Complaints & Recalls
Official Safety Recalls - Important!
26 RecallsThese are official manufacturer recalls ordered by NHTSA for safety defects. If you own this vehicle, contact your dealer immediately for free repairs.
Volvo Car Usa, Llc
Safety Issue:
Volvo Car USA, LLC (Volvo Car) is recalling certain 2020-2021 S90, 2020-2022 S60, V60, XC60, XC90, and 2022 V90 plug-in hybrid vehicles. The high-voltage battery may experience a short circuit within the battery module when the battery is fully charged and the vehicle is parked.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 888-327-4236 (TTY 888-275-9171) or go to nhtsa.gov.
Mfg Campaign: R10312
Recall Date: Mar 20, 2025
Volvo Car Usa, Llc
Safety Issue:
Volvo Car USA, LLC (Volvo Car) is recalling certain 2019-2022 V60CC, XC60, and XC90 vehicles. During steering gear assembly, double screws may have been assembled on top of each other, which can cause a screw to fall into the gearbox housing.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Mfg Campaign: R10213
Recall Date: Jan 5, 2023
Volvo Car Usa, Llc
Safety Issue:
Volvo Car USA, LLC (Volvo Car) is recalling certain 2021 S90L, 2020-2021 XC60, and XC90 vehicles. An improperly welded rotor and shaft may separate within the integrated brake system.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Mfg Campaign: R10120
Recall Date: Sep 15, 2021
Volvo Car Usa, Llc
Safety Issue:
Volvo Car USA, LLC (Volvo Car) is recalling certain 2021 XC40, XC 40 Recharge, V60CC, V90, V90CC, XC90, and 2021-2022 V60, XC60, S60 vehicles. The seat belt automatic locking retractors may deactivate early, which can prevent the child restraint system from securing properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Mfg Campaign: R10111
Recall Date: Sep 1, 2021
Volvo Car Usa, Llc
Safety Issue:
Volvo Cars USA, LLC (Volvo Car) is recalling certain 2021 Volvo V60, V60 Cross Country, V90, V90 Cross Country, XC60, and XC90 vehicles. The Supplementary Restraint System (SRS) control unit may not have been properly attached to the car body and may detach during a crash.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Mfg Campaign: R10068
Recall Date: Jan 7, 2021
Consumer Complaints
52 ComplaintsVolvo Car Usa, Llc
Defect Description:
SERVICE BRAKES
Potential Consequences:
I’ve taken the vehicle back to dealership several times and they say nothing is wrong with it. The steering wheel vibrates at high speeds or when backing into parking spaces. Loud noise when backing into parking spaces, possibly brakes or steering. Engines unusually loud when starting up. Windshield just spilt all the way across when car was sitting for 5 days in august, not from rocks on road. Vehicle has unusually low mileage of 16-18 mpg city & hyw driving. Brakes are noisy- I thought they were crack when I purchased last year. These happened on multiple dates of which your system doesn’t allow me to add.
Corrective Action:
I’ve taken the vehicle back to dealership several times and they say nothing is wrong with it. The steering wheel vibrates at high speeds or when backing into parking spaces. Loud noise when backing into parking spaces, possibly brakes or steering. Engines unusually loud when starting up. Windshield just spilt all the way across when car was sitting for 5 days in august, not from rocks on road. Vehicle has unusually low mileage of 16-18 mpg city & hyw driving. Brakes are noisy- I thought they were crack when I purchased last year. These happened on multiple dates of which your system doesn’t allow me to add.
Additional Notes:
I’ve taken the vehicle back to dealership several times and they say nothing is wrong with it. The steering wheel vibrates at high speeds or when backing into parking spaces. Loud noise when backing into parking spaces, possibly brakes or steering. Engines unusually loud when starting up. Windshield just spilt all the way across when car was sitting for 5 days in august, not from rocks on road. Vehicle has unusually low mileage of 16-18 mpg city & hyw driving. Brakes are noisy- I thought they were crack when I purchased last year. These happened on multiple dates of which your system doesn’t allow me to add.
Mfg Campaign: 11490467
Recall Date: Oct 23, 2022
Volvo Car Usa, Llc
Defect Description:
UNKNOWN OR OTHER
Potential Consequences:
I’ve taken the vehicle back to dealership several times and they say nothing is wrong with it. The steering wheel vibrates at high speeds or when backing into parking spaces. Loud noise when backing into parking spaces, possibly brakes or steering. Engines unusually loud when starting up. Windshield just spilt all the way across when car was sitting for 5 days in august, not from rocks on road. Vehicle has unusually low mileage of 16-18 mpg city & hyw driving. Brakes are noisy- I thought they were crack when I purchased last year. These happened on multiple dates of which your system doesn’t allow me to add.
Corrective Action:
I’ve taken the vehicle back to dealership several times and they say nothing is wrong with it. The steering wheel vibrates at high speeds or when backing into parking spaces. Loud noise when backing into parking spaces, possibly brakes or steering. Engines unusually loud when starting up. Windshield just spilt all the way across when car was sitting for 5 days in august, not from rocks on road. Vehicle has unusually low mileage of 16-18 mpg city & hyw driving. Brakes are noisy- I thought they were crack when I purchased last year. These happened on multiple dates of which your system doesn’t allow me to add.
Additional Notes:
I’ve taken the vehicle back to dealership several times and they say nothing is wrong with it. The steering wheel vibrates at high speeds or when backing into parking spaces. Loud noise when backing into parking spaces, possibly brakes or steering. Engines unusually loud when starting up. Windshield just spilt all the way across when car was sitting for 5 days in august, not from rocks on road. Vehicle has unusually low mileage of 16-18 mpg city & hyw driving. Brakes are noisy- I thought they were crack when I purchased last year. These happened on multiple dates of which your system doesn’t allow me to add.
Mfg Campaign: 11490467
Recall Date: Oct 23, 2022
Volvo Car Usa, Llc
Defect Description:
ENGINE
Potential Consequences:
I’ve taken the vehicle back to dealership several times and they say nothing is wrong with it. The steering wheel vibrates at high speeds or when backing into parking spaces. Loud noise when backing into parking spaces, possibly brakes or steering. Engines unusually loud when starting up. Windshield just spilt all the way across when car was sitting for 5 days in august, not from rocks on road. Vehicle has unusually low mileage of 16-18 mpg city & hyw driving. Brakes are noisy- I thought they were crack when I purchased last year. These happened on multiple dates of which your system doesn’t allow me to add.
Corrective Action:
I’ve taken the vehicle back to dealership several times and they say nothing is wrong with it. The steering wheel vibrates at high speeds or when backing into parking spaces. Loud noise when backing into parking spaces, possibly brakes or steering. Engines unusually loud when starting up. Windshield just spilt all the way across when car was sitting for 5 days in august, not from rocks on road. Vehicle has unusually low mileage of 16-18 mpg city & hyw driving. Brakes are noisy- I thought they were crack when I purchased last year. These happened on multiple dates of which your system doesn’t allow me to add.
Additional Notes:
I’ve taken the vehicle back to dealership several times and they say nothing is wrong with it. The steering wheel vibrates at high speeds or when backing into parking spaces. Loud noise when backing into parking spaces, possibly brakes or steering. Engines unusually loud when starting up. Windshield just spilt all the way across when car was sitting for 5 days in august, not from rocks on road. Vehicle has unusually low mileage of 16-18 mpg city & hyw driving. Brakes are noisy- I thought they were crack when I purchased last year. These happened on multiple dates of which your system doesn’t allow me to add.
Mfg Campaign: 11490467
Recall Date: Oct 23, 2022
Volvo Car Usa, Llc
Defect Description:
ELECTRICAL SYSTEM
Potential Consequences:
Without warning, car loses BLIS, electric windows and seats fail to work, ventilation system is inoperable. Supposedly fixed by dealer, but same issues have arisen within 60 days of repair.
Corrective Action:
Without warning, car loses BLIS, electric windows and seats fail to work, ventilation system is inoperable. Supposedly fixed by dealer, but same issues have arisen within 60 days of repair.
Additional Notes:
Without warning, car loses BLIS, electric windows and seats fail to work, ventilation system is inoperable. Supposedly fixed by dealer, but same issues have arisen within 60 days of repair.
Mfg Campaign: 11486621
Recall Date: Sep 27, 2022
Volvo Car Usa, Llc
Defect Description:
SEATS
Potential Consequences:
Without warning, car loses BLIS, electric windows and seats fail to work, ventilation system is inoperable. Supposedly fixed by dealer, but same issues have arisen within 60 days of repair.
Corrective Action:
Without warning, car loses BLIS, electric windows and seats fail to work, ventilation system is inoperable. Supposedly fixed by dealer, but same issues have arisen within 60 days of repair.
Additional Notes:
Without warning, car loses BLIS, electric windows and seats fail to work, ventilation system is inoperable. Supposedly fixed by dealer, but same issues have arisen within 60 days of repair.
Mfg Campaign: 11486621
Recall Date: Sep 27, 2022
Volvo Car Usa, Llc
Defect Description:
LANE DEPARTURE: BLIND SPOT DETECTION
Potential Consequences:
Without warning, car loses BLIS, electric windows and seats fail to work, ventilation system is inoperable. Supposedly fixed by dealer, but same issues have arisen within 60 days of repair.
Corrective Action:
Without warning, car loses BLIS, electric windows and seats fail to work, ventilation system is inoperable. Supposedly fixed by dealer, but same issues have arisen within 60 days of repair.
Additional Notes:
Without warning, car loses BLIS, electric windows and seats fail to work, ventilation system is inoperable. Supposedly fixed by dealer, but same issues have arisen within 60 days of repair.
Mfg Campaign: 11486621
Recall Date: Sep 27, 2022
Volvo Car Usa, Llc
Defect Description:
SERVICE BRAKES
Potential Consequences:
I brought the car to the Volvo dealer for my 20,000 miles service. They told me that the rear rotors and pads are worn and need to be replaced. The front brakes are fine. I think that this is a design flaw. No one expects the rear brakes to wear first, and certainly not after only 20,000 miles!
Corrective Action:
I brought the car to the Volvo dealer for my 20,000 miles service. They told me that the rear rotors and pads are worn and need to be replaced. The front brakes are fine. I think that this is a design flaw. No one expects the rear brakes to wear first, and certainly not after only 20,000 miles!
Additional Notes:
I brought the car to the Volvo dealer for my 20,000 miles service. They told me that the rear rotors and pads are worn and need to be replaced. The front brakes are fine. I think that this is a design flaw. No one expects the rear brakes to wear first, and certainly not after only 20,000 miles!
Mfg Campaign: 11485300
Recall Date: Sep 19, 2022
Volvo Car Usa, Llc
Defect Description:
LANE DEPARTURE: BLIND SPOT DETECTION
Potential Consequences:
The BLIS warning light has been malfunctioning and only displaying intermittently for several weeks. We were traveling from Florida to Massachusetts when we discovered the problem. We made arrangements for the car to be serviced twice, but they informed us they did not observe the issue during their test drive the first time. The second time they indicated that although the signal only activates intermittently, it is designed to function intermittently. We were informed that it will only activate if our car is going the same speed as the car we are passing or the car that is passing us. They subsequently advised the indicator will not activate if there is a 9 mph difference between the passing vehicle and the car being passed. We previously understood the indicator would be a signal or warning that it is not safe to return to the lane of the cars we are passing or move to the lane of the cars that are passing us. I have videos detailing what we perceive as the problem.
Corrective Action:
The BLIS warning light has been malfunctioning and only displaying intermittently for several weeks. We were traveling from Florida to Massachusetts when we discovered the problem. We made arrangements for the car to be serviced twice, but they informed us they did not observe the issue during their test drive the first time. The second time they indicated that although the signal only activates intermittently, it is designed to function intermittently. We were informed that it will only activate if our car is going the same speed as the car we are passing or the car that is passing us. They subsequently advised the indicator will not activate if there is a 9 mph difference between the passing vehicle and the car being passed. We previously understood the indicator would be a signal or warning that it is not safe to return to the lane of the cars we are passing or move to the lane of the cars that are passing us. I have videos detailing what we perceive as the problem.
Additional Notes:
The BLIS warning light has been malfunctioning and only displaying intermittently for several weeks. We were traveling from Florida to Massachusetts when we discovered the problem. We made arrangements for the car to be serviced twice, but they informed us they did not observe the issue during their test drive the first time. The second time they indicated that although the signal only activates intermittently, it is designed to function intermittently. We were informed that it will only activate if our car is going the same speed as the car we are passing or the car that is passing us. They subsequently advised the indicator will not activate if there is a 9 mph difference between the passing vehicle and the car being passed. We previously understood the indicator would be a signal or warning that it is not safe to return to the lane of the cars we are passing or move to the lane of the cars that are passing us. I have videos detailing what we perceive as the problem.
Mfg Campaign: 11484780
Recall Date: Sep 16, 2022
Volvo Car Usa, Llc
Defect Description:
VISIBILITY/WIPER
Potential Consequences:
Hi, I bought this XC60 in SEP/2020 which is 2021type. In 2020 winter, after snowing The car's left(driver' window) doesn't work. I have searched the problem of wiper through on-line. I found the recall and then wrote on the manufacturer's online site & regular exam oil change Volvo service. But, I didn't get the right answer. They just this is not a recall SUV. When rainy days I can't see anything both of the wipers don't work and shows a warning of not working. It's too dangerous. I always bring a driver in order to open the window wiper cap. I have fixed it over 10 times. Today my wife drive this vehicle on a rainy day She was frustrated and fall into a dangerous situation. Both wipes don't work. Please review and fix it.
Corrective Action:
Hi, I bought this XC60 in SEP/2020 which is 2021type. In 2020 winter, after snowing The car's left(driver' window) doesn't work. I have searched the problem of wiper through on-line. I found the recall and then wrote on the manufacturer's online site & regular exam oil change Volvo service. But, I didn't get the right answer. They just this is not a recall SUV. When rainy days I can't see anything both of the wipers don't work and shows a warning of not working. It's too dangerous. I always bring a driver in order to open the window wiper cap. I have fixed it over 10 times. Today my wife drive this vehicle on a rainy day She was frustrated and fall into a dangerous situation. Both wipes don't work. Please review and fix it.
Additional Notes:
Hi, I bought this XC60 in SEP/2020 which is 2021type. In 2020 winter, after snowing The car's left(driver' window) doesn't work. I have searched the problem of wiper through on-line. I found the recall and then wrote on the manufacturer's online site & regular exam oil change Volvo service. But, I didn't get the right answer. They just this is not a recall SUV. When rainy days I can't see anything both of the wipers don't work and shows a warning of not working. It's too dangerous. I always bring a driver in order to open the window wiper cap. I have fixed it over 10 times. Today my wife drive this vehicle on a rainy day She was frustrated and fall into a dangerous situation. Both wipes don't work. Please review and fix it.
Mfg Campaign: 11482966
Recall Date: Sep 6, 2022
Volvo Car Usa, Llc
Defect Description:
LANE DEPARTURE: BLIND SPOT DETECTION
Potential Consequences:
The BLIS warning light has been malfunctioning and only displaying intermittently for several weeks. We were traveling from Florida to Massachusetts when we discovered the problem. We made arrangements for the car to be serviced, but the dealer informed us they did not observe the issue during their test drive and suggested we check the manual to read about BLIS limitations. We did that, but none of the situations applies in our case. The dealer did inform us that they downloaded and reinstalled the appropriate software, however the problem has not been resolved. The passenger side indicator works about 40% of the time and the driver side indicator works about 50% of the time. (I did two manual counts of this while traveling to come up with the stats.) We have another appointment scheduled and will request the mechanic or the service rep take a ride with us in the passenger seat so he or she can observe the problem. There were no messages or warnings that the function was not working properly. The first indication there was an issue came when we actually observed the problem when we were passing a trailer truck on the highway. Although we are able to drive without this feature, it is a problem and could cause and accident.
Corrective Action:
The BLIS warning light has been malfunctioning and only displaying intermittently for several weeks. We were traveling from Florida to Massachusetts when we discovered the problem. We made arrangements for the car to be serviced, but the dealer informed us they did not observe the issue during their test drive and suggested we check the manual to read about BLIS limitations. We did that, but none of the situations applies in our case. The dealer did inform us that they downloaded and reinstalled the appropriate software, however the problem has not been resolved. The passenger side indicator works about 40% of the time and the driver side indicator works about 50% of the time. (I did two manual counts of this while traveling to come up with the stats.) We have another appointment scheduled and will request the mechanic or the service rep take a ride with us in the passenger seat so he or she can observe the problem. There were no messages or warnings that the function was not working properly. The first indication there was an issue came when we actually observed the problem when we were passing a trailer truck on the highway. Although we are able to drive without this feature, it is a problem and could cause and accident.
Additional Notes:
The BLIS warning light has been malfunctioning and only displaying intermittently for several weeks. We were traveling from Florida to Massachusetts when we discovered the problem. We made arrangements for the car to be serviced, but the dealer informed us they did not observe the issue during their test drive and suggested we check the manual to read about BLIS limitations. We did that, but none of the situations applies in our case. The dealer did inform us that they downloaded and reinstalled the appropriate software, however the problem has not been resolved. The passenger side indicator works about 40% of the time and the driver side indicator works about 50% of the time. (I did two manual counts of this while traveling to come up with the stats.) We have another appointment scheduled and will request the mechanic or the service rep take a ride with us in the passenger seat so he or she can observe the problem. There were no messages or warnings that the function was not working properly. The first indication there was an issue came when we actually observed the problem when we were passing a trailer truck on the highway. Although we are able to drive without this feature, it is a problem and could cause and accident.
Mfg Campaign: 11481259
Recall Date: Aug 25, 2022
Volvo Car Usa, Llc
Defect Description:
AIR BAGS
Potential Consequences:
Side impact curtain air bags only deployed on right side (side of impact), causing head concussion from hitting driverside window on left side. Vehicle has been towed for repair, but may still be available for inspection for a short time. Fire department stated airbags tried but failed deployment. Contacted dealer. Dealer said contact Volvo North America. Volvo has yet to connect me to the right person or department.
Corrective Action:
Side impact curtain air bags only deployed on right side (side of impact), causing head concussion from hitting driverside window on left side. Vehicle has been towed for repair, but may still be available for inspection for a short time. Fire department stated airbags tried but failed deployment. Contacted dealer. Dealer said contact Volvo North America. Volvo has yet to connect me to the right person or department.
Additional Notes:
Side impact curtain air bags only deployed on right side (side of impact), causing head concussion from hitting driverside window on left side. Vehicle has been towed for repair, but may still be available for inspection for a short time. Fire department stated airbags tried but failed deployment. Contacted dealer. Dealer said contact Volvo North America. Volvo has yet to connect me to the right person or department.
Mfg Campaign: 11475285
Recall Date: Jul 22, 2022
Volvo Car Usa, Llc
Defect Description:
STEERING
Potential Consequences:
In September 2021 on 3 occasions, my car's steering locked up while driving. I could not unwind my wheel from a turn. Each time nearly resulted in a collision with a garage ticket booth, a median, drifting into an oncoming lane. II slammed on brakes each time to avoid and accident or collision. It was frightening. This happened at low speed (approx. 10 mph), I had no warning indicators, and the wheel released after I stepped off the brake. I took the car to the dealer who could not replicate it; they suggested I keep all lane keeping aids off. They have since been off. This month of July 2022, this began to happen again: 4 times in one week. The last time I could not correct out of turn in the road and nearly resulted in a head-on collision at about 32 mph and I ended up in the approaching traffic lane. I was terrified and very shaken up. I returned to the dealer. This time, I googled the problem and found two instances of this SAME issue here: https://www.carproblemzoo.com/volvo/xc60/steering-problems.php I shared this page with my dealer. Again, they could not replicate it. Also, the dealer could not find the Volvo Advisory about it. They did take me seriously however and replace the sub-battery to my power steering. Its been a week since this repair, and it hasn't happened in this time period, but I am still concerned. The dealers said they "can't report it to Volvo" as "no warning code [issue] was indicated in the software/computer/system." (As no signals popped up on my dash). This is also disconcerting it can't be reported to the manufacturer. This may be related to power steering, electrical, or other. I felt in danger and at risk of injury or collision with my car. Yes, the car is available for inspection. I trust the dealer is trying to help and has been helpful, but I'm still wary of driving it without acknowledgement of issue from Volvo or a fix from Volvo. It feels risky.
Corrective Action:
In September 2021 on 3 occasions, my car's steering locked up while driving. I could not unwind my wheel from a turn. Each time nearly resulted in a collision with a garage ticket booth, a median, drifting into an oncoming lane. II slammed on brakes each time to avoid and accident or collision. It was frightening. This happened at low speed (approx. 10 mph), I had no warning indicators, and the wheel released after I stepped off the brake. I took the car to the dealer who could not replicate it; they suggested I keep all lane keeping aids off. They have since been off. This month of July 2022, this began to happen again: 4 times in one week. The last time I could not correct out of turn in the road and nearly resulted in a head-on collision at about 32 mph and I ended up in the approaching traffic lane. I was terrified and very shaken up. I returned to the dealer. This time, I googled the problem and found two instances of this SAME issue here: https://www.carproblemzoo.com/volvo/xc60/steering-problems.php I shared this page with my dealer. Again, they could not replicate it. Also, the dealer could not find the Volvo Advisory about it. They did take me seriously however and replace the sub-battery to my power steering. Its been a week since this repair, and it hasn't happened in this time period, but I am still concerned. The dealers said they "can't report it to Volvo" as "no warning code [issue] was indicated in the software/computer/system." (As no signals popped up on my dash). This is also disconcerting it can't be reported to the manufacturer. This may be related to power steering, electrical, or other. I felt in danger and at risk of injury or collision with my car. Yes, the car is available for inspection. I trust the dealer is trying to help and has been helpful, but I'm still wary of driving it without acknowledgement of issue from Volvo or a fix from Volvo. It feels risky.
Additional Notes:
In September 2021 on 3 occasions, my car's steering locked up while driving. I could not unwind my wheel from a turn. Each time nearly resulted in a collision with a garage ticket booth, a median, drifting into an oncoming lane. II slammed on brakes each time to avoid and accident or collision. It was frightening. This happened at low speed (approx. 10 mph), I had no warning indicators, and the wheel released after I stepped off the brake. I took the car to the dealer who could not replicate it; they suggested I keep all lane keeping aids off. They have since been off. This month of July 2022, this began to happen again: 4 times in one week. The last time I could not correct out of turn in the road and nearly resulted in a head-on collision at about 32 mph and I ended up in the approaching traffic lane. I was terrified and very shaken up. I returned to the dealer. This time, I googled the problem and found two instances of this SAME issue here: https://www.carproblemzoo.com/volvo/xc60/steering-problems.php I shared this page with my dealer. Again, they could not replicate it. Also, the dealer could not find the Volvo Advisory about it. They did take me seriously however and replace the sub-battery to my power steering. Its been a week since this repair, and it hasn't happened in this time period, but I am still concerned. The dealers said they "can't report it to Volvo" as "no warning code [issue] was indicated in the software/computer/system." (As no signals popped up on my dash). This is also disconcerting it can't be reported to the manufacturer. This may be related to power steering, electrical, or other. I felt in danger and at risk of injury or collision with my car. Yes, the car is available for inspection. I trust the dealer is trying to help and has been helpful, but I'm still wary of driving it without acknowledgement of issue from Volvo or a fix from Volvo. It feels risky.
Mfg Campaign: 11474508
Recall Date: Jul 18, 2022
Volvo Car Usa, Llc
Defect Description:
UNKNOWN OR OTHER
Potential Consequences:
In September 2021 on 3 occasions, my car's steering locked up while driving. I could not unwind my wheel from a turn. Each time nearly resulted in a collision with a garage ticket booth, a median, drifting into an oncoming lane. II slammed on brakes each time to avoid and accident or collision. It was frightening. This happened at low speed (approx. 10 mph), I had no warning indicators, and the wheel released after I stepped off the brake. I took the car to the dealer who could not replicate it; they suggested I keep all lane keeping aids off. They have since been off. This month of July 2022, this began to happen again: 4 times in one week. The last time I could not correct out of turn in the road and nearly resulted in a head-on collision at about 32 mph and I ended up in the approaching traffic lane. I was terrified and very shaken up. I returned to the dealer. This time, I googled the problem and found two instances of this SAME issue here: https://www.carproblemzoo.com/volvo/xc60/steering-problems.php I shared this page with my dealer. Again, they could not replicate it. Also, the dealer could not find the Volvo Advisory about it. They did take me seriously however and replace the sub-battery to my power steering. Its been a week since this repair, and it hasn't happened in this time period, but I am still concerned. The dealers said they "can't report it to Volvo" as "no warning code [issue] was indicated in the software/computer/system." (As no signals popped up on my dash). This is also disconcerting it can't be reported to the manufacturer. This may be related to power steering, electrical, or other. I felt in danger and at risk of injury or collision with my car. Yes, the car is available for inspection. I trust the dealer is trying to help and has been helpful, but I'm still wary of driving it without acknowledgement of issue from Volvo or a fix from Volvo. It feels risky.
Corrective Action:
In September 2021 on 3 occasions, my car's steering locked up while driving. I could not unwind my wheel from a turn. Each time nearly resulted in a collision with a garage ticket booth, a median, drifting into an oncoming lane. II slammed on brakes each time to avoid and accident or collision. It was frightening. This happened at low speed (approx. 10 mph), I had no warning indicators, and the wheel released after I stepped off the brake. I took the car to the dealer who could not replicate it; they suggested I keep all lane keeping aids off. They have since been off. This month of July 2022, this began to happen again: 4 times in one week. The last time I could not correct out of turn in the road and nearly resulted in a head-on collision at about 32 mph and I ended up in the approaching traffic lane. I was terrified and very shaken up. I returned to the dealer. This time, I googled the problem and found two instances of this SAME issue here: https://www.carproblemzoo.com/volvo/xc60/steering-problems.php I shared this page with my dealer. Again, they could not replicate it. Also, the dealer could not find the Volvo Advisory about it. They did take me seriously however and replace the sub-battery to my power steering. Its been a week since this repair, and it hasn't happened in this time period, but I am still concerned. The dealers said they "can't report it to Volvo" as "no warning code [issue] was indicated in the software/computer/system." (As no signals popped up on my dash). This is also disconcerting it can't be reported to the manufacturer. This may be related to power steering, electrical, or other. I felt in danger and at risk of injury or collision with my car. Yes, the car is available for inspection. I trust the dealer is trying to help and has been helpful, but I'm still wary of driving it without acknowledgement of issue from Volvo or a fix from Volvo. It feels risky.
Additional Notes:
In September 2021 on 3 occasions, my car's steering locked up while driving. I could not unwind my wheel from a turn. Each time nearly resulted in a collision with a garage ticket booth, a median, drifting into an oncoming lane. II slammed on brakes each time to avoid and accident or collision. It was frightening. This happened at low speed (approx. 10 mph), I had no warning indicators, and the wheel released after I stepped off the brake. I took the car to the dealer who could not replicate it; they suggested I keep all lane keeping aids off. They have since been off. This month of July 2022, this began to happen again: 4 times in one week. The last time I could not correct out of turn in the road and nearly resulted in a head-on collision at about 32 mph and I ended up in the approaching traffic lane. I was terrified and very shaken up. I returned to the dealer. This time, I googled the problem and found two instances of this SAME issue here: https://www.carproblemzoo.com/volvo/xc60/steering-problems.php I shared this page with my dealer. Again, they could not replicate it. Also, the dealer could not find the Volvo Advisory about it. They did take me seriously however and replace the sub-battery to my power steering. Its been a week since this repair, and it hasn't happened in this time period, but I am still concerned. The dealers said they "can't report it to Volvo" as "no warning code [issue] was indicated in the software/computer/system." (As no signals popped up on my dash). This is also disconcerting it can't be reported to the manufacturer. This may be related to power steering, electrical, or other. I felt in danger and at risk of injury or collision with my car. Yes, the car is available for inspection. I trust the dealer is trying to help and has been helpful, but I'm still wary of driving it without acknowledgement of issue from Volvo or a fix from Volvo. It feels risky.
Mfg Campaign: 11474508
Recall Date: Jul 18, 2022
Volvo Car Usa, Llc
Defect Description:
STEERING
Potential Consequences:
On three occasions in September 2021 the car's steering locked up while driving so that I was unable to unwind the wheel, nearly sending me into stationary objects or the opposing lane. After slamming on the brakes, the wheel released. These all happened at low speeds, around 10mph. No signals or warnings popped up on my display. This was very upsetting. The dealer could not reproduce, could find nothing wrong, and advised me to keep all lane keeping aids off. They have since been off. FOUR times last week of July 2022 this happened again, the last time sending me into oncoming traffic with multiple cars in both directions all nearly colliding at speeds in the 30-35mph I was crying and extremely upset, I've been in an accident before and this was triggering. My husband thinks the car is unsafe to drive. I returned to the dealer and cited two posts I found online of this same incident being reported with the same year and model car. The dealer could find nothing wrong again, but did believe me and did replace the sub battery to the power steering as one online public complaint cited a Volvo advisory recommending this fix in this situation. My dealer could not find this advisory from Volvo however. They also said there is nothing to report to Volvo as there are no computer prompts, or something along those lines. At this point if it fails again we'll be pursuing the lemon law. I want to trust the car is fixed, but this is terrifying.
Corrective Action:
On three occasions in September 2021 the car's steering locked up while driving so that I was unable to unwind the wheel, nearly sending me into stationary objects or the opposing lane. After slamming on the brakes, the wheel released. These all happened at low speeds, around 10mph. No signals or warnings popped up on my display. This was very upsetting. The dealer could not reproduce, could find nothing wrong, and advised me to keep all lane keeping aids off. They have since been off. FOUR times last week of July 2022 this happened again, the last time sending me into oncoming traffic with multiple cars in both directions all nearly colliding at speeds in the 30-35mph I was crying and extremely upset, I've been in an accident before and this was triggering. My husband thinks the car is unsafe to drive. I returned to the dealer and cited two posts I found online of this same incident being reported with the same year and model car. The dealer could find nothing wrong again, but did believe me and did replace the sub battery to the power steering as one online public complaint cited a Volvo advisory recommending this fix in this situation. My dealer could not find this advisory from Volvo however. They also said there is nothing to report to Volvo as there are no computer prompts, or something along those lines. At this point if it fails again we'll be pursuing the lemon law. I want to trust the car is fixed, but this is terrifying.
Additional Notes:
On three occasions in September 2021 the car's steering locked up while driving so that I was unable to unwind the wheel, nearly sending me into stationary objects or the opposing lane. After slamming on the brakes, the wheel released. These all happened at low speeds, around 10mph. No signals or warnings popped up on my display. This was very upsetting. The dealer could not reproduce, could find nothing wrong, and advised me to keep all lane keeping aids off. They have since been off. FOUR times last week of July 2022 this happened again, the last time sending me into oncoming traffic with multiple cars in both directions all nearly colliding at speeds in the 30-35mph I was crying and extremely upset, I've been in an accident before and this was triggering. My husband thinks the car is unsafe to drive. I returned to the dealer and cited two posts I found online of this same incident being reported with the same year and model car. The dealer could find nothing wrong again, but did believe me and did replace the sub battery to the power steering as one online public complaint cited a Volvo advisory recommending this fix in this situation. My dealer could not find this advisory from Volvo however. They also said there is nothing to report to Volvo as there are no computer prompts, or something along those lines. At this point if it fails again we'll be pursuing the lemon law. I want to trust the car is fixed, but this is terrifying.
Mfg Campaign: 11474232
Recall Date: Jul 16, 2022
Volvo Car Usa, Llc
Defect Description:
FORWARD COLLISION AVOIDANCE: WARNINGS
Potential Consequences:
The car started to move and accelerate with brake pressed. Accident prevention system did not activate itself. It did not display any warnings as it typically do during parking and being close to other cars. The car caused an accident with mild injuries to the driver of the other car, but could have hit a pedestrian or go to the intersection and involved with an accident with a car moving perpendicularly at a higher speed. I am waiting for an investigator from Volvo and Travelers Insurance. Prior to the accident the electronic display of the car started to malfunction. I have a video of the whole accident , but it is in mp4 format and thus i could not upload it. The dashboard camera's microphone picked some electromagnetic interference that increased as we got closer to the accident. Description of the accident: We pulled to a red light behind another car. After not moving for a few seconds, the car started to move on its own, accelerating and hitting the car in the front, continuing to move forward. I was able to put the shifter into the park, stopping it. The road conditions were good. Roads were dry. The sky were cloudy overhead. The vehicle is not drivable ( radiator leak ). The car behaved usually before the accident, except for some reason, for the first time, all the displays dimmed significantly ( it was hard to see anything, and I could not increase brightness ). The screens went back to normal brightness right before the accident. Also, the dashboard camera that recorded the incident, for some reason, picked up audio evidence of electromagnetic interference which was increasing as we were getting closer to the intersection.
Corrective Action:
The car started to move and accelerate with brake pressed. Accident prevention system did not activate itself. It did not display any warnings as it typically do during parking and being close to other cars. The car caused an accident with mild injuries to the driver of the other car, but could have hit a pedestrian or go to the intersection and involved with an accident with a car moving perpendicularly at a higher speed. I am waiting for an investigator from Volvo and Travelers Insurance. Prior to the accident the electronic display of the car started to malfunction. I have a video of the whole accident , but it is in mp4 format and thus i could not upload it. The dashboard camera's microphone picked some electromagnetic interference that increased as we got closer to the accident. Description of the accident: We pulled to a red light behind another car. After not moving for a few seconds, the car started to move on its own, accelerating and hitting the car in the front, continuing to move forward. I was able to put the shifter into the park, stopping it. The road conditions were good. Roads were dry. The sky were cloudy overhead. The vehicle is not drivable ( radiator leak ). The car behaved usually before the accident, except for some reason, for the first time, all the displays dimmed significantly ( it was hard to see anything, and I could not increase brightness ). The screens went back to normal brightness right before the accident. Also, the dashboard camera that recorded the incident, for some reason, picked up audio evidence of electromagnetic interference which was increasing as we were getting closer to the intersection.
Additional Notes:
The car started to move and accelerate with brake pressed. Accident prevention system did not activate itself. It did not display any warnings as it typically do during parking and being close to other cars. The car caused an accident with mild injuries to the driver of the other car, but could have hit a pedestrian or go to the intersection and involved with an accident with a car moving perpendicularly at a higher speed. I am waiting for an investigator from Volvo and Travelers Insurance. Prior to the accident the electronic display of the car started to malfunction. I have a video of the whole accident , but it is in mp4 format and thus i could not upload it. The dashboard camera's microphone picked some electromagnetic interference that increased as we got closer to the accident. Description of the accident: We pulled to a red light behind another car. After not moving for a few seconds, the car started to move on its own, accelerating and hitting the car in the front, continuing to move forward. I was able to put the shifter into the park, stopping it. The road conditions were good. Roads were dry. The sky were cloudy overhead. The vehicle is not drivable ( radiator leak ). The car behaved usually before the accident, except for some reason, for the first time, all the displays dimmed significantly ( it was hard to see anything, and I could not increase brightness ). The screens went back to normal brightness right before the accident. Also, the dashboard camera that recorded the incident, for some reason, picked up audio evidence of electromagnetic interference which was increasing as we were getting closer to the intersection.
Mfg Campaign: 11461792
Recall Date: Apr 22, 2022
Volvo Car Usa, Llc
Defect Description:
FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING
Potential Consequences:
The car started to move and accelerate with brake pressed. Accident prevention system did not activate itself. It did not display any warnings as it typically do during parking and being close to other cars. The car caused an accident with mild injuries to the driver of the other car, but could have hit a pedestrian or go to the intersection and involved with an accident with a car moving perpendicularly at a higher speed. I am waiting for an investigator from Volvo and Travelers Insurance. Prior to the accident the electronic display of the car started to malfunction. I have a video of the whole accident , but it is in mp4 format and thus i could not upload it. The dashboard camera's microphone picked some electromagnetic interference that increased as we got closer to the accident. Description of the accident: We pulled to a red light behind another car. After not moving for a few seconds, the car started to move on its own, accelerating and hitting the car in the front, continuing to move forward. I was able to put the shifter into the park, stopping it. The road conditions were good. Roads were dry. The sky were cloudy overhead. The vehicle is not drivable ( radiator leak ). The car behaved usually before the accident, except for some reason, for the first time, all the displays dimmed significantly ( it was hard to see anything, and I could not increase brightness ). The screens went back to normal brightness right before the accident. Also, the dashboard camera that recorded the incident, for some reason, picked up audio evidence of electromagnetic interference which was increasing as we were getting closer to the intersection.
Corrective Action:
The car started to move and accelerate with brake pressed. Accident prevention system did not activate itself. It did not display any warnings as it typically do during parking and being close to other cars. The car caused an accident with mild injuries to the driver of the other car, but could have hit a pedestrian or go to the intersection and involved with an accident with a car moving perpendicularly at a higher speed. I am waiting for an investigator from Volvo and Travelers Insurance. Prior to the accident the electronic display of the car started to malfunction. I have a video of the whole accident , but it is in mp4 format and thus i could not upload it. The dashboard camera's microphone picked some electromagnetic interference that increased as we got closer to the accident. Description of the accident: We pulled to a red light behind another car. After not moving for a few seconds, the car started to move on its own, accelerating and hitting the car in the front, continuing to move forward. I was able to put the shifter into the park, stopping it. The road conditions were good. Roads were dry. The sky were cloudy overhead. The vehicle is not drivable ( radiator leak ). The car behaved usually before the accident, except for some reason, for the first time, all the displays dimmed significantly ( it was hard to see anything, and I could not increase brightness ). The screens went back to normal brightness right before the accident. Also, the dashboard camera that recorded the incident, for some reason, picked up audio evidence of electromagnetic interference which was increasing as we were getting closer to the intersection.
Additional Notes:
The car started to move and accelerate with brake pressed. Accident prevention system did not activate itself. It did not display any warnings as it typically do during parking and being close to other cars. The car caused an accident with mild injuries to the driver of the other car, but could have hit a pedestrian or go to the intersection and involved with an accident with a car moving perpendicularly at a higher speed. I am waiting for an investigator from Volvo and Travelers Insurance. Prior to the accident the electronic display of the car started to malfunction. I have a video of the whole accident , but it is in mp4 format and thus i could not upload it. The dashboard camera's microphone picked some electromagnetic interference that increased as we got closer to the accident. Description of the accident: We pulled to a red light behind another car. After not moving for a few seconds, the car started to move on its own, accelerating and hitting the car in the front, continuing to move forward. I was able to put the shifter into the park, stopping it. The road conditions were good. Roads were dry. The sky were cloudy overhead. The vehicle is not drivable ( radiator leak ). The car behaved usually before the accident, except for some reason, for the first time, all the displays dimmed significantly ( it was hard to see anything, and I could not increase brightness ). The screens went back to normal brightness right before the accident. Also, the dashboard camera that recorded the incident, for some reason, picked up audio evidence of electromagnetic interference which was increasing as we were getting closer to the intersection.
Mfg Campaign: 11461792
Recall Date: Apr 22, 2022
Volvo Car Usa, Llc
Defect Description:
ELECTRICAL SYSTEM
Potential Consequences:
The car started to move and accelerate with brake pressed. Accident prevention system did not activate itself. It did not display any warnings as it typically do during parking and being close to other cars. The car caused an accident with mild injuries to the driver of the other car, but could have hit a pedestrian or go to the intersection and involved with an accident with a car moving perpendicularly at a higher speed. I am waiting for an investigator from Volvo and Travelers Insurance. Prior to the accident the electronic display of the car started to malfunction. I have a video of the whole accident , but it is in mp4 format and thus i could not upload it. The dashboard camera's microphone picked some electromagnetic interference that increased as we got closer to the accident. Description of the accident: We pulled to a red light behind another car. After not moving for a few seconds, the car started to move on its own, accelerating and hitting the car in the front, continuing to move forward. I was able to put the shifter into the park, stopping it. The road conditions were good. Roads were dry. The sky were cloudy overhead. The vehicle is not drivable ( radiator leak ). The car behaved usually before the accident, except for some reason, for the first time, all the displays dimmed significantly ( it was hard to see anything, and I could not increase brightness ). The screens went back to normal brightness right before the accident. Also, the dashboard camera that recorded the incident, for some reason, picked up audio evidence of electromagnetic interference which was increasing as we were getting closer to the intersection.
Corrective Action:
The car started to move and accelerate with brake pressed. Accident prevention system did not activate itself. It did not display any warnings as it typically do during parking and being close to other cars. The car caused an accident with mild injuries to the driver of the other car, but could have hit a pedestrian or go to the intersection and involved with an accident with a car moving perpendicularly at a higher speed. I am waiting for an investigator from Volvo and Travelers Insurance. Prior to the accident the electronic display of the car started to malfunction. I have a video of the whole accident , but it is in mp4 format and thus i could not upload it. The dashboard camera's microphone picked some electromagnetic interference that increased as we got closer to the accident. Description of the accident: We pulled to a red light behind another car. After not moving for a few seconds, the car started to move on its own, accelerating and hitting the car in the front, continuing to move forward. I was able to put the shifter into the park, stopping it. The road conditions were good. Roads were dry. The sky were cloudy overhead. The vehicle is not drivable ( radiator leak ). The car behaved usually before the accident, except for some reason, for the first time, all the displays dimmed significantly ( it was hard to see anything, and I could not increase brightness ). The screens went back to normal brightness right before the accident. Also, the dashboard camera that recorded the incident, for some reason, picked up audio evidence of electromagnetic interference which was increasing as we were getting closer to the intersection.
Additional Notes:
The car started to move and accelerate with brake pressed. Accident prevention system did not activate itself. It did not display any warnings as it typically do during parking and being close to other cars. The car caused an accident with mild injuries to the driver of the other car, but could have hit a pedestrian or go to the intersection and involved with an accident with a car moving perpendicularly at a higher speed. I am waiting for an investigator from Volvo and Travelers Insurance. Prior to the accident the electronic display of the car started to malfunction. I have a video of the whole accident , but it is in mp4 format and thus i could not upload it. The dashboard camera's microphone picked some electromagnetic interference that increased as we got closer to the accident. Description of the accident: We pulled to a red light behind another car. After not moving for a few seconds, the car started to move on its own, accelerating and hitting the car in the front, continuing to move forward. I was able to put the shifter into the park, stopping it. The road conditions were good. Roads were dry. The sky were cloudy overhead. The vehicle is not drivable ( radiator leak ). The car behaved usually before the accident, except for some reason, for the first time, all the displays dimmed significantly ( it was hard to see anything, and I could not increase brightness ). The screens went back to normal brightness right before the accident. Also, the dashboard camera that recorded the incident, for some reason, picked up audio evidence of electromagnetic interference which was increasing as we were getting closer to the intersection.
Mfg Campaign: 11461792
Recall Date: Apr 22, 2022
Volvo Car Usa, Llc
Defect Description:
FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL
Potential Consequences:
Today, my Sensus in the center console, as well as my instrument panel that shows the map between the gauges, went black and switched my drive mode out of ECO, shutting off my adaptive cruise control. Rebooted 2 times before becoming stable. I have a video, but your system doesn't allow me to upload the file type
Corrective Action:
Today, my Sensus in the center console, as well as my instrument panel that shows the map between the gauges, went black and switched my drive mode out of ECO, shutting off my adaptive cruise control. Rebooted 2 times before becoming stable. I have a video, but your system doesn't allow me to upload the file type
Additional Notes:
Today, my Sensus in the center console, as well as my instrument panel that shows the map between the gauges, went black and switched my drive mode out of ECO, shutting off my adaptive cruise control. Rebooted 2 times before becoming stable. I have a video, but your system doesn't allow me to upload the file type
Mfg Campaign: 11453722
Recall Date: Feb 23, 2022
Volvo Car Usa, Llc
Defect Description:
UNKNOWN OR OTHER
Potential Consequences:
Today, my Sensus in the center console, as well as my instrument panel that shows the map between the gauges, went black and switched my drive mode out of ECO, shutting off my adaptive cruise control. Rebooted 2 times before becoming stable. I have a video, but your system doesn't allow me to upload the file type
Corrective Action:
Today, my Sensus in the center console, as well as my instrument panel that shows the map between the gauges, went black and switched my drive mode out of ECO, shutting off my adaptive cruise control. Rebooted 2 times before becoming stable. I have a video, but your system doesn't allow me to upload the file type
Additional Notes:
Today, my Sensus in the center console, as well as my instrument panel that shows the map between the gauges, went black and switched my drive mode out of ECO, shutting off my adaptive cruise control. Rebooted 2 times before becoming stable. I have a video, but your system doesn't allow me to upload the file type
Mfg Campaign: 11453722
Recall Date: Feb 23, 2022
Volvo Car Usa, Llc
Defect Description:
ELECTRICAL SYSTEM
Potential Consequences:
Today, my Sensus in the center console, as well as my instrument panel that shows the map between the gauges, went black and switched my drive mode out of ECO, shutting off my adaptive cruise control. Rebooted 2 times before becoming stable. I have a video, but your system doesn't allow me to upload the file type
Corrective Action:
Today, my Sensus in the center console, as well as my instrument panel that shows the map between the gauges, went black and switched my drive mode out of ECO, shutting off my adaptive cruise control. Rebooted 2 times before becoming stable. I have a video, but your system doesn't allow me to upload the file type
Additional Notes:
Today, my Sensus in the center console, as well as my instrument panel that shows the map between the gauges, went black and switched my drive mode out of ECO, shutting off my adaptive cruise control. Rebooted 2 times before becoming stable. I have a video, but your system doesn't allow me to upload the file type
Mfg Campaign: 11453722
Recall Date: Feb 23, 2022
Need Legal Help?
Featured Attorneys
Barry Edzant
Edzant Price LLC
Valencia, CA • 36 yrs
Focus: Lemon Law, Personal Injury
Recent Articles
Jeep Grand Cherokee Head Restraint Problem
Chrysler (FCA US, LLC) has announced a safety issue affecting certain 2023–2024 Jeep Grand Ch ...
Aug 1, 2025Fuel Injector Problem: 2021-2024 Ford Bronco Sport and 2020-2022 Ford Escape
If you own a 2021-2024 Ford Bronco Sport or 2020-2022 Ford Escape equipped with a 1.5L Dragon GTDI e ...
Jul 28, 2025Airbag Problem Affects 2022-2025 Chrysler Pacifica and Voyager Vehicles
If you own a Chrysler Pacifica or Voyager, your vehicle may be equipped with defective side curtain ...
Jul 24, 2025