Complaints & Recalls
Official Safety Recalls - Important!
27 RecallsThese are official manufacturer recalls ordered by NHTSA for safety defects. If you own this vehicle, contact your dealer immediately for free repairs.
Tesla, Inc.
Safety Issue:
Tesla, Inc. (Tesla) is recalling certain 2023 Model 3 and Model Y vehicles operating software prior to 2023.38.4. The printed circuit board for the electronic power steering assist may experience an overstress condition, causing a loss of power steering assist when the vehicle reaches a stop and then accelerates again.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 888-275-9171) or go to nhtsa.gov.
Mfg Campaign: SB-25-00-004
Recall Date: Feb 14, 2025
Tesla, Inc.
Safety Issue:
Tesla, Inc. (Tesla) is recalling certain 2024-2025 Model 3, Model S, 2023-2025 Model X, and Model Y vehicles. The computer circuit board may short, resulting in the loss of the rearview camera image. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153) or go to nhtsa.gov.
Mfg Campaign: SB-25-00-001
Recall Date: Jan 6, 2025
Tesla, Inc.
Safety Issue:
Tesla, Inc. (Tesla) is recalling certain 2024 Cybertruck, 2017-2025 Model 3, and 2020-2025 Model Y vehicles. The tire pressure monitoring system (TPMS) warning light may not remain illuminated between drive cycles, failing to warn the driver of low tire pressure. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 138, "Tire Pressure Monitoring Systems."
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Mfg Campaign: SB-24-00-018
Recall Date: Dec 17, 2024
Tesla, Inc.
Safety Issue:
Tesla, Inc. (Tesla) is recalling certain 2021-2024 Model 3, Model S, Model X, and 2020-2024 Model Y vehicles. The hood latch assembly may fail to detect an unlatched hood condition after the hood has been opened.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Mfg Campaign: SB-24-00-012
Recall Date: Jul 24, 2024
Tesla, Inc.
Safety Issue:
Tesla, Inc. (Tesla) is recalling certain 2012-2024 Model S, 2015-2024 Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles. In the event of an unbelted driver, the seat belt warning light and audible chime may not activate as intended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Mfg Campaign: SB-24-00-008
Recall Date: May 28, 2024
Tesla, Inc.
Safety Issue:
Tesla, Inc. (Tesla) is recalling certain 2012-2023 Model S, 2016-2024 Model X, 2017-2023 Model 3, 2019-2024 Model Y, and 2024 Cybertruck vehicles. An incorrect font size is displayed on the instrument panel for the Brake, Park, and Antilock Brake System (ABS) warning lights. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 105, "Hydraulic and Electric Brake Systems" and 135, "Light Vehicle Brake Systems."
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Mfg Campaign: SB-24-00-003
Recall Date: Jan 30, 2024
Tesla, Inc.
Safety Issue:
Tesla, Inc. (Tesla) is recalling certain 2023 Model S, X, and Y vehicles equipped with full self-driving computer 4.0 and running a software release version 2023.44.30 through 2023.44.30.6 or 2023.44.100. Software instability may prevent the rearview camera image from displaying.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Mfg Campaign: SB-24-00-002
Recall Date: Jan 22, 2024
Tesla, Inc.
Safety Issue:
Tesla, Inc. (Tesla) is recalling 2012-2023 Model S, 2016-2023 Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles equipped with all versions of Autosteer leading up to the version(s) that contains the recall remedy. In certain circumstances when Autosteer is engaged, the prominence and scope of the feature's controls may not be sufficient to prevent driver misuse of the SAE Level 2 advanced driver-assistance feature.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Mfg Campaign: SB-23-00-008
Recall Date: Dec 12, 2023
Tesla, Inc.
Safety Issue:
Tesla, Inc. (Tesla) is recalling certain 2023 Model S, Model X, and Model Y vehicles. The forward-facing camera may be misaligned, causing some of the active safety features such as emergency braking, forward collision warning, and lane assist to become unavailable without alerting the driver.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Mfg Campaign: SB-23-17-006
Recall Date: Jul 14, 2023
Tesla, Inc.
Safety Issue:
Tesla, Inc. (Tesla) is recalling certain 2023 Model 3 and Model Y vehicles. The pyrotechnic battery disconnect may be defective.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Mfg Campaign: SB-23-16-005
Recall Date: Jun 19, 2023
Tesla, Inc.
Safety Issue:
Tesla, Inc. (Tesla) is recalling certain 2022-2023 Model Y vehicles. The steering wheel fastener may be loose.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Mfg Campaign: SB-23-32-001
Recall Date: May 30, 2023
Tesla, Inc.
Safety Issue:
Tesla, Inc. (Tesla) is recalling certain 2022-2023 Model Y vehicles. The bolts securing the second-row seat back frames may not have been securely tightened.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Mfg Campaign: SB-23-13-001
Recall Date: Feb 27, 2023
Tesla, Inc.
Safety Issue:
Tesla, Inc. (Tesla) is recalling certain 2016-2023 Model S, Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles equipped with Full Self-Driving Beta (FSD Beta) software or pending installation. The FSD Beta system may allow the vehicle to act unsafe around intersections, such as traveling straight through an intersection while in a turn-only lane, entering a stop sign-controlled intersection without coming to a complete stop, or proceeding into an intersection during a steady yellow traffic signal without due caution. In addition, the system may respond insufficiently to changes in posted speed limits or not adequately account for the driver's adjustment of the vehicle's speed to exceed posted speed limits.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Mfg Campaign: SB-23-00-001
Recall Date: Feb 15, 2023
Tesla, Inc.
Safety Issue:
Tesla, Inc. (Tesla) is recalling certain 2023 Model Y vehicles. The front suspension lateral link fasteners may not have been properly attached to the sub-frame.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153) or go to www.nhtsa.gov.
Mfg Campaign: SB-22-31-002
Recall Date: Dec 5, 2022
Tesla, Inc.
Safety Issue:
Tesla, Inc. (Tesla) is recalling certain 2023 Model 3 and 2020-2023 Model Y vehicles. One or both taillights may intermittently fail to illuminate.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Mfg Campaign: SB-22-00-016
Recall Date: Nov 15, 2022
Consumer Complaints
1.6K ComplaintsTesla, Inc.
Defect Description:
FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL
Potential Consequences:
This Tesla engages in "phantom braking" on a daily basis. I will be driving along at 70 mph on Adaptive Cruise Control, no other cars or otherwise around, and the brakes will suddenly slam on reducing speed to 40-50mph. It is clearly a sensor type issue. Seems to happen when a turn lane is sensed? a side road? who knows?? This has been a know issue for a very long time. it's dangerous as it will lead to rear end collision if anyone is behind. this happens without warning, almost daily, and I am not the only one experiencing this. Tesla people have no solutions. I do not routinely report things, but I feel very strongly that this is a major safety issue, so much that I am considering trading in the car for something else.
Corrective Action:
This Tesla engages in "phantom braking" on a daily basis. I will be driving along at 70 mph on Adaptive Cruise Control, no other cars or otherwise around, and the brakes will suddenly slam on reducing speed to 40-50mph. It is clearly a sensor type issue. Seems to happen when a turn lane is sensed? a side road? who knows?? This has been a know issue for a very long time. it's dangerous as it will lead to rear end collision if anyone is behind. this happens without warning, almost daily, and I am not the only one experiencing this. Tesla people have no solutions. I do not routinely report things, but I feel very strongly that this is a major safety issue, so much that I am considering trading in the car for something else.
Additional Notes:
This Tesla engages in "phantom braking" on a daily basis. I will be driving along at 70 mph on Adaptive Cruise Control, no other cars or otherwise around, and the brakes will suddenly slam on reducing speed to 40-50mph. It is clearly a sensor type issue. Seems to happen when a turn lane is sensed? a side road? who knows?? This has been a know issue for a very long time. it's dangerous as it will lead to rear end collision if anyone is behind. this happens without warning, almost daily, and I am not the only one experiencing this. Tesla people have no solutions. I do not routinely report things, but I feel very strongly that this is a major safety issue, so much that I am considering trading in the car for something else.
Mfg Campaign: 11591807
Recall Date: May 31, 2024
Tesla, Inc.
Defect Description:
VISIBILITY/WIPER
Potential Consequences:
While driving on a freeway during very heavy rain, the windshield wipers were working in auto mode. All of a sudden the wipers stopped working. Even though the visibility was almost non existent due to windshield wipers not working, I managed safely to pull over to the curb of the freeway. Upon further investigation, I realized that the auto mode of windshield wipers was not working, but manual mode was working. With the manual mode I was able to get home safely. At home in my driveway I tried the auto mode again and it worked for a few seconds and stopped. Two days later my wife contacted Tesla about the issue and was informed by service representative that it`s a known problem to Tesla for the vehicle, but as of now they do not have a fix for the problem and there is no known expected time for the fix.
Corrective Action:
While driving on a freeway during very heavy rain, the windshield wipers were working in auto mode. All of a sudden the wipers stopped working. Even though the visibility was almost non existent due to windshield wipers not working, I managed safely to pull over to the curb of the freeway. Upon further investigation, I realized that the auto mode of windshield wipers was not working, but manual mode was working. With the manual mode I was able to get home safely. At home in my driveway I tried the auto mode again and it worked for a few seconds and stopped. Two days later my wife contacted Tesla about the issue and was informed by service representative that it`s a known problem to Tesla for the vehicle, but as of now they do not have a fix for the problem and there is no known expected time for the fix.
Additional Notes:
While driving on a freeway during very heavy rain, the windshield wipers were working in auto mode. All of a sudden the wipers stopped working. Even though the visibility was almost non existent due to windshield wipers not working, I managed safely to pull over to the curb of the freeway. Upon further investigation, I realized that the auto mode of windshield wipers was not working, but manual mode was working. With the manual mode I was able to get home safely. At home in my driveway I tried the auto mode again and it worked for a few seconds and stopped. Two days later my wife contacted Tesla about the issue and was informed by service representative that it`s a known problem to Tesla for the vehicle, but as of now they do not have a fix for the problem and there is no known expected time for the fix.
Mfg Campaign: 11591605
Recall Date: May 30, 2024
Tesla, Inc.
Defect Description:
VEHICLE SPEED CONTROL
Potential Consequences:
Was traveling along the [XXX] about 5 miles north of the [XXX]. Vehicle was in traffic awareness cruise control when it suddenly applied the brakes. Vehicle did not sound any warnings. Vehicle did not display any warnings. Vehicle made no attempt to warn driver of a braking event. Vehicle traffic awareness cruise control was set to 79 or 78 mph in a 70 mile per hour zone. I was able to push the accelerator pedal to regain speed but had already dropped to about 65 mph. Vehicle did not pass under a shaded section ( I. E. no bridge or trees or big rigs) There was change in color of the road top. My foot was resting just in front of the accelerator pedal. Fortunately for us, there was no vehicles directly behind us. This incident is the 3 of this kind in this vehicle. This has me spooked to use any of the convenience software. I already do not like using the autopilot feature because of it erratic behavior. It feels very unsafe and unpredictable. We are unable to predict when this car will act on its own and feel it will cause us harm one day with actions like this. We are glad that no one was following us closely because they might have hit us. We are also upset that the vehicle never stated why it braked suddenly. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Corrective Action:
Was traveling along the [XXX] about 5 miles north of the [XXX]. Vehicle was in traffic awareness cruise control when it suddenly applied the brakes. Vehicle did not sound any warnings. Vehicle did not display any warnings. Vehicle made no attempt to warn driver of a braking event. Vehicle traffic awareness cruise control was set to 79 or 78 mph in a 70 mile per hour zone. I was able to push the accelerator pedal to regain speed but had already dropped to about 65 mph. Vehicle did not pass under a shaded section ( I. E. no bridge or trees or big rigs) There was change in color of the road top. My foot was resting just in front of the accelerator pedal. Fortunately for us, there was no vehicles directly behind us. This incident is the 3 of this kind in this vehicle. This has me spooked to use any of the convenience software. I already do not like using the autopilot feature because of it erratic behavior. It feels very unsafe and unpredictable. We are unable to predict when this car will act on its own and feel it will cause us harm one day with actions like this. We are glad that no one was following us closely because they might have hit us. We are also upset that the vehicle never stated why it braked suddenly. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Additional Notes:
Was traveling along the [XXX] about 5 miles north of the [XXX]. Vehicle was in traffic awareness cruise control when it suddenly applied the brakes. Vehicle did not sound any warnings. Vehicle did not display any warnings. Vehicle made no attempt to warn driver of a braking event. Vehicle traffic awareness cruise control was set to 79 or 78 mph in a 70 mile per hour zone. I was able to push the accelerator pedal to regain speed but had already dropped to about 65 mph. Vehicle did not pass under a shaded section ( I. E. no bridge or trees or big rigs) There was change in color of the road top. My foot was resting just in front of the accelerator pedal. Fortunately for us, there was no vehicles directly behind us. This incident is the 3 of this kind in this vehicle. This has me spooked to use any of the convenience software. I already do not like using the autopilot feature because of it erratic behavior. It feels very unsafe and unpredictable. We are unable to predict when this car will act on its own and feel it will cause us harm one day with actions like this. We are glad that no one was following us closely because they might have hit us. We are also upset that the vehicle never stated why it braked suddenly. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Mfg Campaign: 11591262
Recall Date: May 29, 2024
Tesla, Inc.
Defect Description:
FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL
Potential Consequences:
Was traveling along the [XXX] about 5 miles north of the [XXX]. Vehicle was in traffic awareness cruise control when it suddenly applied the brakes. Vehicle did not sound any warnings. Vehicle did not display any warnings. Vehicle made no attempt to warn driver of a braking event. Vehicle traffic awareness cruise control was set to 79 or 78 mph in a 70 mile per hour zone. I was able to push the accelerator pedal to regain speed but had already dropped to about 65 mph. Vehicle did not pass under a shaded section ( I. E. no bridge or trees or big rigs) There was change in color of the road top. My foot was resting just in front of the accelerator pedal. Fortunately for us, there was no vehicles directly behind us. This incident is the 3 of this kind in this vehicle. This has me spooked to use any of the convenience software. I already do not like using the autopilot feature because of it erratic behavior. It feels very unsafe and unpredictable. We are unable to predict when this car will act on its own and feel it will cause us harm one day with actions like this. We are glad that no one was following us closely because they might have hit us. We are also upset that the vehicle never stated why it braked suddenly. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Corrective Action:
Was traveling along the [XXX] about 5 miles north of the [XXX]. Vehicle was in traffic awareness cruise control when it suddenly applied the brakes. Vehicle did not sound any warnings. Vehicle did not display any warnings. Vehicle made no attempt to warn driver of a braking event. Vehicle traffic awareness cruise control was set to 79 or 78 mph in a 70 mile per hour zone. I was able to push the accelerator pedal to regain speed but had already dropped to about 65 mph. Vehicle did not pass under a shaded section ( I. E. no bridge or trees or big rigs) There was change in color of the road top. My foot was resting just in front of the accelerator pedal. Fortunately for us, there was no vehicles directly behind us. This incident is the 3 of this kind in this vehicle. This has me spooked to use any of the convenience software. I already do not like using the autopilot feature because of it erratic behavior. It feels very unsafe and unpredictable. We are unable to predict when this car will act on its own and feel it will cause us harm one day with actions like this. We are glad that no one was following us closely because they might have hit us. We are also upset that the vehicle never stated why it braked suddenly. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Additional Notes:
Was traveling along the [XXX] about 5 miles north of the [XXX]. Vehicle was in traffic awareness cruise control when it suddenly applied the brakes. Vehicle did not sound any warnings. Vehicle did not display any warnings. Vehicle made no attempt to warn driver of a braking event. Vehicle traffic awareness cruise control was set to 79 or 78 mph in a 70 mile per hour zone. I was able to push the accelerator pedal to regain speed but had already dropped to about 65 mph. Vehicle did not pass under a shaded section ( I. E. no bridge or trees or big rigs) There was change in color of the road top. My foot was resting just in front of the accelerator pedal. Fortunately for us, there was no vehicles directly behind us. This incident is the 3 of this kind in this vehicle. This has me spooked to use any of the convenience software. I already do not like using the autopilot feature because of it erratic behavior. It feels very unsafe and unpredictable. We are unable to predict when this car will act on its own and feel it will cause us harm one day with actions like this. We are glad that no one was following us closely because they might have hit us. We are also upset that the vehicle never stated why it braked suddenly. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Mfg Campaign: 11591262
Recall Date: May 29, 2024
Tesla, Inc.
Defect Description:
FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING
Potential Consequences:
Was traveling along the [XXX] about 5 miles north of the [XXX]. Vehicle was in traffic awareness cruise control when it suddenly applied the brakes. Vehicle did not sound any warnings. Vehicle did not display any warnings. Vehicle made no attempt to warn driver of a braking event. Vehicle traffic awareness cruise control was set to 79 or 78 mph in a 70 mile per hour zone. I was able to push the accelerator pedal to regain speed but had already dropped to about 65 mph. Vehicle did not pass under a shaded section ( I. E. no bridge or trees or big rigs) There was change in color of the road top. My foot was resting just in front of the accelerator pedal. Fortunately for us, there was no vehicles directly behind us. This incident is the 3 of this kind in this vehicle. This has me spooked to use any of the convenience software. I already do not like using the autopilot feature because of it erratic behavior. It feels very unsafe and unpredictable. We are unable to predict when this car will act on its own and feel it will cause us harm one day with actions like this. We are glad that no one was following us closely because they might have hit us. We are also upset that the vehicle never stated why it braked suddenly. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Corrective Action:
Was traveling along the [XXX] about 5 miles north of the [XXX]. Vehicle was in traffic awareness cruise control when it suddenly applied the brakes. Vehicle did not sound any warnings. Vehicle did not display any warnings. Vehicle made no attempt to warn driver of a braking event. Vehicle traffic awareness cruise control was set to 79 or 78 mph in a 70 mile per hour zone. I was able to push the accelerator pedal to regain speed but had already dropped to about 65 mph. Vehicle did not pass under a shaded section ( I. E. no bridge or trees or big rigs) There was change in color of the road top. My foot was resting just in front of the accelerator pedal. Fortunately for us, there was no vehicles directly behind us. This incident is the 3 of this kind in this vehicle. This has me spooked to use any of the convenience software. I already do not like using the autopilot feature because of it erratic behavior. It feels very unsafe and unpredictable. We are unable to predict when this car will act on its own and feel it will cause us harm one day with actions like this. We are glad that no one was following us closely because they might have hit us. We are also upset that the vehicle never stated why it braked suddenly. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Additional Notes:
Was traveling along the [XXX] about 5 miles north of the [XXX]. Vehicle was in traffic awareness cruise control when it suddenly applied the brakes. Vehicle did not sound any warnings. Vehicle did not display any warnings. Vehicle made no attempt to warn driver of a braking event. Vehicle traffic awareness cruise control was set to 79 or 78 mph in a 70 mile per hour zone. I was able to push the accelerator pedal to regain speed but had already dropped to about 65 mph. Vehicle did not pass under a shaded section ( I. E. no bridge or trees or big rigs) There was change in color of the road top. My foot was resting just in front of the accelerator pedal. Fortunately for us, there was no vehicles directly behind us. This incident is the 3 of this kind in this vehicle. This has me spooked to use any of the convenience software. I already do not like using the autopilot feature because of it erratic behavior. It feels very unsafe and unpredictable. We are unable to predict when this car will act on its own and feel it will cause us harm one day with actions like this. We are glad that no one was following us closely because they might have hit us. We are also upset that the vehicle never stated why it braked suddenly. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Mfg Campaign: 11591262
Recall Date: May 29, 2024
Tesla, Inc.
Defect Description:
VISIBILITY/WIPER
Potential Consequences:
Windshield wipers put in manual maximum sensitivity mode. During the trip they stopped working multiple times. They just froze. When a manual one time wipe button was pressed wipers menu showed “II” manual sensitivity and started working. Selected back manual III sensitivity. Wipers worked for a while and stopped again. SW version: 2024.14.6. Autopilot was not engaged.
Corrective Action:
Windshield wipers put in manual maximum sensitivity mode. During the trip they stopped working multiple times. They just froze. When a manual one time wipe button was pressed wipers menu showed “II” manual sensitivity and started working. Selected back manual III sensitivity. Wipers worked for a while and stopped again. SW version: 2024.14.6. Autopilot was not engaged.
Additional Notes:
Windshield wipers put in manual maximum sensitivity mode. During the trip they stopped working multiple times. They just froze. When a manual one time wipe button was pressed wipers menu showed “II” manual sensitivity and started working. Selected back manual III sensitivity. Wipers worked for a while and stopped again. SW version: 2024.14.6. Autopilot was not engaged.
Mfg Campaign: 11591139
Recall Date: May 28, 2024
Tesla, Inc.
Defect Description:
FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL
Potential Consequences:
While driving with the adaptive cruise control on, the vehicle suddenly braked. There was a large truck approaching from the other direction, but it was in its lane. There was no present danger. The hard breaking could have caused the following car to rear end us. It happened more than once, but this was the most dramatic braking.
Corrective Action:
While driving with the adaptive cruise control on, the vehicle suddenly braked. There was a large truck approaching from the other direction, but it was in its lane. There was no present danger. The hard breaking could have caused the following car to rear end us. It happened more than once, but this was the most dramatic braking.
Additional Notes:
While driving with the adaptive cruise control on, the vehicle suddenly braked. There was a large truck approaching from the other direction, but it was in its lane. There was no present danger. The hard breaking could have caused the following car to rear end us. It happened more than once, but this was the most dramatic braking.
Mfg Campaign: 11590924
Recall Date: May 27, 2024
Tesla, Inc.
Defect Description:
FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL
Potential Consequences:
FSD Stops in front of oncoming traffic. The car stops at a two-way stop sign. It pulls out into the intersection and detects traffic heading my way. It stops right in the middle of the oncoming traffic and just sits there. The oncoming traffic was moving about 50MPH. I had to hit the accelerator to get out of the way. FSD SEEMS TO WORK WELL 99% OF THE TIME. THE OTHER 1% MAY GET YOU KILLED. FULL SELF-DRIVING MODE. Tesla sent me a 30-day trial.
Corrective Action:
FSD Stops in front of oncoming traffic. The car stops at a two-way stop sign. It pulls out into the intersection and detects traffic heading my way. It stops right in the middle of the oncoming traffic and just sits there. The oncoming traffic was moving about 50MPH. I had to hit the accelerator to get out of the way. FSD SEEMS TO WORK WELL 99% OF THE TIME. THE OTHER 1% MAY GET YOU KILLED. FULL SELF-DRIVING MODE. Tesla sent me a 30-day trial.
Additional Notes:
FSD Stops in front of oncoming traffic. The car stops at a two-way stop sign. It pulls out into the intersection and detects traffic heading my way. It stops right in the middle of the oncoming traffic and just sits there. The oncoming traffic was moving about 50MPH. I had to hit the accelerator to get out of the way. FSD SEEMS TO WORK WELL 99% OF THE TIME. THE OTHER 1% MAY GET YOU KILLED. FULL SELF-DRIVING MODE. Tesla sent me a 30-day trial.
Mfg Campaign: 11590799
Recall Date: May 26, 2024
Tesla, Inc.
Defect Description:
UNKNOWN OR OTHER
Potential Consequences:
During two hour trip I experienced at least five incidents of so called Fantom Braking, when car engaged in Autopilot or adaptive cruise control brakes suddenly for no apparent reason. At least two time during this trip, the braking was really hard. This is very dangerous conditions and could result in serious accident if someone closely follow the vehicle. I had to keep my foot on the gas pedal during this trip to act if necessary. I have experienced these conditions before and reported it to Tesla. They basically ignored this complaint.
Corrective Action:
During two hour trip I experienced at least five incidents of so called Fantom Braking, when car engaged in Autopilot or adaptive cruise control brakes suddenly for no apparent reason. At least two time during this trip, the braking was really hard. This is very dangerous conditions and could result in serious accident if someone closely follow the vehicle. I had to keep my foot on the gas pedal during this trip to act if necessary. I have experienced these conditions before and reported it to Tesla. They basically ignored this complaint.
Additional Notes:
During two hour trip I experienced at least five incidents of so called Fantom Braking, when car engaged in Autopilot or adaptive cruise control brakes suddenly for no apparent reason. At least two time during this trip, the braking was really hard. This is very dangerous conditions and could result in serious accident if someone closely follow the vehicle. I had to keep my foot on the gas pedal during this trip to act if necessary. I have experienced these conditions before and reported it to Tesla. They basically ignored this complaint.
Mfg Campaign: 11590851
Recall Date: May 26, 2024
Tesla, Inc.
Defect Description:
FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL
Potential Consequences:
During two hour trip I experienced at least five incidents of so called Fantom Braking, when car engaged in Autopilot or adaptive cruise control brakes suddenly for no apparent reason. At least two time during this trip, the braking was really hard. This is very dangerous conditions and could result in serious accident if someone closely follow the vehicle. I had to keep my foot on the gas pedal during this trip to act if necessary. I have experienced these conditions before and reported it to Tesla. They basically ignored this complaint.
Corrective Action:
During two hour trip I experienced at least five incidents of so called Fantom Braking, when car engaged in Autopilot or adaptive cruise control brakes suddenly for no apparent reason. At least two time during this trip, the braking was really hard. This is very dangerous conditions and could result in serious accident if someone closely follow the vehicle. I had to keep my foot on the gas pedal during this trip to act if necessary. I have experienced these conditions before and reported it to Tesla. They basically ignored this complaint.
Additional Notes:
During two hour trip I experienced at least five incidents of so called Fantom Braking, when car engaged in Autopilot or adaptive cruise control brakes suddenly for no apparent reason. At least two time during this trip, the braking was really hard. This is very dangerous conditions and could result in serious accident if someone closely follow the vehicle. I had to keep my foot on the gas pedal during this trip to act if necessary. I have experienced these conditions before and reported it to Tesla. They basically ignored this complaint.
Mfg Campaign: 11590851
Recall Date: May 26, 2024
Tesla, Inc.
Defect Description:
AIR BAGS
Potential Consequences:
What component or system failed or malfunctioned, and is it available for inspection upon request? >>> The passenger detection hardware underneath the front passenger seat had faulty wiring. The repaired hardware completed by Tesla this week is available for inspection upon request. I did take amateur photos of my seat hardware before-and-after repair. How was your safety or the safety of others put at risk? >>> MY PASSENGER'S AIRBAG COULD RANDOMLY FAIL IN THE MIDDLE OF A DRIVE. Anywhere from 10 seconds to 10 minutes while driving with a damp passenger in the front passenger seat (e.g., a 100 lb. person after swim practice), a red airbag indicator will assert with error code rcm2_a636 ("Front passenger safety restraint system fault"). The indicator would stay asserted for days, then start toggling on-and-off randomly. According to Tesla Model Y documentation, "If the airbag system detects a fault in any of the previously mentioned components, the airbag warning indicator stays on. In this case contact Tesla service immediately. Do not drive the vehicle until the airbag system is inspected by Tesla." (reference: [XXX] ) Has the problem been reproduced or confirmed by a dealer or independent service center? >>> YES! I was able to reproduce the problem WITHIN MINUTES with the loaner Model 3 given to me by Tesla (sorry, I did not get that vehicle's VIN but I wager Tesla Ridgepoint Austin TX has it). SURELY THERE ARE TENS OF THOUSANDS OF VEHICLES WITH THIS PROBLEM! Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? >>> Yes, but only after three attempts by Tesla. Each attempt was incremental (first: cable shielding, second: upholstery, third: replace the entire seat). Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? >>> No. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Corrective Action:
What component or system failed or malfunctioned, and is it available for inspection upon request? >>> The passenger detection hardware underneath the front passenger seat had faulty wiring. The repaired hardware completed by Tesla this week is available for inspection upon request. I did take amateur photos of my seat hardware before-and-after repair. How was your safety or the safety of others put at risk? >>> MY PASSENGER'S AIRBAG COULD RANDOMLY FAIL IN THE MIDDLE OF A DRIVE. Anywhere from 10 seconds to 10 minutes while driving with a damp passenger in the front passenger seat (e.g., a 100 lb. person after swim practice), a red airbag indicator will assert with error code rcm2_a636 ("Front passenger safety restraint system fault"). The indicator would stay asserted for days, then start toggling on-and-off randomly. According to Tesla Model Y documentation, "If the airbag system detects a fault in any of the previously mentioned components, the airbag warning indicator stays on. In this case contact Tesla service immediately. Do not drive the vehicle until the airbag system is inspected by Tesla." (reference: [XXX] ) Has the problem been reproduced or confirmed by a dealer or independent service center? >>> YES! I was able to reproduce the problem WITHIN MINUTES with the loaner Model 3 given to me by Tesla (sorry, I did not get that vehicle's VIN but I wager Tesla Ridgepoint Austin TX has it). SURELY THERE ARE TENS OF THOUSANDS OF VEHICLES WITH THIS PROBLEM! Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? >>> Yes, but only after three attempts by Tesla. Each attempt was incremental (first: cable shielding, second: upholstery, third: replace the entire seat). Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? >>> No. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Additional Notes:
What component or system failed or malfunctioned, and is it available for inspection upon request? >>> The passenger detection hardware underneath the front passenger seat had faulty wiring. The repaired hardware completed by Tesla this week is available for inspection upon request. I did take amateur photos of my seat hardware before-and-after repair. How was your safety or the safety of others put at risk? >>> MY PASSENGER'S AIRBAG COULD RANDOMLY FAIL IN THE MIDDLE OF A DRIVE. Anywhere from 10 seconds to 10 minutes while driving with a damp passenger in the front passenger seat (e.g., a 100 lb. person after swim practice), a red airbag indicator will assert with error code rcm2_a636 ("Front passenger safety restraint system fault"). The indicator would stay asserted for days, then start toggling on-and-off randomly. According to Tesla Model Y documentation, "If the airbag system detects a fault in any of the previously mentioned components, the airbag warning indicator stays on. In this case contact Tesla service immediately. Do not drive the vehicle until the airbag system is inspected by Tesla." (reference: [XXX] ) Has the problem been reproduced or confirmed by a dealer or independent service center? >>> YES! I was able to reproduce the problem WITHIN MINUTES with the loaner Model 3 given to me by Tesla (sorry, I did not get that vehicle's VIN but I wager Tesla Ridgepoint Austin TX has it). SURELY THERE ARE TENS OF THOUSANDS OF VEHICLES WITH THIS PROBLEM! Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? >>> Yes, but only after three attempts by Tesla. Each attempt was incremental (first: cable shielding, second: upholstery, third: replace the entire seat). Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? >>> No. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Mfg Campaign: 11590663
Recall Date: May 24, 2024
Tesla, Inc.
Defect Description:
SEAT BELTS
Potential Consequences:
What component or system failed or malfunctioned, and is it available for inspection upon request? >>> The passenger detection hardware underneath the front passenger seat had faulty wiring. The repaired hardware completed by Tesla this week is available for inspection upon request. I did take amateur photos of my seat hardware before-and-after repair. How was your safety or the safety of others put at risk? >>> MY PASSENGER'S AIRBAG COULD RANDOMLY FAIL IN THE MIDDLE OF A DRIVE. Anywhere from 10 seconds to 10 minutes while driving with a damp passenger in the front passenger seat (e.g., a 100 lb. person after swim practice), a red airbag indicator will assert with error code rcm2_a636 ("Front passenger safety restraint system fault"). The indicator would stay asserted for days, then start toggling on-and-off randomly. According to Tesla Model Y documentation, "If the airbag system detects a fault in any of the previously mentioned components, the airbag warning indicator stays on. In this case contact Tesla service immediately. Do not drive the vehicle until the airbag system is inspected by Tesla." (reference: [XXX] ) Has the problem been reproduced or confirmed by a dealer or independent service center? >>> YES! I was able to reproduce the problem WITHIN MINUTES with the loaner Model 3 given to me by Tesla (sorry, I did not get that vehicle's VIN but I wager Tesla Ridgepoint Austin TX has it). SURELY THERE ARE TENS OF THOUSANDS OF VEHICLES WITH THIS PROBLEM! Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? >>> Yes, but only after three attempts by Tesla. Each attempt was incremental (first: cable shielding, second: upholstery, third: replace the entire seat). Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? >>> No. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Corrective Action:
What component or system failed or malfunctioned, and is it available for inspection upon request? >>> The passenger detection hardware underneath the front passenger seat had faulty wiring. The repaired hardware completed by Tesla this week is available for inspection upon request. I did take amateur photos of my seat hardware before-and-after repair. How was your safety or the safety of others put at risk? >>> MY PASSENGER'S AIRBAG COULD RANDOMLY FAIL IN THE MIDDLE OF A DRIVE. Anywhere from 10 seconds to 10 minutes while driving with a damp passenger in the front passenger seat (e.g., a 100 lb. person after swim practice), a red airbag indicator will assert with error code rcm2_a636 ("Front passenger safety restraint system fault"). The indicator would stay asserted for days, then start toggling on-and-off randomly. According to Tesla Model Y documentation, "If the airbag system detects a fault in any of the previously mentioned components, the airbag warning indicator stays on. In this case contact Tesla service immediately. Do not drive the vehicle until the airbag system is inspected by Tesla." (reference: [XXX] ) Has the problem been reproduced or confirmed by a dealer or independent service center? >>> YES! I was able to reproduce the problem WITHIN MINUTES with the loaner Model 3 given to me by Tesla (sorry, I did not get that vehicle's VIN but I wager Tesla Ridgepoint Austin TX has it). SURELY THERE ARE TENS OF THOUSANDS OF VEHICLES WITH THIS PROBLEM! Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? >>> Yes, but only after three attempts by Tesla. Each attempt was incremental (first: cable shielding, second: upholstery, third: replace the entire seat). Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? >>> No. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Additional Notes:
What component or system failed or malfunctioned, and is it available for inspection upon request? >>> The passenger detection hardware underneath the front passenger seat had faulty wiring. The repaired hardware completed by Tesla this week is available for inspection upon request. I did take amateur photos of my seat hardware before-and-after repair. How was your safety or the safety of others put at risk? >>> MY PASSENGER'S AIRBAG COULD RANDOMLY FAIL IN THE MIDDLE OF A DRIVE. Anywhere from 10 seconds to 10 minutes while driving with a damp passenger in the front passenger seat (e.g., a 100 lb. person after swim practice), a red airbag indicator will assert with error code rcm2_a636 ("Front passenger safety restraint system fault"). The indicator would stay asserted for days, then start toggling on-and-off randomly. According to Tesla Model Y documentation, "If the airbag system detects a fault in any of the previously mentioned components, the airbag warning indicator stays on. In this case contact Tesla service immediately. Do not drive the vehicle until the airbag system is inspected by Tesla." (reference: [XXX] ) Has the problem been reproduced or confirmed by a dealer or independent service center? >>> YES! I was able to reproduce the problem WITHIN MINUTES with the loaner Model 3 given to me by Tesla (sorry, I did not get that vehicle's VIN but I wager Tesla Ridgepoint Austin TX has it). SURELY THERE ARE TENS OF THOUSANDS OF VEHICLES WITH THIS PROBLEM! Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? >>> Yes, but only after three attempts by Tesla. Each attempt was incremental (first: cable shielding, second: upholstery, third: replace the entire seat). Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? >>> No. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Mfg Campaign: 11590663
Recall Date: May 24, 2024
Tesla, Inc.
Defect Description:
AIR BAGS
Potential Consequences:
My car collided with another car and a fine white powder was released but no airbag was deployed along with a slight burning odor
Corrective Action:
My car collided with another car and a fine white powder was released but no airbag was deployed along with a slight burning odor
Additional Notes:
My car collided with another car and a fine white powder was released but no airbag was deployed along with a slight burning odor
Mfg Campaign: 11590673
Recall Date: May 24, 2024
Tesla, Inc.
Defect Description:
SEAT BELTS
Potential Consequences:
The contact owns a 2023 Tesla Model Y. The contact stated that while the vehicle was parked with the car seat installed, the technician pulled on the seat belt and the rear passenger’s side seat belt buckle fractured. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was approximately 3,000.
Corrective Action:
The contact owns a 2023 Tesla Model Y. The contact stated that while the vehicle was parked with the car seat installed, the technician pulled on the seat belt and the rear passenger’s side seat belt buckle fractured. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was approximately 3,000.
Additional Notes:
The contact owns a 2023 Tesla Model Y. The contact stated that while the vehicle was parked with the car seat installed, the technician pulled on the seat belt and the rear passenger’s side seat belt buckle fractured. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was approximately 3,000.
Mfg Campaign: 11590442
Recall Date: May 23, 2024
Tesla, Inc.
Defect Description:
AIR BAGS
Potential Consequences:
I’ve received repeated errors of front right safety restraint system needs service with an indication of the airbags being disabled. Tesla has attempted to fix this on two occasions by replacing various wiring and seat belt parts, but the problem returns each time.
Corrective Action:
I’ve received repeated errors of front right safety restraint system needs service with an indication of the airbags being disabled. Tesla has attempted to fix this on two occasions by replacing various wiring and seat belt parts, but the problem returns each time.
Additional Notes:
I’ve received repeated errors of front right safety restraint system needs service with an indication of the airbags being disabled. Tesla has attempted to fix this on two occasions by replacing various wiring and seat belt parts, but the problem returns each time.
Mfg Campaign: 11590269
Recall Date: May 22, 2024
Tesla, Inc.
Defect Description:
SEATS
Potential Consequences:
I’ve received repeated errors of front right safety restraint system needs service with an indication of the airbags being disabled. Tesla has attempted to fix this on two occasions by replacing various wiring and seat belt parts, but the problem returns each time.
Corrective Action:
I’ve received repeated errors of front right safety restraint system needs service with an indication of the airbags being disabled. Tesla has attempted to fix this on two occasions by replacing various wiring and seat belt parts, but the problem returns each time.
Additional Notes:
I’ve received repeated errors of front right safety restraint system needs service with an indication of the airbags being disabled. Tesla has attempted to fix this on two occasions by replacing various wiring and seat belt parts, but the problem returns each time.
Mfg Campaign: 11590269
Recall Date: May 22, 2024
Tesla, Inc.
Defect Description:
SEAT BELTS
Potential Consequences:
I’ve received repeated errors of front right safety restraint system needs service with an indication of the airbags being disabled. Tesla has attempted to fix this on two occasions by replacing various wiring and seat belt parts, but the problem returns each time.
Corrective Action:
I’ve received repeated errors of front right safety restraint system needs service with an indication of the airbags being disabled. Tesla has attempted to fix this on two occasions by replacing various wiring and seat belt parts, but the problem returns each time.
Additional Notes:
I’ve received repeated errors of front right safety restraint system needs service with an indication of the airbags being disabled. Tesla has attempted to fix this on two occasions by replacing various wiring and seat belt parts, but the problem returns each time.
Mfg Campaign: 11590269
Recall Date: May 22, 2024
Tesla, Inc.
Defect Description:
SERVICE BRAKES
Potential Consequences:
I bought a 2023 Tesla Long-range Y in June 2023 at Tesla Santa Fe, New Mexico. I have had trouble with the brakes applying on their own during cruise control. It was very scary the first time it happened, but luckily there was very little traffic on the 2-lane highway I was traveling on. The Tesla dealer in Santa Fe told me they don't have a software fix yet and he simply avoids cruise control. After a few months I cautiously tried cruise control again and got away with it...but the third time, months later, it happened again. When the free month trial of Auto Pilot was installed, I did not intend to use it. Toward the end of the trial, I used it on [XXX] coming home to Las Cruces and realized it might actually auto-brake on the freeway, which could be a disaster. After that trip a Tesla friend shared his near-accident-causing experience with the cruise control braking. Another issue is that the key card didn't unlock the car, then wouldn't start the car. I called Tesla and was told I could reset the key card using the Tesla App, but it did not work. The next day I called Tesla support; he ran the diagnostics and said "oh yes, your car needs to be re-booted". He did so, and the key card worked to lock the car, but not to unlock or start it. I asked him to send me a new key card. "We sell a set of 2 for $45" (this is what came with the car). I told him I paid $53,000 for the car less than a year ago, it did not come with a charge cable, and now the key card didn't work? He looked to see if the key card was covered under warranty and found it was not. I have been unable to reach a person to speak with at either the NM dealer where I bought it or the El Paso dealer where I test-drove and attended the seminar, and have waited on the phone for exorbitant amounts of time while the bot tells me I can manage most problems on the Tesla app. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Corrective Action:
I bought a 2023 Tesla Long-range Y in June 2023 at Tesla Santa Fe, New Mexico. I have had trouble with the brakes applying on their own during cruise control. It was very scary the first time it happened, but luckily there was very little traffic on the 2-lane highway I was traveling on. The Tesla dealer in Santa Fe told me they don't have a software fix yet and he simply avoids cruise control. After a few months I cautiously tried cruise control again and got away with it...but the third time, months later, it happened again. When the free month trial of Auto Pilot was installed, I did not intend to use it. Toward the end of the trial, I used it on [XXX] coming home to Las Cruces and realized it might actually auto-brake on the freeway, which could be a disaster. After that trip a Tesla friend shared his near-accident-causing experience with the cruise control braking. Another issue is that the key card didn't unlock the car, then wouldn't start the car. I called Tesla and was told I could reset the key card using the Tesla App, but it did not work. The next day I called Tesla support; he ran the diagnostics and said "oh yes, your car needs to be re-booted". He did so, and the key card worked to lock the car, but not to unlock or start it. I asked him to send me a new key card. "We sell a set of 2 for $45" (this is what came with the car). I told him I paid $53,000 for the car less than a year ago, it did not come with a charge cable, and now the key card didn't work? He looked to see if the key card was covered under warranty and found it was not. I have been unable to reach a person to speak with at either the NM dealer where I bought it or the El Paso dealer where I test-drove and attended the seminar, and have waited on the phone for exorbitant amounts of time while the bot tells me I can manage most problems on the Tesla app. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Additional Notes:
I bought a 2023 Tesla Long-range Y in June 2023 at Tesla Santa Fe, New Mexico. I have had trouble with the brakes applying on their own during cruise control. It was very scary the first time it happened, but luckily there was very little traffic on the 2-lane highway I was traveling on. The Tesla dealer in Santa Fe told me they don't have a software fix yet and he simply avoids cruise control. After a few months I cautiously tried cruise control again and got away with it...but the third time, months later, it happened again. When the free month trial of Auto Pilot was installed, I did not intend to use it. Toward the end of the trial, I used it on [XXX] coming home to Las Cruces and realized it might actually auto-brake on the freeway, which could be a disaster. After that trip a Tesla friend shared his near-accident-causing experience with the cruise control braking. Another issue is that the key card didn't unlock the car, then wouldn't start the car. I called Tesla and was told I could reset the key card using the Tesla App, but it did not work. The next day I called Tesla support; he ran the diagnostics and said "oh yes, your car needs to be re-booted". He did so, and the key card worked to lock the car, but not to unlock or start it. I asked him to send me a new key card. "We sell a set of 2 for $45" (this is what came with the car). I told him I paid $53,000 for the car less than a year ago, it did not come with a charge cable, and now the key card didn't work? He looked to see if the key card was covered under warranty and found it was not. I have been unable to reach a person to speak with at either the NM dealer where I bought it or the El Paso dealer where I test-drove and attended the seminar, and have waited on the phone for exorbitant amounts of time while the bot tells me I can manage most problems on the Tesla app. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Mfg Campaign: 11589255
Recall Date: May 17, 2024
Tesla, Inc.
Defect Description:
ELECTRICAL SYSTEM
Potential Consequences:
I bought a 2023 Tesla Long-range Y in June 2023 at Tesla Santa Fe, New Mexico. I have had trouble with the brakes applying on their own during cruise control. It was very scary the first time it happened, but luckily there was very little traffic on the 2-lane highway I was traveling on. The Tesla dealer in Santa Fe told me they don't have a software fix yet and he simply avoids cruise control. After a few months I cautiously tried cruise control again and got away with it...but the third time, months later, it happened again. When the free month trial of Auto Pilot was installed, I did not intend to use it. Toward the end of the trial, I used it on [XXX] coming home to Las Cruces and realized it might actually auto-brake on the freeway, which could be a disaster. After that trip a Tesla friend shared his near-accident-causing experience with the cruise control braking. Another issue is that the key card didn't unlock the car, then wouldn't start the car. I called Tesla and was told I could reset the key card using the Tesla App, but it did not work. The next day I called Tesla support; he ran the diagnostics and said "oh yes, your car needs to be re-booted". He did so, and the key card worked to lock the car, but not to unlock or start it. I asked him to send me a new key card. "We sell a set of 2 for $45" (this is what came with the car). I told him I paid $53,000 for the car less than a year ago, it did not come with a charge cable, and now the key card didn't work? He looked to see if the key card was covered under warranty and found it was not. I have been unable to reach a person to speak with at either the NM dealer where I bought it or the El Paso dealer where I test-drove and attended the seminar, and have waited on the phone for exorbitant amounts of time while the bot tells me I can manage most problems on the Tesla app. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Corrective Action:
I bought a 2023 Tesla Long-range Y in June 2023 at Tesla Santa Fe, New Mexico. I have had trouble with the brakes applying on their own during cruise control. It was very scary the first time it happened, but luckily there was very little traffic on the 2-lane highway I was traveling on. The Tesla dealer in Santa Fe told me they don't have a software fix yet and he simply avoids cruise control. After a few months I cautiously tried cruise control again and got away with it...but the third time, months later, it happened again. When the free month trial of Auto Pilot was installed, I did not intend to use it. Toward the end of the trial, I used it on [XXX] coming home to Las Cruces and realized it might actually auto-brake on the freeway, which could be a disaster. After that trip a Tesla friend shared his near-accident-causing experience with the cruise control braking. Another issue is that the key card didn't unlock the car, then wouldn't start the car. I called Tesla and was told I could reset the key card using the Tesla App, but it did not work. The next day I called Tesla support; he ran the diagnostics and said "oh yes, your car needs to be re-booted". He did so, and the key card worked to lock the car, but not to unlock or start it. I asked him to send me a new key card. "We sell a set of 2 for $45" (this is what came with the car). I told him I paid $53,000 for the car less than a year ago, it did not come with a charge cable, and now the key card didn't work? He looked to see if the key card was covered under warranty and found it was not. I have been unable to reach a person to speak with at either the NM dealer where I bought it or the El Paso dealer where I test-drove and attended the seminar, and have waited on the phone for exorbitant amounts of time while the bot tells me I can manage most problems on the Tesla app. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Additional Notes:
I bought a 2023 Tesla Long-range Y in June 2023 at Tesla Santa Fe, New Mexico. I have had trouble with the brakes applying on their own during cruise control. It was very scary the first time it happened, but luckily there was very little traffic on the 2-lane highway I was traveling on. The Tesla dealer in Santa Fe told me they don't have a software fix yet and he simply avoids cruise control. After a few months I cautiously tried cruise control again and got away with it...but the third time, months later, it happened again. When the free month trial of Auto Pilot was installed, I did not intend to use it. Toward the end of the trial, I used it on [XXX] coming home to Las Cruces and realized it might actually auto-brake on the freeway, which could be a disaster. After that trip a Tesla friend shared his near-accident-causing experience with the cruise control braking. Another issue is that the key card didn't unlock the car, then wouldn't start the car. I called Tesla and was told I could reset the key card using the Tesla App, but it did not work. The next day I called Tesla support; he ran the diagnostics and said "oh yes, your car needs to be re-booted". He did so, and the key card worked to lock the car, but not to unlock or start it. I asked him to send me a new key card. "We sell a set of 2 for $45" (this is what came with the car). I told him I paid $53,000 for the car less than a year ago, it did not come with a charge cable, and now the key card didn't work? He looked to see if the key card was covered under warranty and found it was not. I have been unable to reach a person to speak with at either the NM dealer where I bought it or the El Paso dealer where I test-drove and attended the seminar, and have waited on the phone for exorbitant amounts of time while the bot tells me I can manage most problems on the Tesla app. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Mfg Campaign: 11589255
Recall Date: May 17, 2024
Tesla, Inc.
Defect Description:
FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING
Potential Consequences:
I bought a 2023 Tesla Long-range Y in June 2023 at Tesla Santa Fe, New Mexico. I have had trouble with the brakes applying on their own during cruise control. It was very scary the first time it happened, but luckily there was very little traffic on the 2-lane highway I was traveling on. The Tesla dealer in Santa Fe told me they don't have a software fix yet and he simply avoids cruise control. After a few months I cautiously tried cruise control again and got away with it...but the third time, months later, it happened again. When the free month trial of Auto Pilot was installed, I did not intend to use it. Toward the end of the trial, I used it on [XXX] coming home to Las Cruces and realized it might actually auto-brake on the freeway, which could be a disaster. After that trip a Tesla friend shared his near-accident-causing experience with the cruise control braking. Another issue is that the key card didn't unlock the car, then wouldn't start the car. I called Tesla and was told I could reset the key card using the Tesla App, but it did not work. The next day I called Tesla support; he ran the diagnostics and said "oh yes, your car needs to be re-booted". He did so, and the key card worked to lock the car, but not to unlock or start it. I asked him to send me a new key card. "We sell a set of 2 for $45" (this is what came with the car). I told him I paid $53,000 for the car less than a year ago, it did not come with a charge cable, and now the key card didn't work? He looked to see if the key card was covered under warranty and found it was not. I have been unable to reach a person to speak with at either the NM dealer where I bought it or the El Paso dealer where I test-drove and attended the seminar, and have waited on the phone for exorbitant amounts of time while the bot tells me I can manage most problems on the Tesla app. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Corrective Action:
I bought a 2023 Tesla Long-range Y in June 2023 at Tesla Santa Fe, New Mexico. I have had trouble with the brakes applying on their own during cruise control. It was very scary the first time it happened, but luckily there was very little traffic on the 2-lane highway I was traveling on. The Tesla dealer in Santa Fe told me they don't have a software fix yet and he simply avoids cruise control. After a few months I cautiously tried cruise control again and got away with it...but the third time, months later, it happened again. When the free month trial of Auto Pilot was installed, I did not intend to use it. Toward the end of the trial, I used it on [XXX] coming home to Las Cruces and realized it might actually auto-brake on the freeway, which could be a disaster. After that trip a Tesla friend shared his near-accident-causing experience with the cruise control braking. Another issue is that the key card didn't unlock the car, then wouldn't start the car. I called Tesla and was told I could reset the key card using the Tesla App, but it did not work. The next day I called Tesla support; he ran the diagnostics and said "oh yes, your car needs to be re-booted". He did so, and the key card worked to lock the car, but not to unlock or start it. I asked him to send me a new key card. "We sell a set of 2 for $45" (this is what came with the car). I told him I paid $53,000 for the car less than a year ago, it did not come with a charge cable, and now the key card didn't work? He looked to see if the key card was covered under warranty and found it was not. I have been unable to reach a person to speak with at either the NM dealer where I bought it or the El Paso dealer where I test-drove and attended the seminar, and have waited on the phone for exorbitant amounts of time while the bot tells me I can manage most problems on the Tesla app. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Additional Notes:
I bought a 2023 Tesla Long-range Y in June 2023 at Tesla Santa Fe, New Mexico. I have had trouble with the brakes applying on their own during cruise control. It was very scary the first time it happened, but luckily there was very little traffic on the 2-lane highway I was traveling on. The Tesla dealer in Santa Fe told me they don't have a software fix yet and he simply avoids cruise control. After a few months I cautiously tried cruise control again and got away with it...but the third time, months later, it happened again. When the free month trial of Auto Pilot was installed, I did not intend to use it. Toward the end of the trial, I used it on [XXX] coming home to Las Cruces and realized it might actually auto-brake on the freeway, which could be a disaster. After that trip a Tesla friend shared his near-accident-causing experience with the cruise control braking. Another issue is that the key card didn't unlock the car, then wouldn't start the car. I called Tesla and was told I could reset the key card using the Tesla App, but it did not work. The next day I called Tesla support; he ran the diagnostics and said "oh yes, your car needs to be re-booted". He did so, and the key card worked to lock the car, but not to unlock or start it. I asked him to send me a new key card. "We sell a set of 2 for $45" (this is what came with the car). I told him I paid $53,000 for the car less than a year ago, it did not come with a charge cable, and now the key card didn't work? He looked to see if the key card was covered under warranty and found it was not. I have been unable to reach a person to speak with at either the NM dealer where I bought it or the El Paso dealer where I test-drove and attended the seminar, and have waited on the phone for exorbitant amounts of time while the bot tells me I can manage most problems on the Tesla app. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Mfg Campaign: 11589255
Recall Date: May 17, 2024
Need Legal Help?
Featured Attorneys
Barry Edzant
Edzant Price LLC
Valencia, CA • 36 yrs
Focus: Lemon Law, Personal Injury
Recent Articles
Jeep Grand Cherokee Head Restraint Problem
Chrysler (FCA US, LLC) has announced a safety issue affecting certain 2023–2024 Jeep Grand Ch ...
Aug 1, 2025Fuel Injector Problem: 2021-2024 Ford Bronco Sport and 2020-2022 Ford Escape
If you own a 2021-2024 Ford Bronco Sport or 2020-2022 Ford Escape equipped with a 1.5L Dragon GTDI e ...
Jul 28, 2025Airbag Problem Affects 2022-2025 Chrysler Pacifica and Voyager Vehicles
If you own a Chrysler Pacifica or Voyager, your vehicle may be equipped with defective side curtain ...
Jul 24, 2025