Complaints & Recalls
Official Safety Recalls - Important!
11 RecallsThese are official manufacturer recalls ordered by NHTSA for safety defects. If you own this vehicle, contact your dealer immediately for free repairs.
Rivian Automotive, Llc
Safety Issue:
Rivian Automotive, LLC (Rivian) is recalling certain 2022-2025 R1T and R1S vehicles. The D-ring bolts for one or both front seat belt anchorage assemblies may not have been properly installed.
Potential Risk:
FREE Recall Solution:
Mfg Campaign: FSAM-1681
Recall Date: Jun 3, 2025
Rivian Automotive, Llc
Safety Issue:
Rivian Automotive, LLC. (Rivian) is recalling certain 2022-2023 R1S and R1T vehicles. The maximum vehicle capacity weight value on the tire placard label is incorrect. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 110, "Tire Selection and Rims."
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Mfg Campaign: FSAM-1491
Recall Date: Jun 20, 2024
Rivian Automotive, Llc
Safety Issue:
Rivian Automotive, LLC (Rivian) is recalling certain 2022-2024 R1T and R1S vehicles. The attachment clips on the upper B-pillar and/or C-pillar trim panels may have been damaged during a service procedure.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Mfg Campaign: FSAM-1464
Recall Date: Jun 5, 2024
Rivian Automotive, Llc
Safety Issue:
Rivian Automotive, LLC. (Rivian) is recalling certain 2023-2024 EDV, R1S, and R1T vehicles. The headlights may be improperly aimed. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamp, Reflective Devices and Associated Equipment."
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Mfg Campaign: FSAM-1445
Recall Date: May 23, 2024
Rivian Automotive, Llc
Safety Issue:
Rivian Automotive, LLC (Rivian) is recalling certain 2022-2023 R1T and R1S vehicles. A software update may have deactivated the defroster and defogger system controls.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Mfg Campaign: FSAM-1331
Recall Date: Nov 21, 2023
Rivian Automotive, Llc
Safety Issue:
Rivian Automotive, LLC (Rivian) is recalling certain 2022-2023 R1S vehicles. The reverse light beam may not be visible from certain angles. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Mfg Campaign: FSAM-1216
Recall Date: Mar 31, 2023
Rivian Automotive, Llc
Safety Issue:
Rivian Automotive, LLC (Rivian) is recalling certain 2022-2023 R1S vehicles. The fasteners that secure the right and left side curtain air bags may be improperly secured.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Mfg Campaign: FSAM-1185
Recall Date: Mar 9, 2023
Consumer Complaints
104 ComplaintsRivian Automotive, Llc
Defect Description:
UNKNOWN OR OTHER
Potential Consequences:
OTA update 2023.42 failed to install and left car without working screens, the only way to really manage the vehicle's settings. No formal communication until mid-afternoon next day, approximately 16+ hours after problem became known. Rivian stating vehicle can be driven without speedometer and working systems.
Corrective Action:
OTA update 2023.42 failed to install and left car without working screens, the only way to really manage the vehicle's settings. No formal communication until mid-afternoon next day, approximately 16+ hours after problem became known. Rivian stating vehicle can be driven without speedometer and working systems.
Additional Notes:
OTA update 2023.42 failed to install and left car without working screens, the only way to really manage the vehicle's settings. No formal communication until mid-afternoon next day, approximately 16+ hours after problem became known. Rivian stating vehicle can be driven without speedometer and working systems.
Mfg Campaign: 11555106
Recall Date: Nov 14, 2023
Rivian Automotive, Llc
Defect Description:
ELECTRICAL SYSTEM
Potential Consequences:
Stopped at McDonalds drive through waiting to order with my foot on the brake and the vehicle lunged forward rearending the car stopped 5 feet in front of me ordering. I was trying to brake but it kept pushing the car in front of me then careened to the right hitting a sign and a parked car. I kept pumping the brakes and I thought it was going to run into a building when the vehicle finally stopped about 30 feet from the 2nd parked car it struck. Apparently it was "sudden unintended acceleration" and I've been reading on-line this has happened to many people including Actor Alan Ruck (see article). Rivian has not been responsive to us. Crash involving ‘Ferris Bueller,’ ‘Succession’ actor Alan Ruck was not a crime: LAPD by: Marc SternfieldPosted: Nov 2, 2023 / 03:22 PM PDT No charges will be filed as a result of the multi-car crash in Hollywood involving “Ferris Bueller” and “Succession” actor Alan Ruck, Los Angeles Police told KTLA on Thursday. The collision happened around 9 p.m. on Halloween night at the busy intersection of La Brea Avenue and Hollywood Boulevard. In two surveillance videos obtained by KTLA, Ruck’s Rivian electric pickup truck is seen stopped behind another car at a red light as pedestrians cross in the crosswalk. For reasons still unclear, the truck suddenly lunges forward and rear-ends the other car, and then careens across lanes of traffic, hitting another vehicle before crashing through the wall of Raffallo’s Pizza. At least one person is hospitalized after a three-vehicle collision sent a truck crashing through a pizza shop in Hollywood on Oct. ... Actor Alan Ruck is seen at the crash scene. Tim Ratcliff, who owns several adjacent restaurants, rushed to help the actor who he says was more concerned about the safety of the people he hit than his own wellbeing. “I asked him, ‘Are you okay? And the first thing out of his mouth was, ‘Is everyone [else] okay? I think I hit someone. Is he okay?’,” Ratcliff told KTLA.A 32-year-old man from one of th
Corrective Action:
Stopped at McDonalds drive through waiting to order with my foot on the brake and the vehicle lunged forward rearending the car stopped 5 feet in front of me ordering. I was trying to brake but it kept pushing the car in front of me then careened to the right hitting a sign and a parked car. I kept pumping the brakes and I thought it was going to run into a building when the vehicle finally stopped about 30 feet from the 2nd parked car it struck. Apparently it was "sudden unintended acceleration" and I've been reading on-line this has happened to many people including Actor Alan Ruck (see article). Rivian has not been responsive to us. Crash involving ‘Ferris Bueller,’ ‘Succession’ actor Alan Ruck was not a crime: LAPD by: Marc SternfieldPosted: Nov 2, 2023 / 03:22 PM PDT No charges will be filed as a result of the multi-car crash in Hollywood involving “Ferris Bueller” and “Succession” actor Alan Ruck, Los Angeles Police told KTLA on Thursday. The collision happened around 9 p.m. on Halloween night at the busy intersection of La Brea Avenue and Hollywood Boulevard. In two surveillance videos obtained by KTLA, Ruck’s Rivian electric pickup truck is seen stopped behind another car at a red light as pedestrians cross in the crosswalk. For reasons still unclear, the truck suddenly lunges forward and rear-ends the other car, and then careens across lanes of traffic, hitting another vehicle before crashing through the wall of Raffallo’s Pizza. At least one person is hospitalized after a three-vehicle collision sent a truck crashing through a pizza shop in Hollywood on Oct. ... Actor Alan Ruck is seen at the crash scene. Tim Ratcliff, who owns several adjacent restaurants, rushed to help the actor who he says was more concerned about the safety of the people he hit than his own wellbeing. “I asked him, ‘Are you okay? And the first thing out of his mouth was, ‘Is everyone [else] okay? I think I hit someone. Is he okay?’,” Ratcliff told KTLA.A 32-year-old man from one of th
Additional Notes:
Stopped at McDonalds drive through waiting to order with my foot on the brake and the vehicle lunged forward rearending the car stopped 5 feet in front of me ordering. I was trying to brake but it kept pushing the car in front of me then careened to the right hitting a sign and a parked car. I kept pumping the brakes and I thought it was going to run into a building when the vehicle finally stopped about 30 feet from the 2nd parked car it struck. Apparently it was "sudden unintended acceleration" and I've been reading on-line this has happened to many people including Actor Alan Ruck (see article). Rivian has not been responsive to us. Crash involving ‘Ferris Bueller,’ ‘Succession’ actor Alan Ruck was not a crime: LAPD by: Marc SternfieldPosted: Nov 2, 2023 / 03:22 PM PDT No charges will be filed as a result of the multi-car crash in Hollywood involving “Ferris Bueller” and “Succession” actor Alan Ruck, Los Angeles Police told KTLA on Thursday. The collision happened around 9 p.m. on Halloween night at the busy intersection of La Brea Avenue and Hollywood Boulevard. In two surveillance videos obtained by KTLA, Ruck’s Rivian electric pickup truck is seen stopped behind another car at a red light as pedestrians cross in the crosswalk. For reasons still unclear, the truck suddenly lunges forward and rear-ends the other car, and then careens across lanes of traffic, hitting another vehicle before crashing through the wall of Raffallo’s Pizza. At least one person is hospitalized after a three-vehicle collision sent a truck crashing through a pizza shop in Hollywood on Oct. ... Actor Alan Ruck is seen at the crash scene. Tim Ratcliff, who owns several adjacent restaurants, rushed to help the actor who he says was more concerned about the safety of the people he hit than his own wellbeing. “I asked him, ‘Are you okay? And the first thing out of his mouth was, ‘Is everyone [else] okay? I think I hit someone. Is he okay?’,” Ratcliff told KTLA.A 32-year-old man from one of th
Mfg Campaign: 11553554
Recall Date: Nov 4, 2023
Rivian Automotive, Llc
Defect Description:
SERVICE BRAKES
Potential Consequences:
Stopped at McDonalds drive through waiting to order with my foot on the brake and the vehicle lunged forward rearending the car stopped 5 feet in front of me ordering. I was trying to brake but it kept pushing the car in front of me then careened to the right hitting a sign and a parked car. I kept pumping the brakes and I thought it was going to run into a building when the vehicle finally stopped about 30 feet from the 2nd parked car it struck. Apparently it was "sudden unintended acceleration" and I've been reading on-line this has happened to many people including Actor Alan Ruck (see article). Rivian has not been responsive to us. Crash involving ‘Ferris Bueller,’ ‘Succession’ actor Alan Ruck was not a crime: LAPD by: Marc SternfieldPosted: Nov 2, 2023 / 03:22 PM PDT No charges will be filed as a result of the multi-car crash in Hollywood involving “Ferris Bueller” and “Succession” actor Alan Ruck, Los Angeles Police told KTLA on Thursday. The collision happened around 9 p.m. on Halloween night at the busy intersection of La Brea Avenue and Hollywood Boulevard. In two surveillance videos obtained by KTLA, Ruck’s Rivian electric pickup truck is seen stopped behind another car at a red light as pedestrians cross in the crosswalk. For reasons still unclear, the truck suddenly lunges forward and rear-ends the other car, and then careens across lanes of traffic, hitting another vehicle before crashing through the wall of Raffallo’s Pizza. At least one person is hospitalized after a three-vehicle collision sent a truck crashing through a pizza shop in Hollywood on Oct. ... Actor Alan Ruck is seen at the crash scene. Tim Ratcliff, who owns several adjacent restaurants, rushed to help the actor who he says was more concerned about the safety of the people he hit than his own wellbeing. “I asked him, ‘Are you okay? And the first thing out of his mouth was, ‘Is everyone [else] okay? I think I hit someone. Is he okay?’,” Ratcliff told KTLA.A 32-year-old man from one of th
Corrective Action:
Stopped at McDonalds drive through waiting to order with my foot on the brake and the vehicle lunged forward rearending the car stopped 5 feet in front of me ordering. I was trying to brake but it kept pushing the car in front of me then careened to the right hitting a sign and a parked car. I kept pumping the brakes and I thought it was going to run into a building when the vehicle finally stopped about 30 feet from the 2nd parked car it struck. Apparently it was "sudden unintended acceleration" and I've been reading on-line this has happened to many people including Actor Alan Ruck (see article). Rivian has not been responsive to us. Crash involving ‘Ferris Bueller,’ ‘Succession’ actor Alan Ruck was not a crime: LAPD by: Marc SternfieldPosted: Nov 2, 2023 / 03:22 PM PDT No charges will be filed as a result of the multi-car crash in Hollywood involving “Ferris Bueller” and “Succession” actor Alan Ruck, Los Angeles Police told KTLA on Thursday. The collision happened around 9 p.m. on Halloween night at the busy intersection of La Brea Avenue and Hollywood Boulevard. In two surveillance videos obtained by KTLA, Ruck’s Rivian electric pickup truck is seen stopped behind another car at a red light as pedestrians cross in the crosswalk. For reasons still unclear, the truck suddenly lunges forward and rear-ends the other car, and then careens across lanes of traffic, hitting another vehicle before crashing through the wall of Raffallo’s Pizza. At least one person is hospitalized after a three-vehicle collision sent a truck crashing through a pizza shop in Hollywood on Oct. ... Actor Alan Ruck is seen at the crash scene. Tim Ratcliff, who owns several adjacent restaurants, rushed to help the actor who he says was more concerned about the safety of the people he hit than his own wellbeing. “I asked him, ‘Are you okay? And the first thing out of his mouth was, ‘Is everyone [else] okay? I think I hit someone. Is he okay?’,” Ratcliff told KTLA.A 32-year-old man from one of th
Additional Notes:
Stopped at McDonalds drive through waiting to order with my foot on the brake and the vehicle lunged forward rearending the car stopped 5 feet in front of me ordering. I was trying to brake but it kept pushing the car in front of me then careened to the right hitting a sign and a parked car. I kept pumping the brakes and I thought it was going to run into a building when the vehicle finally stopped about 30 feet from the 2nd parked car it struck. Apparently it was "sudden unintended acceleration" and I've been reading on-line this has happened to many people including Actor Alan Ruck (see article). Rivian has not been responsive to us. Crash involving ‘Ferris Bueller,’ ‘Succession’ actor Alan Ruck was not a crime: LAPD by: Marc SternfieldPosted: Nov 2, 2023 / 03:22 PM PDT No charges will be filed as a result of the multi-car crash in Hollywood involving “Ferris Bueller” and “Succession” actor Alan Ruck, Los Angeles Police told KTLA on Thursday. The collision happened around 9 p.m. on Halloween night at the busy intersection of La Brea Avenue and Hollywood Boulevard. In two surveillance videos obtained by KTLA, Ruck’s Rivian electric pickup truck is seen stopped behind another car at a red light as pedestrians cross in the crosswalk. For reasons still unclear, the truck suddenly lunges forward and rear-ends the other car, and then careens across lanes of traffic, hitting another vehicle before crashing through the wall of Raffallo’s Pizza. At least one person is hospitalized after a three-vehicle collision sent a truck crashing through a pizza shop in Hollywood on Oct. ... Actor Alan Ruck is seen at the crash scene. Tim Ratcliff, who owns several adjacent restaurants, rushed to help the actor who he says was more concerned about the safety of the people he hit than his own wellbeing. “I asked him, ‘Are you okay? And the first thing out of his mouth was, ‘Is everyone [else] okay? I think I hit someone. Is he okay?’,” Ratcliff told KTLA.A 32-year-old man from one of th
Mfg Campaign: 11553554
Recall Date: Nov 4, 2023
Rivian Automotive, Llc
Defect Description:
FORWARD COLLISION AVOIDANCE: WARNINGS
Potential Consequences:
Stopped at McDonalds drive through waiting to order with my foot on the brake and the vehicle lunged forward rearending the car stopped 5 feet in front of me ordering. I was trying to brake but it kept pushing the car in front of me then careened to the right hitting a sign and a parked car. I kept pumping the brakes and I thought it was going to run into a building when the vehicle finally stopped about 30 feet from the 2nd parked car it struck. Apparently it was "sudden unintended acceleration" and I've been reading on-line this has happened to many people including Actor Alan Ruck (see article). Rivian has not been responsive to us. Crash involving ‘Ferris Bueller,’ ‘Succession’ actor Alan Ruck was not a crime: LAPD by: Marc SternfieldPosted: Nov 2, 2023 / 03:22 PM PDT No charges will be filed as a result of the multi-car crash in Hollywood involving “Ferris Bueller” and “Succession” actor Alan Ruck, Los Angeles Police told KTLA on Thursday. The collision happened around 9 p.m. on Halloween night at the busy intersection of La Brea Avenue and Hollywood Boulevard. In two surveillance videos obtained by KTLA, Ruck’s Rivian electric pickup truck is seen stopped behind another car at a red light as pedestrians cross in the crosswalk. For reasons still unclear, the truck suddenly lunges forward and rear-ends the other car, and then careens across lanes of traffic, hitting another vehicle before crashing through the wall of Raffallo’s Pizza. At least one person is hospitalized after a three-vehicle collision sent a truck crashing through a pizza shop in Hollywood on Oct. ... Actor Alan Ruck is seen at the crash scene. Tim Ratcliff, who owns several adjacent restaurants, rushed to help the actor who he says was more concerned about the safety of the people he hit than his own wellbeing. “I asked him, ‘Are you okay? And the first thing out of his mouth was, ‘Is everyone [else] okay? I think I hit someone. Is he okay?’,” Ratcliff told KTLA.A 32-year-old man from one of th
Corrective Action:
Stopped at McDonalds drive through waiting to order with my foot on the brake and the vehicle lunged forward rearending the car stopped 5 feet in front of me ordering. I was trying to brake but it kept pushing the car in front of me then careened to the right hitting a sign and a parked car. I kept pumping the brakes and I thought it was going to run into a building when the vehicle finally stopped about 30 feet from the 2nd parked car it struck. Apparently it was "sudden unintended acceleration" and I've been reading on-line this has happened to many people including Actor Alan Ruck (see article). Rivian has not been responsive to us. Crash involving ‘Ferris Bueller,’ ‘Succession’ actor Alan Ruck was not a crime: LAPD by: Marc SternfieldPosted: Nov 2, 2023 / 03:22 PM PDT No charges will be filed as a result of the multi-car crash in Hollywood involving “Ferris Bueller” and “Succession” actor Alan Ruck, Los Angeles Police told KTLA on Thursday. The collision happened around 9 p.m. on Halloween night at the busy intersection of La Brea Avenue and Hollywood Boulevard. In two surveillance videos obtained by KTLA, Ruck’s Rivian electric pickup truck is seen stopped behind another car at a red light as pedestrians cross in the crosswalk. For reasons still unclear, the truck suddenly lunges forward and rear-ends the other car, and then careens across lanes of traffic, hitting another vehicle before crashing through the wall of Raffallo’s Pizza. At least one person is hospitalized after a three-vehicle collision sent a truck crashing through a pizza shop in Hollywood on Oct. ... Actor Alan Ruck is seen at the crash scene. Tim Ratcliff, who owns several adjacent restaurants, rushed to help the actor who he says was more concerned about the safety of the people he hit than his own wellbeing. “I asked him, ‘Are you okay? And the first thing out of his mouth was, ‘Is everyone [else] okay? I think I hit someone. Is he okay?’,” Ratcliff told KTLA.A 32-year-old man from one of th
Additional Notes:
Stopped at McDonalds drive through waiting to order with my foot on the brake and the vehicle lunged forward rearending the car stopped 5 feet in front of me ordering. I was trying to brake but it kept pushing the car in front of me then careened to the right hitting a sign and a parked car. I kept pumping the brakes and I thought it was going to run into a building when the vehicle finally stopped about 30 feet from the 2nd parked car it struck. Apparently it was "sudden unintended acceleration" and I've been reading on-line this has happened to many people including Actor Alan Ruck (see article). Rivian has not been responsive to us. Crash involving ‘Ferris Bueller,’ ‘Succession’ actor Alan Ruck was not a crime: LAPD by: Marc SternfieldPosted: Nov 2, 2023 / 03:22 PM PDT No charges will be filed as a result of the multi-car crash in Hollywood involving “Ferris Bueller” and “Succession” actor Alan Ruck, Los Angeles Police told KTLA on Thursday. The collision happened around 9 p.m. on Halloween night at the busy intersection of La Brea Avenue and Hollywood Boulevard. In two surveillance videos obtained by KTLA, Ruck’s Rivian electric pickup truck is seen stopped behind another car at a red light as pedestrians cross in the crosswalk. For reasons still unclear, the truck suddenly lunges forward and rear-ends the other car, and then careens across lanes of traffic, hitting another vehicle before crashing through the wall of Raffallo’s Pizza. At least one person is hospitalized after a three-vehicle collision sent a truck crashing through a pizza shop in Hollywood on Oct. ... Actor Alan Ruck is seen at the crash scene. Tim Ratcliff, who owns several adjacent restaurants, rushed to help the actor who he says was more concerned about the safety of the people he hit than his own wellbeing. “I asked him, ‘Are you okay? And the first thing out of his mouth was, ‘Is everyone [else] okay? I think I hit someone. Is he okay?’,” Ratcliff told KTLA.A 32-year-old man from one of th
Mfg Campaign: 11553554
Recall Date: Nov 4, 2023
Rivian Automotive, Llc
Defect Description:
SERVICE BRAKES
Potential Consequences:
One fine morning, went to start the car and the car threw a bunch of error messages related to servicing 12 V battery system and dis-engaged the parking brake that lead the vehicle to start rolling down the driveway. The message on screen warned of applying brakes, and luckily circumstances were safe around the car, and I was able to apply brakes and was able to reboot the car and systems restored. Considering this vehicle does not have traditional ignition and is capable of waking up via remote application, and this incident happened merely as the vehicle was waking up, this can be a dangerous situation especially if it happens while unattended. The vehicle does not have mechanical parking brake controls, and is completely computer controlled. The fail safe condition around parking brake systems and circuit/software faults need to ensure parking brake stays engaged during any computer faults.
Corrective Action:
One fine morning, went to start the car and the car threw a bunch of error messages related to servicing 12 V battery system and dis-engaged the parking brake that lead the vehicle to start rolling down the driveway. The message on screen warned of applying brakes, and luckily circumstances were safe around the car, and I was able to apply brakes and was able to reboot the car and systems restored. Considering this vehicle does not have traditional ignition and is capable of waking up via remote application, and this incident happened merely as the vehicle was waking up, this can be a dangerous situation especially if it happens while unattended. The vehicle does not have mechanical parking brake controls, and is completely computer controlled. The fail safe condition around parking brake systems and circuit/software faults need to ensure parking brake stays engaged during any computer faults.
Additional Notes:
One fine morning, went to start the car and the car threw a bunch of error messages related to servicing 12 V battery system and dis-engaged the parking brake that lead the vehicle to start rolling down the driveway. The message on screen warned of applying brakes, and luckily circumstances were safe around the car, and I was able to apply brakes and was able to reboot the car and systems restored. Considering this vehicle does not have traditional ignition and is capable of waking up via remote application, and this incident happened merely as the vehicle was waking up, this can be a dangerous situation especially if it happens while unattended. The vehicle does not have mechanical parking brake controls, and is completely computer controlled. The fail safe condition around parking brake systems and circuit/software faults need to ensure parking brake stays engaged during any computer faults.
Mfg Campaign: 11552954
Recall Date: Nov 1, 2023
Rivian Automotive, Llc
Defect Description:
AIR BAGS
Potential Consequences:
When my wife, 5 ft 5 in about ~100lbs sits in the front passenger seat (legs and feet forward in a regular up-right position), the airbag does not always turn on. It is intermittent and unpredictable when it turns on vs. off. It even turns off and on while driving. It makes us uncomfortable not knowing if she is protected in a crash. Rivian has told us it's working as expected but the photos show otherwise and they say there is nothing they can do to fix.
Corrective Action:
When my wife, 5 ft 5 in about ~100lbs sits in the front passenger seat (legs and feet forward in a regular up-right position), the airbag does not always turn on. It is intermittent and unpredictable when it turns on vs. off. It even turns off and on while driving. It makes us uncomfortable not knowing if she is protected in a crash. Rivian has told us it's working as expected but the photos show otherwise and they say there is nothing they can do to fix.
Additional Notes:
When my wife, 5 ft 5 in about ~100lbs sits in the front passenger seat (legs and feet forward in a regular up-right position), the airbag does not always turn on. It is intermittent and unpredictable when it turns on vs. off. It even turns off and on while driving. It makes us uncomfortable not knowing if she is protected in a crash. Rivian has told us it's working as expected but the photos show otherwise and they say there is nothing they can do to fix.
Mfg Campaign: 11552916
Recall Date: Oct 31, 2023
Rivian Automotive, Llc
Defect Description:
LANE DEPARTURE: BLIND SPOT DETECTION
Potential Consequences:
Immediately after purchasing the vehicle, I got error codes thrown to service the suspension while driving to my house, specifically at 15-20mph over traffic calming bumps. This fault cleared immediately the first few times. On July 25 I submitted a service request as my family headed out on a two week, 900 mile trip. The service suspension fault had returned and disabled my ability to change modes/ride heights, blind spot sensors and cruise control, all of which I was counting on using during trip. I shut off and restarted the vehicle several times trying to clear the fault and regain functionality, but the fault inevitably returned. On July 25, Rivian added a response in the service portal that they would address the problem by July 28th. I heard nothing more. On August 1, I was driving south on HWY 57 in North Idaho. I hoped that code would have cleared, but it came back on almost immediately. After driving for about 5 miles, I decided to pull over at a visitor center parking lot to try and reset again to change modes, regain safety sensors, and cruise control. While turning left into the parking lot, another driver tried to pass on my left on a double yellow line driving above the 55mph speed limit. He collided with the front left part of my vehicle, damaging the body and breaking the front tie rod ends, leaving me unable to steer or drive forward, disabled, in the oncoming traffic lane. I asked Rivian to share data about the turn signal use, brake light, and speed data at the time of the accident with me. They did not respond in writing, but called and refused, getting quite angry during the call. After researching and observing other Rivians, I don't believe that my brake lights were on during regenerative braking. The rear, side, and blind spot sensors were disabled. Turning 1/4 second sooner or 5º sharper would have killed me.
Corrective Action:
Immediately after purchasing the vehicle, I got error codes thrown to service the suspension while driving to my house, specifically at 15-20mph over traffic calming bumps. This fault cleared immediately the first few times. On July 25 I submitted a service request as my family headed out on a two week, 900 mile trip. The service suspension fault had returned and disabled my ability to change modes/ride heights, blind spot sensors and cruise control, all of which I was counting on using during trip. I shut off and restarted the vehicle several times trying to clear the fault and regain functionality, but the fault inevitably returned. On July 25, Rivian added a response in the service portal that they would address the problem by July 28th. I heard nothing more. On August 1, I was driving south on HWY 57 in North Idaho. I hoped that code would have cleared, but it came back on almost immediately. After driving for about 5 miles, I decided to pull over at a visitor center parking lot to try and reset again to change modes, regain safety sensors, and cruise control. While turning left into the parking lot, another driver tried to pass on my left on a double yellow line driving above the 55mph speed limit. He collided with the front left part of my vehicle, damaging the body and breaking the front tie rod ends, leaving me unable to steer or drive forward, disabled, in the oncoming traffic lane. I asked Rivian to share data about the turn signal use, brake light, and speed data at the time of the accident with me. They did not respond in writing, but called and refused, getting quite angry during the call. After researching and observing other Rivians, I don't believe that my brake lights were on during regenerative braking. The rear, side, and blind spot sensors were disabled. Turning 1/4 second sooner or 5º sharper would have killed me.
Additional Notes:
Immediately after purchasing the vehicle, I got error codes thrown to service the suspension while driving to my house, specifically at 15-20mph over traffic calming bumps. This fault cleared immediately the first few times. On July 25 I submitted a service request as my family headed out on a two week, 900 mile trip. The service suspension fault had returned and disabled my ability to change modes/ride heights, blind spot sensors and cruise control, all of which I was counting on using during trip. I shut off and restarted the vehicle several times trying to clear the fault and regain functionality, but the fault inevitably returned. On July 25, Rivian added a response in the service portal that they would address the problem by July 28th. I heard nothing more. On August 1, I was driving south on HWY 57 in North Idaho. I hoped that code would have cleared, but it came back on almost immediately. After driving for about 5 miles, I decided to pull over at a visitor center parking lot to try and reset again to change modes, regain safety sensors, and cruise control. While turning left into the parking lot, another driver tried to pass on my left on a double yellow line driving above the 55mph speed limit. He collided with the front left part of my vehicle, damaging the body and breaking the front tie rod ends, leaving me unable to steer or drive forward, disabled, in the oncoming traffic lane. I asked Rivian to share data about the turn signal use, brake light, and speed data at the time of the accident with me. They did not respond in writing, but called and refused, getting quite angry during the call. After researching and observing other Rivians, I don't believe that my brake lights were on during regenerative braking. The rear, side, and blind spot sensors were disabled. Turning 1/4 second sooner or 5º sharper would have killed me.
Mfg Campaign: 11550710
Recall Date: Oct 18, 2023
Rivian Automotive, Llc
Defect Description:
SUSPENSION
Potential Consequences:
Immediately after purchasing the vehicle, I got error codes thrown to service the suspension while driving to my house, specifically at 15-20mph over traffic calming bumps. This fault cleared immediately the first few times. On July 25 I submitted a service request as my family headed out on a two week, 900 mile trip. The service suspension fault had returned and disabled my ability to change modes/ride heights, blind spot sensors and cruise control, all of which I was counting on using during trip. I shut off and restarted the vehicle several times trying to clear the fault and regain functionality, but the fault inevitably returned. On July 25, Rivian added a response in the service portal that they would address the problem by July 28th. I heard nothing more. On August 1, I was driving south on HWY 57 in North Idaho. I hoped that code would have cleared, but it came back on almost immediately. After driving for about 5 miles, I decided to pull over at a visitor center parking lot to try and reset again to change modes, regain safety sensors, and cruise control. While turning left into the parking lot, another driver tried to pass on my left on a double yellow line driving above the 55mph speed limit. He collided with the front left part of my vehicle, damaging the body and breaking the front tie rod ends, leaving me unable to steer or drive forward, disabled, in the oncoming traffic lane. I asked Rivian to share data about the turn signal use, brake light, and speed data at the time of the accident with me. They did not respond in writing, but called and refused, getting quite angry during the call. After researching and observing other Rivians, I don't believe that my brake lights were on during regenerative braking. The rear, side, and blind spot sensors were disabled. Turning 1/4 second sooner or 5º sharper would have killed me.
Corrective Action:
Immediately after purchasing the vehicle, I got error codes thrown to service the suspension while driving to my house, specifically at 15-20mph over traffic calming bumps. This fault cleared immediately the first few times. On July 25 I submitted a service request as my family headed out on a two week, 900 mile trip. The service suspension fault had returned and disabled my ability to change modes/ride heights, blind spot sensors and cruise control, all of which I was counting on using during trip. I shut off and restarted the vehicle several times trying to clear the fault and regain functionality, but the fault inevitably returned. On July 25, Rivian added a response in the service portal that they would address the problem by July 28th. I heard nothing more. On August 1, I was driving south on HWY 57 in North Idaho. I hoped that code would have cleared, but it came back on almost immediately. After driving for about 5 miles, I decided to pull over at a visitor center parking lot to try and reset again to change modes, regain safety sensors, and cruise control. While turning left into the parking lot, another driver tried to pass on my left on a double yellow line driving above the 55mph speed limit. He collided with the front left part of my vehicle, damaging the body and breaking the front tie rod ends, leaving me unable to steer or drive forward, disabled, in the oncoming traffic lane. I asked Rivian to share data about the turn signal use, brake light, and speed data at the time of the accident with me. They did not respond in writing, but called and refused, getting quite angry during the call. After researching and observing other Rivians, I don't believe that my brake lights were on during regenerative braking. The rear, side, and blind spot sensors were disabled. Turning 1/4 second sooner or 5º sharper would have killed me.
Additional Notes:
Immediately after purchasing the vehicle, I got error codes thrown to service the suspension while driving to my house, specifically at 15-20mph over traffic calming bumps. This fault cleared immediately the first few times. On July 25 I submitted a service request as my family headed out on a two week, 900 mile trip. The service suspension fault had returned and disabled my ability to change modes/ride heights, blind spot sensors and cruise control, all of which I was counting on using during trip. I shut off and restarted the vehicle several times trying to clear the fault and regain functionality, but the fault inevitably returned. On July 25, Rivian added a response in the service portal that they would address the problem by July 28th. I heard nothing more. On August 1, I was driving south on HWY 57 in North Idaho. I hoped that code would have cleared, but it came back on almost immediately. After driving for about 5 miles, I decided to pull over at a visitor center parking lot to try and reset again to change modes, regain safety sensors, and cruise control. While turning left into the parking lot, another driver tried to pass on my left on a double yellow line driving above the 55mph speed limit. He collided with the front left part of my vehicle, damaging the body and breaking the front tie rod ends, leaving me unable to steer or drive forward, disabled, in the oncoming traffic lane. I asked Rivian to share data about the turn signal use, brake light, and speed data at the time of the accident with me. They did not respond in writing, but called and refused, getting quite angry during the call. After researching and observing other Rivians, I don't believe that my brake lights were on during regenerative braking. The rear, side, and blind spot sensors were disabled. Turning 1/4 second sooner or 5º sharper would have killed me.
Mfg Campaign: 11550710
Recall Date: Oct 18, 2023
Rivian Automotive, Llc
Defect Description:
SERVICE BRAKES
Potential Consequences:
Immediately after purchasing the vehicle, I got error codes thrown to service the suspension while driving to my house, specifically at 15-20mph over traffic calming bumps. This fault cleared immediately the first few times. On July 25 I submitted a service request as my family headed out on a two week, 900 mile trip. The service suspension fault had returned and disabled my ability to change modes/ride heights, blind spot sensors and cruise control, all of which I was counting on using during trip. I shut off and restarted the vehicle several times trying to clear the fault and regain functionality, but the fault inevitably returned. On July 25, Rivian added a response in the service portal that they would address the problem by July 28th. I heard nothing more. On August 1, I was driving south on HWY 57 in North Idaho. I hoped that code would have cleared, but it came back on almost immediately. After driving for about 5 miles, I decided to pull over at a visitor center parking lot to try and reset again to change modes, regain safety sensors, and cruise control. While turning left into the parking lot, another driver tried to pass on my left on a double yellow line driving above the 55mph speed limit. He collided with the front left part of my vehicle, damaging the body and breaking the front tie rod ends, leaving me unable to steer or drive forward, disabled, in the oncoming traffic lane. I asked Rivian to share data about the turn signal use, brake light, and speed data at the time of the accident with me. They did not respond in writing, but called and refused, getting quite angry during the call. After researching and observing other Rivians, I don't believe that my brake lights were on during regenerative braking. The rear, side, and blind spot sensors were disabled. Turning 1/4 second sooner or 5º sharper would have killed me.
Corrective Action:
Immediately after purchasing the vehicle, I got error codes thrown to service the suspension while driving to my house, specifically at 15-20mph over traffic calming bumps. This fault cleared immediately the first few times. On July 25 I submitted a service request as my family headed out on a two week, 900 mile trip. The service suspension fault had returned and disabled my ability to change modes/ride heights, blind spot sensors and cruise control, all of which I was counting on using during trip. I shut off and restarted the vehicle several times trying to clear the fault and regain functionality, but the fault inevitably returned. On July 25, Rivian added a response in the service portal that they would address the problem by July 28th. I heard nothing more. On August 1, I was driving south on HWY 57 in North Idaho. I hoped that code would have cleared, but it came back on almost immediately. After driving for about 5 miles, I decided to pull over at a visitor center parking lot to try and reset again to change modes, regain safety sensors, and cruise control. While turning left into the parking lot, another driver tried to pass on my left on a double yellow line driving above the 55mph speed limit. He collided with the front left part of my vehicle, damaging the body and breaking the front tie rod ends, leaving me unable to steer or drive forward, disabled, in the oncoming traffic lane. I asked Rivian to share data about the turn signal use, brake light, and speed data at the time of the accident with me. They did not respond in writing, but called and refused, getting quite angry during the call. After researching and observing other Rivians, I don't believe that my brake lights were on during regenerative braking. The rear, side, and blind spot sensors were disabled. Turning 1/4 second sooner or 5º sharper would have killed me.
Additional Notes:
Immediately after purchasing the vehicle, I got error codes thrown to service the suspension while driving to my house, specifically at 15-20mph over traffic calming bumps. This fault cleared immediately the first few times. On July 25 I submitted a service request as my family headed out on a two week, 900 mile trip. The service suspension fault had returned and disabled my ability to change modes/ride heights, blind spot sensors and cruise control, all of which I was counting on using during trip. I shut off and restarted the vehicle several times trying to clear the fault and regain functionality, but the fault inevitably returned. On July 25, Rivian added a response in the service portal that they would address the problem by July 28th. I heard nothing more. On August 1, I was driving south on HWY 57 in North Idaho. I hoped that code would have cleared, but it came back on almost immediately. After driving for about 5 miles, I decided to pull over at a visitor center parking lot to try and reset again to change modes, regain safety sensors, and cruise control. While turning left into the parking lot, another driver tried to pass on my left on a double yellow line driving above the 55mph speed limit. He collided with the front left part of my vehicle, damaging the body and breaking the front tie rod ends, leaving me unable to steer or drive forward, disabled, in the oncoming traffic lane. I asked Rivian to share data about the turn signal use, brake light, and speed data at the time of the accident with me. They did not respond in writing, but called and refused, getting quite angry during the call. After researching and observing other Rivians, I don't believe that my brake lights were on during regenerative braking. The rear, side, and blind spot sensors were disabled. Turning 1/4 second sooner or 5º sharper would have killed me.
Mfg Campaign: 11550710
Recall Date: Oct 18, 2023
Rivian Automotive, Llc
Defect Description:
UNKNOWN OR OTHER
Potential Consequences:
Horn on the car not loud enough. Other drivers on road can barely hear it. I can barely hear inside my own car.
Corrective Action:
Horn on the car not loud enough. Other drivers on road can barely hear it. I can barely hear inside my own car.
Additional Notes:
Horn on the car not loud enough. Other drivers on road can barely hear it. I can barely hear inside my own car.
Mfg Campaign: 11548357
Recall Date: Oct 5, 2023
Rivian Automotive, Llc
Defect Description:
AIR BAGS
Potential Consequences:
Passenger side airbag off sign stayed on while my girlfriend was sitting in the seat. She weighs about 100 pounds. When I sat in the passenger seat, the Passenger side airbag off sign turned off. I weigh about 170 pounds.
Corrective Action:
Passenger side airbag off sign stayed on while my girlfriend was sitting in the seat. She weighs about 100 pounds. When I sat in the passenger seat, the Passenger side airbag off sign turned off. I weigh about 170 pounds.
Additional Notes:
Passenger side airbag off sign stayed on while my girlfriend was sitting in the seat. She weighs about 100 pounds. When I sat in the passenger seat, the Passenger side airbag off sign turned off. I weigh about 170 pounds.
Mfg Campaign: 11547649
Recall Date: Oct 2, 2023
Rivian Automotive, Llc
Defect Description:
SEATS
Potential Consequences:
Passenger side airbag off sign stayed on while my girlfriend was sitting in the seat. She weighs about 100 pounds. When I sat in the passenger seat, the Passenger side airbag off sign turned off. I weigh about 170 pounds.
Corrective Action:
Passenger side airbag off sign stayed on while my girlfriend was sitting in the seat. She weighs about 100 pounds. When I sat in the passenger seat, the Passenger side airbag off sign turned off. I weigh about 170 pounds.
Additional Notes:
Passenger side airbag off sign stayed on while my girlfriend was sitting in the seat. She weighs about 100 pounds. When I sat in the passenger seat, the Passenger side airbag off sign turned off. I weigh about 170 pounds.
Mfg Campaign: 11547649
Recall Date: Oct 2, 2023
Rivian Automotive, Llc
Defect Description:
AIR BAGS
Potential Consequences:
I noticed when driving with a passenger (female, approximately 135 pounds) that the screen keeps switching between "PASSENGER AIRBAG OFF" and showing the vehicle detects the passenger (hence the airbag is on). I'm concerned about the safety of my passenger when driving as I do not know whether the passenger airbag will work properly. I took photos and videos of this issue with my vehicle as it is reproducible when driving with this passenger. I took the vehicle to the manufacturer's service center, and they noted: "Followed along with the repair plan created by diagnostics team, notated each step as completed, upon following repair plan was unable to duplicate customer concern, found the occupancy sensor works as expected, The occupancy sensor is very sensitive and dependent upon the weight being distributed equally throughout the seat, if the occupant sits too far forward in the seat the sensor will not detect the weight". The issue was first detected on September 9, 2023 and the vehicle had less than 1000 miles on the odometer.
Corrective Action:
I noticed when driving with a passenger (female, approximately 135 pounds) that the screen keeps switching between "PASSENGER AIRBAG OFF" and showing the vehicle detects the passenger (hence the airbag is on). I'm concerned about the safety of my passenger when driving as I do not know whether the passenger airbag will work properly. I took photos and videos of this issue with my vehicle as it is reproducible when driving with this passenger. I took the vehicle to the manufacturer's service center, and they noted: "Followed along with the repair plan created by diagnostics team, notated each step as completed, upon following repair plan was unable to duplicate customer concern, found the occupancy sensor works as expected, The occupancy sensor is very sensitive and dependent upon the weight being distributed equally throughout the seat, if the occupant sits too far forward in the seat the sensor will not detect the weight". The issue was first detected on September 9, 2023 and the vehicle had less than 1000 miles on the odometer.
Additional Notes:
I noticed when driving with a passenger (female, approximately 135 pounds) that the screen keeps switching between "PASSENGER AIRBAG OFF" and showing the vehicle detects the passenger (hence the airbag is on). I'm concerned about the safety of my passenger when driving as I do not know whether the passenger airbag will work properly. I took photos and videos of this issue with my vehicle as it is reproducible when driving with this passenger. I took the vehicle to the manufacturer's service center, and they noted: "Followed along with the repair plan created by diagnostics team, notated each step as completed, upon following repair plan was unable to duplicate customer concern, found the occupancy sensor works as expected, The occupancy sensor is very sensitive and dependent upon the weight being distributed equally throughout the seat, if the occupant sits too far forward in the seat the sensor will not detect the weight". The issue was first detected on September 9, 2023 and the vehicle had less than 1000 miles on the odometer.
Mfg Campaign: 11547422
Recall Date: Sep 29, 2023
Rivian Automotive, Llc
Defect Description:
STEERING
Potential Consequences:
Vehicle lunged to the right without any driver input. Damaged rim and wheel and could have hurt someone . Have never experienced anything like this in my life. Steering wheel was perfectly straight but vehicle lunges to the right. This is a safety issue.
Corrective Action:
Vehicle lunged to the right without any driver input. Damaged rim and wheel and could have hurt someone . Have never experienced anything like this in my life. Steering wheel was perfectly straight but vehicle lunges to the right. This is a safety issue.
Additional Notes:
Vehicle lunged to the right without any driver input. Damaged rim and wheel and could have hurt someone . Have never experienced anything like this in my life. Steering wheel was perfectly straight but vehicle lunges to the right. This is a safety issue.
Mfg Campaign: 11546818
Recall Date: Sep 27, 2023
Rivian Automotive, Llc
Defect Description:
WHEELS
Potential Consequences:
Vehicle lunged to the right without any driver input. Damaged rim and wheel and could have hurt someone . Have never experienced anything like this in my life. Steering wheel was perfectly straight but vehicle lunges to the right. This is a safety issue.
Corrective Action:
Vehicle lunged to the right without any driver input. Damaged rim and wheel and could have hurt someone . Have never experienced anything like this in my life. Steering wheel was perfectly straight but vehicle lunges to the right. This is a safety issue.
Additional Notes:
Vehicle lunged to the right without any driver input. Damaged rim and wheel and could have hurt someone . Have never experienced anything like this in my life. Steering wheel was perfectly straight but vehicle lunges to the right. This is a safety issue.
Mfg Campaign: 11546818
Recall Date: Sep 27, 2023
Rivian Automotive, Llc
Defect Description:
UNKNOWN OR OTHER
Potential Consequences:
Vehicle lunged to the right without any driver input. Damaged rim and wheel and could have hurt someone . Have never experienced anything like this in my life. Steering wheel was perfectly straight but vehicle lunges to the right. This is a safety issue.
Corrective Action:
Vehicle lunged to the right without any driver input. Damaged rim and wheel and could have hurt someone . Have never experienced anything like this in my life. Steering wheel was perfectly straight but vehicle lunges to the right. This is a safety issue.
Additional Notes:
Vehicle lunged to the right without any driver input. Damaged rim and wheel and could have hurt someone . Have never experienced anything like this in my life. Steering wheel was perfectly straight but vehicle lunges to the right. This is a safety issue.
Mfg Campaign: 11546818
Recall Date: Sep 27, 2023
Rivian Automotive, Llc
Defect Description:
AIR BAGS
Potential Consequences:
They have set the sensors for the passenger airbag outside of the acceptable department standards. There are many instances where a person under 120 pounds does not activate the sensor and therefore the passenger airbag is not activated. I have notified the company on several occasions and not been given any response other than they are aware or it is working as intended. It is not worth someone getting hurt to create a response.
Corrective Action:
They have set the sensors for the passenger airbag outside of the acceptable department standards. There are many instances where a person under 120 pounds does not activate the sensor and therefore the passenger airbag is not activated. I have notified the company on several occasions and not been given any response other than they are aware or it is working as intended. It is not worth someone getting hurt to create a response.
Additional Notes:
They have set the sensors for the passenger airbag outside of the acceptable department standards. There are many instances where a person under 120 pounds does not activate the sensor and therefore the passenger airbag is not activated. I have notified the company on several occasions and not been given any response other than they are aware or it is working as intended. It is not worth someone getting hurt to create a response.
Mfg Campaign: 11546987
Recall Date: Sep 27, 2023
Rivian Automotive, Llc
Defect Description:
POWER TRAIN
Potential Consequences:
On the morning of 9/14/2023 while commuting to work, my one month old, 2100 mile R1S ground to a halt while driving normally in All-Purpose Mode at about 15mph in the middle of a busy road. There were zero warning signs or noticeable weirdness with the vehicle before this happened. The vehicle stopped itself, parked and put the hazard lights on with multiple warning messages on the screen displayed. There was heavy morning traffic and we had no ability to shift out of park to move the vehicle to a safer place. This was a very unsafe situation. It was stuck in the middle of the road and other drivers began swerving around us, nearly colliding with us and each other. I had to call a tow truck and 911 to dispatch a police officer to come and light us up to keep the situation safe while waiting on the tow. Today the Rivian Service Center confirmed the diagnosis was a failure of the front drive inverter, which will be replaced accordingly and the vehicle will be put back in service once the repairs are completed. My concerns and reason for this report are the way this failure happens without warning at any speed at any location, and the inability of the driver to move the vehicle, even under limited power and speed, using the other drive unit (either front or rear). In order to be confident in driving my R1S going forward, I'd like to know what exactly failed in the inverter and why, and what was revised on the new inverters to prevent or significantly lower the failure rate. If nothing is done, someone is going to get hurt or killed by this. Also if Rivian can push a software update to allow the vehicle to be limped to a safe place using the other drive unit in the event of an inverter failure, that would be helpful as well. I know of several other Rivian owners who have experienced this exact failure and they all had to be towed away from an unsafe situation on the road after being unable to move their vehicles.
Corrective Action:
On the morning of 9/14/2023 while commuting to work, my one month old, 2100 mile R1S ground to a halt while driving normally in All-Purpose Mode at about 15mph in the middle of a busy road. There were zero warning signs or noticeable weirdness with the vehicle before this happened. The vehicle stopped itself, parked and put the hazard lights on with multiple warning messages on the screen displayed. There was heavy morning traffic and we had no ability to shift out of park to move the vehicle to a safer place. This was a very unsafe situation. It was stuck in the middle of the road and other drivers began swerving around us, nearly colliding with us and each other. I had to call a tow truck and 911 to dispatch a police officer to come and light us up to keep the situation safe while waiting on the tow. Today the Rivian Service Center confirmed the diagnosis was a failure of the front drive inverter, which will be replaced accordingly and the vehicle will be put back in service once the repairs are completed. My concerns and reason for this report are the way this failure happens without warning at any speed at any location, and the inability of the driver to move the vehicle, even under limited power and speed, using the other drive unit (either front or rear). In order to be confident in driving my R1S going forward, I'd like to know what exactly failed in the inverter and why, and what was revised on the new inverters to prevent or significantly lower the failure rate. If nothing is done, someone is going to get hurt or killed by this. Also if Rivian can push a software update to allow the vehicle to be limped to a safe place using the other drive unit in the event of an inverter failure, that would be helpful as well. I know of several other Rivian owners who have experienced this exact failure and they all had to be towed away from an unsafe situation on the road after being unable to move their vehicles.
Additional Notes:
On the morning of 9/14/2023 while commuting to work, my one month old, 2100 mile R1S ground to a halt while driving normally in All-Purpose Mode at about 15mph in the middle of a busy road. There were zero warning signs or noticeable weirdness with the vehicle before this happened. The vehicle stopped itself, parked and put the hazard lights on with multiple warning messages on the screen displayed. There was heavy morning traffic and we had no ability to shift out of park to move the vehicle to a safer place. This was a very unsafe situation. It was stuck in the middle of the road and other drivers began swerving around us, nearly colliding with us and each other. I had to call a tow truck and 911 to dispatch a police officer to come and light us up to keep the situation safe while waiting on the tow. Today the Rivian Service Center confirmed the diagnosis was a failure of the front drive inverter, which will be replaced accordingly and the vehicle will be put back in service once the repairs are completed. My concerns and reason for this report are the way this failure happens without warning at any speed at any location, and the inability of the driver to move the vehicle, even under limited power and speed, using the other drive unit (either front or rear). In order to be confident in driving my R1S going forward, I'd like to know what exactly failed in the inverter and why, and what was revised on the new inverters to prevent or significantly lower the failure rate. If nothing is done, someone is going to get hurt or killed by this. Also if Rivian can push a software update to allow the vehicle to be limped to a safe place using the other drive unit in the event of an inverter failure, that would be helpful as well. I know of several other Rivian owners who have experienced this exact failure and they all had to be towed away from an unsafe situation on the road after being unable to move their vehicles.
Mfg Campaign: 11546596
Recall Date: Sep 26, 2023
Rivian Automotive, Llc
Defect Description:
UNKNOWN OR OTHER
Potential Consequences:
The car automatically, abruptly, and without warning shift into park as I slowed down at a stop sign and stalled in the middle of the road. It did not shift into Park for 30-35 mins and even after doing hard and soft resets while on the phone with service. Somehow it worked again after my hitting the brakes several times and I was able to move it out to the side and drive it back home. This issue has happened multiple times in the past too but it only happened for a few seconds as opposed to such a long time. The car had a ‘charger not connected properly’ warning on the dashboard. My safety and that of my wife was put in danger as an abrupt and automatic shift to park disrupted traffic and we could’ve been rear-ended. This is also a particularly troubling issue if the car stalls abruptly when slowing down on the freeway and cars in the back are speeding up and end up rear-ending my car. This situation could be fatal. I wasn’t able to reproduce the event but it has happened to me multiple times in the past. Rivian is looking into this issue now as I’ve dropped off my car for service today (9/6). I did receive responses to my post on Reddit about this situation and other customers complaining of experiencing the same issue. There were no warning lamps or prior warnings of this issue. The dashboard showed a charger not installed correctly error but I believe that’s for another issue I’ve had with the car where the car does not fast charge. The issue first appeared for me in stop and go traffic in Seattle downtown a few days after taking delivery of the car in June, and once again on the Canada-US border in Vancouver in July when moving slowly in line to reach the immigration booth. The car abruptly stopped and would not shift back to drive. It took a minute or two but it eventually shifted back to drive.
Corrective Action:
The car automatically, abruptly, and without warning shift into park as I slowed down at a stop sign and stalled in the middle of the road. It did not shift into Park for 30-35 mins and even after doing hard and soft resets while on the phone with service. Somehow it worked again after my hitting the brakes several times and I was able to move it out to the side and drive it back home. This issue has happened multiple times in the past too but it only happened for a few seconds as opposed to such a long time. The car had a ‘charger not connected properly’ warning on the dashboard. My safety and that of my wife was put in danger as an abrupt and automatic shift to park disrupted traffic and we could’ve been rear-ended. This is also a particularly troubling issue if the car stalls abruptly when slowing down on the freeway and cars in the back are speeding up and end up rear-ending my car. This situation could be fatal. I wasn’t able to reproduce the event but it has happened to me multiple times in the past. Rivian is looking into this issue now as I’ve dropped off my car for service today (9/6). I did receive responses to my post on Reddit about this situation and other customers complaining of experiencing the same issue. There were no warning lamps or prior warnings of this issue. The dashboard showed a charger not installed correctly error but I believe that’s for another issue I’ve had with the car where the car does not fast charge. The issue first appeared for me in stop and go traffic in Seattle downtown a few days after taking delivery of the car in June, and once again on the Canada-US border in Vancouver in July when moving slowly in line to reach the immigration booth. The car abruptly stopped and would not shift back to drive. It took a minute or two but it eventually shifted back to drive.
Additional Notes:
The car automatically, abruptly, and without warning shift into park as I slowed down at a stop sign and stalled in the middle of the road. It did not shift into Park for 30-35 mins and even after doing hard and soft resets while on the phone with service. Somehow it worked again after my hitting the brakes several times and I was able to move it out to the side and drive it back home. This issue has happened multiple times in the past too but it only happened for a few seconds as opposed to such a long time. The car had a ‘charger not connected properly’ warning on the dashboard. My safety and that of my wife was put in danger as an abrupt and automatic shift to park disrupted traffic and we could’ve been rear-ended. This is also a particularly troubling issue if the car stalls abruptly when slowing down on the freeway and cars in the back are speeding up and end up rear-ending my car. This situation could be fatal. I wasn’t able to reproduce the event but it has happened to me multiple times in the past. Rivian is looking into this issue now as I’ve dropped off my car for service today (9/6). I did receive responses to my post on Reddit about this situation and other customers complaining of experiencing the same issue. There were no warning lamps or prior warnings of this issue. The dashboard showed a charger not installed correctly error but I believe that’s for another issue I’ve had with the car where the car does not fast charge. The issue first appeared for me in stop and go traffic in Seattle downtown a few days after taking delivery of the car in June, and once again on the Canada-US border in Vancouver in July when moving slowly in line to reach the immigration booth. The car abruptly stopped and would not shift back to drive. It took a minute or two but it eventually shifted back to drive.
Mfg Campaign: 11543063
Recall Date: Sep 7, 2023
Rivian Automotive, Llc
Defect Description:
ELECTRICAL SYSTEM
Potential Consequences:
The car automatically, abruptly, and without warning shift into park as I slowed down at a stop sign and stalled in the middle of the road. It did not shift into Park for 30-35 mins and even after doing hard and soft resets while on the phone with service. Somehow it worked again after my hitting the brakes several times and I was able to move it out to the side and drive it back home. This issue has happened multiple times in the past too but it only happened for a few seconds as opposed to such a long time. The car had a ‘charger not connected properly’ warning on the dashboard. My safety and that of my wife was put in danger as an abrupt and automatic shift to park disrupted traffic and we could’ve been rear-ended. This is also a particularly troubling issue if the car stalls abruptly when slowing down on the freeway and cars in the back are speeding up and end up rear-ending my car. This situation could be fatal. I wasn’t able to reproduce the event but it has happened to me multiple times in the past. Rivian is looking into this issue now as I’ve dropped off my car for service today (9/6). I did receive responses to my post on Reddit about this situation and other customers complaining of experiencing the same issue. There were no warning lamps or prior warnings of this issue. The dashboard showed a charger not installed correctly error but I believe that’s for another issue I’ve had with the car where the car does not fast charge. The issue first appeared for me in stop and go traffic in Seattle downtown a few days after taking delivery of the car in June, and once again on the Canada-US border in Vancouver in July when moving slowly in line to reach the immigration booth. The car abruptly stopped and would not shift back to drive. It took a minute or two but it eventually shifted back to drive.
Corrective Action:
The car automatically, abruptly, and without warning shift into park as I slowed down at a stop sign and stalled in the middle of the road. It did not shift into Park for 30-35 mins and even after doing hard and soft resets while on the phone with service. Somehow it worked again after my hitting the brakes several times and I was able to move it out to the side and drive it back home. This issue has happened multiple times in the past too but it only happened for a few seconds as opposed to such a long time. The car had a ‘charger not connected properly’ warning on the dashboard. My safety and that of my wife was put in danger as an abrupt and automatic shift to park disrupted traffic and we could’ve been rear-ended. This is also a particularly troubling issue if the car stalls abruptly when slowing down on the freeway and cars in the back are speeding up and end up rear-ending my car. This situation could be fatal. I wasn’t able to reproduce the event but it has happened to me multiple times in the past. Rivian is looking into this issue now as I’ve dropped off my car for service today (9/6). I did receive responses to my post on Reddit about this situation and other customers complaining of experiencing the same issue. There were no warning lamps or prior warnings of this issue. The dashboard showed a charger not installed correctly error but I believe that’s for another issue I’ve had with the car where the car does not fast charge. The issue first appeared for me in stop and go traffic in Seattle downtown a few days after taking delivery of the car in June, and once again on the Canada-US border in Vancouver in July when moving slowly in line to reach the immigration booth. The car abruptly stopped and would not shift back to drive. It took a minute or two but it eventually shifted back to drive.
Additional Notes:
The car automatically, abruptly, and without warning shift into park as I slowed down at a stop sign and stalled in the middle of the road. It did not shift into Park for 30-35 mins and even after doing hard and soft resets while on the phone with service. Somehow it worked again after my hitting the brakes several times and I was able to move it out to the side and drive it back home. This issue has happened multiple times in the past too but it only happened for a few seconds as opposed to such a long time. The car had a ‘charger not connected properly’ warning on the dashboard. My safety and that of my wife was put in danger as an abrupt and automatic shift to park disrupted traffic and we could’ve been rear-ended. This is also a particularly troubling issue if the car stalls abruptly when slowing down on the freeway and cars in the back are speeding up and end up rear-ending my car. This situation could be fatal. I wasn’t able to reproduce the event but it has happened to me multiple times in the past. Rivian is looking into this issue now as I’ve dropped off my car for service today (9/6). I did receive responses to my post on Reddit about this situation and other customers complaining of experiencing the same issue. There were no warning lamps or prior warnings of this issue. The dashboard showed a charger not installed correctly error but I believe that’s for another issue I’ve had with the car where the car does not fast charge. The issue first appeared for me in stop and go traffic in Seattle downtown a few days after taking delivery of the car in June, and once again on the Canada-US border in Vancouver in July when moving slowly in line to reach the immigration booth. The car abruptly stopped and would not shift back to drive. It took a minute or two but it eventually shifted back to drive.
Mfg Campaign: 11543063
Recall Date: Sep 7, 2023
Need Legal Help?
Featured Attorneys
Barry Edzant
Edzant Price LLC
Valencia, CA • 36 yrs
Focus: Lemon Law, Personal Injury
Recent Articles
Jeep Grand Cherokee Head Restraint Problem
Chrysler (FCA US, LLC) has announced a safety issue affecting certain 2023–2024 Jeep Grand Ch ...
Aug 1, 2025Fuel Injector Problem: 2021-2024 Ford Bronco Sport and 2020-2022 Ford Escape
If you own a 2021-2024 Ford Bronco Sport or 2020-2022 Ford Escape equipped with a 1.5L Dragon GTDI e ...
Jul 28, 2025Airbag Problem Affects 2022-2025 Chrysler Pacifica and Voyager Vehicles
If you own a Chrysler Pacifica or Voyager, your vehicle may be equipped with defective side curtain ...
Jul 24, 2025