TESLA MODEL S 2016

Complete listing of complaints and recalls for this vehicle

971
Complaints
14
Recalls

Complaints & Recalls

971 Complaints 14 Recalls

Official Safety Recalls - Important!

14 Recalls

These are official manufacturer recalls ordered by NHTSA for safety defects. If you own this vehicle, contact your dealer immediately for free repairs.

Tesla, Inc.
NHTSA Campaign: 24V376000 SAFETY RECALL
125.2K Vehicles Affected
Recall Date: May 28, 2024
Safety Issue:

Tesla, Inc. (Tesla) is recalling certain 2012-2024 Model S, 2015-2024 Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles. In the event of an unbelted driver, the seat belt warning light and audible chime may not activate as intended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."

Potential Risk:
A seat belt warning system that fails to alert occupants of an unbelted seat belt can increase the risk of injury during a crash.
FREE Recall Solution:
Tesla will release an over-the-air (OTA) software update. Owner notification letters were mailed July 26, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-008.
Additional Details:

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.

Action Required: Contact your local TESLA dealer to schedule your FREE recall repair.
Manufacturer: TESLA
Mfg Campaign: SB-24-00-008
Notice Date: Jul 26, 2024
Recall Date: May 28, 2024
Tesla, Inc.
NHTSA Campaign: 24V051000 SAFETY RECALL
2.2M Vehicles Affected
Recall Date: Jan 30, 2024
Safety Issue:

Tesla, Inc. (Tesla) is recalling certain 2012-2023 Model S, 2016-2024 Model X, 2017-2023 Model 3, 2019-2024 Model Y, and 2024 Cybertruck vehicles. An incorrect font size is displayed on the instrument panel for the Brake, Park, and Antilock Brake System (ABS) warning lights. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 105, "Hydraulic and Electric Brake Systems" and 135, "Light Vehicle Brake Systems."

Potential Risk:
Warning lights with a smaller font size can make critical safety information on the instrument panel difficult to read, increasing the risk of a crash.
FREE Recall Solution:
Tesla began releasing an over-the-air (OTA) software update, free of charge. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-003.
Additional Details:

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.

Action Required: Contact your local TESLA dealer to schedule your FREE recall repair.
Manufacturer: TESLA
Mfg Campaign: SB-24-00-003
Notice Date: Feb 21, 2024
Recall Date: Jan 30, 2024
Tesla, Inc.
NHTSA Campaign: 23V838000 SAFETY RECALL
2M Vehicles Affected
Recall Date: Dec 12, 2023
Safety Issue:

Tesla, Inc. (Tesla) is recalling 2012-2023 Model S, 2016-2023 Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles equipped with all versions of Autosteer leading up to the version(s) that contains the recall remedy. In certain circumstances when Autosteer is engaged, the prominence and scope of the feature's controls may not be sufficient to prevent driver misuse of the SAE Level 2 advanced driver-assistance feature.

Potential Risk:
In certain circumstances when Autosteer is engaged, and the driver does not maintain responsibility for vehicle operation and is unprepared to intervene as necessary or fails to recognize when Autosteer is canceled or not engaged, there may be an increased risk of a crash.
FREE Recall Solution:
Tesla will release an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed February 10, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-23-00-008.
Additional Details:

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.

Action Required: Contact your local TESLA dealer to schedule your FREE recall repair.
Manufacturer: TESLA
Mfg Campaign: SB-23-00-008
Notice Date: Feb 10, 2024
Recall Date: Dec 12, 2023
Tesla, Inc.
NHTSA Campaign: 23V085000 SAFETY RECALL
362.8K Vehicles Affected
Recall Date: Feb 15, 2023
Safety Issue:

Tesla, Inc. (Tesla) is recalling certain 2016-2023 Model S, Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles equipped with Full Self-Driving Beta (FSD Beta) software or pending installation. The FSD Beta system may allow the vehicle to act unsafe around intersections, such as traveling straight through an intersection while in a turn-only lane, entering a stop sign-controlled intersection without coming to a complete stop, or proceeding into an intersection during a steady yellow traffic signal without due caution. In addition, the system may respond insufficiently to changes in posted speed limits or not adequately account for the driver's adjustment of the vehicle's speed to exceed posted speed limits.

Potential Risk:
FSD Beta software that allows a vehicle to exceed speed limits or travel through intersections in an unlawful or unpredictable manner increases the risk of a crash.
FREE Recall Solution:
Tesla will release an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed April 15, 2023. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-23-00-001.
Additional Details:

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.

Action Required: Contact your local TESLA dealer to schedule your FREE recall repair.
Manufacturer: TESLA
Mfg Campaign: SB-23-00-001
Notice Date: Apr 15, 2023
Recall Date: Feb 15, 2023
Tesla, Inc.
NHTSA Campaign: 22V037000 SAFETY RECALL
53.8K Vehicles Affected
Recall Date: Jan 27, 2022
Safety Issue:

Tesla, Inc. (Tesla) is recalling certain 2016-2022 Model S and Model X, 2017-2022 Model 3, and 2020-2022 Model Y vehicles. The "rolling stop" functionality available as part of the Full Self-Driving (Beta) software may allow the vehicle to travel through an all-way stop intersection without first coming to a stop.

Potential Risk:
Failing to stop at a stop sign can increase the risk of a crash.
FREE Recall Solution:
Tesla will perform an over-the-air (OTA) software update that disables the "rolling stop" functionality, free of charge. Owner notification letters were mailed March 28, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-001.
Additional Details:

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.

Action Required: Contact your local TESLA dealer to schedule your FREE recall repair.
Manufacturer: TESLA
Mfg Campaign: SB-22-00-001
Notice Date: Mar 28, 2022
Recall Date: Jan 27, 2022
Tesla, Inc.
NHTSA Campaign: 21V00B000 SAFETY RECALL
130.4K Vehicles Affected
Recall Date: Dec 21, 2021
Safety Issue:

Tesla, Inc. (Tesla) is recalling certain 2014-2021 Model S vehicles. The front trunk latch assembly may be misaligned, preventing the secondary hood latch from engaging. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 113, "Hood Latch System."

Potential Risk:
If the primary latch is inadvertently released and the secondary latch is not engaged, the hood could open unexpectedly, obstructing the driver's view and increasing the risk of a crash.
FREE Recall Solution:
Tesla Service will inspect and reposition the latch assembly as necessary, free of charge. Owner notification letters were mailed February 18, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-21-11-003.
Additional Details:

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.

Action Required: Contact your local TESLA dealer to schedule your FREE recall repair.
Manufacturer: TESLA
Mfg Campaign: SB-21-11-003
Notice Date: Feb 18, 2022
Recall Date: Dec 21, 2021
Tesla, Inc.
NHTSA Campaign: 21V035000 SAFETY RECALL
135K Vehicles Affected
Recall Date: Jan 29, 2021
Safety Issue:

Tesla, Inc. (Tesla) is recalling certain 2012-2018 Tesla Model S and 2016-2018 Model X vehicles with a center display equipped with a NVIDIA Tegra 3 processor and an 8GB eMMC NAND flash memory device. When the 8GB eMMC NAND flash memory device for the center display reaches lifetime wear, the eMMC controller will no longer be able to maintain the integrity of the filesystem, causing a failure in some of the center display functions.

Potential Risk:
The eMMC controller wear-out condition can cause the loss of the rearview camera display, defrost/defog control settings, and exterior turn signal lighting, reducing visibility and increasing the risk of a crash.
FREE Recall Solution:
Owners should ensure their vehicles are operating firmware release 2020.48.48.12 or newer, which will alert owners if the eMMC is approaching lifetime wear. Tesla will notify owners, and will replace the VCM daughterboard with one containing an enhanced eMMC controller, free of charge. The recall began March 29, 2021. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-21-21-001.
Additional Details:

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Action Required: Contact your local TESLA dealer to schedule your FREE recall repair.
Manufacturer: TESLA
Mfg Campaign: SB-21-21-001
Notice Date: Mar 29, 2021
Recall Date: Jan 29, 2021
Tesla, Inc.
NHTSA Campaign: 19V002000 SAFETY RECALL
68.7K Vehicles Affected
Recall Date: Jan 7, 2019
Safety Issue:

Tesla, Inc. (Tesla) is recalling all 2014-2016 Model S vehicles equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.

Potential Risk:
An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
FREE Recall Solution:
Tesla will notify owners, and Tesla Service Centers will replace the passenger frontal air bag modules, free of charge. The recall began May 29, 2019. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-19-20-001.
Additional Details:

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Action Required: Contact your local TESLA dealer to schedule your FREE recall repair.
Manufacturer: TESLA
Mfg Campaign: SB-19-20-001
Notice Date: May 29, 2019
Recall Date: Jan 7, 2019
Tesla, Inc.
NHTSA Campaign: 18V204000 SAFETY RECALL
70.4K Vehicles Affected
Recall Date: Mar 29, 2018
Safety Issue:

Tesla, Inc. (Tesla) is recalling certain 2012-2016 Tesla Model S vehicles equipped with Bosch steering racks. The aluminum bolts that attach the power steering gear assist motor to the gear housing may corrode and fracture causing a reduction or complete loss of power steering assist.

Potential Risk:
Loss of power steering assist would require a higher steering effort, especially at lower speeds, which may increase the risk of a crash.
FREE Recall Solution:
Tesla will notify owners, and Tesla Service Centers will replace the steering gear mounting bolts and add a corrosion-preventative sealer, free of charge. The recall began May 7, 2019. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-18-32-002.
Additional Details:

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Action Required: Contact your local TESLA dealer to schedule your FREE recall repair.
Manufacturer: TESLA
Mfg Campaign: SB-18-32-002
Notice Date: May 7, 2019
Recall Date: Mar 29, 2018
Tesla Motors, Inc.
NHTSA Campaign: 17V260000 SAFETY RECALL
31.7K Vehicles Affected
Recall Date: Apr 19, 2017
Safety Issue:

Tesla, Inc. (Tesla) is recalling certain 2016 Model S and Model X vehicles. The electric parking brake calipers have an internal gear that may be improperly manufactured, possibly resulting in the gear fracturing during parking brake application or release.

Potential Risk:
If the gear breaks during parking brake release, the vehicle will not be able to be moved. If the gear breaks during parking brake application, the parking brake may not adequately hold the vehicle, potentially resulting in the vehicle rolling, increasing the risk of a crash.
FREE Recall Solution:
Tesla will notify owners, and service centers will replace both the left and right electric parking brake calipers, free of charge. The recall began March 6, 2018. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-17-33-002.
Additional Details:

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Action Required: Contact your local TESLA dealer to schedule your FREE recall repair.
Manufacturer: TESLA
Mfg Campaign: SB-17-33-002
Notice Date: Mar 6, 2018
Recall Date: Apr 19, 2017

Consumer Complaints

971 Complaints
Tesla, Inc.
Campaign: 11676368 Other
Jul 26, 2025
Defect Description:

SUSPENSION

Potential Consequences:

I was backing out of a parking space and the front driver side fore link broke. Internet search reveals this is a known issue associated with Tesla Model S during the period mine was manufactured (February 2016), caused an investigation & service bulletin from the NHTSA, and a recall in China, hence I wanted to report this occurence.

Corrective Action:

I was backing out of a parking space and the front driver side fore link broke. Internet search reveals this is a known issue associated with Tesla Model S during the period mine was manufactured (February 2016), caused an investigation & service bulletin from the NHTSA, and a recall in China, hence I wanted to report this occurence.

Additional Notes:

I was backing out of a parking space and the front driver side fore link broke. Internet search reveals this is a known issue associated with Tesla Model S during the period mine was manufactured (February 2016), caused an investigation & service bulletin from the NHTSA, and a recall in China, hence I wanted to report this occurence.

Manufacturer: TESLA
Mfg Campaign: 11676368
Notice Date: Jul 26, 2025
Recall Date: Jul 26, 2025
Tesla, Inc.
Campaign: 11673529 Other
Jul 14, 2025
Defect Description:

ELECTRICAL SYSTEM

Potential Consequences:

While the car is parked and locked the rear driver side door opens in its own. The door handle does not present itself and is scheduled for repair. This is new and started happening today. Despite how many times I close it. It opens on it own. The door is locked when this happens. Door sitting still. Plugged in to charge and locked. The door opens on its own. It unlatches, Does not fully open.

Corrective Action:

While the car is parked and locked the rear driver side door opens in its own. The door handle does not present itself and is scheduled for repair. This is new and started happening today. Despite how many times I close it. It opens on it own. The door is locked when this happens. Door sitting still. Plugged in to charge and locked. The door opens on its own. It unlatches, Does not fully open.

Additional Notes:

While the car is parked and locked the rear driver side door opens in its own. The door handle does not present itself and is scheduled for repair. This is new and started happening today. Despite how many times I close it. It opens on it own. The door is locked when this happens. Door sitting still. Plugged in to charge and locked. The door opens on its own. It unlatches, Does not fully open.

Manufacturer: TESLA
Mfg Campaign: 11673529
Notice Date: Jul 14, 2025
Recall Date: Jul 14, 2025
Tesla, Inc.
Campaign: 11673529 Other
Jul 14, 2025
Defect Description:

UNKNOWN OR OTHER

Potential Consequences:

While the car is parked and locked the rear driver side door opens in its own. The door handle does not present itself and is scheduled for repair. This is new and started happening today. Despite how many times I close it. It opens on it own. The door is locked when this happens. Door sitting still. Plugged in to charge and locked. The door opens on its own. It unlatches, Does not fully open.

Corrective Action:

While the car is parked and locked the rear driver side door opens in its own. The door handle does not present itself and is scheduled for repair. This is new and started happening today. Despite how many times I close it. It opens on it own. The door is locked when this happens. Door sitting still. Plugged in to charge and locked. The door opens on its own. It unlatches, Does not fully open.

Additional Notes:

While the car is parked and locked the rear driver side door opens in its own. The door handle does not present itself and is scheduled for repair. This is new and started happening today. Despite how many times I close it. It opens on it own. The door is locked when this happens. Door sitting still. Plugged in to charge and locked. The door opens on its own. It unlatches, Does not fully open.

Manufacturer: TESLA
Mfg Campaign: 11673529
Notice Date: Jul 14, 2025
Recall Date: Jul 14, 2025
Tesla, Inc.
Campaign: 11667966 Other
Jun 19, 2025
Defect Description:

UNKNOWN OR OTHER

Potential Consequences:

My driver's side of the vehicle looks like it's melting. I was informed by the service advisor at Tesla that this is a common issue, and the computer needs to be replaced at my expense.

Corrective Action:

My driver's side of the vehicle looks like it's melting. I was informed by the service advisor at Tesla that this is a common issue, and the computer needs to be replaced at my expense.

Additional Notes:

My driver's side of the vehicle looks like it's melting. I was informed by the service advisor at Tesla that this is a common issue, and the computer needs to be replaced at my expense.

Manufacturer: TESLA
Mfg Campaign: 11667966
Notice Date: Jun 19, 2025
Recall Date: Jun 19, 2025
Tesla, Inc.
Campaign: 11667966 Other
Jun 19, 2025
Defect Description:

ELECTRICAL SYSTEM

Potential Consequences:

My driver's side of the vehicle looks like it's melting. I was informed by the service advisor at Tesla that this is a common issue, and the computer needs to be replaced at my expense.

Corrective Action:

My driver's side of the vehicle looks like it's melting. I was informed by the service advisor at Tesla that this is a common issue, and the computer needs to be replaced at my expense.

Additional Notes:

My driver's side of the vehicle looks like it's melting. I was informed by the service advisor at Tesla that this is a common issue, and the computer needs to be replaced at my expense.

Manufacturer: TESLA
Mfg Campaign: 11667966
Notice Date: Jun 19, 2025
Recall Date: Jun 19, 2025
Tesla, Inc.
Campaign: 11666935 Other
Jun 14, 2025
Defect Description:

SUSPENSION

Potential Consequences:

on 5/20/25, I had my Tesla repaired as I had suspension issues. They repaired my car to rectify my suspension for both my front and rear tires. Then on 6/12/25, I was driving on the highway and going about 70-75 mph when I heard a huge pop. No warning indicators came on and something did not feel right. I figured nothing else came of it. I was about 30 miles away from home and when I got home, my tire was pushed inward. I was concerned on whether this was related to a bad repair since it was so soon to my previous repair and they indicated that they did not touch that area. After they saw my video, they indicated that the lower control arm of my rear tire broke and they indicated that this was just a damaged component. My biggest concern is that if this issue was not related to the repair work done a month ago, this could be bigger issue as I could have been very concerning that this part broke when I was driving at high speeds and I think it's warranted to check on the quality of the component. In my 40 plus years of driving, I have never experienced this happened to me. If you need documentation or video of how the tire and the axle looks, I can forward it to you. The vehicle has only been inspected by the Tesla Dealership service center and as stated earlier, there weren't any warning signs or messages that showed as I specifically was looking for it when I heard the loud pop.

Corrective Action:

on 5/20/25, I had my Tesla repaired as I had suspension issues. They repaired my car to rectify my suspension for both my front and rear tires. Then on 6/12/25, I was driving on the highway and going about 70-75 mph when I heard a huge pop. No warning indicators came on and something did not feel right. I figured nothing else came of it. I was about 30 miles away from home and when I got home, my tire was pushed inward. I was concerned on whether this was related to a bad repair since it was so soon to my previous repair and they indicated that they did not touch that area. After they saw my video, they indicated that the lower control arm of my rear tire broke and they indicated that this was just a damaged component. My biggest concern is that if this issue was not related to the repair work done a month ago, this could be bigger issue as I could have been very concerning that this part broke when I was driving at high speeds and I think it's warranted to check on the quality of the component. In my 40 plus years of driving, I have never experienced this happened to me. If you need documentation or video of how the tire and the axle looks, I can forward it to you. The vehicle has only been inspected by the Tesla Dealership service center and as stated earlier, there weren't any warning signs or messages that showed as I specifically was looking for it when I heard the loud pop.

Additional Notes:

on 5/20/25, I had my Tesla repaired as I had suspension issues. They repaired my car to rectify my suspension for both my front and rear tires. Then on 6/12/25, I was driving on the highway and going about 70-75 mph when I heard a huge pop. No warning indicators came on and something did not feel right. I figured nothing else came of it. I was about 30 miles away from home and when I got home, my tire was pushed inward. I was concerned on whether this was related to a bad repair since it was so soon to my previous repair and they indicated that they did not touch that area. After they saw my video, they indicated that the lower control arm of my rear tire broke and they indicated that this was just a damaged component. My biggest concern is that if this issue was not related to the repair work done a month ago, this could be bigger issue as I could have been very concerning that this part broke when I was driving at high speeds and I think it's warranted to check on the quality of the component. In my 40 plus years of driving, I have never experienced this happened to me. If you need documentation or video of how the tire and the axle looks, I can forward it to you. The vehicle has only been inspected by the Tesla Dealership service center and as stated earlier, there weren't any warning signs or messages that showed as I specifically was looking for it when I heard the loud pop.

Manufacturer: TESLA
Mfg Campaign: 11666935
Notice Date: Jun 14, 2025
Recall Date: Jun 14, 2025
Tesla, Inc.
Campaign: 11666935 Other
Jun 14, 2025
Defect Description:

UNKNOWN OR OTHER

Potential Consequences:

on 5/20/25, I had my Tesla repaired as I had suspension issues. They repaired my car to rectify my suspension for both my front and rear tires. Then on 6/12/25, I was driving on the highway and going about 70-75 mph when I heard a huge pop. No warning indicators came on and something did not feel right. I figured nothing else came of it. I was about 30 miles away from home and when I got home, my tire was pushed inward. I was concerned on whether this was related to a bad repair since it was so soon to my previous repair and they indicated that they did not touch that area. After they saw my video, they indicated that the lower control arm of my rear tire broke and they indicated that this was just a damaged component. My biggest concern is that if this issue was not related to the repair work done a month ago, this could be bigger issue as I could have been very concerning that this part broke when I was driving at high speeds and I think it's warranted to check on the quality of the component. In my 40 plus years of driving, I have never experienced this happened to me. If you need documentation or video of how the tire and the axle looks, I can forward it to you. The vehicle has only been inspected by the Tesla Dealership service center and as stated earlier, there weren't any warning signs or messages that showed as I specifically was looking for it when I heard the loud pop.

Corrective Action:

on 5/20/25, I had my Tesla repaired as I had suspension issues. They repaired my car to rectify my suspension for both my front and rear tires. Then on 6/12/25, I was driving on the highway and going about 70-75 mph when I heard a huge pop. No warning indicators came on and something did not feel right. I figured nothing else came of it. I was about 30 miles away from home and when I got home, my tire was pushed inward. I was concerned on whether this was related to a bad repair since it was so soon to my previous repair and they indicated that they did not touch that area. After they saw my video, they indicated that the lower control arm of my rear tire broke and they indicated that this was just a damaged component. My biggest concern is that if this issue was not related to the repair work done a month ago, this could be bigger issue as I could have been very concerning that this part broke when I was driving at high speeds and I think it's warranted to check on the quality of the component. In my 40 plus years of driving, I have never experienced this happened to me. If you need documentation or video of how the tire and the axle looks, I can forward it to you. The vehicle has only been inspected by the Tesla Dealership service center and as stated earlier, there weren't any warning signs or messages that showed as I specifically was looking for it when I heard the loud pop.

Additional Notes:

on 5/20/25, I had my Tesla repaired as I had suspension issues. They repaired my car to rectify my suspension for both my front and rear tires. Then on 6/12/25, I was driving on the highway and going about 70-75 mph when I heard a huge pop. No warning indicators came on and something did not feel right. I figured nothing else came of it. I was about 30 miles away from home and when I got home, my tire was pushed inward. I was concerned on whether this was related to a bad repair since it was so soon to my previous repair and they indicated that they did not touch that area. After they saw my video, they indicated that the lower control arm of my rear tire broke and they indicated that this was just a damaged component. My biggest concern is that if this issue was not related to the repair work done a month ago, this could be bigger issue as I could have been very concerning that this part broke when I was driving at high speeds and I think it's warranted to check on the quality of the component. In my 40 plus years of driving, I have never experienced this happened to me. If you need documentation or video of how the tire and the axle looks, I can forward it to you. The vehicle has only been inspected by the Tesla Dealership service center and as stated earlier, there weren't any warning signs or messages that showed as I specifically was looking for it when I heard the loud pop.

Manufacturer: TESLA
Mfg Campaign: 11666935
Notice Date: Jun 14, 2025
Recall Date: Jun 14, 2025
Tesla, Inc.
Campaign: 11666935 Other
Jun 14, 2025
Defect Description:

WHEELS

Potential Consequences:

on 5/20/25, I had my Tesla repaired as I had suspension issues. They repaired my car to rectify my suspension for both my front and rear tires. Then on 6/12/25, I was driving on the highway and going about 70-75 mph when I heard a huge pop. No warning indicators came on and something did not feel right. I figured nothing else came of it. I was about 30 miles away from home and when I got home, my tire was pushed inward. I was concerned on whether this was related to a bad repair since it was so soon to my previous repair and they indicated that they did not touch that area. After they saw my video, they indicated that the lower control arm of my rear tire broke and they indicated that this was just a damaged component. My biggest concern is that if this issue was not related to the repair work done a month ago, this could be bigger issue as I could have been very concerning that this part broke when I was driving at high speeds and I think it's warranted to check on the quality of the component. In my 40 plus years of driving, I have never experienced this happened to me. If you need documentation or video of how the tire and the axle looks, I can forward it to you. The vehicle has only been inspected by the Tesla Dealership service center and as stated earlier, there weren't any warning signs or messages that showed as I specifically was looking for it when I heard the loud pop.

Corrective Action:

on 5/20/25, I had my Tesla repaired as I had suspension issues. They repaired my car to rectify my suspension for both my front and rear tires. Then on 6/12/25, I was driving on the highway and going about 70-75 mph when I heard a huge pop. No warning indicators came on and something did not feel right. I figured nothing else came of it. I was about 30 miles away from home and when I got home, my tire was pushed inward. I was concerned on whether this was related to a bad repair since it was so soon to my previous repair and they indicated that they did not touch that area. After they saw my video, they indicated that the lower control arm of my rear tire broke and they indicated that this was just a damaged component. My biggest concern is that if this issue was not related to the repair work done a month ago, this could be bigger issue as I could have been very concerning that this part broke when I was driving at high speeds and I think it's warranted to check on the quality of the component. In my 40 plus years of driving, I have never experienced this happened to me. If you need documentation or video of how the tire and the axle looks, I can forward it to you. The vehicle has only been inspected by the Tesla Dealership service center and as stated earlier, there weren't any warning signs or messages that showed as I specifically was looking for it when I heard the loud pop.

Additional Notes:

on 5/20/25, I had my Tesla repaired as I had suspension issues. They repaired my car to rectify my suspension for both my front and rear tires. Then on 6/12/25, I was driving on the highway and going about 70-75 mph when I heard a huge pop. No warning indicators came on and something did not feel right. I figured nothing else came of it. I was about 30 miles away from home and when I got home, my tire was pushed inward. I was concerned on whether this was related to a bad repair since it was so soon to my previous repair and they indicated that they did not touch that area. After they saw my video, they indicated that the lower control arm of my rear tire broke and they indicated that this was just a damaged component. My biggest concern is that if this issue was not related to the repair work done a month ago, this could be bigger issue as I could have been very concerning that this part broke when I was driving at high speeds and I think it's warranted to check on the quality of the component. In my 40 plus years of driving, I have never experienced this happened to me. If you need documentation or video of how the tire and the axle looks, I can forward it to you. The vehicle has only been inspected by the Tesla Dealership service center and as stated earlier, there weren't any warning signs or messages that showed as I specifically was looking for it when I heard the loud pop.

Manufacturer: TESLA
Mfg Campaign: 11666935
Notice Date: Jun 14, 2025
Recall Date: Jun 14, 2025
Tesla, Inc.
Campaign: 11665646 Other
Jun 8, 2025
Defect Description:

POWER TRAIN

Potential Consequences:

I wanted to bring a situation to your attention, report an incident and understand why model years 2012-2020 Tesla Model Ss have not been recalled for a defective drive unit. This is a known defect - known by Tesla. There have been no recalls for mine - VIN number [XXX] . On [XXX], my 2016 Tesla Model S suddenly lunged and jerked down to less than 5 mph from about 45 mph in 5-10 seconds as a result of a defective and failed drive unit, here in San Ramon , CA. NO WARNING. We forced the car to lunge and hop over to the median with traffic stopping, building up, honking, braking....truly a miracle no one got hurt. I later saw both front and back wheels turning in OPPOSITE directions, simultaneously, as the tow truck driver was pulling the car on his flat bed. The tow truck driver said he has never seen anything like this! The defective drive unit has been a known issue which they corrected in 2020. A Master Tesla mechanic states that this is not about IF the failure was to take place, but WHEN it was going to take place. Tesla refuses to own up to the problem despite emailing their Head, Tom Zhu. I came across this conversation on Reddit and it appears that a comment made by the Tesla mechanic below is relevant. They could have prevented this by recalling the cars and changing the coolant seal. Here is his quote: "Every single large Tesla Drive unit will fail unless it's a recent revision U replacement (~2022 or newer) or has been retrofitted by a 3rd party. This applies to all RWD Model S made between 2012 and 2020, and all Performance S/X made until 2020. The coolant seal will fail and destroy the motor. This is not an if, but a when. If you have a car with one of these motors, there are a variety of 3rd party shops who can fix this issue forever for a lot less money than a fully dead motor. An attorney on this thread commented on a 2015 Tesla Model S: "This is a known issue with older Model S/X cars, yes. A 2015 is HIGHLY at risk of that. Also, a INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION

Corrective Action:

I wanted to bring a situation to your attention, report an incident and understand why model years 2012-2020 Tesla Model Ss have not been recalled for a defective drive unit. This is a known defect - known by Tesla. There have been no recalls for mine - VIN number [XXX] . On [XXX], my 2016 Tesla Model S suddenly lunged and jerked down to less than 5 mph from about 45 mph in 5-10 seconds as a result of a defective and failed drive unit, here in San Ramon , CA. NO WARNING. We forced the car to lunge and hop over to the median with traffic stopping, building up, honking, braking....truly a miracle no one got hurt. I later saw both front and back wheels turning in OPPOSITE directions, simultaneously, as the tow truck driver was pulling the car on his flat bed. The tow truck driver said he has never seen anything like this! The defective drive unit has been a known issue which they corrected in 2020. A Master Tesla mechanic states that this is not about IF the failure was to take place, but WHEN it was going to take place. Tesla refuses to own up to the problem despite emailing their Head, Tom Zhu. I came across this conversation on Reddit and it appears that a comment made by the Tesla mechanic below is relevant. They could have prevented this by recalling the cars and changing the coolant seal. Here is his quote: "Every single large Tesla Drive unit will fail unless it's a recent revision U replacement (~2022 or newer) or has been retrofitted by a 3rd party. This applies to all RWD Model S made between 2012 and 2020, and all Performance S/X made until 2020. The coolant seal will fail and destroy the motor. This is not an if, but a when. If you have a car with one of these motors, there are a variety of 3rd party shops who can fix this issue forever for a lot less money than a fully dead motor. An attorney on this thread commented on a 2015 Tesla Model S: "This is a known issue with older Model S/X cars, yes. A 2015 is HIGHLY at risk of that. Also, a INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION

Additional Notes:

I wanted to bring a situation to your attention, report an incident and understand why model years 2012-2020 Tesla Model Ss have not been recalled for a defective drive unit. This is a known defect - known by Tesla. There have been no recalls for mine - VIN number [XXX] . On [XXX], my 2016 Tesla Model S suddenly lunged and jerked down to less than 5 mph from about 45 mph in 5-10 seconds as a result of a defective and failed drive unit, here in San Ramon , CA. NO WARNING. We forced the car to lunge and hop over to the median with traffic stopping, building up, honking, braking....truly a miracle no one got hurt. I later saw both front and back wheels turning in OPPOSITE directions, simultaneously, as the tow truck driver was pulling the car on his flat bed. The tow truck driver said he has never seen anything like this! The defective drive unit has been a known issue which they corrected in 2020. A Master Tesla mechanic states that this is not about IF the failure was to take place, but WHEN it was going to take place. Tesla refuses to own up to the problem despite emailing their Head, Tom Zhu. I came across this conversation on Reddit and it appears that a comment made by the Tesla mechanic below is relevant. They could have prevented this by recalling the cars and changing the coolant seal. Here is his quote: "Every single large Tesla Drive unit will fail unless it's a recent revision U replacement (~2022 or newer) or has been retrofitted by a 3rd party. This applies to all RWD Model S made between 2012 and 2020, and all Performance S/X made until 2020. The coolant seal will fail and destroy the motor. This is not an if, but a when. If you have a car with one of these motors, there are a variety of 3rd party shops who can fix this issue forever for a lot less money than a fully dead motor. An attorney on this thread commented on a 2015 Tesla Model S: "This is a known issue with older Model S/X cars, yes. A 2015 is HIGHLY at risk of that. Also, a INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION

Manufacturer: TESLA
Mfg Campaign: 11665646
Notice Date: Jun 8, 2025
Recall Date: Jun 8, 2025
Tesla, Inc.
Campaign: 11653299 Other
Apr 7, 2025
Defect Description:

ELECTRICAL SYSTEM:ADAS:AUTONOMOUS/SELF DRIVING

Potential Consequences:

The contact owns a 2016 Tesla Model S. The contact stated while attempting to park the vehicle, the brake pedal was depressed and failed to respond. There were no warning lights illuminated. The contact depressed the brake and the vehicle kept rolling forward. The contact opened the door for the vehicle to come to a stop. On another occasion, the contact stated that the ADAS feature engaged and while driving at various speeds, and the vehicle failed to recognize stop signs, traffic lights, or pedestrians. The contact stated that the function was a paid feature; however, the system failed to operate as designed. On another occasion, the contact stated that the steering will shift to one side while driving at various speeds, and the vehicle became difficult to steer. The vehicle was not taken to the dealer to be diagnosed or repaired. The dealer was made aware, and the contact had a pending appointment scheduled. The manufacturer was not made aware of the failure. The failure mileage was approximately 79,000.

Corrective Action:

The contact owns a 2016 Tesla Model S. The contact stated while attempting to park the vehicle, the brake pedal was depressed and failed to respond. There were no warning lights illuminated. The contact depressed the brake and the vehicle kept rolling forward. The contact opened the door for the vehicle to come to a stop. On another occasion, the contact stated that the ADAS feature engaged and while driving at various speeds, and the vehicle failed to recognize stop signs, traffic lights, or pedestrians. The contact stated that the function was a paid feature; however, the system failed to operate as designed. On another occasion, the contact stated that the steering will shift to one side while driving at various speeds, and the vehicle became difficult to steer. The vehicle was not taken to the dealer to be diagnosed or repaired. The dealer was made aware, and the contact had a pending appointment scheduled. The manufacturer was not made aware of the failure. The failure mileage was approximately 79,000.

Additional Notes:

The contact owns a 2016 Tesla Model S. The contact stated while attempting to park the vehicle, the brake pedal was depressed and failed to respond. There were no warning lights illuminated. The contact depressed the brake and the vehicle kept rolling forward. The contact opened the door for the vehicle to come to a stop. On another occasion, the contact stated that the ADAS feature engaged and while driving at various speeds, and the vehicle failed to recognize stop signs, traffic lights, or pedestrians. The contact stated that the function was a paid feature; however, the system failed to operate as designed. On another occasion, the contact stated that the steering will shift to one side while driving at various speeds, and the vehicle became difficult to steer. The vehicle was not taken to the dealer to be diagnosed or repaired. The dealer was made aware, and the contact had a pending appointment scheduled. The manufacturer was not made aware of the failure. The failure mileage was approximately 79,000.

Manufacturer: TESLA
Mfg Campaign: 11653299
Notice Date: Apr 7, 2025
Recall Date: Apr 7, 2025
Tesla, Inc.
Campaign: 11653299 Other
Apr 7, 2025
Defect Description:

STEERING

Potential Consequences:

The contact owns a 2016 Tesla Model S. The contact stated while attempting to park the vehicle, the brake pedal was depressed and failed to respond. There were no warning lights illuminated. The contact depressed the brake and the vehicle kept rolling forward. The contact opened the door for the vehicle to come to a stop. On another occasion, the contact stated that the ADAS feature engaged and while driving at various speeds, and the vehicle failed to recognize stop signs, traffic lights, or pedestrians. The contact stated that the function was a paid feature; however, the system failed to operate as designed. On another occasion, the contact stated that the steering will shift to one side while driving at various speeds, and the vehicle became difficult to steer. The vehicle was not taken to the dealer to be diagnosed or repaired. The dealer was made aware, and the contact had a pending appointment scheduled. The manufacturer was not made aware of the failure. The failure mileage was approximately 79,000.

Corrective Action:

The contact owns a 2016 Tesla Model S. The contact stated while attempting to park the vehicle, the brake pedal was depressed and failed to respond. There were no warning lights illuminated. The contact depressed the brake and the vehicle kept rolling forward. The contact opened the door for the vehicle to come to a stop. On another occasion, the contact stated that the ADAS feature engaged and while driving at various speeds, and the vehicle failed to recognize stop signs, traffic lights, or pedestrians. The contact stated that the function was a paid feature; however, the system failed to operate as designed. On another occasion, the contact stated that the steering will shift to one side while driving at various speeds, and the vehicle became difficult to steer. The vehicle was not taken to the dealer to be diagnosed or repaired. The dealer was made aware, and the contact had a pending appointment scheduled. The manufacturer was not made aware of the failure. The failure mileage was approximately 79,000.

Additional Notes:

The contact owns a 2016 Tesla Model S. The contact stated while attempting to park the vehicle, the brake pedal was depressed and failed to respond. There were no warning lights illuminated. The contact depressed the brake and the vehicle kept rolling forward. The contact opened the door for the vehicle to come to a stop. On another occasion, the contact stated that the ADAS feature engaged and while driving at various speeds, and the vehicle failed to recognize stop signs, traffic lights, or pedestrians. The contact stated that the function was a paid feature; however, the system failed to operate as designed. On another occasion, the contact stated that the steering will shift to one side while driving at various speeds, and the vehicle became difficult to steer. The vehicle was not taken to the dealer to be diagnosed or repaired. The dealer was made aware, and the contact had a pending appointment scheduled. The manufacturer was not made aware of the failure. The failure mileage was approximately 79,000.

Manufacturer: TESLA
Mfg Campaign: 11653299
Notice Date: Apr 7, 2025
Recall Date: Apr 7, 2025
Tesla, Inc.
Campaign: 11653299 Other
Apr 7, 2025
Defect Description:

SERVICE BRAKES, HYDRAULIC

Potential Consequences:

The contact owns a 2016 Tesla Model S. The contact stated while attempting to park the vehicle, the brake pedal was depressed and failed to respond. There were no warning lights illuminated. The contact depressed the brake and the vehicle kept rolling forward. The contact opened the door for the vehicle to come to a stop. On another occasion, the contact stated that the ADAS feature engaged and while driving at various speeds, and the vehicle failed to recognize stop signs, traffic lights, or pedestrians. The contact stated that the function was a paid feature; however, the system failed to operate as designed. On another occasion, the contact stated that the steering will shift to one side while driving at various speeds, and the vehicle became difficult to steer. The vehicle was not taken to the dealer to be diagnosed or repaired. The dealer was made aware, and the contact had a pending appointment scheduled. The manufacturer was not made aware of the failure. The failure mileage was approximately 79,000.

Corrective Action:

The contact owns a 2016 Tesla Model S. The contact stated while attempting to park the vehicle, the brake pedal was depressed and failed to respond. There were no warning lights illuminated. The contact depressed the brake and the vehicle kept rolling forward. The contact opened the door for the vehicle to come to a stop. On another occasion, the contact stated that the ADAS feature engaged and while driving at various speeds, and the vehicle failed to recognize stop signs, traffic lights, or pedestrians. The contact stated that the function was a paid feature; however, the system failed to operate as designed. On another occasion, the contact stated that the steering will shift to one side while driving at various speeds, and the vehicle became difficult to steer. The vehicle was not taken to the dealer to be diagnosed or repaired. The dealer was made aware, and the contact had a pending appointment scheduled. The manufacturer was not made aware of the failure. The failure mileage was approximately 79,000.

Additional Notes:

The contact owns a 2016 Tesla Model S. The contact stated while attempting to park the vehicle, the brake pedal was depressed and failed to respond. There were no warning lights illuminated. The contact depressed the brake and the vehicle kept rolling forward. The contact opened the door for the vehicle to come to a stop. On another occasion, the contact stated that the ADAS feature engaged and while driving at various speeds, and the vehicle failed to recognize stop signs, traffic lights, or pedestrians. The contact stated that the function was a paid feature; however, the system failed to operate as designed. On another occasion, the contact stated that the steering will shift to one side while driving at various speeds, and the vehicle became difficult to steer. The vehicle was not taken to the dealer to be diagnosed or repaired. The dealer was made aware, and the contact had a pending appointment scheduled. The manufacturer was not made aware of the failure. The failure mileage was approximately 79,000.

Manufacturer: TESLA
Mfg Campaign: 11653299
Notice Date: Apr 7, 2025
Recall Date: Apr 7, 2025
Tesla, Inc.
Campaign: 11645180 Other
Feb 26, 2025
Defect Description:

ELECTRICAL SYSTEM

Potential Consequences:

Component Failure: The Tesla NEMA 14-50 charging adapter for my 2016 Model S malfunctioned, causing overheating that melted a prong and led to an electrical fire. The defective adapter appears identical to those in Tesla's November 2016 recall, though mine was designated "not affected." The damaged adapter and charging cable are available for inspection. Safety Risk: This malfunction created a serious fire hazard endangering myself and my property. The electrical fire damaged both my vehicle and charging equipment, and the fire could have spread to my home, potentially endangering my family and neighbors. Verification: I took the damaged adapter to the Tesla Service Center in Colorado Springs, where technicians acknowledged the damage but refused to replace it under the recall. They visually confirmed the melted prong and fire damage. Manufacturer Response: After the incident, I contacted Tesla Corporate requesting replacement of the defective equipment. They responded that they don't believe the electrical fire was caused by the defective plug, despite physical evidence showing the same issue as recalled units. Warning Signs: Prior to failure, I noticed intermittent charging interruptions and the adapter becoming unusually hot. These symptoms began approximately three weeks before the fire incident. There were no dashboard warnings about potential charging equipment issues.

Corrective Action:

Component Failure: The Tesla NEMA 14-50 charging adapter for my 2016 Model S malfunctioned, causing overheating that melted a prong and led to an electrical fire. The defective adapter appears identical to those in Tesla's November 2016 recall, though mine was designated "not affected." The damaged adapter and charging cable are available for inspection. Safety Risk: This malfunction created a serious fire hazard endangering myself and my property. The electrical fire damaged both my vehicle and charging equipment, and the fire could have spread to my home, potentially endangering my family and neighbors. Verification: I took the damaged adapter to the Tesla Service Center in Colorado Springs, where technicians acknowledged the damage but refused to replace it under the recall. They visually confirmed the melted prong and fire damage. Manufacturer Response: After the incident, I contacted Tesla Corporate requesting replacement of the defective equipment. They responded that they don't believe the electrical fire was caused by the defective plug, despite physical evidence showing the same issue as recalled units. Warning Signs: Prior to failure, I noticed intermittent charging interruptions and the adapter becoming unusually hot. These symptoms began approximately three weeks before the fire incident. There were no dashboard warnings about potential charging equipment issues.

Additional Notes:

Component Failure: The Tesla NEMA 14-50 charging adapter for my 2016 Model S malfunctioned, causing overheating that melted a prong and led to an electrical fire. The defective adapter appears identical to those in Tesla's November 2016 recall, though mine was designated "not affected." The damaged adapter and charging cable are available for inspection. Safety Risk: This malfunction created a serious fire hazard endangering myself and my property. The electrical fire damaged both my vehicle and charging equipment, and the fire could have spread to my home, potentially endangering my family and neighbors. Verification: I took the damaged adapter to the Tesla Service Center in Colorado Springs, where technicians acknowledged the damage but refused to replace it under the recall. They visually confirmed the melted prong and fire damage. Manufacturer Response: After the incident, I contacted Tesla Corporate requesting replacement of the defective equipment. They responded that they don't believe the electrical fire was caused by the defective plug, despite physical evidence showing the same issue as recalled units. Warning Signs: Prior to failure, I noticed intermittent charging interruptions and the adapter becoming unusually hot. These symptoms began approximately three weeks before the fire incident. There were no dashboard warnings about potential charging equipment issues.

Manufacturer: TESLA
Mfg Campaign: 11645180
Notice Date: Feb 26, 2025
Recall Date: Feb 26, 2025
Tesla, Inc.
Campaign: 11644292 Other
Feb 22, 2025
Defect Description:

STEERING

Potential Consequences:

While driving on the highway at maximum speed limit, I had a series of error messages that covered the complete screen. At the same time, my MPH dropped to zero although I was traveling probably 70 miles per hour. I had no control over the vehicle, no steering, I had no brakes. There was no way to control the car. Fortunately, I was traveling in a low populated area of the [XXX] between Los Angeles and Las Vegas in the far right lane, as I was preparing to exit less than a mile to a Super Charger Station. I was able to get off that exit but since the odometer had a 0 reading, I had no idea what speed I was still traveling at. When I reached the end of the freeway exit, I was unable to stop the vehicle at the stop sign, running it while attempting with all of my strength to veer to the right on to a desolate road. The only thing that saved the car from running the stop sign at what I can only guess would have been 60 mph was a slight incline in the off ramp which slowed the car to about half that when I managed to make the turn. From there, I coasted to a rolling stop about 200 ft from exit, half on shoulder, half stilI on road. I was not able to put the car in park nor see what gear the car was in due to the flashing warnings blocking the display screen. I could not use the hazard lights, the gear shift, power off, open glove box, turn off display, open trunk, as if it was in D. Once exited, no way to get back in the car. Tesla ER Service only able to tow next A.M. to nearest S C, 85 miles at my expense. Sat in car as getting dark, cold along desolate road with no services, until my ride could get me over 4 hrs or stay in car overnight with temps of 20°. After 2 days at Tesla, told steering rack failed, $4,900. Any other time, I would have plowed into the car in front of me at 70mph with no way to stop or steer away. Only prevented by the empty freeway I just happened to be traveling. Tesla claims to have no idea why this part failed at this low mileage. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMAT

Corrective Action:

While driving on the highway at maximum speed limit, I had a series of error messages that covered the complete screen. At the same time, my MPH dropped to zero although I was traveling probably 70 miles per hour. I had no control over the vehicle, no steering, I had no brakes. There was no way to control the car. Fortunately, I was traveling in a low populated area of the [XXX] between Los Angeles and Las Vegas in the far right lane, as I was preparing to exit less than a mile to a Super Charger Station. I was able to get off that exit but since the odometer had a 0 reading, I had no idea what speed I was still traveling at. When I reached the end of the freeway exit, I was unable to stop the vehicle at the stop sign, running it while attempting with all of my strength to veer to the right on to a desolate road. The only thing that saved the car from running the stop sign at what I can only guess would have been 60 mph was a slight incline in the off ramp which slowed the car to about half that when I managed to make the turn. From there, I coasted to a rolling stop about 200 ft from exit, half on shoulder, half stilI on road. I was not able to put the car in park nor see what gear the car was in due to the flashing warnings blocking the display screen. I could not use the hazard lights, the gear shift, power off, open glove box, turn off display, open trunk, as if it was in D. Once exited, no way to get back in the car. Tesla ER Service only able to tow next A.M. to nearest S C, 85 miles at my expense. Sat in car as getting dark, cold along desolate road with no services, until my ride could get me over 4 hrs or stay in car overnight with temps of 20°. After 2 days at Tesla, told steering rack failed, $4,900. Any other time, I would have plowed into the car in front of me at 70mph with no way to stop or steer away. Only prevented by the empty freeway I just happened to be traveling. Tesla claims to have no idea why this part failed at this low mileage. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMAT

Additional Notes:

While driving on the highway at maximum speed limit, I had a series of error messages that covered the complete screen. At the same time, my MPH dropped to zero although I was traveling probably 70 miles per hour. I had no control over the vehicle, no steering, I had no brakes. There was no way to control the car. Fortunately, I was traveling in a low populated area of the [XXX] between Los Angeles and Las Vegas in the far right lane, as I was preparing to exit less than a mile to a Super Charger Station. I was able to get off that exit but since the odometer had a 0 reading, I had no idea what speed I was still traveling at. When I reached the end of the freeway exit, I was unable to stop the vehicle at the stop sign, running it while attempting with all of my strength to veer to the right on to a desolate road. The only thing that saved the car from running the stop sign at what I can only guess would have been 60 mph was a slight incline in the off ramp which slowed the car to about half that when I managed to make the turn. From there, I coasted to a rolling stop about 200 ft from exit, half on shoulder, half stilI on road. I was not able to put the car in park nor see what gear the car was in due to the flashing warnings blocking the display screen. I could not use the hazard lights, the gear shift, power off, open glove box, turn off display, open trunk, as if it was in D. Once exited, no way to get back in the car. Tesla ER Service only able to tow next A.M. to nearest S C, 85 miles at my expense. Sat in car as getting dark, cold along desolate road with no services, until my ride could get me over 4 hrs or stay in car overnight with temps of 20°. After 2 days at Tesla, told steering rack failed, $4,900. Any other time, I would have plowed into the car in front of me at 70mph with no way to stop or steer away. Only prevented by the empty freeway I just happened to be traveling. Tesla claims to have no idea why this part failed at this low mileage. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMAT

Manufacturer: TESLA
Mfg Campaign: 11644292
Notice Date: Feb 22, 2025
Recall Date: Feb 22, 2025
Tesla, Inc.
Campaign: 11635982 Other
Jan 14, 2025
Defect Description:

LATCHES/LOCKS/LINKAGES:TRUNK LID:LATCH:EMERGENCY MECHANICAL RELEASE

Potential Consequences:

The Trunk/Hatchback failed to open. When I attempted to use the EMERGENCY release ( which you would expect to work in a real emergency) IT DID NOT WORK!! The truck would not open. How can you have an emergency release cord that does not work?!! And they are now charging to repair this!

Corrective Action:

The Trunk/Hatchback failed to open. When I attempted to use the EMERGENCY release ( which you would expect to work in a real emergency) IT DID NOT WORK!! The truck would not open. How can you have an emergency release cord that does not work?!! And they are now charging to repair this!

Additional Notes:

The Trunk/Hatchback failed to open. When I attempted to use the EMERGENCY release ( which you would expect to work in a real emergency) IT DID NOT WORK!! The truck would not open. How can you have an emergency release cord that does not work?!! And they are now charging to repair this!

Manufacturer: TESLA
Mfg Campaign: 11635982
Notice Date: Jan 14, 2025
Recall Date: Jan 14, 2025
Tesla, Inc.
Campaign: 11630835 Other
Dec 15, 2024
Defect Description:

VEHICLE SPEED CONTROL

Potential Consequences:

My car slams on the brakes consistently at green lights when FSD is activated. This is version 12.5.4.2 of FSD. Tesla is not responding to my inquiries.

Corrective Action:

My car slams on the brakes consistently at green lights when FSD is activated. This is version 12.5.4.2 of FSD. Tesla is not responding to my inquiries.

Additional Notes:

My car slams on the brakes consistently at green lights when FSD is activated. This is version 12.5.4.2 of FSD. Tesla is not responding to my inquiries.

Manufacturer: TESLA
Mfg Campaign: 11630835
Notice Date: Dec 15, 2024
Recall Date: Dec 15, 2024
Tesla, Inc.
Campaign: 11630835 Other
Dec 15, 2024
Defect Description:

SERVICE BRAKES

Potential Consequences:

My car slams on the brakes consistently at green lights when FSD is activated. This is version 12.5.4.2 of FSD. Tesla is not responding to my inquiries.

Corrective Action:

My car slams on the brakes consistently at green lights when FSD is activated. This is version 12.5.4.2 of FSD. Tesla is not responding to my inquiries.

Additional Notes:

My car slams on the brakes consistently at green lights when FSD is activated. This is version 12.5.4.2 of FSD. Tesla is not responding to my inquiries.

Manufacturer: TESLA
Mfg Campaign: 11630835
Notice Date: Dec 15, 2024
Recall Date: Dec 15, 2024
Tesla, Inc.
Campaign: 11630835 Other
Dec 15, 2024
Defect Description:

FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL

Potential Consequences:

My car slams on the brakes consistently at green lights when FSD is activated. This is version 12.5.4.2 of FSD. Tesla is not responding to my inquiries.

Corrective Action:

My car slams on the brakes consistently at green lights when FSD is activated. This is version 12.5.4.2 of FSD. Tesla is not responding to my inquiries.

Additional Notes:

My car slams on the brakes consistently at green lights when FSD is activated. This is version 12.5.4.2 of FSD. Tesla is not responding to my inquiries.

Manufacturer: TESLA
Mfg Campaign: 11630835
Notice Date: Dec 15, 2024
Recall Date: Dec 15, 2024
Tesla, Inc.
Campaign: 11627727 Other
Nov 27, 2024
Defect Description:

VEHICLE SPEED CONTROL

Potential Consequences:

The accelerating pedal is the one that was affect it is available upon request for inspection. It put me in danger because while I was driving, it snapped off. Has not been inspected by others. There was no warning lamps and it just happened out of nowhere as well. I was driving.

Corrective Action:

The accelerating pedal is the one that was affect it is available upon request for inspection. It put me in danger because while I was driving, it snapped off. Has not been inspected by others. There was no warning lamps and it just happened out of nowhere as well. I was driving.

Additional Notes:

The accelerating pedal is the one that was affect it is available upon request for inspection. It put me in danger because while I was driving, it snapped off. Has not been inspected by others. There was no warning lamps and it just happened out of nowhere as well. I was driving.

Manufacturer: TESLA
Mfg Campaign: 11627727
Notice Date: Nov 27, 2024
Recall Date: Nov 27, 2024
Tesla, Inc.
Campaign: 11627580 Other
Nov 26, 2024
Defect Description:

LATCHES/LOCKS/LINKAGES:DOORS:LATCH:EMERGENCY MECHANICAL RELEASE

Potential Consequences:

The latches for the rear passenger doors of a Model S are electric and do not function in the event the vehicle loses electrical power from the 12v system. A mechanical release is provided in the rear of interior passenger compartment. However the release pulls are located under the carpeting and no labelling is provided and no instructions are posted. The emergency door release pulls consistent of plastic tab about 1-inch long by 0.5-inch wide and connected to a release cable. The plastic tab color is black, under the carpeting, and within an area coated in black coloring. The location of the release is below the rear seating above the floor boards, behind the rear passengers' footwell. The location is not intuitive or obvious and likely could not be located without reading the owner's manual, which passengers are unlikely to do. The location is not labeled inside the vehicle. The tab is small and black, under the carpeting that has to be moved to locate the tab, and provided with a black background. Passengers of limited mobility would not be able to locate and access the pull tabs to release the doors. Small children would not able able to locate and access the pull tabs without climbing off the seat and into the footwell. The pull force must be directed to the center of the vehicle. No mechanic exterior door releases are provided. In an emergency where the vehicle is without 12v electrical power, opening a rear passenger door would require an open rear window, or breaking the window to open access, climbing partially into the vehicle to the other side of the passenger's legs, locating the release below the carpeting, and pulling the release while simultaneously pulling the door outward to open. No labelling for this process is provide, nor is this maneuver detailing in the owner's manual. This level of detail is also missing from the, First Responders Reference: "INFORMATION FOR FIRST AND SECOND RESPONDERS EMERGENCY RESPONSE GUIDE TESLA MODEL S ELECTRIC".

Corrective Action:

The latches for the rear passenger doors of a Model S are electric and do not function in the event the vehicle loses electrical power from the 12v system. A mechanical release is provided in the rear of interior passenger compartment. However the release pulls are located under the carpeting and no labelling is provided and no instructions are posted. The emergency door release pulls consistent of plastic tab about 1-inch long by 0.5-inch wide and connected to a release cable. The plastic tab color is black, under the carpeting, and within an area coated in black coloring. The location of the release is below the rear seating above the floor boards, behind the rear passengers' footwell. The location is not intuitive or obvious and likely could not be located without reading the owner's manual, which passengers are unlikely to do. The location is not labeled inside the vehicle. The tab is small and black, under the carpeting that has to be moved to locate the tab, and provided with a black background. Passengers of limited mobility would not be able to locate and access the pull tabs to release the doors. Small children would not able able to locate and access the pull tabs without climbing off the seat and into the footwell. The pull force must be directed to the center of the vehicle. No mechanic exterior door releases are provided. In an emergency where the vehicle is without 12v electrical power, opening a rear passenger door would require an open rear window, or breaking the window to open access, climbing partially into the vehicle to the other side of the passenger's legs, locating the release below the carpeting, and pulling the release while simultaneously pulling the door outward to open. No labelling for this process is provide, nor is this maneuver detailing in the owner's manual. This level of detail is also missing from the, First Responders Reference: "INFORMATION FOR FIRST AND SECOND RESPONDERS EMERGENCY RESPONSE GUIDE TESLA MODEL S ELECTRIC".

Additional Notes:

The latches for the rear passenger doors of a Model S are electric and do not function in the event the vehicle loses electrical power from the 12v system. A mechanical release is provided in the rear of interior passenger compartment. However the release pulls are located under the carpeting and no labelling is provided and no instructions are posted. The emergency door release pulls consistent of plastic tab about 1-inch long by 0.5-inch wide and connected to a release cable. The plastic tab color is black, under the carpeting, and within an area coated in black coloring. The location of the release is below the rear seating above the floor boards, behind the rear passengers' footwell. The location is not intuitive or obvious and likely could not be located without reading the owner's manual, which passengers are unlikely to do. The location is not labeled inside the vehicle. The tab is small and black, under the carpeting that has to be moved to locate the tab, and provided with a black background. Passengers of limited mobility would not be able to locate and access the pull tabs to release the doors. Small children would not able able to locate and access the pull tabs without climbing off the seat and into the footwell. The pull force must be directed to the center of the vehicle. No mechanic exterior door releases are provided. In an emergency where the vehicle is without 12v electrical power, opening a rear passenger door would require an open rear window, or breaking the window to open access, climbing partially into the vehicle to the other side of the passenger's legs, locating the release below the carpeting, and pulling the release while simultaneously pulling the door outward to open. No labelling for this process is provide, nor is this maneuver detailing in the owner's manual. This level of detail is also missing from the, First Responders Reference: "INFORMATION FOR FIRST AND SECOND RESPONDERS EMERGENCY RESPONSE GUIDE TESLA MODEL S ELECTRIC".

Manufacturer: TESLA
Mfg Campaign: 11627580
Notice Date: Nov 26, 2024
Recall Date: Nov 26, 2024

Need Legal Help?

Featured Attorneys
Barry Edzant

Edzant Price LLC

Valencia, CA • 36 yrs

Focus: Lemon Law, Personal Injury

Recent Articles
Jeep Grand Cherokee Head Restraint Problem

Chrysler (FCA US, LLC) has announced a safety issue affecting certain 2023–2024 Jeep Grand Ch ...

Aug 1, 2025
Fuel Injector Problem: 2021-2024 Ford Bronco Sport and 2020-2022 Ford Escape

If you own a 2021-2024 Ford Bronco Sport or 2020-2022 Ford Escape equipped with a 1.5L Dragon GTDI e ...

Jul 28, 2025
Airbag Problem Affects 2022-2025 Chrysler Pacifica and Voyager Vehicles

If you own a Chrysler Pacifica or Voyager, your vehicle may be equipped with defective side curtain ...

Jul 24, 2025