Complaints & Recalls
Official Safety Recalls - Important!
3 RecallsThese are official manufacturer recalls ordered by NHTSA for safety defects. If you own this vehicle, contact your dealer immediately for free repairs.
Volvo Car Usa, Llc
Safety Issue:
Volvo Car USA, LLC (Volvo Car) is recalling certain 2015-2024 XC90 vehicles. The second-row seat belt buckle and lower belt anchor bolts may not be tightened properly.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Mfg Campaign: R10259
Recall Date: Dec 7, 2023
Volvo Car Usa, Llc
Safety Issue:
Volvo Car USA, LLC (Volvo Car) is recalling certain 2016-2020 XC90 Excellence vehicles. Liquid or condensation on the rear seat control display may cause the front passenger seat to move back as far as possible.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Mfg Campaign: R10093
Recall Date: Apr 21, 2021
Volvo Car Usa Llc
Safety Issue:
Volvo Car USA LLC (Volvo) is recalling certain 2017-2019 Volvo XC90, S90, V60, V60 Cross Country, V90, XC40, XC60, and V90 Cross Country vehicles. The software installed in the Vehicle Connectivity Module (VCM) may have an error causing the Telematics and Driver Support Systems to function improperly. As a result, the GPS will not provide location information to emergency personnel in the event of an emergency.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Mfg Campaign: R39917
Recall Date: Nov 13, 2018
Consumer Complaints
50 ComplaintsVolvo Car Usa, Llc
Defect Description:
ELECTRICAL SYSTEM
Potential Consequences:
3 weeks ago we had the transmission module fail on our vehicle while it was being driven. According to Volvo forums, this is a multi-model year, multi vehicle issue for those with sunroofs. Accrding to the dealer in our case, the seal failed, and water runs into the compartment where the transmission module is located, causing it to fail. We had it happen twice, and both times on the highway, with the engine running ragged causing it ot accelerate and then quickly decelerate. There were 3 warnings that popped up-"Gear lever locked," "transmission acceleration performance reduced," and "Parking Brake unaavialble." It happened twice and and was towed to the dealer both times, as it was not drivable-once the vehicle was parked it would no longer move out of park. The first time the diagnosis and module reset was comped by the dealer (Borton Volvo, Golden Valley, MN) and the second time, the transmission module was "dried out," and the sunroof seal was replaced, which was just under $700. It is available to be inspected if necessary. The vehicle was a hazard to others on the road while it was "acting up." Dealer was familia with the issue. No inspection was done other than by the dealer Warning lamps as outlined above
Corrective Action:
3 weeks ago we had the transmission module fail on our vehicle while it was being driven. According to Volvo forums, this is a multi-model year, multi vehicle issue for those with sunroofs. Accrding to the dealer in our case, the seal failed, and water runs into the compartment where the transmission module is located, causing it to fail. We had it happen twice, and both times on the highway, with the engine running ragged causing it ot accelerate and then quickly decelerate. There were 3 warnings that popped up-"Gear lever locked," "transmission acceleration performance reduced," and "Parking Brake unaavialble." It happened twice and and was towed to the dealer both times, as it was not drivable-once the vehicle was parked it would no longer move out of park. The first time the diagnosis and module reset was comped by the dealer (Borton Volvo, Golden Valley, MN) and the second time, the transmission module was "dried out," and the sunroof seal was replaced, which was just under $700. It is available to be inspected if necessary. The vehicle was a hazard to others on the road while it was "acting up." Dealer was familia with the issue. No inspection was done other than by the dealer Warning lamps as outlined above
Additional Notes:
3 weeks ago we had the transmission module fail on our vehicle while it was being driven. According to Volvo forums, this is a multi-model year, multi vehicle issue for those with sunroofs. Accrding to the dealer in our case, the seal failed, and water runs into the compartment where the transmission module is located, causing it to fail. We had it happen twice, and both times on the highway, with the engine running ragged causing it ot accelerate and then quickly decelerate. There were 3 warnings that popped up-"Gear lever locked," "transmission acceleration performance reduced," and "Parking Brake unaavialble." It happened twice and and was towed to the dealer both times, as it was not drivable-once the vehicle was parked it would no longer move out of park. The first time the diagnosis and module reset was comped by the dealer (Borton Volvo, Golden Valley, MN) and the second time, the transmission module was "dried out," and the sunroof seal was replaced, which was just under $700. It is available to be inspected if necessary. The vehicle was a hazard to others on the road while it was "acting up." Dealer was familia with the issue. No inspection was done other than by the dealer Warning lamps as outlined above
Mfg Campaign: 11676768
Recall Date: Jul 28, 2025
Volvo Car Usa, Llc
Defect Description:
FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING
Potential Consequences:
3 weeks ago we had the transmission module fail on our vehicle while it was being driven. According to Volvo forums, this is a multi-model year, multi vehicle issue for those with sunroofs. Accrding to the dealer in our case, the seal failed, and water runs into the compartment where the transmission module is located, causing it to fail. We had it happen twice, and both times on the highway, with the engine running ragged causing it ot accelerate and then quickly decelerate. There were 3 warnings that popped up-"Gear lever locked," "transmission acceleration performance reduced," and "Parking Brake unaavialble." It happened twice and and was towed to the dealer both times, as it was not drivable-once the vehicle was parked it would no longer move out of park. The first time the diagnosis and module reset was comped by the dealer (Borton Volvo, Golden Valley, MN) and the second time, the transmission module was "dried out," and the sunroof seal was replaced, which was just under $700. It is available to be inspected if necessary. The vehicle was a hazard to others on the road while it was "acting up." Dealer was familia with the issue. No inspection was done other than by the dealer Warning lamps as outlined above
Corrective Action:
3 weeks ago we had the transmission module fail on our vehicle while it was being driven. According to Volvo forums, this is a multi-model year, multi vehicle issue for those with sunroofs. Accrding to the dealer in our case, the seal failed, and water runs into the compartment where the transmission module is located, causing it to fail. We had it happen twice, and both times on the highway, with the engine running ragged causing it ot accelerate and then quickly decelerate. There were 3 warnings that popped up-"Gear lever locked," "transmission acceleration performance reduced," and "Parking Brake unaavialble." It happened twice and and was towed to the dealer both times, as it was not drivable-once the vehicle was parked it would no longer move out of park. The first time the diagnosis and module reset was comped by the dealer (Borton Volvo, Golden Valley, MN) and the second time, the transmission module was "dried out," and the sunroof seal was replaced, which was just under $700. It is available to be inspected if necessary. The vehicle was a hazard to others on the road while it was "acting up." Dealer was familia with the issue. No inspection was done other than by the dealer Warning lamps as outlined above
Additional Notes:
3 weeks ago we had the transmission module fail on our vehicle while it was being driven. According to Volvo forums, this is a multi-model year, multi vehicle issue for those with sunroofs. Accrding to the dealer in our case, the seal failed, and water runs into the compartment where the transmission module is located, causing it to fail. We had it happen twice, and both times on the highway, with the engine running ragged causing it ot accelerate and then quickly decelerate. There were 3 warnings that popped up-"Gear lever locked," "transmission acceleration performance reduced," and "Parking Brake unaavialble." It happened twice and and was towed to the dealer both times, as it was not drivable-once the vehicle was parked it would no longer move out of park. The first time the diagnosis and module reset was comped by the dealer (Borton Volvo, Golden Valley, MN) and the second time, the transmission module was "dried out," and the sunroof seal was replaced, which was just under $700. It is available to be inspected if necessary. The vehicle was a hazard to others on the road while it was "acting up." Dealer was familia with the issue. No inspection was done other than by the dealer Warning lamps as outlined above
Mfg Campaign: 11676768
Recall Date: Jul 28, 2025
Volvo Car Usa, Llc
Defect Description:
VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM
Potential Consequences:
The contact owns a 2018 Volvo XC90. The contact stated that the A/C unit failed to operate as needed, causing the HVAC system to become inoperable. The vehicle was taken to a dealer where a diagnostic test was performed, which showed that the evaporator core inside the HVAC system was cracked and needed to be replaced. The contact attempted to have the part replaced; however, the contact was informed that the part was on backorder. The vehicle was not repaired. The manufacturer was notified of the failure but offered no assistance. The failure mileage was 100,000.
Corrective Action:
The contact owns a 2018 Volvo XC90. The contact stated that the A/C unit failed to operate as needed, causing the HVAC system to become inoperable. The vehicle was taken to a dealer where a diagnostic test was performed, which showed that the evaporator core inside the HVAC system was cracked and needed to be replaced. The contact attempted to have the part replaced; however, the contact was informed that the part was on backorder. The vehicle was not repaired. The manufacturer was notified of the failure but offered no assistance. The failure mileage was 100,000.
Additional Notes:
The contact owns a 2018 Volvo XC90. The contact stated that the A/C unit failed to operate as needed, causing the HVAC system to become inoperable. The vehicle was taken to a dealer where a diagnostic test was performed, which showed that the evaporator core inside the HVAC system was cracked and needed to be replaced. The contact attempted to have the part replaced; however, the contact was informed that the part was on backorder. The vehicle was not repaired. The manufacturer was notified of the failure but offered no assistance. The failure mileage was 100,000.
Mfg Campaign: 11663103
Recall Date: May 27, 2025
Volvo Car Usa, Llc
Defect Description:
ELECTRICAL SYSTEM
Potential Consequences:
While actively driving into an intersection, driving on the street and or stopped at a light or at a stop the vehicle will shut off, the lights on the dashboard will sometimes be on, other times go completely black, a notification pops up on the dashboard saying "engine not in P". There is no way I'm aware of to re create this action. My children's safety as well as mine has been put at significant risk and in harms way as well as others due to the severity and nature of this unexpected risk while driving on the freeway, through intersections and in general driving through traffic and busy streets. I've had multiple close calls of almost being hit when the car stopped while I'm driving with my children. The problem has yet to be reproduced by the dealer at this time however we have photos and video of it's ongoing safety concern. It has not been inspected by the manufacturer nor police but is currently at the dealer undergoing inspection. There has not been any notifications or warnings prior to any one of these serious events, the message only comes up when the car is off and won't go.
Corrective Action:
While actively driving into an intersection, driving on the street and or stopped at a light or at a stop the vehicle will shut off, the lights on the dashboard will sometimes be on, other times go completely black, a notification pops up on the dashboard saying "engine not in P". There is no way I'm aware of to re create this action. My children's safety as well as mine has been put at significant risk and in harms way as well as others due to the severity and nature of this unexpected risk while driving on the freeway, through intersections and in general driving through traffic and busy streets. I've had multiple close calls of almost being hit when the car stopped while I'm driving with my children. The problem has yet to be reproduced by the dealer at this time however we have photos and video of it's ongoing safety concern. It has not been inspected by the manufacturer nor police but is currently at the dealer undergoing inspection. There has not been any notifications or warnings prior to any one of these serious events, the message only comes up when the car is off and won't go.
Additional Notes:
While actively driving into an intersection, driving on the street and or stopped at a light or at a stop the vehicle will shut off, the lights on the dashboard will sometimes be on, other times go completely black, a notification pops up on the dashboard saying "engine not in P". There is no way I'm aware of to re create this action. My children's safety as well as mine has been put at significant risk and in harms way as well as others due to the severity and nature of this unexpected risk while driving on the freeway, through intersections and in general driving through traffic and busy streets. I've had multiple close calls of almost being hit when the car stopped while I'm driving with my children. The problem has yet to be reproduced by the dealer at this time however we have photos and video of it's ongoing safety concern. It has not been inspected by the manufacturer nor police but is currently at the dealer undergoing inspection. There has not been any notifications or warnings prior to any one of these serious events, the message only comes up when the car is off and won't go.
Mfg Campaign: 11657576
Recall Date: Apr 29, 2025
Volvo Car Usa, Llc
Defect Description:
ENGINE
Potential Consequences:
While actively driving into an intersection, driving on the street and or stopped at a light or at a stop the vehicle will shut off, the lights on the dashboard will sometimes be on, other times go completely black, a notification pops up on the dashboard saying "engine not in P". There is no way I'm aware of to re create this action. My children's safety as well as mine has been put at significant risk and in harms way as well as others due to the severity and nature of this unexpected risk while driving on the freeway, through intersections and in general driving through traffic and busy streets. I've had multiple close calls of almost being hit when the car stopped while I'm driving with my children. The problem has yet to be reproduced by the dealer at this time however we have photos and video of it's ongoing safety concern. It has not been inspected by the manufacturer nor police but is currently at the dealer undergoing inspection. There has not been any notifications or warnings prior to any one of these serious events, the message only comes up when the car is off and won't go.
Corrective Action:
While actively driving into an intersection, driving on the street and or stopped at a light or at a stop the vehicle will shut off, the lights on the dashboard will sometimes be on, other times go completely black, a notification pops up on the dashboard saying "engine not in P". There is no way I'm aware of to re create this action. My children's safety as well as mine has been put at significant risk and in harms way as well as others due to the severity and nature of this unexpected risk while driving on the freeway, through intersections and in general driving through traffic and busy streets. I've had multiple close calls of almost being hit when the car stopped while I'm driving with my children. The problem has yet to be reproduced by the dealer at this time however we have photos and video of it's ongoing safety concern. It has not been inspected by the manufacturer nor police but is currently at the dealer undergoing inspection. There has not been any notifications or warnings prior to any one of these serious events, the message only comes up when the car is off and won't go.
Additional Notes:
While actively driving into an intersection, driving on the street and or stopped at a light or at a stop the vehicle will shut off, the lights on the dashboard will sometimes be on, other times go completely black, a notification pops up on the dashboard saying "engine not in P". There is no way I'm aware of to re create this action. My children's safety as well as mine has been put at significant risk and in harms way as well as others due to the severity and nature of this unexpected risk while driving on the freeway, through intersections and in general driving through traffic and busy streets. I've had multiple close calls of almost being hit when the car stopped while I'm driving with my children. The problem has yet to be reproduced by the dealer at this time however we have photos and video of it's ongoing safety concern. It has not been inspected by the manufacturer nor police but is currently at the dealer undergoing inspection. There has not been any notifications or warnings prior to any one of these serious events, the message only comes up when the car is off and won't go.
Mfg Campaign: 11657576
Recall Date: Apr 29, 2025
Volvo Car Usa, Llc
Defect Description:
STEERING
Potential Consequences:
While actively driving into an intersection, driving on the street and or stopped at a light or at a stop the vehicle will shut off, the lights on the dashboard will sometimes be on, other times go completely black, a notification pops up on the dashboard saying "engine not in P". There is no way I'm aware of to re create this action. My children's safety as well as mine has been put at significant risk and in harms way as well as others due to the severity and nature of this unexpected risk while driving on the freeway, through intersections and in general driving through traffic and busy streets. I've had multiple close calls of almost being hit when the car stopped while I'm driving with my children. The problem has yet to be reproduced by the dealer at this time however we have photos and video of it's ongoing safety concern. It has not been inspected by the manufacturer nor police but is currently at the dealer undergoing inspection. There has not been any notifications or warnings prior to any one of these serious events, the message only comes up when the car is off and won't go.
Corrective Action:
While actively driving into an intersection, driving on the street and or stopped at a light or at a stop the vehicle will shut off, the lights on the dashboard will sometimes be on, other times go completely black, a notification pops up on the dashboard saying "engine not in P". There is no way I'm aware of to re create this action. My children's safety as well as mine has been put at significant risk and in harms way as well as others due to the severity and nature of this unexpected risk while driving on the freeway, through intersections and in general driving through traffic and busy streets. I've had multiple close calls of almost being hit when the car stopped while I'm driving with my children. The problem has yet to be reproduced by the dealer at this time however we have photos and video of it's ongoing safety concern. It has not been inspected by the manufacturer nor police but is currently at the dealer undergoing inspection. There has not been any notifications or warnings prior to any one of these serious events, the message only comes up when the car is off and won't go.
Additional Notes:
While actively driving into an intersection, driving on the street and or stopped at a light or at a stop the vehicle will shut off, the lights on the dashboard will sometimes be on, other times go completely black, a notification pops up on the dashboard saying "engine not in P". There is no way I'm aware of to re create this action. My children's safety as well as mine has been put at significant risk and in harms way as well as others due to the severity and nature of this unexpected risk while driving on the freeway, through intersections and in general driving through traffic and busy streets. I've had multiple close calls of almost being hit when the car stopped while I'm driving with my children. The problem has yet to be reproduced by the dealer at this time however we have photos and video of it's ongoing safety concern. It has not been inspected by the manufacturer nor police but is currently at the dealer undergoing inspection. There has not been any notifications or warnings prior to any one of these serious events, the message only comes up when the car is off and won't go.
Mfg Campaign: 11657576
Recall Date: Apr 29, 2025
Volvo Car Usa, Llc
Defect Description:
ENGINE
Potential Consequences:
The engine coolant bleeder hose in my 2018 Volvo XC90 cracked in the middle of my journey causing a severe coolant leak. This happened in August of 2024 while driving and the engine coolant suddenly started showed warning with low level and the engine started overheating. The vehicle would not accelerate past 20 mph, and the temperature warning light flashed continuously, creating a safety hazard in traffic. The Volvo dealership diagnosed the issue and confirmed that the coolant bleeder on the supercharger is broken and leaking. They replaced the bleeder hose and vacuum fill system. I believe similar issues happened to the 2016 models and a recall was issued for the coolant bleeder hose (part # 32249907-0) to be replaced by Volvo. This has not been recalled for the 2018 models, making it an expensive replacement for me. I urge NHTSA to investigate Volvo XC90 coolant hoses for material defects, as this issue endangers drivers through unexpected breakdowns and engine failure.
Corrective Action:
The engine coolant bleeder hose in my 2018 Volvo XC90 cracked in the middle of my journey causing a severe coolant leak. This happened in August of 2024 while driving and the engine coolant suddenly started showed warning with low level and the engine started overheating. The vehicle would not accelerate past 20 mph, and the temperature warning light flashed continuously, creating a safety hazard in traffic. The Volvo dealership diagnosed the issue and confirmed that the coolant bleeder on the supercharger is broken and leaking. They replaced the bleeder hose and vacuum fill system. I believe similar issues happened to the 2016 models and a recall was issued for the coolant bleeder hose (part # 32249907-0) to be replaced by Volvo. This has not been recalled for the 2018 models, making it an expensive replacement for me. I urge NHTSA to investigate Volvo XC90 coolant hoses for material defects, as this issue endangers drivers through unexpected breakdowns and engine failure.
Additional Notes:
The engine coolant bleeder hose in my 2018 Volvo XC90 cracked in the middle of my journey causing a severe coolant leak. This happened in August of 2024 while driving and the engine coolant suddenly started showed warning with low level and the engine started overheating. The vehicle would not accelerate past 20 mph, and the temperature warning light flashed continuously, creating a safety hazard in traffic. The Volvo dealership diagnosed the issue and confirmed that the coolant bleeder on the supercharger is broken and leaking. They replaced the bleeder hose and vacuum fill system. I believe similar issues happened to the 2016 models and a recall was issued for the coolant bleeder hose (part # 32249907-0) to be replaced by Volvo. This has not been recalled for the 2018 models, making it an expensive replacement for me. I urge NHTSA to investigate Volvo XC90 coolant hoses for material defects, as this issue endangers drivers through unexpected breakdowns and engine failure.
Mfg Campaign: 11655729
Recall Date: Apr 21, 2025
Volvo Car Usa, Llc
Defect Description:
FUEL/PROPULSION SYSTEM
Potential Consequences:
The vehicle engine will fail while driving. The electronics reflect the vehicle is still running. Restarting is not immediate and is difficult. This is a known problem that Volvo recalled for 2019/2020 XC90s. Volvo will not diagnose and repair under goodwill despite my repeated attempts.
Corrective Action:
The vehicle engine will fail while driving. The electronics reflect the vehicle is still running. Restarting is not immediate and is difficult. This is a known problem that Volvo recalled for 2019/2020 XC90s. Volvo will not diagnose and repair under goodwill despite my repeated attempts.
Additional Notes:
The vehicle engine will fail while driving. The electronics reflect the vehicle is still running. Restarting is not immediate and is difficult. This is a known problem that Volvo recalled for 2019/2020 XC90s. Volvo will not diagnose and repair under goodwill despite my repeated attempts.
Mfg Campaign: 11655417
Recall Date: Apr 18, 2025
Volvo Car Usa, Llc
Defect Description:
ENGINE
Potential Consequences:
The vehicle engine will fail while driving. The electronics reflect the vehicle is still running. Restarting is not immediate and is difficult. This is a known problem that Volvo recalled for 2019/2020 XC90s. Volvo will not diagnose and repair under goodwill despite my repeated attempts.
Corrective Action:
The vehicle engine will fail while driving. The electronics reflect the vehicle is still running. Restarting is not immediate and is difficult. This is a known problem that Volvo recalled for 2019/2020 XC90s. Volvo will not diagnose and repair under goodwill despite my repeated attempts.
Additional Notes:
The vehicle engine will fail while driving. The electronics reflect the vehicle is still running. Restarting is not immediate and is difficult. This is a known problem that Volvo recalled for 2019/2020 XC90s. Volvo will not diagnose and repair under goodwill despite my repeated attempts.
Mfg Campaign: 11655417
Recall Date: Apr 18, 2025
Volvo Car Usa, Llc
Defect Description:
SERVICE BRAKES
Potential Consequences:
The first incidence occurred around [XXX]. I was traveling [XXX] on [XXX] in North Carolina about an hour north of Charlotte. I pulled into a rest area and, upon pressing the brake pedal, heard a bit of a hissing noise and suddenly the brake pedal was extremely hard and the car was very difficult to bring to a stop. I did an online search for what might be wrong and discovered it was likely a brake booster failure. I drove the car onto Charlotte, carefully and with extreme difficulty, and took it to the Swedish Connection, a local Volvo specialist. They confirm the diagnosis and replaced the brake booster. Last night, [XXX], I drove the car down to Pickens South Carolina for work. When I got in to return to Charlotte late at night, I turned the ignition, put the car in reverse, and, with my foot on the brake and waiting to back out of the parking space, I heard that hissing noise again. Sure enough, the brake booster had evidently failed again. I drove the car back to Charlotte, mostly on [XXX], and the electronic braking seemed to work OK under cruise control maintaining speed and distance between other cars in traffic. Of course, driving the vehicle on local roads, through stoplights, and turns was extremely difficult and dangerous. I have returned the car to the same mechanic that repaired the last brake booster. I will be reporting this to Volvo as well, as this is a serious safety issue and defect with my vehicle. The mechanic has confirmed that this has happened in other Volvo XC 90s. The vehicle has NOT been inspected by the manufacturer. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Corrective Action:
The first incidence occurred around [XXX]. I was traveling [XXX] on [XXX] in North Carolina about an hour north of Charlotte. I pulled into a rest area and, upon pressing the brake pedal, heard a bit of a hissing noise and suddenly the brake pedal was extremely hard and the car was very difficult to bring to a stop. I did an online search for what might be wrong and discovered it was likely a brake booster failure. I drove the car onto Charlotte, carefully and with extreme difficulty, and took it to the Swedish Connection, a local Volvo specialist. They confirm the diagnosis and replaced the brake booster. Last night, [XXX], I drove the car down to Pickens South Carolina for work. When I got in to return to Charlotte late at night, I turned the ignition, put the car in reverse, and, with my foot on the brake and waiting to back out of the parking space, I heard that hissing noise again. Sure enough, the brake booster had evidently failed again. I drove the car back to Charlotte, mostly on [XXX], and the electronic braking seemed to work OK under cruise control maintaining speed and distance between other cars in traffic. Of course, driving the vehicle on local roads, through stoplights, and turns was extremely difficult and dangerous. I have returned the car to the same mechanic that repaired the last brake booster. I will be reporting this to Volvo as well, as this is a serious safety issue and defect with my vehicle. The mechanic has confirmed that this has happened in other Volvo XC 90s. The vehicle has NOT been inspected by the manufacturer. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Additional Notes:
The first incidence occurred around [XXX]. I was traveling [XXX] on [XXX] in North Carolina about an hour north of Charlotte. I pulled into a rest area and, upon pressing the brake pedal, heard a bit of a hissing noise and suddenly the brake pedal was extremely hard and the car was very difficult to bring to a stop. I did an online search for what might be wrong and discovered it was likely a brake booster failure. I drove the car onto Charlotte, carefully and with extreme difficulty, and took it to the Swedish Connection, a local Volvo specialist. They confirm the diagnosis and replaced the brake booster. Last night, [XXX], I drove the car down to Pickens South Carolina for work. When I got in to return to Charlotte late at night, I turned the ignition, put the car in reverse, and, with my foot on the brake and waiting to back out of the parking space, I heard that hissing noise again. Sure enough, the brake booster had evidently failed again. I drove the car back to Charlotte, mostly on [XXX], and the electronic braking seemed to work OK under cruise control maintaining speed and distance between other cars in traffic. Of course, driving the vehicle on local roads, through stoplights, and turns was extremely difficult and dangerous. I have returned the car to the same mechanic that repaired the last brake booster. I will be reporting this to Volvo as well, as this is a serious safety issue and defect with my vehicle. The mechanic has confirmed that this has happened in other Volvo XC 90s. The vehicle has NOT been inspected by the manufacturer. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Mfg Campaign: 11654773
Recall Date: Apr 15, 2025
Volvo Car Usa, Llc
Defect Description:
STRUCTURE:BODY
Potential Consequences:
My 2018 Volvo XC90 had repeated water leakage from the panoramic sunroof. In most cases, when the vehicle is parked flat or the front is at a slight angle, water leaks in and collects in the cargo area. It collects into a plastic compartment over the battery located on the right side of the cargo area and/or on top of the rear cargo mat. When the vehicle is moving and it is raining, water leaks in from the rearview mirror, making the entire dash, screen, shifter and both driver and passenger wet. The rain also comes in from the rear right side of the second row making the entire seat or any passenger sitting there wet. Volvo is not acknowledging this defect nor are there any solutions in place. This is extremely concerning.
Corrective Action:
My 2018 Volvo XC90 had repeated water leakage from the panoramic sunroof. In most cases, when the vehicle is parked flat or the front is at a slight angle, water leaks in and collects in the cargo area. It collects into a plastic compartment over the battery located on the right side of the cargo area and/or on top of the rear cargo mat. When the vehicle is moving and it is raining, water leaks in from the rearview mirror, making the entire dash, screen, shifter and both driver and passenger wet. The rain also comes in from the rear right side of the second row making the entire seat or any passenger sitting there wet. Volvo is not acknowledging this defect nor are there any solutions in place. This is extremely concerning.
Additional Notes:
My 2018 Volvo XC90 had repeated water leakage from the panoramic sunroof. In most cases, when the vehicle is parked flat or the front is at a slight angle, water leaks in and collects in the cargo area. It collects into a plastic compartment over the battery located on the right side of the cargo area and/or on top of the rear cargo mat. When the vehicle is moving and it is raining, water leaks in from the rearview mirror, making the entire dash, screen, shifter and both driver and passenger wet. The rain also comes in from the rear right side of the second row making the entire seat or any passenger sitting there wet. Volvo is not acknowledging this defect nor are there any solutions in place. This is extremely concerning.
Mfg Campaign: 11631071
Recall Date: Dec 16, 2024
Volvo Car Usa, Llc
Defect Description:
UNKNOWN OR OTHER
Potential Consequences:
My 2018 Volvo XC90 had repeated water leakage from the panoramic sunroof. In most cases, when the vehicle is parked flat or the front is at a slight angle, water leaks in and collects in the cargo area. It collects into a plastic compartment over the battery located on the right side of the cargo area and/or on top of the rear cargo mat. When the vehicle is moving and it is raining, water leaks in from the rearview mirror, making the entire dash, screen, shifter and both driver and passenger wet. The rain also comes in from the rear right side of the second row making the entire seat or any passenger sitting there wet. Volvo is not acknowledging this defect nor are there any solutions in place. This is extremely concerning.
Corrective Action:
My 2018 Volvo XC90 had repeated water leakage from the panoramic sunroof. In most cases, when the vehicle is parked flat or the front is at a slight angle, water leaks in and collects in the cargo area. It collects into a plastic compartment over the battery located on the right side of the cargo area and/or on top of the rear cargo mat. When the vehicle is moving and it is raining, water leaks in from the rearview mirror, making the entire dash, screen, shifter and both driver and passenger wet. The rain also comes in from the rear right side of the second row making the entire seat or any passenger sitting there wet. Volvo is not acknowledging this defect nor are there any solutions in place. This is extremely concerning.
Additional Notes:
My 2018 Volvo XC90 had repeated water leakage from the panoramic sunroof. In most cases, when the vehicle is parked flat or the front is at a slight angle, water leaks in and collects in the cargo area. It collects into a plastic compartment over the battery located on the right side of the cargo area and/or on top of the rear cargo mat. When the vehicle is moving and it is raining, water leaks in from the rearview mirror, making the entire dash, screen, shifter and both driver and passenger wet. The rain also comes in from the rear right side of the second row making the entire seat or any passenger sitting there wet. Volvo is not acknowledging this defect nor are there any solutions in place. This is extremely concerning.
Mfg Campaign: 11631071
Recall Date: Dec 16, 2024
Volvo Car Usa, Llc
Defect Description:
STRUCTURE:BODY:DOOR:HANDLE:INTERIOR
Potential Consequences:
Door handle for drivers side door breaks off into hand. Exiting vehicle made extremely complicated: if window is compromised in any way or lock system is compromised in any way, exit of vehicle is impossible.
Corrective Action:
Door handle for drivers side door breaks off into hand. Exiting vehicle made extremely complicated: if window is compromised in any way or lock system is compromised in any way, exit of vehicle is impossible.
Additional Notes:
Door handle for drivers side door breaks off into hand. Exiting vehicle made extremely complicated: if window is compromised in any way or lock system is compromised in any way, exit of vehicle is impossible.
Mfg Campaign: 11622921
Recall Date: Oct 31, 2024
Volvo Car Usa, Llc
Defect Description:
VISIBILITY/WIPER
Potential Consequences:
This morning and a few days ago, ice cold water was dripping onto my control display pad and on me. The leakage came from the ourside down the plastic compartment behind my rearview mirror. This was distracting while I was driving since there was now water on me, and it was shorting out and affecting my control display. It would continue to be buggy while driving. I believe this issue is a result from a cracked seal between the windshield and the car body. I have seen other documented cases on volvo forums.
Corrective Action:
This morning and a few days ago, ice cold water was dripping onto my control display pad and on me. The leakage came from the ourside down the plastic compartment behind my rearview mirror. This was distracting while I was driving since there was now water on me, and it was shorting out and affecting my control display. It would continue to be buggy while driving. I believe this issue is a result from a cracked seal between the windshield and the car body. I have seen other documented cases on volvo forums.
Additional Notes:
This morning and a few days ago, ice cold water was dripping onto my control display pad and on me. The leakage came from the ourside down the plastic compartment behind my rearview mirror. This was distracting while I was driving since there was now water on me, and it was shorting out and affecting my control display. It would continue to be buggy while driving. I believe this issue is a result from a cracked seal between the windshield and the car body. I have seen other documented cases on volvo forums.
Mfg Campaign: 11602688
Recall Date: Jul 16, 2024
Volvo Car Usa, Llc
Defect Description:
ELECTRICAL SYSTEM
Potential Consequences:
This morning and a few days ago, ice cold water was dripping onto my control display pad and on me. The leakage came from the ourside down the plastic compartment behind my rearview mirror. This was distracting while I was driving since there was now water on me, and it was shorting out and affecting my control display. It would continue to be buggy while driving. I believe this issue is a result from a cracked seal between the windshield and the car body. I have seen other documented cases on volvo forums.
Corrective Action:
This morning and a few days ago, ice cold water was dripping onto my control display pad and on me. The leakage came from the ourside down the plastic compartment behind my rearview mirror. This was distracting while I was driving since there was now water on me, and it was shorting out and affecting my control display. It would continue to be buggy while driving. I believe this issue is a result from a cracked seal between the windshield and the car body. I have seen other documented cases on volvo forums.
Additional Notes:
This morning and a few days ago, ice cold water was dripping onto my control display pad and on me. The leakage came from the ourside down the plastic compartment behind my rearview mirror. This was distracting while I was driving since there was now water on me, and it was shorting out and affecting my control display. It would continue to be buggy while driving. I believe this issue is a result from a cracked seal between the windshield and the car body. I have seen other documented cases on volvo forums.
Mfg Campaign: 11602688
Recall Date: Jul 16, 2024
Volvo Car Usa, Llc
Defect Description:
UNKNOWN OR OTHER
Potential Consequences:
Rear passenger door handle inoperable from both inside and outside the car. A quick google search shows this is a common, well known issue in all 2016 - 2024 and beyond Volvo XC90s. Concerning is this prevents egress from the vehicle in case of emergency. Confirmed issue exists while car is unlocked and child locks deactivated as can be seen in video. Rear driver door works as appropriately, rear passenger fails to open. No warning lights or codes. Issue first appeared 7/10/2024 and persists. Door cannot be opened. Videos available upon request.
Corrective Action:
Rear passenger door handle inoperable from both inside and outside the car. A quick google search shows this is a common, well known issue in all 2016 - 2024 and beyond Volvo XC90s. Concerning is this prevents egress from the vehicle in case of emergency. Confirmed issue exists while car is unlocked and child locks deactivated as can be seen in video. Rear driver door works as appropriately, rear passenger fails to open. No warning lights or codes. Issue first appeared 7/10/2024 and persists. Door cannot be opened. Videos available upon request.
Additional Notes:
Rear passenger door handle inoperable from both inside and outside the car. A quick google search shows this is a common, well known issue in all 2016 - 2024 and beyond Volvo XC90s. Concerning is this prevents egress from the vehicle in case of emergency. Confirmed issue exists while car is unlocked and child locks deactivated as can be seen in video. Rear driver door works as appropriately, rear passenger fails to open. No warning lights or codes. Issue first appeared 7/10/2024 and persists. Door cannot be opened. Videos available upon request.
Mfg Campaign: 11601082
Recall Date: Jul 11, 2024
Volvo Car Usa, Llc
Defect Description:
FUEL/PROPULSION SYSTEM
Potential Consequences:
On Monday [XXX] I started my car and immediately a warning signal on the dashboard read ENGINE LOW Performance , and the dashboard went black and the engine cut off. The car was then towed to the Glen Cove Volvo. After a diagnostic I was informed the following needed to be replaced - FUEL FILLER PIPE 2) FUEL PRESSURE LOW FUEL indicator 3) the aforementioned replacements will require calibrated software update. . I bought this car brand new and I am the only owner and it has only been serviced by Volvo. This car ONLY has 59, 300 miles. I researched the problem online and noted it was a common problem with the. same make and year of my car and could not understand why there is not a recall for my car, by Volvo for this issue no matter the mileage. I came across correspondence on the internet from [XXX] referencing service action S29843 - fuel tank filler pipe insert was manufactured out of specification for ONLY T8 engines. I reached out to Volvo Car USA customer care and inquired about them covering the cost of the repairs and also informing them that this problem is not only affecting T8 engines. I just received a response for my concern stating THEY ARE SORRY THEY CAN NOT ASSIST ME WITH THIS MATTER. I cannot begin to express how sadden and disappointed in the corporation, to experience their lack of compassion and. concern about their product after I spent thousands of dollars of my hard earned money on this defective car. I have no faith in Volvo and no longer feel safe driving this car. I will tell all my relatives and friends of my experience to save them from Volvo's lack of concern about their CUSTOMERS' safety. This is clearly no wear and tear. There are multiple posts on the internet. There's a case of replacement at 10,000 miles, another case where it was replaced and failed again and the dealer is requesting the owner to pay. This this not right. There should be a recall for the entire system when it fails.-clearly defective INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT
Corrective Action:
On Monday [XXX] I started my car and immediately a warning signal on the dashboard read ENGINE LOW Performance , and the dashboard went black and the engine cut off. The car was then towed to the Glen Cove Volvo. After a diagnostic I was informed the following needed to be replaced - FUEL FILLER PIPE 2) FUEL PRESSURE LOW FUEL indicator 3) the aforementioned replacements will require calibrated software update. . I bought this car brand new and I am the only owner and it has only been serviced by Volvo. This car ONLY has 59, 300 miles. I researched the problem online and noted it was a common problem with the. same make and year of my car and could not understand why there is not a recall for my car, by Volvo for this issue no matter the mileage. I came across correspondence on the internet from [XXX] referencing service action S29843 - fuel tank filler pipe insert was manufactured out of specification for ONLY T8 engines. I reached out to Volvo Car USA customer care and inquired about them covering the cost of the repairs and also informing them that this problem is not only affecting T8 engines. I just received a response for my concern stating THEY ARE SORRY THEY CAN NOT ASSIST ME WITH THIS MATTER. I cannot begin to express how sadden and disappointed in the corporation, to experience their lack of compassion and. concern about their product after I spent thousands of dollars of my hard earned money on this defective car. I have no faith in Volvo and no longer feel safe driving this car. I will tell all my relatives and friends of my experience to save them from Volvo's lack of concern about their CUSTOMERS' safety. This is clearly no wear and tear. There are multiple posts on the internet. There's a case of replacement at 10,000 miles, another case where it was replaced and failed again and the dealer is requesting the owner to pay. This this not right. There should be a recall for the entire system when it fails.-clearly defective INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT
Additional Notes:
On Monday [XXX] I started my car and immediately a warning signal on the dashboard read ENGINE LOW Performance , and the dashboard went black and the engine cut off. The car was then towed to the Glen Cove Volvo. After a diagnostic I was informed the following needed to be replaced - FUEL FILLER PIPE 2) FUEL PRESSURE LOW FUEL indicator 3) the aforementioned replacements will require calibrated software update. . I bought this car brand new and I am the only owner and it has only been serviced by Volvo. This car ONLY has 59, 300 miles. I researched the problem online and noted it was a common problem with the. same make and year of my car and could not understand why there is not a recall for my car, by Volvo for this issue no matter the mileage. I came across correspondence on the internet from [XXX] referencing service action S29843 - fuel tank filler pipe insert was manufactured out of specification for ONLY T8 engines. I reached out to Volvo Car USA customer care and inquired about them covering the cost of the repairs and also informing them that this problem is not only affecting T8 engines. I just received a response for my concern stating THEY ARE SORRY THEY CAN NOT ASSIST ME WITH THIS MATTER. I cannot begin to express how sadden and disappointed in the corporation, to experience their lack of compassion and. concern about their product after I spent thousands of dollars of my hard earned money on this defective car. I have no faith in Volvo and no longer feel safe driving this car. I will tell all my relatives and friends of my experience to save them from Volvo's lack of concern about their CUSTOMERS' safety. This is clearly no wear and tear. There are multiple posts on the internet. There's a case of replacement at 10,000 miles, another case where it was replaced and failed again and the dealer is requesting the owner to pay. This this not right. There should be a recall for the entire system when it fails.-clearly defective INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT
Mfg Campaign: 11587090
Recall Date: May 5, 2024
Volvo Car Usa, Llc
Defect Description:
ENGINE
Potential Consequences:
On Monday [XXX] I started my car and immediately a warning signal on the dashboard read ENGINE LOW Performance , and the dashboard went black and the engine cut off. The car was then towed to the Glen Cove Volvo. After a diagnostic I was informed the following needed to be replaced - FUEL FILLER PIPE 2) FUEL PRESSURE LOW FUEL indicator 3) the aforementioned replacements will require calibrated software update. . I bought this car brand new and I am the only owner and it has only been serviced by Volvo. This car ONLY has 59, 300 miles. I researched the problem online and noted it was a common problem with the. same make and year of my car and could not understand why there is not a recall for my car, by Volvo for this issue no matter the mileage. I came across correspondence on the internet from [XXX] referencing service action S29843 - fuel tank filler pipe insert was manufactured out of specification for ONLY T8 engines. I reached out to Volvo Car USA customer care and inquired about them covering the cost of the repairs and also informing them that this problem is not only affecting T8 engines. I just received a response for my concern stating THEY ARE SORRY THEY CAN NOT ASSIST ME WITH THIS MATTER. I cannot begin to express how sadden and disappointed in the corporation, to experience their lack of compassion and. concern about their product after I spent thousands of dollars of my hard earned money on this defective car. I have no faith in Volvo and no longer feel safe driving this car. I will tell all my relatives and friends of my experience to save them from Volvo's lack of concern about their CUSTOMERS' safety. This is clearly no wear and tear. There are multiple posts on the internet. There's a case of replacement at 10,000 miles, another case where it was replaced and failed again and the dealer is requesting the owner to pay. This this not right. There should be a recall for the entire system when it fails.-clearly defective INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT
Corrective Action:
On Monday [XXX] I started my car and immediately a warning signal on the dashboard read ENGINE LOW Performance , and the dashboard went black and the engine cut off. The car was then towed to the Glen Cove Volvo. After a diagnostic I was informed the following needed to be replaced - FUEL FILLER PIPE 2) FUEL PRESSURE LOW FUEL indicator 3) the aforementioned replacements will require calibrated software update. . I bought this car brand new and I am the only owner and it has only been serviced by Volvo. This car ONLY has 59, 300 miles. I researched the problem online and noted it was a common problem with the. same make and year of my car and could not understand why there is not a recall for my car, by Volvo for this issue no matter the mileage. I came across correspondence on the internet from [XXX] referencing service action S29843 - fuel tank filler pipe insert was manufactured out of specification for ONLY T8 engines. I reached out to Volvo Car USA customer care and inquired about them covering the cost of the repairs and also informing them that this problem is not only affecting T8 engines. I just received a response for my concern stating THEY ARE SORRY THEY CAN NOT ASSIST ME WITH THIS MATTER. I cannot begin to express how sadden and disappointed in the corporation, to experience their lack of compassion and. concern about their product after I spent thousands of dollars of my hard earned money on this defective car. I have no faith in Volvo and no longer feel safe driving this car. I will tell all my relatives and friends of my experience to save them from Volvo's lack of concern about their CUSTOMERS' safety. This is clearly no wear and tear. There are multiple posts on the internet. There's a case of replacement at 10,000 miles, another case where it was replaced and failed again and the dealer is requesting the owner to pay. This this not right. There should be a recall for the entire system when it fails.-clearly defective INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT
Additional Notes:
On Monday [XXX] I started my car and immediately a warning signal on the dashboard read ENGINE LOW Performance , and the dashboard went black and the engine cut off. The car was then towed to the Glen Cove Volvo. After a diagnostic I was informed the following needed to be replaced - FUEL FILLER PIPE 2) FUEL PRESSURE LOW FUEL indicator 3) the aforementioned replacements will require calibrated software update. . I bought this car brand new and I am the only owner and it has only been serviced by Volvo. This car ONLY has 59, 300 miles. I researched the problem online and noted it was a common problem with the. same make and year of my car and could not understand why there is not a recall for my car, by Volvo for this issue no matter the mileage. I came across correspondence on the internet from [XXX] referencing service action S29843 - fuel tank filler pipe insert was manufactured out of specification for ONLY T8 engines. I reached out to Volvo Car USA customer care and inquired about them covering the cost of the repairs and also informing them that this problem is not only affecting T8 engines. I just received a response for my concern stating THEY ARE SORRY THEY CAN NOT ASSIST ME WITH THIS MATTER. I cannot begin to express how sadden and disappointed in the corporation, to experience their lack of compassion and. concern about their product after I spent thousands of dollars of my hard earned money on this defective car. I have no faith in Volvo and no longer feel safe driving this car. I will tell all my relatives and friends of my experience to save them from Volvo's lack of concern about their CUSTOMERS' safety. This is clearly no wear and tear. There are multiple posts on the internet. There's a case of replacement at 10,000 miles, another case where it was replaced and failed again and the dealer is requesting the owner to pay. This this not right. There should be a recall for the entire system when it fails.-clearly defective INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT
Mfg Campaign: 11587090
Recall Date: May 5, 2024
Volvo Car Usa, Llc
Defect Description:
UNKNOWN OR OTHER
Potential Consequences:
Chrome plated trim peels away from the surface on middle console and exterior door handles and is extremely sharp causing deep cuts, seems to be a common and known issue but Volvo will not repairs or address the issue.
Corrective Action:
Chrome plated trim peels away from the surface on middle console and exterior door handles and is extremely sharp causing deep cuts, seems to be a common and known issue but Volvo will not repairs or address the issue.
Additional Notes:
Chrome plated trim peels away from the surface on middle console and exterior door handles and is extremely sharp causing deep cuts, seems to be a common and known issue but Volvo will not repairs or address the issue.
Mfg Campaign: 11555413
Recall Date: Nov 16, 2023
Volvo Car Usa, Llc
Defect Description:
VISIBILITY/WIPER
Potential Consequences:
Wipers began to turn on randomly without driver command causing distractions in a vehicle with 38,000 miles. There is a technical service bulletin about this issue (32366). It is known that the wipers will completely fail to work after an unknown, but rather short interval. Failed windshield wipers would render the vehicle unsafe to operate, therefore we elected for Immediate repair. The repair was in excess of $1,500 and the manufacturer refused to pay for the repair out of warranty.
Corrective Action:
Wipers began to turn on randomly without driver command causing distractions in a vehicle with 38,000 miles. There is a technical service bulletin about this issue (32366). It is known that the wipers will completely fail to work after an unknown, but rather short interval. Failed windshield wipers would render the vehicle unsafe to operate, therefore we elected for Immediate repair. The repair was in excess of $1,500 and the manufacturer refused to pay for the repair out of warranty.
Additional Notes:
Wipers began to turn on randomly without driver command causing distractions in a vehicle with 38,000 miles. There is a technical service bulletin about this issue (32366). It is known that the wipers will completely fail to work after an unknown, but rather short interval. Failed windshield wipers would render the vehicle unsafe to operate, therefore we elected for Immediate repair. The repair was in excess of $1,500 and the manufacturer refused to pay for the repair out of warranty.
Mfg Campaign: 11549503
Recall Date: Oct 11, 2023
Need Legal Help?
Featured Attorneys
Barry Edzant
Edzant Price LLC
Valencia, CA • 36 yrs
Focus: Lemon Law, Personal Injury
Recent Articles
Jeep Grand Cherokee Head Restraint Problem
Chrysler (FCA US, LLC) has announced a safety issue affecting certain 2023–2024 Jeep Grand Ch ...
Aug 1, 2025Fuel Injector Problem: 2021-2024 Ford Bronco Sport and 2020-2022 Ford Escape
If you own a 2021-2024 Ford Bronco Sport or 2020-2022 Ford Escape equipped with a 1.5L Dragon GTDI e ...
Jul 28, 2025Airbag Problem Affects 2022-2025 Chrysler Pacifica and Voyager Vehicles
If you own a Chrysler Pacifica or Voyager, your vehicle may be equipped with defective side curtain ...
Jul 24, 2025