Complaints & Recalls
Official Safety Recalls - Important!
1 RecallThese are official manufacturer recalls ordered by NHTSA for safety defects. If you own this vehicle, contact your dealer immediately for free repairs.
Bmw Of North America, Llc
Safety Issue:
BMW of North America, LLC (BMW) is recalling certain 2018 430i, 430i xDrive, 440i, 440i xDrive, and M4 convertible vehicles. The Emergency Locking Retractors (ELR) within the front seat belt assemblies may have been produced with incompatible vehicle-sensitive locking mechanism housings.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Recall Date: Aug 16, 2017
Consumer Complaints
39 ComplaintsBmw Of North America, Llc
Defect Description:
SEAT BELTS
Potential Consequences:
Seatbelt alert pops up and noise sounds even when seatbelt is already buckled
Corrective Action:
Seatbelt alert pops up and noise sounds even when seatbelt is already buckled
Additional Notes:
Seatbelt alert pops up and noise sounds even when seatbelt is already buckled
Mfg Campaign: 11656217
Recall Date: Apr 23, 2025
Bmw Of North America, Llc
Defect Description:
ENGINE AND ENGINE COOLING
Potential Consequences:
The contact owns a 2018 BMW 430I. The contact stated that while the vehicle was parked, the contact discovered that there was an unknown liquid leaking underneath the vehicle. The coolant warning light was illuminated. The vehicle was taken to a dealer, where it was diagnosed that there was a leak in the water pump and that the water pump needed to be replaced. The contact researched and became aware of NHTSA Campaign Number: 24V608000 (Engine and Engine Cooling; Electrical System); however, the VIN was not included. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 74,000.
Corrective Action:
The contact owns a 2018 BMW 430I. The contact stated that while the vehicle was parked, the contact discovered that there was an unknown liquid leaking underneath the vehicle. The coolant warning light was illuminated. The vehicle was taken to a dealer, where it was diagnosed that there was a leak in the water pump and that the water pump needed to be replaced. The contact researched and became aware of NHTSA Campaign Number: 24V608000 (Engine and Engine Cooling; Electrical System); however, the VIN was not included. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 74,000.
Additional Notes:
The contact owns a 2018 BMW 430I. The contact stated that while the vehicle was parked, the contact discovered that there was an unknown liquid leaking underneath the vehicle. The coolant warning light was illuminated. The vehicle was taken to a dealer, where it was diagnosed that there was a leak in the water pump and that the water pump needed to be replaced. The contact researched and became aware of NHTSA Campaign Number: 24V608000 (Engine and Engine Cooling; Electrical System); however, the VIN was not included. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 74,000.
Mfg Campaign: 11649102
Recall Date: Mar 18, 2025
Bmw Of North America, Llc
Defect Description:
ELECTRICAL SYSTEM
Potential Consequences:
The contact owns a 2018 BMW 430I. The contact stated that while the vehicle was parked, the contact discovered that there was an unknown liquid leaking underneath the vehicle. The coolant warning light was illuminated. The vehicle was taken to a dealer, where it was diagnosed that there was a leak in the water pump and that the water pump needed to be replaced. The contact researched and became aware of NHTSA Campaign Number: 24V608000 (Engine and Engine Cooling; Electrical System); however, the VIN was not included. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 74,000.
Corrective Action:
The contact owns a 2018 BMW 430I. The contact stated that while the vehicle was parked, the contact discovered that there was an unknown liquid leaking underneath the vehicle. The coolant warning light was illuminated. The vehicle was taken to a dealer, where it was diagnosed that there was a leak in the water pump and that the water pump needed to be replaced. The contact researched and became aware of NHTSA Campaign Number: 24V608000 (Engine and Engine Cooling; Electrical System); however, the VIN was not included. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 74,000.
Additional Notes:
The contact owns a 2018 BMW 430I. The contact stated that while the vehicle was parked, the contact discovered that there was an unknown liquid leaking underneath the vehicle. The coolant warning light was illuminated. The vehicle was taken to a dealer, where it was diagnosed that there was a leak in the water pump and that the water pump needed to be replaced. The contact researched and became aware of NHTSA Campaign Number: 24V608000 (Engine and Engine Cooling; Electrical System); however, the VIN was not included. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 74,000.
Mfg Campaign: 11649102
Recall Date: Mar 18, 2025
Bmw Of North America, Llc
Defect Description:
ENGINE AND ENGINE COOLING
Potential Consequences:
The contact owns a 2018 BMW 430I. The contact stated while driving at an undisclosed speed, the vehicle lost motive power. The vehicle was restarted; however, the failure persisted. The vehicle was driven to a local parking lot and then to the residence. The vehicle was later towed to the dealer where it was diagnosed with coolant pump failure. The contact was informed that the coolant pump needed to be replaced. The vehicle was not repaired. In addition, the contact stated that the coolant pump was previously replaced and covered under an unknown recall repair a year prior to the failure. The manufacturer was made aware of the failure but provided no assistance. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was unknown.
Corrective Action:
The contact owns a 2018 BMW 430I. The contact stated while driving at an undisclosed speed, the vehicle lost motive power. The vehicle was restarted; however, the failure persisted. The vehicle was driven to a local parking lot and then to the residence. The vehicle was later towed to the dealer where it was diagnosed with coolant pump failure. The contact was informed that the coolant pump needed to be replaced. The vehicle was not repaired. In addition, the contact stated that the coolant pump was previously replaced and covered under an unknown recall repair a year prior to the failure. The manufacturer was made aware of the failure but provided no assistance. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was unknown.
Additional Notes:
The contact owns a 2018 BMW 430I. The contact stated while driving at an undisclosed speed, the vehicle lost motive power. The vehicle was restarted; however, the failure persisted. The vehicle was driven to a local parking lot and then to the residence. The vehicle was later towed to the dealer where it was diagnosed with coolant pump failure. The contact was informed that the coolant pump needed to be replaced. The vehicle was not repaired. In addition, the contact stated that the coolant pump was previously replaced and covered under an unknown recall repair a year prior to the failure. The manufacturer was made aware of the failure but provided no assistance. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was unknown.
Mfg Campaign: 11636564
Recall Date: Jan 17, 2025
Bmw Of North America, Llc
Defect Description:
SERVICE BRAKES
Potential Consequences:
I pulled out onto Southside Blvd. My brakes failed, my driver’s front of the car hit a Waste Management garbage truck right back tire and cut the sidewall of the tire. The engine was racing, the truck pulled off the road, and I had sudden unintended acceleration. I immediately turned into a strip center and my car was racing through the strip center, the brakes were not working, the car controls were not working, and I turned the ignition switch off and the car stopped. The car had to be towed. Presently my insurance company has issued an estimate to repair the cosmetic issues, but not the mechanical issues.
Corrective Action:
I pulled out onto Southside Blvd. My brakes failed, my driver’s front of the car hit a Waste Management garbage truck right back tire and cut the sidewall of the tire. The engine was racing, the truck pulled off the road, and I had sudden unintended acceleration. I immediately turned into a strip center and my car was racing through the strip center, the brakes were not working, the car controls were not working, and I turned the ignition switch off and the car stopped. The car had to be towed. Presently my insurance company has issued an estimate to repair the cosmetic issues, but not the mechanical issues.
Additional Notes:
I pulled out onto Southside Blvd. My brakes failed, my driver’s front of the car hit a Waste Management garbage truck right back tire and cut the sidewall of the tire. The engine was racing, the truck pulled off the road, and I had sudden unintended acceleration. I immediately turned into a strip center and my car was racing through the strip center, the brakes were not working, the car controls were not working, and I turned the ignition switch off and the car stopped. The car had to be towed. Presently my insurance company has issued an estimate to repair the cosmetic issues, but not the mechanical issues.
Mfg Campaign: 11630502
Recall Date: Dec 13, 2024
Bmw Of North America, Llc
Defect Description:
ELECTRICAL SYSTEM
Potential Consequences:
I pulled out onto Southside Blvd. My brakes failed, my driver’s front of the car hit a Waste Management garbage truck right back tire and cut the sidewall of the tire. The engine was racing, the truck pulled off the road, and I had sudden unintended acceleration. I immediately turned into a strip center and my car was racing through the strip center, the brakes were not working, the car controls were not working, and I turned the ignition switch off and the car stopped. The car had to be towed. Presently my insurance company has issued an estimate to repair the cosmetic issues, but not the mechanical issues.
Corrective Action:
I pulled out onto Southside Blvd. My brakes failed, my driver’s front of the car hit a Waste Management garbage truck right back tire and cut the sidewall of the tire. The engine was racing, the truck pulled off the road, and I had sudden unintended acceleration. I immediately turned into a strip center and my car was racing through the strip center, the brakes were not working, the car controls were not working, and I turned the ignition switch off and the car stopped. The car had to be towed. Presently my insurance company has issued an estimate to repair the cosmetic issues, but not the mechanical issues.
Additional Notes:
I pulled out onto Southside Blvd. My brakes failed, my driver’s front of the car hit a Waste Management garbage truck right back tire and cut the sidewall of the tire. The engine was racing, the truck pulled off the road, and I had sudden unintended acceleration. I immediately turned into a strip center and my car was racing through the strip center, the brakes were not working, the car controls were not working, and I turned the ignition switch off and the car stopped. The car had to be towed. Presently my insurance company has issued an estimate to repair the cosmetic issues, but not the mechanical issues.
Mfg Campaign: 11630502
Recall Date: Dec 13, 2024
Bmw Of North America, Llc
Defect Description:
ENGINE
Potential Consequences:
I pulled out onto Southside Blvd. My brakes failed, my driver’s front of the car hit a Waste Management garbage truck right back tire and cut the sidewall of the tire. The engine was racing, the truck pulled off the road, and I had sudden unintended acceleration. I immediately turned into a strip center and my car was racing through the strip center, the brakes were not working, the car controls were not working, and I turned the ignition switch off and the car stopped. The car had to be towed. Presently my insurance company has issued an estimate to repair the cosmetic issues, but not the mechanical issues.
Corrective Action:
I pulled out onto Southside Blvd. My brakes failed, my driver’s front of the car hit a Waste Management garbage truck right back tire and cut the sidewall of the tire. The engine was racing, the truck pulled off the road, and I had sudden unintended acceleration. I immediately turned into a strip center and my car was racing through the strip center, the brakes were not working, the car controls were not working, and I turned the ignition switch off and the car stopped. The car had to be towed. Presently my insurance company has issued an estimate to repair the cosmetic issues, but not the mechanical issues.
Additional Notes:
I pulled out onto Southside Blvd. My brakes failed, my driver’s front of the car hit a Waste Management garbage truck right back tire and cut the sidewall of the tire. The engine was racing, the truck pulled off the road, and I had sudden unintended acceleration. I immediately turned into a strip center and my car was racing through the strip center, the brakes were not working, the car controls were not working, and I turned the ignition switch off and the car stopped. The car had to be towed. Presently my insurance company has issued an estimate to repair the cosmetic issues, but not the mechanical issues.
Mfg Campaign: 11630502
Recall Date: Dec 13, 2024
Bmw Of North America, Llc
Defect Description:
ENGINE AND ENGINE COOLING
Potential Consequences:
The contact owns a 2018 BMW 430I. The contact stated while driving at an undisclosed speed, the engine started overheating with the low coolant warning light illuminated. The contact parked and left the vehicle at a local dealer. The dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure and confirmed that the VIN was not included in SIB: 17 01 21 (Service Action: Replace the Coolant Vent Line on the Cylinder Head) and referred the contact to the NHTSA Hotline for assistance. The approximate failure mileage was 80,769.
Corrective Action:
The contact owns a 2018 BMW 430I. The contact stated while driving at an undisclosed speed, the engine started overheating with the low coolant warning light illuminated. The contact parked and left the vehicle at a local dealer. The dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure and confirmed that the VIN was not included in SIB: 17 01 21 (Service Action: Replace the Coolant Vent Line on the Cylinder Head) and referred the contact to the NHTSA Hotline for assistance. The approximate failure mileage was 80,769.
Additional Notes:
The contact owns a 2018 BMW 430I. The contact stated while driving at an undisclosed speed, the engine started overheating with the low coolant warning light illuminated. The contact parked and left the vehicle at a local dealer. The dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure and confirmed that the VIN was not included in SIB: 17 01 21 (Service Action: Replace the Coolant Vent Line on the Cylinder Head) and referred the contact to the NHTSA Hotline for assistance. The approximate failure mileage was 80,769.
Mfg Campaign: 11629099
Recall Date: Dec 5, 2024
Bmw Of North America, Llc
Defect Description:
SEATS
Potential Consequences:
Front driver seat , keep sliding when u hit on breaks on the left legs where seat controls are located the balance between right thigh and left thigh is not well measured so becomes increasingly uncomfortable when thicker person driving the car, could cause an accident and risky, Engine problem - so many coolant leak which has cost me over 6000 dollars to repair and yet Still leaking, when I switch to spot mode this coolant overheat and thrn Another leaking, switch to sports plus more coolant leak Second the seat belt holder, a system is design to hand over the seat belt when doors close the that holder keep missing the seat belt or couldn’t drag it to you I’ve seen this in many of the bmw Another incident I notice when you reverse there’s crack or skip between the tires u could feel it like car is shaking reversing especially when wheel turn all the to the end
Corrective Action:
Front driver seat , keep sliding when u hit on breaks on the left legs where seat controls are located the balance between right thigh and left thigh is not well measured so becomes increasingly uncomfortable when thicker person driving the car, could cause an accident and risky, Engine problem - so many coolant leak which has cost me over 6000 dollars to repair and yet Still leaking, when I switch to spot mode this coolant overheat and thrn Another leaking, switch to sports plus more coolant leak Second the seat belt holder, a system is design to hand over the seat belt when doors close the that holder keep missing the seat belt or couldn’t drag it to you I’ve seen this in many of the bmw Another incident I notice when you reverse there’s crack or skip between the tires u could feel it like car is shaking reversing especially when wheel turn all the to the end
Additional Notes:
Front driver seat , keep sliding when u hit on breaks on the left legs where seat controls are located the balance between right thigh and left thigh is not well measured so becomes increasingly uncomfortable when thicker person driving the car, could cause an accident and risky, Engine problem - so many coolant leak which has cost me over 6000 dollars to repair and yet Still leaking, when I switch to spot mode this coolant overheat and thrn Another leaking, switch to sports plus more coolant leak Second the seat belt holder, a system is design to hand over the seat belt when doors close the that holder keep missing the seat belt or couldn’t drag it to you I’ve seen this in many of the bmw Another incident I notice when you reverse there’s crack or skip between the tires u could feel it like car is shaking reversing especially when wheel turn all the to the end
Mfg Campaign: 11627063
Recall Date: Nov 24, 2024
Bmw Of North America, Llc
Defect Description:
ENGINE
Potential Consequences:
Front driver seat , keep sliding when u hit on breaks on the left legs where seat controls are located the balance between right thigh and left thigh is not well measured so becomes increasingly uncomfortable when thicker person driving the car, could cause an accident and risky, Engine problem - so many coolant leak which has cost me over 6000 dollars to repair and yet Still leaking, when I switch to spot mode this coolant overheat and thrn Another leaking, switch to sports plus more coolant leak Second the seat belt holder, a system is design to hand over the seat belt when doors close the that holder keep missing the seat belt or couldn’t drag it to you I’ve seen this in many of the bmw Another incident I notice when you reverse there’s crack or skip between the tires u could feel it like car is shaking reversing especially when wheel turn all the to the end
Corrective Action:
Front driver seat , keep sliding when u hit on breaks on the left legs where seat controls are located the balance between right thigh and left thigh is not well measured so becomes increasingly uncomfortable when thicker person driving the car, could cause an accident and risky, Engine problem - so many coolant leak which has cost me over 6000 dollars to repair and yet Still leaking, when I switch to spot mode this coolant overheat and thrn Another leaking, switch to sports plus more coolant leak Second the seat belt holder, a system is design to hand over the seat belt when doors close the that holder keep missing the seat belt or couldn’t drag it to you I’ve seen this in many of the bmw Another incident I notice when you reverse there’s crack or skip between the tires u could feel it like car is shaking reversing especially when wheel turn all the to the end
Additional Notes:
Front driver seat , keep sliding when u hit on breaks on the left legs where seat controls are located the balance between right thigh and left thigh is not well measured so becomes increasingly uncomfortable when thicker person driving the car, could cause an accident and risky, Engine problem - so many coolant leak which has cost me over 6000 dollars to repair and yet Still leaking, when I switch to spot mode this coolant overheat and thrn Another leaking, switch to sports plus more coolant leak Second the seat belt holder, a system is design to hand over the seat belt when doors close the that holder keep missing the seat belt or couldn’t drag it to you I’ve seen this in many of the bmw Another incident I notice when you reverse there’s crack or skip between the tires u could feel it like car is shaking reversing especially when wheel turn all the to the end
Mfg Campaign: 11627063
Recall Date: Nov 24, 2024
Bmw Of North America, Llc
Defect Description:
LANE DEPARTURE: WARNING
Potential Consequences:
Front driver seat , keep sliding when u hit on breaks on the left legs where seat controls are located the balance between right thigh and left thigh is not well measured so becomes increasingly uncomfortable when thicker person driving the car, could cause an accident and risky, Engine problem - so many coolant leak which has cost me over 6000 dollars to repair and yet Still leaking, when I switch to spot mode this coolant overheat and thrn Another leaking, switch to sports plus more coolant leak Second the seat belt holder, a system is design to hand over the seat belt when doors close the that holder keep missing the seat belt or couldn’t drag it to you I’ve seen this in many of the bmw Another incident I notice when you reverse there’s crack or skip between the tires u could feel it like car is shaking reversing especially when wheel turn all the to the end
Corrective Action:
Front driver seat , keep sliding when u hit on breaks on the left legs where seat controls are located the balance between right thigh and left thigh is not well measured so becomes increasingly uncomfortable when thicker person driving the car, could cause an accident and risky, Engine problem - so many coolant leak which has cost me over 6000 dollars to repair and yet Still leaking, when I switch to spot mode this coolant overheat and thrn Another leaking, switch to sports plus more coolant leak Second the seat belt holder, a system is design to hand over the seat belt when doors close the that holder keep missing the seat belt or couldn’t drag it to you I’ve seen this in many of the bmw Another incident I notice when you reverse there’s crack or skip between the tires u could feel it like car is shaking reversing especially when wheel turn all the to the end
Additional Notes:
Front driver seat , keep sliding when u hit on breaks on the left legs where seat controls are located the balance between right thigh and left thigh is not well measured so becomes increasingly uncomfortable when thicker person driving the car, could cause an accident and risky, Engine problem - so many coolant leak which has cost me over 6000 dollars to repair and yet Still leaking, when I switch to spot mode this coolant overheat and thrn Another leaking, switch to sports plus more coolant leak Second the seat belt holder, a system is design to hand over the seat belt when doors close the that holder keep missing the seat belt or couldn’t drag it to you I’ve seen this in many of the bmw Another incident I notice when you reverse there’s crack or skip between the tires u could feel it like car is shaking reversing especially when wheel turn all the to the end
Mfg Campaign: 11627063
Recall Date: Nov 24, 2024
Bmw Of North America, Llc
Defect Description:
ENGINE AND ENGINE COOLING
Potential Consequences:
The contact owns a 2018 BMW 430I. The contact stated that while the dealer was servicing the vehicle, the dealer informed the contact there were several coolant leaks found. The dealer advised the contact to regularly add coolant to the vehicle. Additionally, the contact stated while driving 40-50 MPH, the vehicle experienced reduced power. Several unknown warning lights were illuminated. The messages "Vehicle Engine Heating - Drive Moderately" and "Drivetrain Malfunction" were displayed. The contact noticed a significant amount of smoke coming from underneath the hood and there was smoke inside the cabin of the vehicle. The contact pulled over to the side of the road, turned off and exited the vehicle. The vehicle failed to restart and was towed to the residence. The vehicle was then towed to a Collision Center, where it was inspected. The Collision Center informed the contact that the engine combusted and several parts under the hood had melted. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 75,000.
Corrective Action:
The contact owns a 2018 BMW 430I. The contact stated that while the dealer was servicing the vehicle, the dealer informed the contact there were several coolant leaks found. The dealer advised the contact to regularly add coolant to the vehicle. Additionally, the contact stated while driving 40-50 MPH, the vehicle experienced reduced power. Several unknown warning lights were illuminated. The messages "Vehicle Engine Heating - Drive Moderately" and "Drivetrain Malfunction" were displayed. The contact noticed a significant amount of smoke coming from underneath the hood and there was smoke inside the cabin of the vehicle. The contact pulled over to the side of the road, turned off and exited the vehicle. The vehicle failed to restart and was towed to the residence. The vehicle was then towed to a Collision Center, where it was inspected. The Collision Center informed the contact that the engine combusted and several parts under the hood had melted. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 75,000.
Additional Notes:
The contact owns a 2018 BMW 430I. The contact stated that while the dealer was servicing the vehicle, the dealer informed the contact there were several coolant leaks found. The dealer advised the contact to regularly add coolant to the vehicle. Additionally, the contact stated while driving 40-50 MPH, the vehicle experienced reduced power. Several unknown warning lights were illuminated. The messages "Vehicle Engine Heating - Drive Moderately" and "Drivetrain Malfunction" were displayed. The contact noticed a significant amount of smoke coming from underneath the hood and there was smoke inside the cabin of the vehicle. The contact pulled over to the side of the road, turned off and exited the vehicle. The vehicle failed to restart and was towed to the residence. The vehicle was then towed to a Collision Center, where it was inspected. The Collision Center informed the contact that the engine combusted and several parts under the hood had melted. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 75,000.
Mfg Campaign: 11616045
Recall Date: Sep 23, 2024
Bmw Of North America, Llc
Defect Description:
ENGINE
Potential Consequences:
In Oct 2022, I was driving normally and suddenly got a message on the dash saying something like "Coolant low, please top up when you have a chance". A minute or so later, I got the red warning "Engine Overheated, turn off engine when safe" and it went into limp mode, and I pulled over immediately and had to flatbed my car to a dealer. Then told me there was a coolant leak (which I was not aware and there was no error message regarding coolant prior to the incident.) And they told me there was a recall on my vehicle coolant vent line. Although I had check NHTSA website frequently and did not see anything being recalled. They replaced the coolant vent line for free. Fast forward 21 months and less than 5000 miles later, I brought the car in for oil change. Upon inspection of my vehicle, the technician noticed some fluid seeping through the turbo coolant feed line and there were buildups. Please see video here. [XXX] . They suggested replacing the turbo coolant feed line and turbo return light for $2,500! I mentioned the incident two years ago due to a coolant leak that was being recalled, if this is related. They told me the recall was only the coolant vent line. The issue now is the turbo coolant feed line and return light. And over time, the coolant just "starts to leak on those lines due to its material". This is a 6 year old mildly driven vehicle with 35K miles. How can the coolant line material so bad that it would start to leak after 5+ years? Found some threads online and there were other people having the same issue. The manufacture should have put in some quality coolant lines. There were other recall in other models (18V755) for regarding a coolant leak that may result in an engine fire, which increases the risk of a crash and injury. If the line material of my coolant feed and return line by nature will start to leak after five years, wouldn't it be the manufacture's responsibility to remedy it before it cause safety issue? INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C
Corrective Action:
In Oct 2022, I was driving normally and suddenly got a message on the dash saying something like "Coolant low, please top up when you have a chance". A minute or so later, I got the red warning "Engine Overheated, turn off engine when safe" and it went into limp mode, and I pulled over immediately and had to flatbed my car to a dealer. Then told me there was a coolant leak (which I was not aware and there was no error message regarding coolant prior to the incident.) And they told me there was a recall on my vehicle coolant vent line. Although I had check NHTSA website frequently and did not see anything being recalled. They replaced the coolant vent line for free. Fast forward 21 months and less than 5000 miles later, I brought the car in for oil change. Upon inspection of my vehicle, the technician noticed some fluid seeping through the turbo coolant feed line and there were buildups. Please see video here. [XXX] . They suggested replacing the turbo coolant feed line and turbo return light for $2,500! I mentioned the incident two years ago due to a coolant leak that was being recalled, if this is related. They told me the recall was only the coolant vent line. The issue now is the turbo coolant feed line and return light. And over time, the coolant just "starts to leak on those lines due to its material". This is a 6 year old mildly driven vehicle with 35K miles. How can the coolant line material so bad that it would start to leak after 5+ years? Found some threads online and there were other people having the same issue. The manufacture should have put in some quality coolant lines. There were other recall in other models (18V755) for regarding a coolant leak that may result in an engine fire, which increases the risk of a crash and injury. If the line material of my coolant feed and return line by nature will start to leak after five years, wouldn't it be the manufacture's responsibility to remedy it before it cause safety issue? INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C
Additional Notes:
In Oct 2022, I was driving normally and suddenly got a message on the dash saying something like "Coolant low, please top up when you have a chance". A minute or so later, I got the red warning "Engine Overheated, turn off engine when safe" and it went into limp mode, and I pulled over immediately and had to flatbed my car to a dealer. Then told me there was a coolant leak (which I was not aware and there was no error message regarding coolant prior to the incident.) And they told me there was a recall on my vehicle coolant vent line. Although I had check NHTSA website frequently and did not see anything being recalled. They replaced the coolant vent line for free. Fast forward 21 months and less than 5000 miles later, I brought the car in for oil change. Upon inspection of my vehicle, the technician noticed some fluid seeping through the turbo coolant feed line and there were buildups. Please see video here. [XXX] . They suggested replacing the turbo coolant feed line and turbo return light for $2,500! I mentioned the incident two years ago due to a coolant leak that was being recalled, if this is related. They told me the recall was only the coolant vent line. The issue now is the turbo coolant feed line and return light. And over time, the coolant just "starts to leak on those lines due to its material". This is a 6 year old mildly driven vehicle with 35K miles. How can the coolant line material so bad that it would start to leak after 5+ years? Found some threads online and there were other people having the same issue. The manufacture should have put in some quality coolant lines. There were other recall in other models (18V755) for regarding a coolant leak that may result in an engine fire, which increases the risk of a crash and injury. If the line material of my coolant feed and return line by nature will start to leak after five years, wouldn't it be the manufacture's responsibility to remedy it before it cause safety issue? INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C
Mfg Campaign: 11599543
Recall Date: Jul 6, 2024
Bmw Of North America, Llc
Defect Description:
ENGINE
Potential Consequences:
My BMW 430i 2018showed no warning and suddenly the car started to shake, I stopped immediately and after the car cooled, there was no coolant, the oil temperature gage was always on normal. The car overheated and caused catastrophic engine failure, and need replacement. Upon inspection by several mechanics, its obvious the coolant leak from a hose that connects with engine block
Corrective Action:
My BMW 430i 2018showed no warning and suddenly the car started to shake, I stopped immediately and after the car cooled, there was no coolant, the oil temperature gage was always on normal. The car overheated and caused catastrophic engine failure, and need replacement. Upon inspection by several mechanics, its obvious the coolant leak from a hose that connects with engine block
Additional Notes:
My BMW 430i 2018showed no warning and suddenly the car started to shake, I stopped immediately and after the car cooled, there was no coolant, the oil temperature gage was always on normal. The car overheated and caused catastrophic engine failure, and need replacement. Upon inspection by several mechanics, its obvious the coolant leak from a hose that connects with engine block
Mfg Campaign: 11580162
Recall Date: Mar 29, 2024
Bmw Of North America, Llc
Defect Description:
ENGINE
Potential Consequences:
When I cold started the car it rattled and shook, this stopped and the car was fine to drive. When I was on the road the cars check engine light came on and the car suddenly slowed down. An error popped up saying that there is a “powertrain malfunction”. BMW dealership said that it is a failure in VANOS system. There was a recall on other BMW models expect mine, 2018 BMW 4 series.
Corrective Action:
When I cold started the car it rattled and shook, this stopped and the car was fine to drive. When I was on the road the cars check engine light came on and the car suddenly slowed down. An error popped up saying that there is a “powertrain malfunction”. BMW dealership said that it is a failure in VANOS system. There was a recall on other BMW models expect mine, 2018 BMW 4 series.
Additional Notes:
When I cold started the car it rattled and shook, this stopped and the car was fine to drive. When I was on the road the cars check engine light came on and the car suddenly slowed down. An error popped up saying that there is a “powertrain malfunction”. BMW dealership said that it is a failure in VANOS system. There was a recall on other BMW models expect mine, 2018 BMW 4 series.
Mfg Campaign: 11575651
Recall Date: Mar 5, 2024
Bmw Of North America, Llc
Defect Description:
POWER TRAIN
Potential Consequences:
When I cold started the car it rattled and shook, this stopped and the car was fine to drive. When I was on the road the cars check engine light came on and the car suddenly slowed down. An error popped up saying that there is a “powertrain malfunction”. BMW dealership said that it is a failure in VANOS system. There was a recall on other BMW models expect mine, 2018 BMW 4 series.
Corrective Action:
When I cold started the car it rattled and shook, this stopped and the car was fine to drive. When I was on the road the cars check engine light came on and the car suddenly slowed down. An error popped up saying that there is a “powertrain malfunction”. BMW dealership said that it is a failure in VANOS system. There was a recall on other BMW models expect mine, 2018 BMW 4 series.
Additional Notes:
When I cold started the car it rattled and shook, this stopped and the car was fine to drive. When I was on the road the cars check engine light came on and the car suddenly slowed down. An error popped up saying that there is a “powertrain malfunction”. BMW dealership said that it is a failure in VANOS system. There was a recall on other BMW models expect mine, 2018 BMW 4 series.
Mfg Campaign: 11575651
Recall Date: Mar 5, 2024
Bmw Of North America, Llc
Defect Description:
VEHICLE SPEED CONTROL
Potential Consequences:
When I cold started the car it rattled and shook, this stopped and the car was fine to drive. When I was on the road the cars check engine light came on and the car suddenly slowed down. An error popped up saying that there is a “powertrain malfunction”. BMW dealership said that it is a failure in VANOS system. There was a recall on other BMW models expect mine, 2018 BMW 4 series.
Corrective Action:
When I cold started the car it rattled and shook, this stopped and the car was fine to drive. When I was on the road the cars check engine light came on and the car suddenly slowed down. An error popped up saying that there is a “powertrain malfunction”. BMW dealership said that it is a failure in VANOS system. There was a recall on other BMW models expect mine, 2018 BMW 4 series.
Additional Notes:
When I cold started the car it rattled and shook, this stopped and the car was fine to drive. When I was on the road the cars check engine light came on and the car suddenly slowed down. An error popped up saying that there is a “powertrain malfunction”. BMW dealership said that it is a failure in VANOS system. There was a recall on other BMW models expect mine, 2018 BMW 4 series.
Mfg Campaign: 11575651
Recall Date: Mar 5, 2024
Bmw Of North America, Llc
Defect Description:
ENGINE
Potential Consequences:
CAR WAS ON THE HIGHWAY GOING 80 MILES COOLANT LIGHT CAME ON CAR DROPPED SPEED TO 30 MILES PER HOUR ON ITS OWN
Corrective Action:
CAR WAS ON THE HIGHWAY GOING 80 MILES COOLANT LIGHT CAME ON CAR DROPPED SPEED TO 30 MILES PER HOUR ON ITS OWN
Additional Notes:
CAR WAS ON THE HIGHWAY GOING 80 MILES COOLANT LIGHT CAME ON CAR DROPPED SPEED TO 30 MILES PER HOUR ON ITS OWN
Mfg Campaign: 11570643
Recall Date: Feb 7, 2024
Bmw Of North America, Llc
Defect Description:
FUEL/PROPULSION SYSTEM
Potential Consequences:
CAR WAS ON THE HIGHWAY GOING 80 MILES COOLANT LIGHT CAME ON CAR DROPPED SPEED TO 30 MILES PER HOUR ON ITS OWN
Corrective Action:
CAR WAS ON THE HIGHWAY GOING 80 MILES COOLANT LIGHT CAME ON CAR DROPPED SPEED TO 30 MILES PER HOUR ON ITS OWN
Additional Notes:
CAR WAS ON THE HIGHWAY GOING 80 MILES COOLANT LIGHT CAME ON CAR DROPPED SPEED TO 30 MILES PER HOUR ON ITS OWN
Mfg Campaign: 11570643
Recall Date: Feb 7, 2024
Bmw Of North America, Llc
Defect Description:
SEAT BELTS
Potential Consequences:
The contact owns a 2018 BMW 430I. The contact stated that while driving with the front driver's side seat belt buckled, the seat belt failed to restrain as needed. Additionally, the contact stated that the front driver's side seat belt failed to retract when unbuckled. The vehicle was taken to the dealer and the contact was provided an estimate to repair the front driver's side seat belt. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact there would be no assistance because the VIN was not included in NHTSA Campaign Number: 17V507000 (Seat Belts). The failure mileage was approximately 77,000.
Corrective Action:
The contact owns a 2018 BMW 430I. The contact stated that while driving with the front driver's side seat belt buckled, the seat belt failed to restrain as needed. Additionally, the contact stated that the front driver's side seat belt failed to retract when unbuckled. The vehicle was taken to the dealer and the contact was provided an estimate to repair the front driver's side seat belt. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact there would be no assistance because the VIN was not included in NHTSA Campaign Number: 17V507000 (Seat Belts). The failure mileage was approximately 77,000.
Additional Notes:
The contact owns a 2018 BMW 430I. The contact stated that while driving with the front driver's side seat belt buckled, the seat belt failed to restrain as needed. Additionally, the contact stated that the front driver's side seat belt failed to retract when unbuckled. The vehicle was taken to the dealer and the contact was provided an estimate to repair the front driver's side seat belt. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact there would be no assistance because the VIN was not included in NHTSA Campaign Number: 17V507000 (Seat Belts). The failure mileage was approximately 77,000.
Mfg Campaign: 11567026
Recall Date: Jan 22, 2024
Need Legal Help?
Featured Attorneys
Barry Edzant
Edzant Price LLC
Valencia, CA • 36 yrs
Focus: Lemon Law, Personal Injury
Recent Articles
Jeep Grand Cherokee Head Restraint Problem
Chrysler (FCA US, LLC) has announced a safety issue affecting certain 2023–2024 Jeep Grand Ch ...
Aug 1, 2025