving at an undisclosed speed, the temperature gauge indicated that the engine was overheating, prompting the contact to pull over to the shoulder of the roadway. After a visual inspection, the contact observed that the coolant reservoir was empty. The overheating warning light was illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the water pump. The vehicle was repaired. The manufacturer was not notified of the failure. The failure mileage was 78,000.
Additional Notes:
The contact owns a 2016 Ford Explorer. The contact stated that while driving at an undisclosed speed, the temperature gauge indicated that the engine was overheating, prompting the contact to pull over to the shoulder of the roadway. After a visual inspection, the contact observed that the coolant reservoir was empty. The overheating warning light was illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the water pump. The vehicle was repaired. The manufacturer was not notified of the failure. The failure mileage was 78,000.
Mfg Campaign: 11594247
Recall Date: Jun 13, 2024
Ford Motor Company
Defect Description:
POWER TRAIN
Potential Consequences:
The contact owns a 2016 Ford Explorer. The contact stated while driving 25 MPH, the vehicle failed to exceed 25 MPH or shift out of 1st gear. Additionally, the contact stated that while shifting to reverse(R), the vehicle failed to respond as needed. There was no warning light illuminated. The contact stated that the failure had been recurring. The vehicle was taken to the dealer, where it was diagnosed that the transmission had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 56,000.
Corrective Action:
The contact owns a 2016 Ford Explorer. The contact stated while driving 25 MPH, the vehicle failed to exceed 25 MPH or shift out of 1st gear. Additionally, the contact stated that while shifting to reverse(R), the vehicle failed to respond as needed. There was no warning light illuminated. The contact stated that the failure had been recurring. The vehicle was taken to the dealer, where it was diagnosed that the transmission had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 56,000.
Additional Notes:
The contact owns a 2016 Ford Explorer. The contact stated while driving 25 MPH, the vehicle failed to exceed 25 MPH or shift out of 1st gear. Additionally, the contact stated that while shifting to reverse(R), the vehicle failed to respond as needed. There was no warning light illuminated. The contact stated that the failure had been recurring. The vehicle was taken to the dealer, where it was diagnosed that the transmission had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 56,000.
Mfg Campaign: 11593845
Recall Date: Jun 12, 2024
Ford Motor Company
Defect Description:
STRUCTURE
Potential Consequences:
The contact owns a 2016 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure). The contact stated that while the vehicle was parked, the contact observed pieces of rubber on both the driver’s and passenger’s sides were deteriorating. The vehicle was taken to a dealer where it was diagnosed that the exterior A-Pillar trim needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 95,000.
Corrective Action:
The contact owns a 2016 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure). The contact stated that while the vehicle was parked, the contact observed pieces of rubber on both the driver’s and passenger’s sides were deteriorating. The vehicle was taken to a dealer where it was diagnosed that the exterior A-Pillar trim needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 95,000.
Additional Notes:
The contact owns a 2016 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure). The contact stated that while the vehicle was parked, the contact observed pieces of rubber on both the driver’s and passenger’s sides were deteriorating. The vehicle was taken to a dealer where it was diagnosed that the exterior A-Pillar trim needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 95,000.
Mfg Campaign: 11593855
Recall Date: Jun 12, 2024
Ford Motor Company
Defect Description:
STRUCTURE:BODY
Potential Consequences:
trim piece flying off while the vehicle was in motion with traffic around me.
Corrective Action:
trim piece flying off while the vehicle was in motion with traffic around me.
Additional Notes:
trim piece flying off while the vehicle was in motion with traffic around me.
Mfg Campaign: 11593713
Recall Date: Jun 11, 2024
Ford Motor Company
Defect Description:
ENGINE
Potential Consequences:
water pump failure at 60K miles on a 2016 ford explorer, this model has the most reported water pump failures on record. this is a 15 hour repair job at the dealer, and the same complaint litters the internet. The failure on my vehicle was confirmed by dealer, $4k to fix. Not to mention the mess in my driveway where the coolant expelled without notice. If I drive it, the engine will be damaged, and there goes my car. In 2020 NY and MI class action lawsuits over this issue were settled & closed WITH payment to plaintiffs, yet no recall. WHY? too expensive for Ford? We see safety recall on clips yet nothing on an admitted engine problem than causes stalling or engine damage while running? There's a class action in Canada. Ford is dodging a known defect. Please do something about this.
Corrective Action:
water pump failure at 60K miles on a 2016 ford explorer, this model has the most reported water pump failures on record. this is a 15 hour repair job at the dealer, and the same complaint litters the internet. The failure on my vehicle was confirmed by dealer, $4k to fix. Not to mention the mess in my driveway where the coolant expelled without notice. If I drive it, the engine will be damaged, and there goes my car. In 2020 NY and MI class action lawsuits over this issue were settled & closed WITH payment to plaintiffs, yet no recall. WHY? too expensive for Ford? We see safety recall on clips yet nothing on an admitted engine problem than causes stalling or engine damage while running? There's a class action in Canada. Ford is dodging a known defect. Please do something about this.
Additional Notes:
water pump failure at 60K miles on a 2016 ford explorer, this model has the most reported water pump failures on record. this is a 15 hour repair job at the dealer, and the same complaint litters the internet. The failure on my vehicle was confirmed by dealer, $4k to fix. Not to mention the mess in my driveway where the coolant expelled without notice. If I drive it, the engine will be damaged, and there goes my car. In 2020 NY and MI class action lawsuits over this issue were settled & closed WITH payment to plaintiffs, yet no recall. WHY? too expensive for Ford? We see safety recall on clips yet nothing on an admitted engine problem than causes stalling or engine damage while running? There's a class action in Canada. Ford is dodging a known defect. Please do something about this.
Mfg Campaign: 11593760
Recall Date: Jun 11, 2024
Ford Motor Company
Defect Description:
STRUCTURE
Potential Consequences:
The contact owns a 2016 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while driving at an undisclosed speed, the front driver's door trim panel detached, and the keyless entry keypad wiring became exposed. The "Door Ajar" message was displayed. The failure prevented the rear liftgate from opening as needed. The dealer was made aware of the failure but confirmed that parts were not yet available. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was 66,205. VIN tool confirms parts not available.
Corrective Action:
The contact owns a 2016 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while driving at an undisclosed speed, the front driver's door trim panel detached, and the keyless entry keypad wiring became exposed. The "Door Ajar" message was displayed. The failure prevented the rear liftgate from opening as needed. The dealer was made aware of the failure but confirmed that parts were not yet available. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was 66,205. VIN tool confirms parts not available.
Additional Notes:
The contact owns a 2016 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while driving at an undisclosed speed, the front driver's door trim panel detached, and the keyless entry keypad wiring became exposed. The "Door Ajar" message was displayed. The failure prevented the rear liftgate from opening as needed. The dealer was made aware of the failure but confirmed that parts were not yet available. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was 66,205. VIN tool confirms parts not available.
Mfg Campaign: 11593360
Recall Date: Jun 10, 2024
Ford Motor Company
Defect Description:
STRUCTURE
Potential Consequences:
The contact owns a 2016 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while driving at an undisclosed speed, the passenger's side front windshield trim detached and flew off. In addition, the driver's front side windshield trim had also detached. The dealer was made aware of the failure but confirmed that parts were not yet available. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 149,000. VIN tool confirms parts not available.
Corrective Action:
The contact owns a 2016 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while driving at an undisclosed speed, the passenger's side front windshield trim detached and flew off. In addition, the driver's front side windshield trim had also detached. The dealer was made aware of the failure but confirmed that parts were not yet available. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 149,000. VIN tool confirms parts not available.
Additional Notes:
The contact owns a 2016 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while driving at an undisclosed speed, the passenger's side front windshield trim detached and flew off. In addition, the driver's front side windshield trim had also detached. The dealer was made aware of the failure but confirmed that parts were not yet available. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 149,000. VIN tool confirms parts not available.
Mfg Campaign: 11593535
Recall Date: Jun 10, 2024
Ford Motor Company
Defect Description:
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CATALYTIC CONVERTOR
Potential Consequences:
Check engine light came on. Took it to the shop and found out that the Cadillac converter needs to be replaced which will be more than 2000.00. I found that there was a recall in 2021 for the same problem.
Corrective Action:
Check engine light came on. Took it to the shop and found out that the Cadillac converter needs to be replaced which will be more than 2000.00. I found that there was a recall in 2021 for the same problem.
Additional Notes:
Check engine light came on. Took it to the shop and found out that the Cadillac converter needs to be replaced which will be more than 2000.00. I found that there was a recall in 2021 for the same problem.
Mfg Campaign: 11592995
Recall Date: Jun 7, 2024
Ford Motor Company
Defect Description:
FUEL/PROPULSION SYSTEM
Potential Consequences:
The power transfer unit is broken. Symptoms are vehicle shuddering, vehicle sounds like it is going to stall. This could cause a major accident at any moment.
Corrective Action:
The power transfer unit is broken. Symptoms are vehicle shuddering, vehicle sounds like it is going to stall. This could cause a major accident at any moment.
Additional Notes:
The power transfer unit is broken. Symptoms are vehicle shuddering, vehicle sounds like it is going to stall. This could cause a major accident at any moment.
Mfg Campaign: 11592838
Recall Date: Jun 6, 2024
Ford Motor Company
Defect Description:
POWER TRAIN
Potential Consequences:
The power transfer unit is broken. Symptoms are vehicle shuddering, vehicle sounds like it is going to stall. This could cause a major accident at any moment.
Corrective Action:
The power transfer unit is broken. Symptoms are vehicle shuddering, vehicle sounds like it is going to stall. This could cause a major accident at any moment.
Additional Notes:
The power transfer unit is broken. Symptoms are vehicle shuddering, vehicle sounds like it is going to stall. This could cause a major accident at any moment.
Mfg Campaign: 11592838
Recall Date: Jun 6, 2024
Ford Motor Company
Defect Description:
ENGINE
Potential Consequences:
The power transfer unit is broken. Symptoms are vehicle shuddering, vehicle sounds like it is going to stall. This could cause a major accident at any moment.
Corrective Action:
The power transfer unit is broken. Symptoms are vehicle shuddering, vehicle sounds like it is going to stall. This could cause a major accident at any moment.
Additional Notes:
The power transfer unit is broken. Symptoms are vehicle shuddering, vehicle sounds like it is going to stall. This could cause a major accident at any moment.
Mfg Campaign: 11592838
Recall Date: Jun 6, 2024
Ford Motor Company
Defect Description:
STRUCTURE
Potential Consequences:
The contact owns a 2016 Ford Explorer. The contact stated while driving 60 MPH, the passenger’s side glove box console detached. There was no warning light illuminated. The vehicle was taken to the dealer but was not diagnosed. The contact was informed that the glove box console needed to be replaced. The vehicle was not repaired. The contact was concerned that he could have been involved in an accident or severely injured due to failure. The manufacturer was not made aware of the failure. The failure mileage was approximately 80,000.
Corrective Action:
The contact owns a 2016 Ford Explorer. The contact stated while driving 60 MPH, the passenger’s side glove box console detached. There was no warning light illuminated. The vehicle was taken to the dealer but was not diagnosed. The contact was informed that the glove box console needed to be replaced. The vehicle was not repaired. The contact was concerned that he could have been involved in an accident or severely injured due to failure. The manufacturer was not made aware of the failure. The failure mileage was approximately 80,000.
Additional Notes:
The contact owns a 2016 Ford Explorer. The contact stated while driving 60 MPH, the passenger’s side glove box console detached. There was no warning light illuminated. The vehicle was taken to the dealer but was not diagnosed. The contact was informed that the glove box console needed to be replaced. The vehicle was not repaired. The contact was concerned that he could have been involved in an accident or severely injured due to failure. The manufacturer was not made aware of the failure. The failure mileage was approximately 80,000.
Mfg Campaign: 11592850
Recall Date: Jun 6, 2024
Ford Motor Company
Defect Description:
ELECTRICAL SYSTEM:ADAS:PARKING ASSIST:SENSORS
Potential Consequences:
The contact owns a 2016 Ford Explorer. The contact stated that while making left and right turns on several occasions at various speeds, the parking assist warning light illuminated, and the steering wheel became stiff. The vehicle was taken to an independent mechanic where it was diagnosed that the rack and pinion needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 122,312.
Corrective Action:
The contact owns a 2016 Ford Explorer. The contact stated that while making left and right turns on several occasions at various speeds, the parking assist warning light illuminated, and the steering wheel became stiff. The vehicle was taken to an independent mechanic where it was diagnosed that the rack and pinion needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 122,312.
Additional Notes:
The contact owns a 2016 Ford Explorer. The contact stated that while making left and right turns on several occasions at various speeds, the parking assist warning light illuminated, and the steering wheel became stiff. The vehicle was taken to an independent mechanic where it was diagnosed that the rack and pinion needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 122,312.
Mfg Campaign: 11592895
Recall Date: Jun 6, 2024
Ford Motor Company
Defect Description:
STEERING:RACK AND PINION
Potential Consequences:
The contact owns a 2016 Ford Explorer. The contact stated that while making left and right turns on several occasions at various speeds, the parking assist warning light illuminated, and the steering wheel became stiff. The vehicle was taken to an independent mechanic where it was diagnosed that the rack and pinion needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 122,312.
Corrective Action:
The contact owns a 2016 Ford Explorer. The contact stated that while making left and right turns on several occasions at various speeds, the parking assist warning light illuminated, and the steering wheel became stiff. The vehicle was taken to an independent mechanic where it was diagnosed that the rack and pinion needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 122,312.
Additional Notes:
The contact owns a 2016 Ford Explorer. The contact stated that while making left and right turns on several occasions at various speeds, the parking assist warning light illuminated, and the steering wheel became stiff. The vehicle was taken to an independent mechanic where it was diagnosed that the rack and pinion needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 122,312.
Mfg Campaign: 11592895
Recall Date: Jun 6, 2024
Ford Motor Company
Defect Description:
STEERING
Potential Consequences:
Steering started grinding in the winter months around 110,900 and locked up while driving. Took to Ford Service and the Rack and Pinion is faulty. The tech said it was not due to any driving damage, but a faulty part. Vehicle currently has 120,000 miles on it and locks up driving down the road. The potential for a dangerous accident is high. This is a known issue for Ford Explorers in various years and Ford should recall this.
Corrective Action:
Steering started grinding in the winter months around 110,900 and locked up while driving. Took to Ford Service and the Rack and Pinion is faulty. The tech said it was not due to any driving damage, but a faulty part. Vehicle currently has 120,000 miles on it and locks up driving down the road. The potential for a dangerous accident is high. This is a known issue for Ford Explorers in various years and Ford should recall this.
Additional Notes:
Steering started grinding in the winter months around 110,900 and locked up while driving. Took to Ford Service and the Rack and Pinion is faulty. The tech said it was not due to any driving damage, but a faulty part. Vehicle currently has 120,000 miles on it and locks up driving down the road. The potential for a dangerous accident is high. This is a known issue for Ford Explorers in various years and Ford should recall this.
Mfg Campaign: 11592624
Recall Date: Jun 5, 2024
Ford Motor Company
Defect Description:
STRUCTURE:BODY
Potential Consequences:
Trim on driver side windshield flew off while driving. ordered Replacement, 2 weeks after i replaced the driver side the passenger side has fallen off while driving. I have not yet ordered the passenger side yet but today while driving home down the interstate the driver side that was just replaced less than 30 days ago flew off again. Being on the interstate it hit my windshield and flew over and hit a truck traveling behind me who swerved I do not know if it did any damage to his vehicle neither of us stopped ( We were on the interstate but I did notice he swerved luckily did not hit any other vehicle. However now I am hearing a whistling I just got home to do some research and see this is in an ongoing issue but what do I do? order and replace again this will be 3 sets in less than 60 days. this site says there is not a known fix yet?
Corrective Action:
Trim on driver side windshield flew off while driving. ordered Replacement, 2 weeks after i replaced the driver side the passenger side has fallen off while driving. I have not yet ordered the passenger side yet but today while driving home down the interstate the driver side that was just replaced less than 30 days ago flew off again. Being on the interstate it hit my windshield and flew over and hit a truck traveling behind me who swerved I do not know if it did any damage to his vehicle neither of us stopped ( We were on the interstate but I did notice he swerved luckily did not hit any other vehicle. However now I am hearing a whistling I just got home to do some research and see this is in an ongoing issue but what do I do? order and replace again this will be 3 sets in less than 60 days. this site says there is not a known fix yet?
Additional Notes:
Trim on driver side windshield flew off while driving. ordered Replacement, 2 weeks after i replaced the driver side the passenger side has fallen off while driving. I have not yet ordered the passenger side yet but today while driving home down the interstate the driver side that was just replaced less than 30 days ago flew off again. Being on the interstate it hit my windshield and flew over and hit a truck traveling behind me who swerved I do not know if it did any damage to his vehicle neither of us stopped ( We were on the interstate but I did notice he swerved luckily did not hit any other vehicle. However now I am hearing a whistling I just got home to do some research and see this is in an ongoing issue but what do I do? order and replace again this will be 3 sets in less than 60 days. this site says there is not a known fix yet?
Mfg Campaign: 11592726
Recall Date: Jun 5, 2024
Need Legal Help?
Featured Attorneys
Barry Edzant
Edzant Price LLC
Valencia, CA • 36 yrs
Focus: Lemon Law, Personal Injury