Complaints & Recalls
Official Safety Recalls - Important!
27 RecallsThese are official manufacturer recalls ordered by NHTSA for safety defects. If you own this vehicle, contact your dealer immediately for free repairs.
Tesla, Inc.
Safety Issue:
Tesla, Inc. (Tesla) is recalling certain 2023 Model 3 and Model Y vehicles operating software prior to 2023.38.4. The printed circuit board for the electronic power steering assist may experience an overstress condition, causing a loss of power steering assist when the vehicle reaches a stop and then accelerates again.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 888-275-9171) or go to nhtsa.gov.
Mfg Campaign: SB-25-00-004
Recall Date: Feb 14, 2025
Tesla, Inc.
Safety Issue:
Tesla, Inc. (Tesla) is recalling certain 2024-2025 Model 3, Model S, 2023-2025 Model X, and Model Y vehicles. The computer circuit board may short, resulting in the loss of the rearview camera image. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153) or go to nhtsa.gov.
Mfg Campaign: SB-25-00-001
Recall Date: Jan 6, 2025
Tesla, Inc.
Safety Issue:
Tesla, Inc. (Tesla) is recalling certain 2024 Cybertruck, 2017-2025 Model 3, and 2020-2025 Model Y vehicles. The tire pressure monitoring system (TPMS) warning light may not remain illuminated between drive cycles, failing to warn the driver of low tire pressure. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 138, "Tire Pressure Monitoring Systems."
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Mfg Campaign: SB-24-00-018
Recall Date: Dec 17, 2024
Tesla, Inc.
Safety Issue:
Tesla, Inc. (Tesla) is recalling certain 2021-2024 Model 3, Model S, Model X, and 2020-2024 Model Y vehicles. The hood latch assembly may fail to detect an unlatched hood condition after the hood has been opened.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Mfg Campaign: SB-24-00-012
Recall Date: Jul 24, 2024
Tesla, Inc.
Safety Issue:
Tesla, Inc. (Tesla) is recalling certain 2012-2024 Model S, 2015-2024 Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles. In the event of an unbelted driver, the seat belt warning light and audible chime may not activate as intended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Mfg Campaign: SB-24-00-008
Recall Date: May 28, 2024
Tesla, Inc.
Safety Issue:
Tesla, Inc. (Tesla) is recalling certain 2012-2023 Model S, 2016-2024 Model X, 2017-2023 Model 3, 2019-2024 Model Y, and 2024 Cybertruck vehicles. An incorrect font size is displayed on the instrument panel for the Brake, Park, and Antilock Brake System (ABS) warning lights. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 105, "Hydraulic and Electric Brake Systems" and 135, "Light Vehicle Brake Systems."
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Mfg Campaign: SB-24-00-003
Recall Date: Jan 30, 2024
Tesla, Inc.
Safety Issue:
Tesla, Inc. (Tesla) is recalling certain 2023 Model S, X, and Y vehicles equipped with full self-driving computer 4.0 and running a software release version 2023.44.30 through 2023.44.30.6 or 2023.44.100. Software instability may prevent the rearview camera image from displaying.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Mfg Campaign: SB-24-00-002
Recall Date: Jan 22, 2024
Tesla, Inc.
Safety Issue:
Tesla, Inc. (Tesla) is recalling 2012-2023 Model S, 2016-2023 Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles equipped with all versions of Autosteer leading up to the version(s) that contains the recall remedy. In certain circumstances when Autosteer is engaged, the prominence and scope of the feature's controls may not be sufficient to prevent driver misuse of the SAE Level 2 advanced driver-assistance feature.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Mfg Campaign: SB-23-00-008
Recall Date: Dec 12, 2023
Tesla, Inc.
Safety Issue:
Tesla, Inc. (Tesla) is recalling certain 2023 Model S, Model X, and Model Y vehicles. The forward-facing camera may be misaligned, causing some of the active safety features such as emergency braking, forward collision warning, and lane assist to become unavailable without alerting the driver.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Mfg Campaign: SB-23-17-006
Recall Date: Jul 14, 2023
Tesla, Inc.
Safety Issue:
Tesla, Inc. (Tesla) is recalling certain 2023 Model 3 and Model Y vehicles. The pyrotechnic battery disconnect may be defective.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Mfg Campaign: SB-23-16-005
Recall Date: Jun 19, 2023
Tesla, Inc.
Safety Issue:
Tesla, Inc. (Tesla) is recalling certain 2022-2023 Model Y vehicles. The steering wheel fastener may be loose.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Mfg Campaign: SB-23-32-001
Recall Date: May 30, 2023
Tesla, Inc.
Safety Issue:
Tesla, Inc. (Tesla) is recalling certain 2022-2023 Model Y vehicles. The bolts securing the second-row seat back frames may not have been securely tightened.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Mfg Campaign: SB-23-13-001
Recall Date: Feb 27, 2023
Tesla, Inc.
Safety Issue:
Tesla, Inc. (Tesla) is recalling certain 2016-2023 Model S, Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles equipped with Full Self-Driving Beta (FSD Beta) software or pending installation. The FSD Beta system may allow the vehicle to act unsafe around intersections, such as traveling straight through an intersection while in a turn-only lane, entering a stop sign-controlled intersection without coming to a complete stop, or proceeding into an intersection during a steady yellow traffic signal without due caution. In addition, the system may respond insufficiently to changes in posted speed limits or not adequately account for the driver's adjustment of the vehicle's speed to exceed posted speed limits.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Mfg Campaign: SB-23-00-001
Recall Date: Feb 15, 2023
Tesla, Inc.
Safety Issue:
Tesla, Inc. (Tesla) is recalling certain 2023 Model Y vehicles. The front suspension lateral link fasteners may not have been properly attached to the sub-frame.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153) or go to www.nhtsa.gov.
Mfg Campaign: SB-22-31-002
Recall Date: Dec 5, 2022
Tesla, Inc.
Safety Issue:
Tesla, Inc. (Tesla) is recalling certain 2023 Model 3 and 2020-2023 Model Y vehicles. One or both taillights may intermittently fail to illuminate.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Mfg Campaign: SB-22-00-016
Recall Date: Nov 15, 2022
Consumer Complaints
1.6K ComplaintsTesla, Inc.
Defect Description:
SUSPENSION
Potential Consequences:
Front lower control arm bushings are torn. This was discovered at 32000 miles. Premature failure of suspension parts can create a unsafe driving condition. Currently available for inspection. But will be replaced under warranty as soon as possible.
Corrective Action:
Front lower control arm bushings are torn. This was discovered at 32000 miles. Premature failure of suspension parts can create a unsafe driving condition. Currently available for inspection. But will be replaced under warranty as soon as possible.
Additional Notes:
Front lower control arm bushings are torn. This was discovered at 32000 miles. Premature failure of suspension parts can create a unsafe driving condition. Currently available for inspection. But will be replaced under warranty as soon as possible.
Mfg Campaign: 11647993
Recall Date: Mar 12, 2025
Tesla, Inc.
Defect Description:
SUSPENSION
Potential Consequences:
Two weeks I had my model Y serviced for shaking of the car and steering wheel. They deemed the cause of the shaking due to unalignment of the wheels and they claimed to have fixed the issue. After receiving the car for the week after it began to make a sound of something hitting every time I made a U turn or any time I turned the wheel. While driving 3/8 with my family in the car I made a U turn in a parking lot and heard the same loud sound of hitting. When I went to check two large approximately 3 inch bolts were on the ground but no nuts in sight and my control arm broke the bottom plate and was completely unattached from the car. Thankfully the bolts came off while in a parking lot and not 20 minutes prior when I was driving on a windy road. Within 24hours Tesla contacted me saying my car was ready for pickup without any explanation of why the bolts came off, No full inspection completed for other issues and no alignment of the tires. Under the Tesla mechanic notes they only reinstalled the bolts and tightened the front wheels and not the back. Upon further research online I have found numerous other people complaining of the same issue of the bolts for the control arm falling off on Model Y and 3 Teslas due to forgetting to weld the bolt nuts to the sub frame.
Corrective Action:
Two weeks I had my model Y serviced for shaking of the car and steering wheel. They deemed the cause of the shaking due to unalignment of the wheels and they claimed to have fixed the issue. After receiving the car for the week after it began to make a sound of something hitting every time I made a U turn or any time I turned the wheel. While driving 3/8 with my family in the car I made a U turn in a parking lot and heard the same loud sound of hitting. When I went to check two large approximately 3 inch bolts were on the ground but no nuts in sight and my control arm broke the bottom plate and was completely unattached from the car. Thankfully the bolts came off while in a parking lot and not 20 minutes prior when I was driving on a windy road. Within 24hours Tesla contacted me saying my car was ready for pickup without any explanation of why the bolts came off, No full inspection completed for other issues and no alignment of the tires. Under the Tesla mechanic notes they only reinstalled the bolts and tightened the front wheels and not the back. Upon further research online I have found numerous other people complaining of the same issue of the bolts for the control arm falling off on Model Y and 3 Teslas due to forgetting to weld the bolt nuts to the sub frame.
Additional Notes:
Two weeks I had my model Y serviced for shaking of the car and steering wheel. They deemed the cause of the shaking due to unalignment of the wheels and they claimed to have fixed the issue. After receiving the car for the week after it began to make a sound of something hitting every time I made a U turn or any time I turned the wheel. While driving 3/8 with my family in the car I made a U turn in a parking lot and heard the same loud sound of hitting. When I went to check two large approximately 3 inch bolts were on the ground but no nuts in sight and my control arm broke the bottom plate and was completely unattached from the car. Thankfully the bolts came off while in a parking lot and not 20 minutes prior when I was driving on a windy road. Within 24hours Tesla contacted me saying my car was ready for pickup without any explanation of why the bolts came off, No full inspection completed for other issues and no alignment of the tires. Under the Tesla mechanic notes they only reinstalled the bolts and tightened the front wheels and not the back. Upon further research online I have found numerous other people complaining of the same issue of the bolts for the control arm falling off on Model Y and 3 Teslas due to forgetting to weld the bolt nuts to the sub frame.
Mfg Campaign: 11647275
Recall Date: Mar 9, 2025
Tesla, Inc.
Defect Description:
WHEELS
Potential Consequences:
Two weeks I had my model Y serviced for shaking of the car and steering wheel. They deemed the cause of the shaking due to unalignment of the wheels and they claimed to have fixed the issue. After receiving the car for the week after it began to make a sound of something hitting every time I made a U turn or any time I turned the wheel. While driving 3/8 with my family in the car I made a U turn in a parking lot and heard the same loud sound of hitting. When I went to check two large approximately 3 inch bolts were on the ground but no nuts in sight and my control arm broke the bottom plate and was completely unattached from the car. Thankfully the bolts came off while in a parking lot and not 20 minutes prior when I was driving on a windy road. Within 24hours Tesla contacted me saying my car was ready for pickup without any explanation of why the bolts came off, No full inspection completed for other issues and no alignment of the tires. Under the Tesla mechanic notes they only reinstalled the bolts and tightened the front wheels and not the back. Upon further research online I have found numerous other people complaining of the same issue of the bolts for the control arm falling off on Model Y and 3 Teslas due to forgetting to weld the bolt nuts to the sub frame.
Corrective Action:
Two weeks I had my model Y serviced for shaking of the car and steering wheel. They deemed the cause of the shaking due to unalignment of the wheels and they claimed to have fixed the issue. After receiving the car for the week after it began to make a sound of something hitting every time I made a U turn or any time I turned the wheel. While driving 3/8 with my family in the car I made a U turn in a parking lot and heard the same loud sound of hitting. When I went to check two large approximately 3 inch bolts were on the ground but no nuts in sight and my control arm broke the bottom plate and was completely unattached from the car. Thankfully the bolts came off while in a parking lot and not 20 minutes prior when I was driving on a windy road. Within 24hours Tesla contacted me saying my car was ready for pickup without any explanation of why the bolts came off, No full inspection completed for other issues and no alignment of the tires. Under the Tesla mechanic notes they only reinstalled the bolts and tightened the front wheels and not the back. Upon further research online I have found numerous other people complaining of the same issue of the bolts for the control arm falling off on Model Y and 3 Teslas due to forgetting to weld the bolt nuts to the sub frame.
Additional Notes:
Two weeks I had my model Y serviced for shaking of the car and steering wheel. They deemed the cause of the shaking due to unalignment of the wheels and they claimed to have fixed the issue. After receiving the car for the week after it began to make a sound of something hitting every time I made a U turn or any time I turned the wheel. While driving 3/8 with my family in the car I made a U turn in a parking lot and heard the same loud sound of hitting. When I went to check two large approximately 3 inch bolts were on the ground but no nuts in sight and my control arm broke the bottom plate and was completely unattached from the car. Thankfully the bolts came off while in a parking lot and not 20 minutes prior when I was driving on a windy road. Within 24hours Tesla contacted me saying my car was ready for pickup without any explanation of why the bolts came off, No full inspection completed for other issues and no alignment of the tires. Under the Tesla mechanic notes they only reinstalled the bolts and tightened the front wheels and not the back. Upon further research online I have found numerous other people complaining of the same issue of the bolts for the control arm falling off on Model Y and 3 Teslas due to forgetting to weld the bolt nuts to the sub frame.
Mfg Campaign: 11647275
Recall Date: Mar 9, 2025
Tesla, Inc.
Defect Description:
STEERING
Potential Consequences:
Two weeks I had my model Y serviced for shaking of the car and steering wheel. They deemed the cause of the shaking due to unalignment of the wheels and they claimed to have fixed the issue. After receiving the car for the week after it began to make a sound of something hitting every time I made a U turn or any time I turned the wheel. While driving 3/8 with my family in the car I made a U turn in a parking lot and heard the same loud sound of hitting. When I went to check two large approximately 3 inch bolts were on the ground but no nuts in sight and my control arm broke the bottom plate and was completely unattached from the car. Thankfully the bolts came off while in a parking lot and not 20 minutes prior when I was driving on a windy road. Within 24hours Tesla contacted me saying my car was ready for pickup without any explanation of why the bolts came off, No full inspection completed for other issues and no alignment of the tires. Under the Tesla mechanic notes they only reinstalled the bolts and tightened the front wheels and not the back. Upon further research online I have found numerous other people complaining of the same issue of the bolts for the control arm falling off on Model Y and 3 Teslas due to forgetting to weld the bolt nuts to the sub frame.
Corrective Action:
Two weeks I had my model Y serviced for shaking of the car and steering wheel. They deemed the cause of the shaking due to unalignment of the wheels and they claimed to have fixed the issue. After receiving the car for the week after it began to make a sound of something hitting every time I made a U turn or any time I turned the wheel. While driving 3/8 with my family in the car I made a U turn in a parking lot and heard the same loud sound of hitting. When I went to check two large approximately 3 inch bolts were on the ground but no nuts in sight and my control arm broke the bottom plate and was completely unattached from the car. Thankfully the bolts came off while in a parking lot and not 20 minutes prior when I was driving on a windy road. Within 24hours Tesla contacted me saying my car was ready for pickup without any explanation of why the bolts came off, No full inspection completed for other issues and no alignment of the tires. Under the Tesla mechanic notes they only reinstalled the bolts and tightened the front wheels and not the back. Upon further research online I have found numerous other people complaining of the same issue of the bolts for the control arm falling off on Model Y and 3 Teslas due to forgetting to weld the bolt nuts to the sub frame.
Additional Notes:
Two weeks I had my model Y serviced for shaking of the car and steering wheel. They deemed the cause of the shaking due to unalignment of the wheels and they claimed to have fixed the issue. After receiving the car for the week after it began to make a sound of something hitting every time I made a U turn or any time I turned the wheel. While driving 3/8 with my family in the car I made a U turn in a parking lot and heard the same loud sound of hitting. When I went to check two large approximately 3 inch bolts were on the ground but no nuts in sight and my control arm broke the bottom plate and was completely unattached from the car. Thankfully the bolts came off while in a parking lot and not 20 minutes prior when I was driving on a windy road. Within 24hours Tesla contacted me saying my car was ready for pickup without any explanation of why the bolts came off, No full inspection completed for other issues and no alignment of the tires. Under the Tesla mechanic notes they only reinstalled the bolts and tightened the front wheels and not the back. Upon further research online I have found numerous other people complaining of the same issue of the bolts for the control arm falling off on Model Y and 3 Teslas due to forgetting to weld the bolt nuts to the sub frame.
Mfg Campaign: 11647275
Recall Date: Mar 9, 2025
Tesla, Inc.
Defect Description:
STEERING
Potential Consequences:
3/5/2024. Upon startup, car does not have power steering. Error code UI_a020 on screen and steering wheel very difficult to move as car reverses. Put car back into park and arranged for alternate transportation. Manufacturer advises "monitoring and reporting back when/if alert re-occurs"
Corrective Action:
3/5/2024. Upon startup, car does not have power steering. Error code UI_a020 on screen and steering wheel very difficult to move as car reverses. Put car back into park and arranged for alternate transportation. Manufacturer advises "monitoring and reporting back when/if alert re-occurs"
Additional Notes:
3/5/2024. Upon startup, car does not have power steering. Error code UI_a020 on screen and steering wheel very difficult to move as car reverses. Put car back into park and arranged for alternate transportation. Manufacturer advises "monitoring and reporting back when/if alert re-occurs"
Mfg Campaign: 11646817
Recall Date: Mar 6, 2025
Tesla, Inc.
Defect Description:
SUSPENSION
Potential Consequences:
The two bolts securing the lower lateral link of the front passenger side loosened and dropped out in 14 months of the car ownership, causing the lateral link detached from the subframe of the car. The car makes loud noise when turning, poses danger of suspension failure and possibly loss of control on freeway driving. I have scheduled a service appointment with Tesla service center and see if they can fix it.
Corrective Action:
The two bolts securing the lower lateral link of the front passenger side loosened and dropped out in 14 months of the car ownership, causing the lateral link detached from the subframe of the car. The car makes loud noise when turning, poses danger of suspension failure and possibly loss of control on freeway driving. I have scheduled a service appointment with Tesla service center and see if they can fix it.
Additional Notes:
The two bolts securing the lower lateral link of the front passenger side loosened and dropped out in 14 months of the car ownership, causing the lateral link detached from the subframe of the car. The car makes loud noise when turning, poses danger of suspension failure and possibly loss of control on freeway driving. I have scheduled a service appointment with Tesla service center and see if they can fix it.
Mfg Campaign: 11646395
Recall Date: Mar 4, 2025
Tesla, Inc.
Defect Description:
SEAT BELTS
Potential Consequences:
The seatbelt does not latch in the buckle.
Corrective Action:
The seatbelt does not latch in the buckle.
Additional Notes:
The seatbelt does not latch in the buckle.
Mfg Campaign: 11644706
Recall Date: Feb 25, 2025
Tesla, Inc.
Defect Description:
UNKNOWN OR OTHER
Potential Consequences:
Tesla offers a "Smart Summon" as part of a PAID feature of Full Self Driving. I have used this feature many times without issue. In this incident, it failed to detect a support column next to a parking spot and while pulling out, it turned right and collided with the pole causing damage to the vehicle. Tesla refused to take responsibility for their feature failing.
Corrective Action:
Tesla offers a "Smart Summon" as part of a PAID feature of Full Self Driving. I have used this feature many times without issue. In this incident, it failed to detect a support column next to a parking spot and while pulling out, it turned right and collided with the pole causing damage to the vehicle. Tesla refused to take responsibility for their feature failing.
Additional Notes:
Tesla offers a "Smart Summon" as part of a PAID feature of Full Self Driving. I have used this feature many times without issue. In this incident, it failed to detect a support column next to a parking spot and while pulling out, it turned right and collided with the pole causing damage to the vehicle. Tesla refused to take responsibility for their feature failing.
Mfg Campaign: 11643906
Recall Date: Feb 20, 2025
Tesla, Inc.
Defect Description:
VEHICLE SPEED CONTROL
Potential Consequences:
This is my 4th safety report about the same issue: unexpected braking while on cruise control. Since my last report, Tesla offered another free month of auto pilot but I did not take it for fear of this braking issue. On Tuesday [XXX] I was returning to my home in Las Cruces NM from Colorado. I was on [XXX] toward Albuquerque, and there was very little traffic. I decided to see if I could get away with the cruise control. As I was pulling into Bernalillo, there were some oncoming cars in a left-turn lane at a signal, and my car braked automatically...enough to lurch me forward. I decided to stop at the "new" Tesla dealer in Bernalillo (I got my car in Santa Fe) and ask about the automatic breaking and whether they'd fixed it. The 2 service employees looked at each other and one said "No". I then asked about whether I needed to re-boot my key card since my screen went blank while I was in CO, during a snow storm, parked. I luckily had my phone and on the Tesla App, under Roadside Service, it gave me the option to re-boot the screen! I did so. The serviceman said he didn't think the blank screen had anything to do with my key card, but I could re-boot it if I want to. (A prior complaint also reported the failed key card in less than a year and Tesla's unwillingness to replace it). INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Corrective Action:
This is my 4th safety report about the same issue: unexpected braking while on cruise control. Since my last report, Tesla offered another free month of auto pilot but I did not take it for fear of this braking issue. On Tuesday [XXX] I was returning to my home in Las Cruces NM from Colorado. I was on [XXX] toward Albuquerque, and there was very little traffic. I decided to see if I could get away with the cruise control. As I was pulling into Bernalillo, there were some oncoming cars in a left-turn lane at a signal, and my car braked automatically...enough to lurch me forward. I decided to stop at the "new" Tesla dealer in Bernalillo (I got my car in Santa Fe) and ask about the automatic breaking and whether they'd fixed it. The 2 service employees looked at each other and one said "No". I then asked about whether I needed to re-boot my key card since my screen went blank while I was in CO, during a snow storm, parked. I luckily had my phone and on the Tesla App, under Roadside Service, it gave me the option to re-boot the screen! I did so. The serviceman said he didn't think the blank screen had anything to do with my key card, but I could re-boot it if I want to. (A prior complaint also reported the failed key card in less than a year and Tesla's unwillingness to replace it). INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Additional Notes:
This is my 4th safety report about the same issue: unexpected braking while on cruise control. Since my last report, Tesla offered another free month of auto pilot but I did not take it for fear of this braking issue. On Tuesday [XXX] I was returning to my home in Las Cruces NM from Colorado. I was on [XXX] toward Albuquerque, and there was very little traffic. I decided to see if I could get away with the cruise control. As I was pulling into Bernalillo, there were some oncoming cars in a left-turn lane at a signal, and my car braked automatically...enough to lurch me forward. I decided to stop at the "new" Tesla dealer in Bernalillo (I got my car in Santa Fe) and ask about the automatic breaking and whether they'd fixed it. The 2 service employees looked at each other and one said "No". I then asked about whether I needed to re-boot my key card since my screen went blank while I was in CO, during a snow storm, parked. I luckily had my phone and on the Tesla App, under Roadside Service, it gave me the option to re-boot the screen! I did so. The serviceman said he didn't think the blank screen had anything to do with my key card, but I could re-boot it if I want to. (A prior complaint also reported the failed key card in less than a year and Tesla's unwillingness to replace it). INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Mfg Campaign: 11643963
Recall Date: Feb 20, 2025
Tesla, Inc.
Defect Description:
SERVICE BRAKES
Potential Consequences:
This is my 4th safety report about the same issue: unexpected braking while on cruise control. Since my last report, Tesla offered another free month of auto pilot but I did not take it for fear of this braking issue. On Tuesday [XXX] I was returning to my home in Las Cruces NM from Colorado. I was on [XXX] toward Albuquerque, and there was very little traffic. I decided to see if I could get away with the cruise control. As I was pulling into Bernalillo, there were some oncoming cars in a left-turn lane at a signal, and my car braked automatically...enough to lurch me forward. I decided to stop at the "new" Tesla dealer in Bernalillo (I got my car in Santa Fe) and ask about the automatic breaking and whether they'd fixed it. The 2 service employees looked at each other and one said "No". I then asked about whether I needed to re-boot my key card since my screen went blank while I was in CO, during a snow storm, parked. I luckily had my phone and on the Tesla App, under Roadside Service, it gave me the option to re-boot the screen! I did so. The serviceman said he didn't think the blank screen had anything to do with my key card, but I could re-boot it if I want to. (A prior complaint also reported the failed key card in less than a year and Tesla's unwillingness to replace it). INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Corrective Action:
This is my 4th safety report about the same issue: unexpected braking while on cruise control. Since my last report, Tesla offered another free month of auto pilot but I did not take it for fear of this braking issue. On Tuesday [XXX] I was returning to my home in Las Cruces NM from Colorado. I was on [XXX] toward Albuquerque, and there was very little traffic. I decided to see if I could get away with the cruise control. As I was pulling into Bernalillo, there were some oncoming cars in a left-turn lane at a signal, and my car braked automatically...enough to lurch me forward. I decided to stop at the "new" Tesla dealer in Bernalillo (I got my car in Santa Fe) and ask about the automatic breaking and whether they'd fixed it. The 2 service employees looked at each other and one said "No". I then asked about whether I needed to re-boot my key card since my screen went blank while I was in CO, during a snow storm, parked. I luckily had my phone and on the Tesla App, under Roadside Service, it gave me the option to re-boot the screen! I did so. The serviceman said he didn't think the blank screen had anything to do with my key card, but I could re-boot it if I want to. (A prior complaint also reported the failed key card in less than a year and Tesla's unwillingness to replace it). INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Additional Notes:
This is my 4th safety report about the same issue: unexpected braking while on cruise control. Since my last report, Tesla offered another free month of auto pilot but I did not take it for fear of this braking issue. On Tuesday [XXX] I was returning to my home in Las Cruces NM from Colorado. I was on [XXX] toward Albuquerque, and there was very little traffic. I decided to see if I could get away with the cruise control. As I was pulling into Bernalillo, there were some oncoming cars in a left-turn lane at a signal, and my car braked automatically...enough to lurch me forward. I decided to stop at the "new" Tesla dealer in Bernalillo (I got my car in Santa Fe) and ask about the automatic breaking and whether they'd fixed it. The 2 service employees looked at each other and one said "No". I then asked about whether I needed to re-boot my key card since my screen went blank while I was in CO, during a snow storm, parked. I luckily had my phone and on the Tesla App, under Roadside Service, it gave me the option to re-boot the screen! I did so. The serviceman said he didn't think the blank screen had anything to do with my key card, but I could re-boot it if I want to. (A prior complaint also reported the failed key card in less than a year and Tesla's unwillingness to replace it). INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Mfg Campaign: 11643963
Recall Date: Feb 20, 2025
Tesla, Inc.
Defect Description:
FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL
Potential Consequences:
This is my 4th safety report about the same issue: unexpected braking while on cruise control. Since my last report, Tesla offered another free month of auto pilot but I did not take it for fear of this braking issue. On Tuesday [XXX] I was returning to my home in Las Cruces NM from Colorado. I was on [XXX] toward Albuquerque, and there was very little traffic. I decided to see if I could get away with the cruise control. As I was pulling into Bernalillo, there were some oncoming cars in a left-turn lane at a signal, and my car braked automatically...enough to lurch me forward. I decided to stop at the "new" Tesla dealer in Bernalillo (I got my car in Santa Fe) and ask about the automatic breaking and whether they'd fixed it. The 2 service employees looked at each other and one said "No". I then asked about whether I needed to re-boot my key card since my screen went blank while I was in CO, during a snow storm, parked. I luckily had my phone and on the Tesla App, under Roadside Service, it gave me the option to re-boot the screen! I did so. The serviceman said he didn't think the blank screen had anything to do with my key card, but I could re-boot it if I want to. (A prior complaint also reported the failed key card in less than a year and Tesla's unwillingness to replace it). INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Corrective Action:
This is my 4th safety report about the same issue: unexpected braking while on cruise control. Since my last report, Tesla offered another free month of auto pilot but I did not take it for fear of this braking issue. On Tuesday [XXX] I was returning to my home in Las Cruces NM from Colorado. I was on [XXX] toward Albuquerque, and there was very little traffic. I decided to see if I could get away with the cruise control. As I was pulling into Bernalillo, there were some oncoming cars in a left-turn lane at a signal, and my car braked automatically...enough to lurch me forward. I decided to stop at the "new" Tesla dealer in Bernalillo (I got my car in Santa Fe) and ask about the automatic breaking and whether they'd fixed it. The 2 service employees looked at each other and one said "No". I then asked about whether I needed to re-boot my key card since my screen went blank while I was in CO, during a snow storm, parked. I luckily had my phone and on the Tesla App, under Roadside Service, it gave me the option to re-boot the screen! I did so. The serviceman said he didn't think the blank screen had anything to do with my key card, but I could re-boot it if I want to. (A prior complaint also reported the failed key card in less than a year and Tesla's unwillingness to replace it). INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Additional Notes:
This is my 4th safety report about the same issue: unexpected braking while on cruise control. Since my last report, Tesla offered another free month of auto pilot but I did not take it for fear of this braking issue. On Tuesday [XXX] I was returning to my home in Las Cruces NM from Colorado. I was on [XXX] toward Albuquerque, and there was very little traffic. I decided to see if I could get away with the cruise control. As I was pulling into Bernalillo, there were some oncoming cars in a left-turn lane at a signal, and my car braked automatically...enough to lurch me forward. I decided to stop at the "new" Tesla dealer in Bernalillo (I got my car in Santa Fe) and ask about the automatic breaking and whether they'd fixed it. The 2 service employees looked at each other and one said "No". I then asked about whether I needed to re-boot my key card since my screen went blank while I was in CO, during a snow storm, parked. I luckily had my phone and on the Tesla App, under Roadside Service, it gave me the option to re-boot the screen! I did so. The serviceman said he didn't think the blank screen had anything to do with my key card, but I could re-boot it if I want to. (A prior complaint also reported the failed key card in less than a year and Tesla's unwillingness to replace it). INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Mfg Campaign: 11643963
Recall Date: Feb 20, 2025
Tesla, Inc.
Defect Description:
SERVICE BRAKES
Potential Consequences:
I am submitting a complaint regarding a serious safety issue with my 2023 Tesla Model Y. The vehicle experienced a sudden and complete power loss while in operation, creating a hazardous situation. Below are the details of the incident: •Component/System Failure: The vehicle’s electrical system failed, leading to a shutdown. The following alerts were displayed on the screen: •VCFRONT_a191: Electrical system power reduced – Vehicle shutting down •VCFRONT_a192: Electrical system unable to support all features – Switching off features to conserve energy •BMS_a151: Vehicle may not restart – Service is required •DI_a227: Please wait while high voltage system powers up •Safety Risk: The unexpected shutdown posed a serious safety risk. If this had occurred in high-speed traffic, it could have led to a crash, endangering my safety and that of others on the road. •Reproduction of Issue: The issue has not been reproduced yet, but it is an ongoing concern. I have not received a resolution from Tesla at this time. •Inspection by Authorities: The vehicle has not yet been inspected by Tesla, law enforcement, or insurance representatives. However, I am willing to make it available for investigation. •Warning Signs: There were no prior warning signs before the failure. The alerts appeared shortly before the vehicle lost power completely. This issue raises concerns about the reliability and safety of Tesla’s electrical system. I urge the NHTSA to investigate this matter to prevent potential accidents caused by similar failures in other vehicles.
Corrective Action:
I am submitting a complaint regarding a serious safety issue with my 2023 Tesla Model Y. The vehicle experienced a sudden and complete power loss while in operation, creating a hazardous situation. Below are the details of the incident: •Component/System Failure: The vehicle’s electrical system failed, leading to a shutdown. The following alerts were displayed on the screen: •VCFRONT_a191: Electrical system power reduced – Vehicle shutting down •VCFRONT_a192: Electrical system unable to support all features – Switching off features to conserve energy •BMS_a151: Vehicle may not restart – Service is required •DI_a227: Please wait while high voltage system powers up •Safety Risk: The unexpected shutdown posed a serious safety risk. If this had occurred in high-speed traffic, it could have led to a crash, endangering my safety and that of others on the road. •Reproduction of Issue: The issue has not been reproduced yet, but it is an ongoing concern. I have not received a resolution from Tesla at this time. •Inspection by Authorities: The vehicle has not yet been inspected by Tesla, law enforcement, or insurance representatives. However, I am willing to make it available for investigation. •Warning Signs: There were no prior warning signs before the failure. The alerts appeared shortly before the vehicle lost power completely. This issue raises concerns about the reliability and safety of Tesla’s electrical system. I urge the NHTSA to investigate this matter to prevent potential accidents caused by similar failures in other vehicles.
Additional Notes:
I am submitting a complaint regarding a serious safety issue with my 2023 Tesla Model Y. The vehicle experienced a sudden and complete power loss while in operation, creating a hazardous situation. Below are the details of the incident: •Component/System Failure: The vehicle’s electrical system failed, leading to a shutdown. The following alerts were displayed on the screen: •VCFRONT_a191: Electrical system power reduced – Vehicle shutting down •VCFRONT_a192: Electrical system unable to support all features – Switching off features to conserve energy •BMS_a151: Vehicle may not restart – Service is required •DI_a227: Please wait while high voltage system powers up •Safety Risk: The unexpected shutdown posed a serious safety risk. If this had occurred in high-speed traffic, it could have led to a crash, endangering my safety and that of others on the road. •Reproduction of Issue: The issue has not been reproduced yet, but it is an ongoing concern. I have not received a resolution from Tesla at this time. •Inspection by Authorities: The vehicle has not yet been inspected by Tesla, law enforcement, or insurance representatives. However, I am willing to make it available for investigation. •Warning Signs: There were no prior warning signs before the failure. The alerts appeared shortly before the vehicle lost power completely. This issue raises concerns about the reliability and safety of Tesla’s electrical system. I urge the NHTSA to investigate this matter to prevent potential accidents caused by similar failures in other vehicles.
Mfg Campaign: 11644018
Recall Date: Feb 20, 2025
Tesla, Inc.
Defect Description:
ELECTRICAL SYSTEM
Potential Consequences:
I am submitting a complaint regarding a serious safety issue with my 2023 Tesla Model Y. The vehicle experienced a sudden and complete power loss while in operation, creating a hazardous situation. Below are the details of the incident: •Component/System Failure: The vehicle’s electrical system failed, leading to a shutdown. The following alerts were displayed on the screen: •VCFRONT_a191: Electrical system power reduced – Vehicle shutting down •VCFRONT_a192: Electrical system unable to support all features – Switching off features to conserve energy •BMS_a151: Vehicle may not restart – Service is required •DI_a227: Please wait while high voltage system powers up •Safety Risk: The unexpected shutdown posed a serious safety risk. If this had occurred in high-speed traffic, it could have led to a crash, endangering my safety and that of others on the road. •Reproduction of Issue: The issue has not been reproduced yet, but it is an ongoing concern. I have not received a resolution from Tesla at this time. •Inspection by Authorities: The vehicle has not yet been inspected by Tesla, law enforcement, or insurance representatives. However, I am willing to make it available for investigation. •Warning Signs: There were no prior warning signs before the failure. The alerts appeared shortly before the vehicle lost power completely. This issue raises concerns about the reliability and safety of Tesla’s electrical system. I urge the NHTSA to investigate this matter to prevent potential accidents caused by similar failures in other vehicles.
Corrective Action:
I am submitting a complaint regarding a serious safety issue with my 2023 Tesla Model Y. The vehicle experienced a sudden and complete power loss while in operation, creating a hazardous situation. Below are the details of the incident: •Component/System Failure: The vehicle’s electrical system failed, leading to a shutdown. The following alerts were displayed on the screen: •VCFRONT_a191: Electrical system power reduced – Vehicle shutting down •VCFRONT_a192: Electrical system unable to support all features – Switching off features to conserve energy •BMS_a151: Vehicle may not restart – Service is required •DI_a227: Please wait while high voltage system powers up •Safety Risk: The unexpected shutdown posed a serious safety risk. If this had occurred in high-speed traffic, it could have led to a crash, endangering my safety and that of others on the road. •Reproduction of Issue: The issue has not been reproduced yet, but it is an ongoing concern. I have not received a resolution from Tesla at this time. •Inspection by Authorities: The vehicle has not yet been inspected by Tesla, law enforcement, or insurance representatives. However, I am willing to make it available for investigation. •Warning Signs: There were no prior warning signs before the failure. The alerts appeared shortly before the vehicle lost power completely. This issue raises concerns about the reliability and safety of Tesla’s electrical system. I urge the NHTSA to investigate this matter to prevent potential accidents caused by similar failures in other vehicles.
Additional Notes:
I am submitting a complaint regarding a serious safety issue with my 2023 Tesla Model Y. The vehicle experienced a sudden and complete power loss while in operation, creating a hazardous situation. Below are the details of the incident: •Component/System Failure: The vehicle’s electrical system failed, leading to a shutdown. The following alerts were displayed on the screen: •VCFRONT_a191: Electrical system power reduced – Vehicle shutting down •VCFRONT_a192: Electrical system unable to support all features – Switching off features to conserve energy •BMS_a151: Vehicle may not restart – Service is required •DI_a227: Please wait while high voltage system powers up •Safety Risk: The unexpected shutdown posed a serious safety risk. If this had occurred in high-speed traffic, it could have led to a crash, endangering my safety and that of others on the road. •Reproduction of Issue: The issue has not been reproduced yet, but it is an ongoing concern. I have not received a resolution from Tesla at this time. •Inspection by Authorities: The vehicle has not yet been inspected by Tesla, law enforcement, or insurance representatives. However, I am willing to make it available for investigation. •Warning Signs: There were no prior warning signs before the failure. The alerts appeared shortly before the vehicle lost power completely. This issue raises concerns about the reliability and safety of Tesla’s electrical system. I urge the NHTSA to investigate this matter to prevent potential accidents caused by similar failures in other vehicles.
Mfg Campaign: 11644018
Recall Date: Feb 20, 2025
Tesla, Inc.
Defect Description:
FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING
Potential Consequences:
I am submitting a complaint regarding a serious safety issue with my 2023 Tesla Model Y. The vehicle experienced a sudden and complete power loss while in operation, creating a hazardous situation. Below are the details of the incident: •Component/System Failure: The vehicle’s electrical system failed, leading to a shutdown. The following alerts were displayed on the screen: •VCFRONT_a191: Electrical system power reduced – Vehicle shutting down •VCFRONT_a192: Electrical system unable to support all features – Switching off features to conserve energy •BMS_a151: Vehicle may not restart – Service is required •DI_a227: Please wait while high voltage system powers up •Safety Risk: The unexpected shutdown posed a serious safety risk. If this had occurred in high-speed traffic, it could have led to a crash, endangering my safety and that of others on the road. •Reproduction of Issue: The issue has not been reproduced yet, but it is an ongoing concern. I have not received a resolution from Tesla at this time. •Inspection by Authorities: The vehicle has not yet been inspected by Tesla, law enforcement, or insurance representatives. However, I am willing to make it available for investigation. •Warning Signs: There were no prior warning signs before the failure. The alerts appeared shortly before the vehicle lost power completely. This issue raises concerns about the reliability and safety of Tesla’s electrical system. I urge the NHTSA to investigate this matter to prevent potential accidents caused by similar failures in other vehicles.
Corrective Action:
I am submitting a complaint regarding a serious safety issue with my 2023 Tesla Model Y. The vehicle experienced a sudden and complete power loss while in operation, creating a hazardous situation. Below are the details of the incident: •Component/System Failure: The vehicle’s electrical system failed, leading to a shutdown. The following alerts were displayed on the screen: •VCFRONT_a191: Electrical system power reduced – Vehicle shutting down •VCFRONT_a192: Electrical system unable to support all features – Switching off features to conserve energy •BMS_a151: Vehicle may not restart – Service is required •DI_a227: Please wait while high voltage system powers up •Safety Risk: The unexpected shutdown posed a serious safety risk. If this had occurred in high-speed traffic, it could have led to a crash, endangering my safety and that of others on the road. •Reproduction of Issue: The issue has not been reproduced yet, but it is an ongoing concern. I have not received a resolution from Tesla at this time. •Inspection by Authorities: The vehicle has not yet been inspected by Tesla, law enforcement, or insurance representatives. However, I am willing to make it available for investigation. •Warning Signs: There were no prior warning signs before the failure. The alerts appeared shortly before the vehicle lost power completely. This issue raises concerns about the reliability and safety of Tesla’s electrical system. I urge the NHTSA to investigate this matter to prevent potential accidents caused by similar failures in other vehicles.
Additional Notes:
I am submitting a complaint regarding a serious safety issue with my 2023 Tesla Model Y. The vehicle experienced a sudden and complete power loss while in operation, creating a hazardous situation. Below are the details of the incident: •Component/System Failure: The vehicle’s electrical system failed, leading to a shutdown. The following alerts were displayed on the screen: •VCFRONT_a191: Electrical system power reduced – Vehicle shutting down •VCFRONT_a192: Electrical system unable to support all features – Switching off features to conserve energy •BMS_a151: Vehicle may not restart – Service is required •DI_a227: Please wait while high voltage system powers up •Safety Risk: The unexpected shutdown posed a serious safety risk. If this had occurred in high-speed traffic, it could have led to a crash, endangering my safety and that of others on the road. •Reproduction of Issue: The issue has not been reproduced yet, but it is an ongoing concern. I have not received a resolution from Tesla at this time. •Inspection by Authorities: The vehicle has not yet been inspected by Tesla, law enforcement, or insurance representatives. However, I am willing to make it available for investigation. •Warning Signs: There were no prior warning signs before the failure. The alerts appeared shortly before the vehicle lost power completely. This issue raises concerns about the reliability and safety of Tesla’s electrical system. I urge the NHTSA to investigate this matter to prevent potential accidents caused by similar failures in other vehicles.
Mfg Campaign: 11644018
Recall Date: Feb 20, 2025
Tesla, Inc.
Defect Description:
SERVICE BRAKES
Potential Consequences:
While in an automatic car wash with the vehicle in "car wash mode" the vehicle suddenly stopped free rolling and the vehicle behind the Tesla Model Y crashed into the Tesla. The Brown Bear car wash reported that these types of incidents are common at Brown Bear car washes and that they ocurr when the drivers of Tesla cars remove their seat belts while the car is in the car wash.
Corrective Action:
While in an automatic car wash with the vehicle in "car wash mode" the vehicle suddenly stopped free rolling and the vehicle behind the Tesla Model Y crashed into the Tesla. The Brown Bear car wash reported that these types of incidents are common at Brown Bear car washes and that they ocurr when the drivers of Tesla cars remove their seat belts while the car is in the car wash.
Additional Notes:
While in an automatic car wash with the vehicle in "car wash mode" the vehicle suddenly stopped free rolling and the vehicle behind the Tesla Model Y crashed into the Tesla. The Brown Bear car wash reported that these types of incidents are common at Brown Bear car washes and that they ocurr when the drivers of Tesla cars remove their seat belts while the car is in the car wash.
Mfg Campaign: 11643017
Recall Date: Feb 16, 2025
Tesla, Inc.
Defect Description:
FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING
Potential Consequences:
While in an automatic car wash with the vehicle in "car wash mode" the vehicle suddenly stopped free rolling and the vehicle behind the Tesla Model Y crashed into the Tesla. The Brown Bear car wash reported that these types of incidents are common at Brown Bear car washes and that they ocurr when the drivers of Tesla cars remove their seat belts while the car is in the car wash.
Corrective Action:
While in an automatic car wash with the vehicle in "car wash mode" the vehicle suddenly stopped free rolling and the vehicle behind the Tesla Model Y crashed into the Tesla. The Brown Bear car wash reported that these types of incidents are common at Brown Bear car washes and that they ocurr when the drivers of Tesla cars remove their seat belts while the car is in the car wash.
Additional Notes:
While in an automatic car wash with the vehicle in "car wash mode" the vehicle suddenly stopped free rolling and the vehicle behind the Tesla Model Y crashed into the Tesla. The Brown Bear car wash reported that these types of incidents are common at Brown Bear car washes and that they ocurr when the drivers of Tesla cars remove their seat belts while the car is in the car wash.
Mfg Campaign: 11643017
Recall Date: Feb 16, 2025
Tesla, Inc.
Defect Description:
STEERING
Potential Consequences:
While driving heard a noise from front end. As I turned right the steering wheel turned left in opposite direction. I heard something fall and found a bolt that fell off the car control arm. I managed to get the car back to my garage and called Tesla service. They say it needs an alignment and are going to charge me for this repair. A bolt should not be falling off the vehicle.
Corrective Action:
While driving heard a noise from front end. As I turned right the steering wheel turned left in opposite direction. I heard something fall and found a bolt that fell off the car control arm. I managed to get the car back to my garage and called Tesla service. They say it needs an alignment and are going to charge me for this repair. A bolt should not be falling off the vehicle.
Additional Notes:
While driving heard a noise from front end. As I turned right the steering wheel turned left in opposite direction. I heard something fall and found a bolt that fell off the car control arm. I managed to get the car back to my garage and called Tesla service. They say it needs an alignment and are going to charge me for this repair. A bolt should not be falling off the vehicle.
Mfg Campaign: 11641831
Recall Date: Feb 10, 2025
Tesla, Inc.
Defect Description:
STEERING
Potential Consequences:
Subject: Urgent Safety Concern – Steering Component Failure in 2023 Tesla Model Y Dear Tesla Customer Support / NHTSA Safety Division, I am writing to formally report a serious safety issue involving a critical steering component failure in my 2023 Tesla Model Y (VIN: [XXX] 38,917 miles). The failure led to a loss of control and resulted in a collision. On [XXX], my wife, [XXX] , was driving the vehicle on our residential street, shortly after leaving our driveway. At a low speed of approximately 8-10 mph, she suddenly lost steering control as the car rapidly veered to the right. Despite attempts to steer, the vehicle was unresponsive, leading to a collision with a parked car. Damage Summary: •Our Tesla Model Y: Damage to front bumper, headlights, right wheel cover and right fender. •Parked Vehicle: Deep scratches and dents on the rear driver-side bumper and passenger door. Upon inspecting the vehicle after the incident, it became apparent that a suspension or steering component (likely the lower control arm) had failed (broken). After researching online, I discovered that multiple Tesla Model Y owners have reported similar sudden failures of the same part, indicating a potential manufacturing defect. Request for Immediate Action: 1.Tesla Inspection & Full Repair at No Cost – Since my vehicle is under warranty and this appears to be a manufacturing defect, I request a full investigation and repair at Tesla’s expense. 2.NHTSA Investigation into a Potential Recall – Given that similar failures have been reported by other Tesla owners, I urge NHTSA to review this issue for a potential recall before more accidents occur. 3.Tesla’s Official Response – I would like Tesla to confirm whether this component has been investigated for defects in other vehicles and what steps are being taken to prevent other accidents. This incident could have been far worse had my wife been driving at higher speeds. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA)
Corrective Action:
Subject: Urgent Safety Concern – Steering Component Failure in 2023 Tesla Model Y Dear Tesla Customer Support / NHTSA Safety Division, I am writing to formally report a serious safety issue involving a critical steering component failure in my 2023 Tesla Model Y (VIN: [XXX] 38,917 miles). The failure led to a loss of control and resulted in a collision. On [XXX], my wife, [XXX] , was driving the vehicle on our residential street, shortly after leaving our driveway. At a low speed of approximately 8-10 mph, she suddenly lost steering control as the car rapidly veered to the right. Despite attempts to steer, the vehicle was unresponsive, leading to a collision with a parked car. Damage Summary: •Our Tesla Model Y: Damage to front bumper, headlights, right wheel cover and right fender. •Parked Vehicle: Deep scratches and dents on the rear driver-side bumper and passenger door. Upon inspecting the vehicle after the incident, it became apparent that a suspension or steering component (likely the lower control arm) had failed (broken). After researching online, I discovered that multiple Tesla Model Y owners have reported similar sudden failures of the same part, indicating a potential manufacturing defect. Request for Immediate Action: 1.Tesla Inspection & Full Repair at No Cost – Since my vehicle is under warranty and this appears to be a manufacturing defect, I request a full investigation and repair at Tesla’s expense. 2.NHTSA Investigation into a Potential Recall – Given that similar failures have been reported by other Tesla owners, I urge NHTSA to review this issue for a potential recall before more accidents occur. 3.Tesla’s Official Response – I would like Tesla to confirm whether this component has been investigated for defects in other vehicles and what steps are being taken to prevent other accidents. This incident could have been far worse had my wife been driving at higher speeds. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA)
Additional Notes:
Subject: Urgent Safety Concern – Steering Component Failure in 2023 Tesla Model Y Dear Tesla Customer Support / NHTSA Safety Division, I am writing to formally report a serious safety issue involving a critical steering component failure in my 2023 Tesla Model Y (VIN: [XXX] 38,917 miles). The failure led to a loss of control and resulted in a collision. On [XXX], my wife, [XXX] , was driving the vehicle on our residential street, shortly after leaving our driveway. At a low speed of approximately 8-10 mph, she suddenly lost steering control as the car rapidly veered to the right. Despite attempts to steer, the vehicle was unresponsive, leading to a collision with a parked car. Damage Summary: •Our Tesla Model Y: Damage to front bumper, headlights, right wheel cover and right fender. •Parked Vehicle: Deep scratches and dents on the rear driver-side bumper and passenger door. Upon inspecting the vehicle after the incident, it became apparent that a suspension or steering component (likely the lower control arm) had failed (broken). After researching online, I discovered that multiple Tesla Model Y owners have reported similar sudden failures of the same part, indicating a potential manufacturing defect. Request for Immediate Action: 1.Tesla Inspection & Full Repair at No Cost – Since my vehicle is under warranty and this appears to be a manufacturing defect, I request a full investigation and repair at Tesla’s expense. 2.NHTSA Investigation into a Potential Recall – Given that similar failures have been reported by other Tesla owners, I urge NHTSA to review this issue for a potential recall before more accidents occur. 3.Tesla’s Official Response – I would like Tesla to confirm whether this component has been investigated for defects in other vehicles and what steps are being taken to prevent other accidents. This incident could have been far worse had my wife been driving at higher speeds. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA)
Mfg Campaign: 11640775
Recall Date: Feb 5, 2025
Tesla, Inc.
Defect Description:
UNKNOWN OR OTHER
Potential Consequences:
My car is equipped with autopilot feature which I am unable to use due to safety score system designed by Tesla which is used for calculating insurance premiums. This safety score system doesn’t count the miles driven on autopilot and only counts the miles driven without autopilot to decide safety score which impacts insurance premium. This policy forces consumers to drive car without autopilot to increase number of miles driven to compensate for any mistakes made during driving without autopilot. This not only compromises safety of the vehicle and passengers but also deprives me to use features of my car that I paid for. Since autopilot is a supervised driving and requires driver active engagement the miles driven using autopilot should also be counted to decide safety score. Dealership are unable to help with any issues related to safety score system and there is no customer support available to address customer concerns.
Corrective Action:
My car is equipped with autopilot feature which I am unable to use due to safety score system designed by Tesla which is used for calculating insurance premiums. This safety score system doesn’t count the miles driven on autopilot and only counts the miles driven without autopilot to decide safety score which impacts insurance premium. This policy forces consumers to drive car without autopilot to increase number of miles driven to compensate for any mistakes made during driving without autopilot. This not only compromises safety of the vehicle and passengers but also deprives me to use features of my car that I paid for. Since autopilot is a supervised driving and requires driver active engagement the miles driven using autopilot should also be counted to decide safety score. Dealership are unable to help with any issues related to safety score system and there is no customer support available to address customer concerns.
Additional Notes:
My car is equipped with autopilot feature which I am unable to use due to safety score system designed by Tesla which is used for calculating insurance premiums. This safety score system doesn’t count the miles driven on autopilot and only counts the miles driven without autopilot to decide safety score which impacts insurance premium. This policy forces consumers to drive car without autopilot to increase number of miles driven to compensate for any mistakes made during driving without autopilot. This not only compromises safety of the vehicle and passengers but also deprives me to use features of my car that I paid for. Since autopilot is a supervised driving and requires driver active engagement the miles driven using autopilot should also be counted to decide safety score. Dealership are unable to help with any issues related to safety score system and there is no customer support available to address customer concerns.
Mfg Campaign: 11640674
Recall Date: Feb 4, 2025
Tesla, Inc.
Defect Description:
FORWARD COLLISION AVOIDANCE: WARNINGS
Potential Consequences:
My car is equipped with autopilot feature which I am unable to use due to safety score system designed by Tesla which is used for calculating insurance premiums. This safety score system doesn’t count the miles driven on autopilot and only counts the miles driven without autopilot to decide safety score which impacts insurance premium. This policy forces consumers to drive car without autopilot to increase number of miles driven to compensate for any mistakes made during driving without autopilot. This not only compromises safety of the vehicle and passengers but also deprives me to use features of my car that I paid for. Since autopilot is a supervised driving and requires driver active engagement the miles driven using autopilot should also be counted to decide safety score. Dealership are unable to help with any issues related to safety score system and there is no customer support available to address customer concerns.
Corrective Action:
My car is equipped with autopilot feature which I am unable to use due to safety score system designed by Tesla which is used for calculating insurance premiums. This safety score system doesn’t count the miles driven on autopilot and only counts the miles driven without autopilot to decide safety score which impacts insurance premium. This policy forces consumers to drive car without autopilot to increase number of miles driven to compensate for any mistakes made during driving without autopilot. This not only compromises safety of the vehicle and passengers but also deprives me to use features of my car that I paid for. Since autopilot is a supervised driving and requires driver active engagement the miles driven using autopilot should also be counted to decide safety score. Dealership are unable to help with any issues related to safety score system and there is no customer support available to address customer concerns.
Additional Notes:
My car is equipped with autopilot feature which I am unable to use due to safety score system designed by Tesla which is used for calculating insurance premiums. This safety score system doesn’t count the miles driven on autopilot and only counts the miles driven without autopilot to decide safety score which impacts insurance premium. This policy forces consumers to drive car without autopilot to increase number of miles driven to compensate for any mistakes made during driving without autopilot. This not only compromises safety of the vehicle and passengers but also deprives me to use features of my car that I paid for. Since autopilot is a supervised driving and requires driver active engagement the miles driven using autopilot should also be counted to decide safety score. Dealership are unable to help with any issues related to safety score system and there is no customer support available to address customer concerns.
Mfg Campaign: 11640674
Recall Date: Feb 4, 2025
Need Legal Help?
Featured Attorneys
Barry Edzant
Edzant Price LLC
Valencia, CA • 36 yrs
Focus: Lemon Law, Personal Injury
Recent Articles
Jeep Grand Cherokee Head Restraint Problem
Chrysler (FCA US, LLC) has announced a safety issue affecting certain 2023–2024 Jeep Grand Ch ...
Aug 1, 2025Fuel Injector Problem: 2021-2024 Ford Bronco Sport and 2020-2022 Ford Escape
If you own a 2021-2024 Ford Bronco Sport or 2020-2022 Ford Escape equipped with a 1.5L Dragon GTDI e ...
Jul 28, 2025Airbag Problem Affects 2022-2025 Chrysler Pacifica and Voyager Vehicles
If you own a Chrysler Pacifica or Voyager, your vehicle may be equipped with defective side curtain ...
Jul 24, 2025