Complaints & Recalls
Official Safety Recalls - Important!
85 RecallsThese are official manufacturer recalls ordered by NHTSA for safety defects. If you own this vehicle, contact your dealer immediately for free repairs.
Ford Motor Company
Safety Issue:
Ford Motor Company (Ford) is recalling certain 2021-2023 Bronco, Explorer, Lincoln Aviator, F-250 SD, F-350 SD, F-450 SD, F-550 SD, 2021-2022 Lincoln Navigator, Mustang, F-150, and 2022 Expedition vehicles. The low-pressure fuel pump may fail, which can result in an engine stall while driving.
Potential Risk:
FREE Recall Solution:
Mfg Campaign: 25S75
Ford Motor Company
Safety Issue:
Ford Motor Company (Ford) is recalling certain 2018-2022 Transit Connect, 2019-2020 MKZ, Edge, Continental, F-150, Nautilus, Fusion, 2019-2023 Ranger, Mustang, 2020-2021 EcoSport, Expedition, Navigator, 2020-2022 Escape, F-250 SD, Corsair, 2020-2023 Aviator, Transit, 2020-2024 Explorer, 2021-2024 Bronco Sport, and 2022-2024 Maverick vehicles. A software error may cause the rearview camera to display a blank image, or the image may remain on the display after the backing event has ended.
Potential Risk:
FREE Recall Solution:
Mfg Campaign: 25S72
Ford Motor Company
Safety Issue:
Ford Motor Company (Ford) is recalling certain 2020-2025 Aviator, and Explorer vehicles. The switch for the easy-entry second-row outer seats may bind or stick, resulting in the seats unlatching, folding, or sliding unexpectedly while driving.
Potential Risk:
FREE Recall Solution:
Mfg Campaign: 25S67
Ford Motor Company
Safety Issue:
Ford Motor Company (Ford) is recalling certain 2020-2025 Aviator vehicles. The rear door window bars and C-pillar trim may have insufficient adhesive bonding, which can allow the trim to detach from the vehicle.
Potential Risk:
FREE Recall Solution:
Mfg Campaign: 25S66
Ford Motor Company
Safety Issue:
Ford Motor Company (Ford) is recalling certain 2020-2023 Lincoln Aviator and Lincoln Corsair vehicles equipped with a Revel Audio System that were repaired incorrectly under recall 22V-953. When the driver's seat belt is not buckled and the vehicle is started, the seat belt warning system may activate the audible warning chime for an insufficient amount of time of less than 4 seconds. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Potential Risk:
FREE Recall Solution:
Mfg Campaign: 25C18
Recall Date: May 23, 2025
Ford Motor Company
Safety Issue:
Ford Motor Company (Ford) is recalling certain 2020-2021 Lincoln Aviator vehicles equipped with 3.0L PHEV engines that were repaired incorrectly under recall 23V626. A manufacturing defect in one or more of the high voltage battery cells may result in an internal short circuit and battery failure.
Potential Risk:
FREE Recall Solution:
Mfg Campaign: 25S58
Recall Date: May 23, 2025
Ford Motor Company
Safety Issue:
Ford Motor Company (Ford) is recalling certain 2020-2023 Explorer, Lincoln Aviator, and 2020-2022 Lincoln Corsair vehicles previously repaired incorrectly under recall number 23V-342. The video output may fail, preventing the rearview camera image from displaying.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 888-327-4236 (TTY 888-275-9171) or go to nhtsa.gov.
Mfg Campaign: 25S27
Recall Date: Mar 14, 2025
Ford Motor Company
Safety Issue:
Ford Motor Company (Ford) is recalling certain 2020-2021 Explorer and Aviator vehicles. The seat belt buckle anchor bolts at one or more seating positions may be improperly secured. Additionally, vehicles may have an improperly secured seat belt retractor anchor bolt and/or seat belt anchor bolt at the second-row center seating position, if equipped.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 888-327-4236 (TTY 888-275-9171) or go to nhtsa.gov.
Mfg Campaign: 25S09
Recall Date: Feb 14, 2025
Ford Motor Company
Safety Issue:
Ford Motor Company (Ford) is recalling certain 2020-2025 Explorer, Lincoln Aviator, 2020-2024 Escape, Lincoln Corsair, 2018-2024 F-150, Expedition and Lincoln Navigator vehicles. The air bag warning label may be missing from the dashboard. As such, these vehicles fail to comply with the requirement Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153) or go to nhtsa.gov.
Mfg Campaign: 24C39
Recall Date: Nov 8, 2024
Ford Motor Company
Safety Issue:
Ford Motor Company (Ford) is recalling certain 2021-2022 Bronco, F-150, Edge, Explorer, Lincoln Nautilus, and Lincoln Aviator vehicles equipped with either a 2.7L or 3.0L Nano EcoBoost engine. The engine intake valves may break while driving, which can result in engine failure and a loss of drive power.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Mfg Campaign: 24S55
Recall Date: Aug 23, 2024
Ford Motor Company
Safety Issue:
Ford Motor Company (Ford) is recalling certain 2020-2024 Lincoln Aviator vehicles. The accessory protocol image module (APIM) can be affected by electromagnetic interference with a cell phone in the vehicle, causing the rearview camera image to flicker or become distorted.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Mfg Campaign: 24S35
Recall Date: May 24, 2024
Ford Motor Company
Safety Issue:
Ford Motor Company (Ford) is recalling certain 2020-2022 Lincoln Aviator and Ford Explorer vehicles equipped with 3.0L PHEV engines. A manufacturing defect in one or more of the high voltage battery cells may result in an internal short circuit and battery failure.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Mfg Campaign: 23S53
Recall Date: Sep 8, 2023
Ford Motor Company
Safety Issue:
Ford Motor Company (Ford) is recalling certain 2020-2023 Lincoln Aviator, 2018-2021 Lincoln Navigator, 2022-2023 Ford Transit, and 2021 Ford Bronco vehicles. The rearview camera, or 360-degree view camera if equipped, may not display a rearview image when the vehicle is placed in reverse.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Mfg Campaign: 23S48
Recall Date: Aug 25, 2023
Ford Motor Company
Safety Issue:
Ford Motor Company (Ford) is recalling certain 2020-2023 Explorer, Lincoln Aviator, and 2020-2022 Lincoln Corsair vehicles equipped with a 360-degree camera. The video output may fail, preventing the rearview camera image from displaying.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Mfg Campaign: 23S23
Recall Date: May 12, 2023
Ford Motor Company
Safety Issue:
Ford Motor Company (Ford) is recalling certain 2020-2023 Explorer, Lincoln Aviator, and 2020-2022 Lincoln Corsair vehicles equipped with a 360-degree camera. The video output may fail, preventing the rearview camera image from displaying.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Mfg Campaign: 23S02
Recall Date: Jan 23, 2023
Ford Motor Company
Safety Issue:
Ford Motor Company (Ford) is recalling certain 2020-2023 Lincoln Aviator and 2020-2022 Lincoln Corsair vehicles equipped with a Revel Audio System. When the driver's seat belt is not buckled and the vehicle is started, the seat belt warning system may activate the audible warning chime for an insufficient amount of time of less than 4 seconds. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Mfg Campaign: 22C35
Recall Date: Dec 23, 2022
Ford Motor Company
Safety Issue:
Ford Motor Company (Ford) is recalling certain 2021 Explorer and Lincoln Aviator vehicles. Incorrect rear suspension module components may have been installed due to a labeling error.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Mfg Campaign: 21S47
Recall Date: Nov 10, 2021
Ford Motor Company
Safety Issue:
Ford Motor Company (Ford) is recalling certain 2020-2021 Explorer, Lincoln Corsair, and Lincoln Aviator vehicles equipped with 360-degree cameras. The video output may fail, preventing the rearview camera image from displaying.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Mfg Campaign: 21S44
Recall Date: Sep 22, 2021
Ford Motor Company
Safety Issue:
Ford Motor Company (Ford) is recalling certain 2021 Explorer and Lincoln Aviator vehicles. The side air bag attachment weld studs could detach during the deployment of the side air bag, resulting in an improper deployment. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard 214, "Side Impact Protection".
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Mfg Campaign: 21C19
Recall Date: Aug 23, 2021
Ford Motor Company
Safety Issue:
Ford Motor Company (Ford) is recalling certain 2020-2021 Lincoln Aviator vehicles equipped with 3.0L gasoline engines. The wire harness may not be secured properly, possibly contacting the air conditioning (A/C) compressor pulley, and resulting in damage to electrical wires, or the A/C compressor drive belt.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Mfg Campaign: 21S34
Recall Date: Jul 15, 2021
Ford Motor Company
Safety Issue:
Ford Motor Company (Ford) is recalling certain 2020-2021 Lincoln Aviator vehicles. The image processing module may be unable to provide video feed to the display, which could result in a loss of the backup camera image. As such, these vehicles fail to comply with the requirements of the Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Mfg Campaign: 21C09
Recall Date: Mar 30, 2021
Ford Motor Company
Safety Issue:
Ford Motor Company (Ford) is recalling certain 2020-2021 Explorer and Lincoln Aviator vehicles. The right hand motor mount fasteners may have been incorrectly tightened, and may loosen over time.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Mfg Campaign: 20S72
Recall Date: Dec 17, 2020
Ford Motor Company
Safety Issue:
Ford Motor Company (Ford) is recalling certain 2021 Lincoln Aviator vehicles. The steering knuckles may have been manufactured improperly.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Mfg Campaign: 20S69
Recall Date: Nov 20, 2020
Consumer Complaints
30 ComplaintsFord Motor Company
Defect Description:
FUEL SYSTEM, GASOLINE
Potential Consequences:
The contact owns a 2021 Lincoln Aviator. The contact stated that while 5 MPH and depressing the accelerator pedal, the vehicle failed to respond as intended. The message to “Shift to Park” was displayed. The contact pulled over to right side of the road, turned off and restarted the vehicle, and the vehicle operated as intended. A dealer was contacted. The contact stated that the failure had occurred on several occasions. The vehicle was not taken to the dealer to be diagnosed; however, the contact had scheduled an appointment for the vehicle to be diagnosed. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 25V455000 (FUEL SYSTEM, GASOLINE); however, the VIN was not included in the recall. The manufacturer was notified of the failure, and informed the contact that the VIN was not included in the recall. The failure mileage was 130,000.
Corrective Action:
The contact owns a 2021 Lincoln Aviator. The contact stated that while 5 MPH and depressing the accelerator pedal, the vehicle failed to respond as intended. The message to “Shift to Park” was displayed. The contact pulled over to right side of the road, turned off and restarted the vehicle, and the vehicle operated as intended. A dealer was contacted. The contact stated that the failure had occurred on several occasions. The vehicle was not taken to the dealer to be diagnosed; however, the contact had scheduled an appointment for the vehicle to be diagnosed. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 25V455000 (FUEL SYSTEM, GASOLINE); however, the VIN was not included in the recall. The manufacturer was notified of the failure, and informed the contact that the VIN was not included in the recall. The failure mileage was 130,000.
Additional Notes:
The contact owns a 2021 Lincoln Aviator. The contact stated that while 5 MPH and depressing the accelerator pedal, the vehicle failed to respond as intended. The message to “Shift to Park” was displayed. The contact pulled over to right side of the road, turned off and restarted the vehicle, and the vehicle operated as intended. A dealer was contacted. The contact stated that the failure had occurred on several occasions. The vehicle was not taken to the dealer to be diagnosed; however, the contact had scheduled an appointment for the vehicle to be diagnosed. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 25V455000 (FUEL SYSTEM, GASOLINE); however, the VIN was not included in the recall. The manufacturer was notified of the failure, and informed the contact that the VIN was not included in the recall. The failure mileage was 130,000.
Mfg Campaign: 11675141
Recall Date: Jul 21, 2025
Ford Motor Company
Defect Description:
STRUCTURE:BODY
Potential Consequences:
Trim piece on back drivers side window has fallen off while driving down the highway.
Corrective Action:
Trim piece on back drivers side window has fallen off while driving down the highway.
Additional Notes:
Trim piece on back drivers side window has fallen off while driving down the highway.
Mfg Campaign: 11673256
Recall Date: Jul 14, 2025
Ford Motor Company
Defect Description:
STRUCTURE
Potential Consequences:
The contact owns a 2021 Lincoln Aviator. The contact stated while driving at an undisclosed speed, the driver's side rear door trim detached and flew off the vehicle. Additionally, the contact stated that after it rained, water entered the interior of the vehicle through the sunroof. The vehicle was taken to the dealer where it was diagnosed with a detached driver's rear door trim and clogged drain tubes in the sunroof assembly. The driver's side rear door trim was not replaced. The dealer repaired the clogged drain tubes in the sunroof assembly. The contact stated that the failure reoccurred. The vehicle was taken back to the dealer; however, the failure was not duplicated. The manufacturer was made aware of the failure. The contact referenced a recall; however, the VIN was not associated with the recall. The failure mileage was approximately 60,000.
Corrective Action:
The contact owns a 2021 Lincoln Aviator. The contact stated while driving at an undisclosed speed, the driver's side rear door trim detached and flew off the vehicle. Additionally, the contact stated that after it rained, water entered the interior of the vehicle through the sunroof. The vehicle was taken to the dealer where it was diagnosed with a detached driver's rear door trim and clogged drain tubes in the sunroof assembly. The driver's side rear door trim was not replaced. The dealer repaired the clogged drain tubes in the sunroof assembly. The contact stated that the failure reoccurred. The vehicle was taken back to the dealer; however, the failure was not duplicated. The manufacturer was made aware of the failure. The contact referenced a recall; however, the VIN was not associated with the recall. The failure mileage was approximately 60,000.
Additional Notes:
The contact owns a 2021 Lincoln Aviator. The contact stated while driving at an undisclosed speed, the driver's side rear door trim detached and flew off the vehicle. Additionally, the contact stated that after it rained, water entered the interior of the vehicle through the sunroof. The vehicle was taken to the dealer where it was diagnosed with a detached driver's rear door trim and clogged drain tubes in the sunroof assembly. The driver's side rear door trim was not replaced. The dealer repaired the clogged drain tubes in the sunroof assembly. The contact stated that the failure reoccurred. The vehicle was taken back to the dealer; however, the failure was not duplicated. The manufacturer was made aware of the failure. The contact referenced a recall; however, the VIN was not associated with the recall. The failure mileage was approximately 60,000.
Mfg Campaign: 11669232
Recall Date: Jun 25, 2025
Ford Motor Company
Defect Description:
VISIBILITY:SUN/MOON ROOF ASSEMBLY
Potential Consequences:
The contact owns a 2021 Lincoln Aviator. The contact stated while driving at an undisclosed speed, the driver's side rear door trim detached and flew off the vehicle. Additionally, the contact stated that after it rained, water entered the interior of the vehicle through the sunroof. The vehicle was taken to the dealer where it was diagnosed with a detached driver's rear door trim and clogged drain tubes in the sunroof assembly. The driver's side rear door trim was not replaced. The dealer repaired the clogged drain tubes in the sunroof assembly. The contact stated that the failure reoccurred. The vehicle was taken back to the dealer; however, the failure was not duplicated. The manufacturer was made aware of the failure. The contact referenced a recall; however, the VIN was not associated with the recall. The failure mileage was approximately 60,000.
Corrective Action:
The contact owns a 2021 Lincoln Aviator. The contact stated while driving at an undisclosed speed, the driver's side rear door trim detached and flew off the vehicle. Additionally, the contact stated that after it rained, water entered the interior of the vehicle through the sunroof. The vehicle was taken to the dealer where it was diagnosed with a detached driver's rear door trim and clogged drain tubes in the sunroof assembly. The driver's side rear door trim was not replaced. The dealer repaired the clogged drain tubes in the sunroof assembly. The contact stated that the failure reoccurred. The vehicle was taken back to the dealer; however, the failure was not duplicated. The manufacturer was made aware of the failure. The contact referenced a recall; however, the VIN was not associated with the recall. The failure mileage was approximately 60,000.
Additional Notes:
The contact owns a 2021 Lincoln Aviator. The contact stated while driving at an undisclosed speed, the driver's side rear door trim detached and flew off the vehicle. Additionally, the contact stated that after it rained, water entered the interior of the vehicle through the sunroof. The vehicle was taken to the dealer where it was diagnosed with a detached driver's rear door trim and clogged drain tubes in the sunroof assembly. The driver's side rear door trim was not replaced. The dealer repaired the clogged drain tubes in the sunroof assembly. The contact stated that the failure reoccurred. The vehicle was taken back to the dealer; however, the failure was not duplicated. The manufacturer was made aware of the failure. The contact referenced a recall; however, the VIN was not associated with the recall. The failure mileage was approximately 60,000.
Mfg Campaign: 11669232
Recall Date: Jun 25, 2025
Ford Motor Company
Defect Description:
FUEL/PROPULSION SYSTEM
Potential Consequences:
When pumping gas it always overflows. Tried several gas stations. Two different dealers have attempted to fix (they did confirm the issue). Each had had at least 3 attempts with no success. Lincoln seems disinterested in finding a remedy. This feels very unsafe to me in many ways.
Corrective Action:
When pumping gas it always overflows. Tried several gas stations. Two different dealers have attempted to fix (they did confirm the issue). Each had had at least 3 attempts with no success. Lincoln seems disinterested in finding a remedy. This feels very unsafe to me in many ways.
Additional Notes:
When pumping gas it always overflows. Tried several gas stations. Two different dealers have attempted to fix (they did confirm the issue). Each had had at least 3 attempts with no success. Lincoln seems disinterested in finding a remedy. This feels very unsafe to me in many ways.
Mfg Campaign: 11666670
Recall Date: Jun 13, 2025
Ford Motor Company
Defect Description:
VEHICLE SPEED CONTROL
Potential Consequences:
Driving 75mph. Cruise set to 75mph. Vehicle randomly reset cruising speed to 85 and 105mph or two separate occasions over 4 days. I went through the settings and disabled intelligent cruise control and switched it to adaptive cruise control, which doesn't use radar and navigation data. Only tell will tell if that fixed it. I already had speed sign recognition disabled.
Corrective Action:
Driving 75mph. Cruise set to 75mph. Vehicle randomly reset cruising speed to 85 and 105mph or two separate occasions over 4 days. I went through the settings and disabled intelligent cruise control and switched it to adaptive cruise control, which doesn't use radar and navigation data. Only tell will tell if that fixed it. I already had speed sign recognition disabled.
Additional Notes:
Driving 75mph. Cruise set to 75mph. Vehicle randomly reset cruising speed to 85 and 105mph or two separate occasions over 4 days. I went through the settings and disabled intelligent cruise control and switched it to adaptive cruise control, which doesn't use radar and navigation data. Only tell will tell if that fixed it. I already had speed sign recognition disabled.
Mfg Campaign: 11644108
Recall Date: Feb 21, 2025
Ford Motor Company
Defect Description:
FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL
Potential Consequences:
Driving 75mph. Cruise set to 75mph. Vehicle randomly reset cruising speed to 85 and 105mph or two separate occasions over 4 days. I went through the settings and disabled intelligent cruise control and switched it to adaptive cruise control, which doesn't use radar and navigation data. Only tell will tell if that fixed it. I already had speed sign recognition disabled.
Corrective Action:
Driving 75mph. Cruise set to 75mph. Vehicle randomly reset cruising speed to 85 and 105mph or two separate occasions over 4 days. I went through the settings and disabled intelligent cruise control and switched it to adaptive cruise control, which doesn't use radar and navigation data. Only tell will tell if that fixed it. I already had speed sign recognition disabled.
Additional Notes:
Driving 75mph. Cruise set to 75mph. Vehicle randomly reset cruising speed to 85 and 105mph or two separate occasions over 4 days. I went through the settings and disabled intelligent cruise control and switched it to adaptive cruise control, which doesn't use radar and navigation data. Only tell will tell if that fixed it. I already had speed sign recognition disabled.
Mfg Campaign: 11644108
Recall Date: Feb 21, 2025
Ford Motor Company
Defect Description:
UNKNOWN OR OTHER
Potential Consequences:
I have been reporting an issue for over two years with multiple dealerships regarding a sulphur and other strong exhaust smell. This Sulphur smell is most problematic and occurs most often at least one per day. This issue started off intermittently but is now occurring as increase frequencies. The Lincoln dealerships tell me this is normal. I am not sure what system is exactly failing as no codes are being presented (so says the dealership. This smell is so strong and can be easily smelled in the car but even more once opening the doors or hatchback. I have children that breath this air as well as myself. Often children (my own as well as school friends for which we give rides to) complain about this smell and it is very noxious in nature. This issue has been reported to the dealership MULTIPLE times (Actually reported to two dealerships). Often, I am being told this is "normal" due to gas used. In beginning they would not even log my concern, but this past year I have been submitting online. Always no code so no issue. No other troubleshooting is done. I have even requested additional basic troubleshooting data and not received. This is not a normal smell, as the Lincoln dealership(s) suggest. This smell makes us feel unpleasant. This smell is strong and is hazardous to the health of my family and others. I need Ford to take this issue seriously. Symptoms experienced indicate there is likely a problem with the catalytic converter and they are not addressing.
Corrective Action:
I have been reporting an issue for over two years with multiple dealerships regarding a sulphur and other strong exhaust smell. This Sulphur smell is most problematic and occurs most often at least one per day. This issue started off intermittently but is now occurring as increase frequencies. The Lincoln dealerships tell me this is normal. I am not sure what system is exactly failing as no codes are being presented (so says the dealership. This smell is so strong and can be easily smelled in the car but even more once opening the doors or hatchback. I have children that breath this air as well as myself. Often children (my own as well as school friends for which we give rides to) complain about this smell and it is very noxious in nature. This issue has been reported to the dealership MULTIPLE times (Actually reported to two dealerships). Often, I am being told this is "normal" due to gas used. In beginning they would not even log my concern, but this past year I have been submitting online. Always no code so no issue. No other troubleshooting is done. I have even requested additional basic troubleshooting data and not received. This is not a normal smell, as the Lincoln dealership(s) suggest. This smell makes us feel unpleasant. This smell is strong and is hazardous to the health of my family and others. I need Ford to take this issue seriously. Symptoms experienced indicate there is likely a problem with the catalytic converter and they are not addressing.
Additional Notes:
I have been reporting an issue for over two years with multiple dealerships regarding a sulphur and other strong exhaust smell. This Sulphur smell is most problematic and occurs most often at least one per day. This issue started off intermittently but is now occurring as increase frequencies. The Lincoln dealerships tell me this is normal. I am not sure what system is exactly failing as no codes are being presented (so says the dealership. This smell is so strong and can be easily smelled in the car but even more once opening the doors or hatchback. I have children that breath this air as well as myself. Often children (my own as well as school friends for which we give rides to) complain about this smell and it is very noxious in nature. This issue has been reported to the dealership MULTIPLE times (Actually reported to two dealerships). Often, I am being told this is "normal" due to gas used. In beginning they would not even log my concern, but this past year I have been submitting online. Always no code so no issue. No other troubleshooting is done. I have even requested additional basic troubleshooting data and not received. This is not a normal smell, as the Lincoln dealership(s) suggest. This smell makes us feel unpleasant. This smell is strong and is hazardous to the health of my family and others. I need Ford to take this issue seriously. Symptoms experienced indicate there is likely a problem with the catalytic converter and they are not addressing.
Mfg Campaign: 11616359
Recall Date: Sep 25, 2024
Ford Motor Company
Defect Description:
UNKNOWN OR OTHER
Potential Consequences:
I am writing to express my frustration regarding the unresolved issue related to recall 24V368 concerning the rearview camera image. This has been an ongoing problem for several years, and despite receiving multiple safety recall notices and scheduling appointments with your service department, the issue remains unaddressed.
Corrective Action:
I am writing to express my frustration regarding the unresolved issue related to recall 24V368 concerning the rearview camera image. This has been an ongoing problem for several years, and despite receiving multiple safety recall notices and scheduling appointments with your service department, the issue remains unaddressed.
Additional Notes:
I am writing to express my frustration regarding the unresolved issue related to recall 24V368 concerning the rearview camera image. This has been an ongoing problem for several years, and despite receiving multiple safety recall notices and scheduling appointments with your service department, the issue remains unaddressed.
Mfg Campaign: 11614521
Recall Date: Sep 13, 2024
Ford Motor Company
Defect Description:
BACK OVER PREVENTION
Potential Consequences:
The contact owns a 2021 Lincoln Aviator. The contact received notification of NHTSA Campaign Number: 23V342000 (Back Over Prevention) however, the part to do the recall repair was not yet available. The local dealer was made aware of the issue. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact stated that the back-over camera displayed distorted images or failed to display an image. The failure mileage was 50,000. VIN tool confirms parts not available.
Corrective Action:
The contact owns a 2021 Lincoln Aviator. The contact received notification of NHTSA Campaign Number: 23V342000 (Back Over Prevention) however, the part to do the recall repair was not yet available. The local dealer was made aware of the issue. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact stated that the back-over camera displayed distorted images or failed to display an image. The failure mileage was 50,000. VIN tool confirms parts not available.
Additional Notes:
The contact owns a 2021 Lincoln Aviator. The contact received notification of NHTSA Campaign Number: 23V342000 (Back Over Prevention) however, the part to do the recall repair was not yet available. The local dealer was made aware of the issue. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact stated that the back-over camera displayed distorted images or failed to display an image. The failure mileage was 50,000. VIN tool confirms parts not available.
Mfg Campaign: 11567279
Recall Date: Jan 23, 2024
Ford Motor Company
Defect Description:
ENGINE
Potential Consequences:
The engine of my 2021 Lincoln Aviator with only 79,403 miles has failed, leaving myself and my family stranded on the side of a very busy interstate in another state far from home. There were absolutely no warnings given before the engine acted as if it had a significant loss of power. Shortly afterwards, very heavy and foul-smelling smoke started coming out of the tail pipe. Had the vehicle transported to a local shop to my home. The car will start and immediately start smoking and running like crap. When you put it in gear it will barely move on it's own power.
Corrective Action:
The engine of my 2021 Lincoln Aviator with only 79,403 miles has failed, leaving myself and my family stranded on the side of a very busy interstate in another state far from home. There were absolutely no warnings given before the engine acted as if it had a significant loss of power. Shortly afterwards, very heavy and foul-smelling smoke started coming out of the tail pipe. Had the vehicle transported to a local shop to my home. The car will start and immediately start smoking and running like crap. When you put it in gear it will barely move on it's own power.
Additional Notes:
The engine of my 2021 Lincoln Aviator with only 79,403 miles has failed, leaving myself and my family stranded on the side of a very busy interstate in another state far from home. There were absolutely no warnings given before the engine acted as if it had a significant loss of power. Shortly afterwards, very heavy and foul-smelling smoke started coming out of the tail pipe. Had the vehicle transported to a local shop to my home. The car will start and immediately start smoking and running like crap. When you put it in gear it will barely move on it's own power.
Mfg Campaign: 11554373
Recall Date: Nov 9, 2023
Ford Motor Company
Defect Description:
ELECTRICAL SYSTEM
Potential Consequences:
UNKNOWN ON several occasions the vehicle would just shut off. Another occasion while getting on the freeway I pressed the accelerator pedal and the car pumped the brakes,there was no one in front of me or on side of me upon entering the freeway. Another incident I was in the fast lane on the freeway and the vehicle just shut off Thank goodness the fast lane had a place where I could pull over and and restart the vehicle. Also where the vehicle pumped the brakes, that happened on several occasions. Another thing the vehicle shut of again in the middle of the street. I couldn't put the car in neutral the steering was locked. All of incidents were extremely dangerous. The vehicle has been in the dealership shop twice now and I mentioned it to them on both occasions. And I was told it was the battery. That starts the engine not battery for the eclectic system. I was also told that they did diagnostic check of the software system and there were no systems alerts it was only showing the battery. Now I now that when you drive a vehicle the engine battery charges, plus the vehicle in a 2021 with only 35,000 miles on it.
Corrective Action:
UNKNOWN ON several occasions the vehicle would just shut off. Another occasion while getting on the freeway I pressed the accelerator pedal and the car pumped the brakes,there was no one in front of me or on side of me upon entering the freeway. Another incident I was in the fast lane on the freeway and the vehicle just shut off Thank goodness the fast lane had a place where I could pull over and and restart the vehicle. Also where the vehicle pumped the brakes, that happened on several occasions. Another thing the vehicle shut of again in the middle of the street. I couldn't put the car in neutral the steering was locked. All of incidents were extremely dangerous. The vehicle has been in the dealership shop twice now and I mentioned it to them on both occasions. And I was told it was the battery. That starts the engine not battery for the eclectic system. I was also told that they did diagnostic check of the software system and there were no systems alerts it was only showing the battery. Now I now that when you drive a vehicle the engine battery charges, plus the vehicle in a 2021 with only 35,000 miles on it.
Additional Notes:
UNKNOWN ON several occasions the vehicle would just shut off. Another occasion while getting on the freeway I pressed the accelerator pedal and the car pumped the brakes,there was no one in front of me or on side of me upon entering the freeway. Another incident I was in the fast lane on the freeway and the vehicle just shut off Thank goodness the fast lane had a place where I could pull over and and restart the vehicle. Also where the vehicle pumped the brakes, that happened on several occasions. Another thing the vehicle shut of again in the middle of the street. I couldn't put the car in neutral the steering was locked. All of incidents were extremely dangerous. The vehicle has been in the dealership shop twice now and I mentioned it to them on both occasions. And I was told it was the battery. That starts the engine not battery for the eclectic system. I was also told that they did diagnostic check of the software system and there were no systems alerts it was only showing the battery. Now I now that when you drive a vehicle the engine battery charges, plus the vehicle in a 2021 with only 35,000 miles on it.
Mfg Campaign: 11554066
Recall Date: Nov 7, 2023
Ford Motor Company
Defect Description:
VEHICLE SPEED CONTROL
Potential Consequences:
UNKNOWN ON several occasions the vehicle would just shut off. Another occasion while getting on the freeway I pressed the accelerator pedal and the car pumped the brakes,there was no one in front of me or on side of me upon entering the freeway. Another incident I was in the fast lane on the freeway and the vehicle just shut off Thank goodness the fast lane had a place where I could pull over and and restart the vehicle. Also where the vehicle pumped the brakes, that happened on several occasions. Another thing the vehicle shut of again in the middle of the street. I couldn't put the car in neutral the steering was locked. All of incidents were extremely dangerous. The vehicle has been in the dealership shop twice now and I mentioned it to them on both occasions. And I was told it was the battery. That starts the engine not battery for the eclectic system. I was also told that they did diagnostic check of the software system and there were no systems alerts it was only showing the battery. Now I now that when you drive a vehicle the engine battery charges, plus the vehicle in a 2021 with only 35,000 miles on it.
Corrective Action:
UNKNOWN ON several occasions the vehicle would just shut off. Another occasion while getting on the freeway I pressed the accelerator pedal and the car pumped the brakes,there was no one in front of me or on side of me upon entering the freeway. Another incident I was in the fast lane on the freeway and the vehicle just shut off Thank goodness the fast lane had a place where I could pull over and and restart the vehicle. Also where the vehicle pumped the brakes, that happened on several occasions. Another thing the vehicle shut of again in the middle of the street. I couldn't put the car in neutral the steering was locked. All of incidents were extremely dangerous. The vehicle has been in the dealership shop twice now and I mentioned it to them on both occasions. And I was told it was the battery. That starts the engine not battery for the eclectic system. I was also told that they did diagnostic check of the software system and there were no systems alerts it was only showing the battery. Now I now that when you drive a vehicle the engine battery charges, plus the vehicle in a 2021 with only 35,000 miles on it.
Additional Notes:
UNKNOWN ON several occasions the vehicle would just shut off. Another occasion while getting on the freeway I pressed the accelerator pedal and the car pumped the brakes,there was no one in front of me or on side of me upon entering the freeway. Another incident I was in the fast lane on the freeway and the vehicle just shut off Thank goodness the fast lane had a place where I could pull over and and restart the vehicle. Also where the vehicle pumped the brakes, that happened on several occasions. Another thing the vehicle shut of again in the middle of the street. I couldn't put the car in neutral the steering was locked. All of incidents were extremely dangerous. The vehicle has been in the dealership shop twice now and I mentioned it to them on both occasions. And I was told it was the battery. That starts the engine not battery for the eclectic system. I was also told that they did diagnostic check of the software system and there were no systems alerts it was only showing the battery. Now I now that when you drive a vehicle the engine battery charges, plus the vehicle in a 2021 with only 35,000 miles on it.
Mfg Campaign: 11554066
Recall Date: Nov 7, 2023
Ford Motor Company
Defect Description:
FUEL/PROPULSION SYSTEM
Potential Consequences:
UNKNOWN ON several occasions the vehicle would just shut off. Another occasion while getting on the freeway I pressed the accelerator pedal and the car pumped the brakes,there was no one in front of me or on side of me upon entering the freeway. Another incident I was in the fast lane on the freeway and the vehicle just shut off Thank goodness the fast lane had a place where I could pull over and and restart the vehicle. Also where the vehicle pumped the brakes, that happened on several occasions. Another thing the vehicle shut of again in the middle of the street. I couldn't put the car in neutral the steering was locked. All of incidents were extremely dangerous. The vehicle has been in the dealership shop twice now and I mentioned it to them on both occasions. And I was told it was the battery. That starts the engine not battery for the eclectic system. I was also told that they did diagnostic check of the software system and there were no systems alerts it was only showing the battery. Now I now that when you drive a vehicle the engine battery charges, plus the vehicle in a 2021 with only 35,000 miles on it.
Corrective Action:
UNKNOWN ON several occasions the vehicle would just shut off. Another occasion while getting on the freeway I pressed the accelerator pedal and the car pumped the brakes,there was no one in front of me or on side of me upon entering the freeway. Another incident I was in the fast lane on the freeway and the vehicle just shut off Thank goodness the fast lane had a place where I could pull over and and restart the vehicle. Also where the vehicle pumped the brakes, that happened on several occasions. Another thing the vehicle shut of again in the middle of the street. I couldn't put the car in neutral the steering was locked. All of incidents were extremely dangerous. The vehicle has been in the dealership shop twice now and I mentioned it to them on both occasions. And I was told it was the battery. That starts the engine not battery for the eclectic system. I was also told that they did diagnostic check of the software system and there were no systems alerts it was only showing the battery. Now I now that when you drive a vehicle the engine battery charges, plus the vehicle in a 2021 with only 35,000 miles on it.
Additional Notes:
UNKNOWN ON several occasions the vehicle would just shut off. Another occasion while getting on the freeway I pressed the accelerator pedal and the car pumped the brakes,there was no one in front of me or on side of me upon entering the freeway. Another incident I was in the fast lane on the freeway and the vehicle just shut off Thank goodness the fast lane had a place where I could pull over and and restart the vehicle. Also where the vehicle pumped the brakes, that happened on several occasions. Another thing the vehicle shut of again in the middle of the street. I couldn't put the car in neutral the steering was locked. All of incidents were extremely dangerous. The vehicle has been in the dealership shop twice now and I mentioned it to them on both occasions. And I was told it was the battery. That starts the engine not battery for the eclectic system. I was also told that they did diagnostic check of the software system and there were no systems alerts it was only showing the battery. Now I now that when you drive a vehicle the engine battery charges, plus the vehicle in a 2021 with only 35,000 miles on it.
Mfg Campaign: 11554066
Recall Date: Nov 7, 2023
Ford Motor Company
Defect Description:
BACK OVER PREVENTION
Potential Consequences:
The contact owns a 2021 Lincoln Aviator. The contact stated that on several occasions while reversing, the rear camera flickered and failed to display an image on the screen. The vehicle was taken to a dealer to be diagnosed. The contact was informed that the rear-view camera needed to be replaced. The vehicle was repaired but the failure persisted. The manufacturer was notified of the failure. The failure mileage was 17,000.
Corrective Action:
The contact owns a 2021 Lincoln Aviator. The contact stated that on several occasions while reversing, the rear camera flickered and failed to display an image on the screen. The vehicle was taken to a dealer to be diagnosed. The contact was informed that the rear-view camera needed to be replaced. The vehicle was repaired but the failure persisted. The manufacturer was notified of the failure. The failure mileage was 17,000.
Additional Notes:
The contact owns a 2021 Lincoln Aviator. The contact stated that on several occasions while reversing, the rear camera flickered and failed to display an image on the screen. The vehicle was taken to a dealer to be diagnosed. The contact was informed that the rear-view camera needed to be replaced. The vehicle was repaired but the failure persisted. The manufacturer was notified of the failure. The failure mileage was 17,000.
Mfg Campaign: 11550183
Recall Date: Oct 16, 2023
Ford Motor Company
Defect Description:
SUSPENSION
Potential Consequences:
Hello. My name is [XXX] and I have a potentially serious issue with my car and Lincoln refuses to look into it. The short story : When you press the brakes moderately or harder (as if stopping for a yellow light) it sounds like you’ve run over a brick or hit a BIG pothole. It has been in 6 times and to 3 dealerships and they all say it is normal for Aviators and Explorers. I have owned an auto repair shop for 12 years and my guys fix 2000 cars per year. I am an ASE master certified mechanic and I can assure anyone that there is nothing normal about this bang. They tell me they drive a like vehicle and if it also makes noise, there is nothing they can do. I have reached out to Lincoln Concierge multiple times and they tell me they will do nothing if a like vehicle also does it. I think of the 2019 Pacifica that the lower ball joint pinch bolts comes out and folds the wheel under the vehicle. I have had 3 service managers drive the car and they have all told me that it sounds really bad and abnormal. I have been told by all of those managers that Lincoln enforces not doing any further diagnostics or repairs if they all do it. I did drive a 2023 Aviator with a service advisor and it did not make the same noise mine does. You can actually feel the noise in the steering wheel. I have pleaded with them to investigate the issue and at least let me speak with a supervisor about it but they refuse. I have asked the dealers to put a set of chassis ears on the suspension to pinpoint the sound and they say Lincoln will not let them. The vehicle has 33k on it and is still under full factory and extended CPO warranty. Can you guys look into this issue before someone gets hurt ? Thanks for reading INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Corrective Action:
Hello. My name is [XXX] and I have a potentially serious issue with my car and Lincoln refuses to look into it. The short story : When you press the brakes moderately or harder (as if stopping for a yellow light) it sounds like you’ve run over a brick or hit a BIG pothole. It has been in 6 times and to 3 dealerships and they all say it is normal for Aviators and Explorers. I have owned an auto repair shop for 12 years and my guys fix 2000 cars per year. I am an ASE master certified mechanic and I can assure anyone that there is nothing normal about this bang. They tell me they drive a like vehicle and if it also makes noise, there is nothing they can do. I have reached out to Lincoln Concierge multiple times and they tell me they will do nothing if a like vehicle also does it. I think of the 2019 Pacifica that the lower ball joint pinch bolts comes out and folds the wheel under the vehicle. I have had 3 service managers drive the car and they have all told me that it sounds really bad and abnormal. I have been told by all of those managers that Lincoln enforces not doing any further diagnostics or repairs if they all do it. I did drive a 2023 Aviator with a service advisor and it did not make the same noise mine does. You can actually feel the noise in the steering wheel. I have pleaded with them to investigate the issue and at least let me speak with a supervisor about it but they refuse. I have asked the dealers to put a set of chassis ears on the suspension to pinpoint the sound and they say Lincoln will not let them. The vehicle has 33k on it and is still under full factory and extended CPO warranty. Can you guys look into this issue before someone gets hurt ? Thanks for reading INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Additional Notes:
Hello. My name is [XXX] and I have a potentially serious issue with my car and Lincoln refuses to look into it. The short story : When you press the brakes moderately or harder (as if stopping for a yellow light) it sounds like you’ve run over a brick or hit a BIG pothole. It has been in 6 times and to 3 dealerships and they all say it is normal for Aviators and Explorers. I have owned an auto repair shop for 12 years and my guys fix 2000 cars per year. I am an ASE master certified mechanic and I can assure anyone that there is nothing normal about this bang. They tell me they drive a like vehicle and if it also makes noise, there is nothing they can do. I have reached out to Lincoln Concierge multiple times and they tell me they will do nothing if a like vehicle also does it. I think of the 2019 Pacifica that the lower ball joint pinch bolts comes out and folds the wheel under the vehicle. I have had 3 service managers drive the car and they have all told me that it sounds really bad and abnormal. I have been told by all of those managers that Lincoln enforces not doing any further diagnostics or repairs if they all do it. I did drive a 2023 Aviator with a service advisor and it did not make the same noise mine does. You can actually feel the noise in the steering wheel. I have pleaded with them to investigate the issue and at least let me speak with a supervisor about it but they refuse. I have asked the dealers to put a set of chassis ears on the suspension to pinpoint the sound and they say Lincoln will not let them. The vehicle has 33k on it and is still under full factory and extended CPO warranty. Can you guys look into this issue before someone gets hurt ? Thanks for reading INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Mfg Campaign: 11549840
Recall Date: Oct 13, 2023
Ford Motor Company
Defect Description:
STEERING
Potential Consequences:
Hello. My name is [XXX] and I have a potentially serious issue with my car and Lincoln refuses to look into it. The short story : When you press the brakes moderately or harder (as if stopping for a yellow light) it sounds like you’ve run over a brick or hit a BIG pothole. It has been in 6 times and to 3 dealerships and they all say it is normal for Aviators and Explorers. I have owned an auto repair shop for 12 years and my guys fix 2000 cars per year. I am an ASE master certified mechanic and I can assure anyone that there is nothing normal about this bang. They tell me they drive a like vehicle and if it also makes noise, there is nothing they can do. I have reached out to Lincoln Concierge multiple times and they tell me they will do nothing if a like vehicle also does it. I think of the 2019 Pacifica that the lower ball joint pinch bolts comes out and folds the wheel under the vehicle. I have had 3 service managers drive the car and they have all told me that it sounds really bad and abnormal. I have been told by all of those managers that Lincoln enforces not doing any further diagnostics or repairs if they all do it. I did drive a 2023 Aviator with a service advisor and it did not make the same noise mine does. You can actually feel the noise in the steering wheel. I have pleaded with them to investigate the issue and at least let me speak with a supervisor about it but they refuse. I have asked the dealers to put a set of chassis ears on the suspension to pinpoint the sound and they say Lincoln will not let them. The vehicle has 33k on it and is still under full factory and extended CPO warranty. Can you guys look into this issue before someone gets hurt ? Thanks for reading INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Corrective Action:
Hello. My name is [XXX] and I have a potentially serious issue with my car and Lincoln refuses to look into it. The short story : When you press the brakes moderately or harder (as if stopping for a yellow light) it sounds like you’ve run over a brick or hit a BIG pothole. It has been in 6 times and to 3 dealerships and they all say it is normal for Aviators and Explorers. I have owned an auto repair shop for 12 years and my guys fix 2000 cars per year. I am an ASE master certified mechanic and I can assure anyone that there is nothing normal about this bang. They tell me they drive a like vehicle and if it also makes noise, there is nothing they can do. I have reached out to Lincoln Concierge multiple times and they tell me they will do nothing if a like vehicle also does it. I think of the 2019 Pacifica that the lower ball joint pinch bolts comes out and folds the wheel under the vehicle. I have had 3 service managers drive the car and they have all told me that it sounds really bad and abnormal. I have been told by all of those managers that Lincoln enforces not doing any further diagnostics or repairs if they all do it. I did drive a 2023 Aviator with a service advisor and it did not make the same noise mine does. You can actually feel the noise in the steering wheel. I have pleaded with them to investigate the issue and at least let me speak with a supervisor about it but they refuse. I have asked the dealers to put a set of chassis ears on the suspension to pinpoint the sound and they say Lincoln will not let them. The vehicle has 33k on it and is still under full factory and extended CPO warranty. Can you guys look into this issue before someone gets hurt ? Thanks for reading INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Additional Notes:
Hello. My name is [XXX] and I have a potentially serious issue with my car and Lincoln refuses to look into it. The short story : When you press the brakes moderately or harder (as if stopping for a yellow light) it sounds like you’ve run over a brick or hit a BIG pothole. It has been in 6 times and to 3 dealerships and they all say it is normal for Aviators and Explorers. I have owned an auto repair shop for 12 years and my guys fix 2000 cars per year. I am an ASE master certified mechanic and I can assure anyone that there is nothing normal about this bang. They tell me they drive a like vehicle and if it also makes noise, there is nothing they can do. I have reached out to Lincoln Concierge multiple times and they tell me they will do nothing if a like vehicle also does it. I think of the 2019 Pacifica that the lower ball joint pinch bolts comes out and folds the wheel under the vehicle. I have had 3 service managers drive the car and they have all told me that it sounds really bad and abnormal. I have been told by all of those managers that Lincoln enforces not doing any further diagnostics or repairs if they all do it. I did drive a 2023 Aviator with a service advisor and it did not make the same noise mine does. You can actually feel the noise in the steering wheel. I have pleaded with them to investigate the issue and at least let me speak with a supervisor about it but they refuse. I have asked the dealers to put a set of chassis ears on the suspension to pinpoint the sound and they say Lincoln will not let them. The vehicle has 33k on it and is still under full factory and extended CPO warranty. Can you guys look into this issue before someone gets hurt ? Thanks for reading INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Mfg Campaign: 11549840
Recall Date: Oct 13, 2023
Ford Motor Company
Defect Description:
UNKNOWN OR OTHER
Potential Consequences:
Hello. My name is [XXX] and I have a potentially serious issue with my car and Lincoln refuses to look into it. The short story : When you press the brakes moderately or harder (as if stopping for a yellow light) it sounds like you’ve run over a brick or hit a BIG pothole. It has been in 6 times and to 3 dealerships and they all say it is normal for Aviators and Explorers. I have owned an auto repair shop for 12 years and my guys fix 2000 cars per year. I am an ASE master certified mechanic and I can assure anyone that there is nothing normal about this bang. They tell me they drive a like vehicle and if it also makes noise, there is nothing they can do. I have reached out to Lincoln Concierge multiple times and they tell me they will do nothing if a like vehicle also does it. I think of the 2019 Pacifica that the lower ball joint pinch bolts comes out and folds the wheel under the vehicle. I have had 3 service managers drive the car and they have all told me that it sounds really bad and abnormal. I have been told by all of those managers that Lincoln enforces not doing any further diagnostics or repairs if they all do it. I did drive a 2023 Aviator with a service advisor and it did not make the same noise mine does. You can actually feel the noise in the steering wheel. I have pleaded with them to investigate the issue and at least let me speak with a supervisor about it but they refuse. I have asked the dealers to put a set of chassis ears on the suspension to pinpoint the sound and they say Lincoln will not let them. The vehicle has 33k on it and is still under full factory and extended CPO warranty. Can you guys look into this issue before someone gets hurt ? Thanks for reading INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Corrective Action:
Hello. My name is [XXX] and I have a potentially serious issue with my car and Lincoln refuses to look into it. The short story : When you press the brakes moderately or harder (as if stopping for a yellow light) it sounds like you’ve run over a brick or hit a BIG pothole. It has been in 6 times and to 3 dealerships and they all say it is normal for Aviators and Explorers. I have owned an auto repair shop for 12 years and my guys fix 2000 cars per year. I am an ASE master certified mechanic and I can assure anyone that there is nothing normal about this bang. They tell me they drive a like vehicle and if it also makes noise, there is nothing they can do. I have reached out to Lincoln Concierge multiple times and they tell me they will do nothing if a like vehicle also does it. I think of the 2019 Pacifica that the lower ball joint pinch bolts comes out and folds the wheel under the vehicle. I have had 3 service managers drive the car and they have all told me that it sounds really bad and abnormal. I have been told by all of those managers that Lincoln enforces not doing any further diagnostics or repairs if they all do it. I did drive a 2023 Aviator with a service advisor and it did not make the same noise mine does. You can actually feel the noise in the steering wheel. I have pleaded with them to investigate the issue and at least let me speak with a supervisor about it but they refuse. I have asked the dealers to put a set of chassis ears on the suspension to pinpoint the sound and they say Lincoln will not let them. The vehicle has 33k on it and is still under full factory and extended CPO warranty. Can you guys look into this issue before someone gets hurt ? Thanks for reading INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Additional Notes:
Hello. My name is [XXX] and I have a potentially serious issue with my car and Lincoln refuses to look into it. The short story : When you press the brakes moderately or harder (as if stopping for a yellow light) it sounds like you’ve run over a brick or hit a BIG pothole. It has been in 6 times and to 3 dealerships and they all say it is normal for Aviators and Explorers. I have owned an auto repair shop for 12 years and my guys fix 2000 cars per year. I am an ASE master certified mechanic and I can assure anyone that there is nothing normal about this bang. They tell me they drive a like vehicle and if it also makes noise, there is nothing they can do. I have reached out to Lincoln Concierge multiple times and they tell me they will do nothing if a like vehicle also does it. I think of the 2019 Pacifica that the lower ball joint pinch bolts comes out and folds the wheel under the vehicle. I have had 3 service managers drive the car and they have all told me that it sounds really bad and abnormal. I have been told by all of those managers that Lincoln enforces not doing any further diagnostics or repairs if they all do it. I did drive a 2023 Aviator with a service advisor and it did not make the same noise mine does. You can actually feel the noise in the steering wheel. I have pleaded with them to investigate the issue and at least let me speak with a supervisor about it but they refuse. I have asked the dealers to put a set of chassis ears on the suspension to pinpoint the sound and they say Lincoln will not let them. The vehicle has 33k on it and is still under full factory and extended CPO warranty. Can you guys look into this issue before someone gets hurt ? Thanks for reading INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Mfg Campaign: 11549840
Recall Date: Oct 13, 2023
Ford Motor Company
Defect Description:
BACK OVER PREVENTION: WARNINGS
Potential Consequences:
It has been almost a half year and still no solution for backup camera that shows blue screen. It is happening more and more. It is a big vehicle (and expensive one) . When backing up, one is at a great disadvantage with just a blue screen. You cannot see people or other objects. Car dealership says they do not know when it will be rectified. I think Ford/Lincoln is dragging their feet, using COVID as an excuse.
Corrective Action:
It has been almost a half year and still no solution for backup camera that shows blue screen. It is happening more and more. It is a big vehicle (and expensive one) . When backing up, one is at a great disadvantage with just a blue screen. You cannot see people or other objects. Car dealership says they do not know when it will be rectified. I think Ford/Lincoln is dragging their feet, using COVID as an excuse.
Additional Notes:
It has been almost a half year and still no solution for backup camera that shows blue screen. It is happening more and more. It is a big vehicle (and expensive one) . When backing up, one is at a great disadvantage with just a blue screen. You cannot see people or other objects. Car dealership says they do not know when it will be rectified. I think Ford/Lincoln is dragging their feet, using COVID as an excuse.
Mfg Campaign: 11524254
Recall Date: May 28, 2023
Ford Motor Company
Defect Description:
ENGINE
Potential Consequences:
Powertrain malfunctioning. The vehicle has had multiple neutral out (not reacting) when the accelerator is applied. Occurring in the middle of an intersection 3 times. Stuck in the middle of the intersection has resulted in two (2) cases of almost being hit by an oncoming vehicle. Pulling into traffic from a stop sign and losing the accelerator another time resulting in traffic breaking hard to avoid an accident. Recently while in cruise control on the highway driving 79 MPH, the vehicle suddenly shifted into what had to be the lowest gear lunging passengers forward and slowing to an unacceptable speed for the highway. Almost initiating being hit from the rear by a tractor trailer and just making it off of the shoulder to safety. This may be the result of service bulletins 22-2145 or SSM 50529. The dealer has stated they cannot reproduce the problems but are aware of the issues and Service Bulletins have been released. No warning lamps have come on when these issues have occurred. Vehicle has been into dealership multiple times. Service Managers had said they are working with Lincoln Engineers to remedy the problem. So far a separator plate and a valve has been replaced, which has not resolved the problem This happens intermittently, but when it does it causes what could be a severe safety issue. Currently the vehicle is in the dealership with no remedy, and has went in if for this issue multiple times. This has been going on for the past six (6) months.
Corrective Action:
Powertrain malfunctioning. The vehicle has had multiple neutral out (not reacting) when the accelerator is applied. Occurring in the middle of an intersection 3 times. Stuck in the middle of the intersection has resulted in two (2) cases of almost being hit by an oncoming vehicle. Pulling into traffic from a stop sign and losing the accelerator another time resulting in traffic breaking hard to avoid an accident. Recently while in cruise control on the highway driving 79 MPH, the vehicle suddenly shifted into what had to be the lowest gear lunging passengers forward and slowing to an unacceptable speed for the highway. Almost initiating being hit from the rear by a tractor trailer and just making it off of the shoulder to safety. This may be the result of service bulletins 22-2145 or SSM 50529. The dealer has stated they cannot reproduce the problems but are aware of the issues and Service Bulletins have been released. No warning lamps have come on when these issues have occurred. Vehicle has been into dealership multiple times. Service Managers had said they are working with Lincoln Engineers to remedy the problem. So far a separator plate and a valve has been replaced, which has not resolved the problem This happens intermittently, but when it does it causes what could be a severe safety issue. Currently the vehicle is in the dealership with no remedy, and has went in if for this issue multiple times. This has been going on for the past six (6) months.
Additional Notes:
Powertrain malfunctioning. The vehicle has had multiple neutral out (not reacting) when the accelerator is applied. Occurring in the middle of an intersection 3 times. Stuck in the middle of the intersection has resulted in two (2) cases of almost being hit by an oncoming vehicle. Pulling into traffic from a stop sign and losing the accelerator another time resulting in traffic breaking hard to avoid an accident. Recently while in cruise control on the highway driving 79 MPH, the vehicle suddenly shifted into what had to be the lowest gear lunging passengers forward and slowing to an unacceptable speed for the highway. Almost initiating being hit from the rear by a tractor trailer and just making it off of the shoulder to safety. This may be the result of service bulletins 22-2145 or SSM 50529. The dealer has stated they cannot reproduce the problems but are aware of the issues and Service Bulletins have been released. No warning lamps have come on when these issues have occurred. Vehicle has been into dealership multiple times. Service Managers had said they are working with Lincoln Engineers to remedy the problem. So far a separator plate and a valve has been replaced, which has not resolved the problem This happens intermittently, but when it does it causes what could be a severe safety issue. Currently the vehicle is in the dealership with no remedy, and has went in if for this issue multiple times. This has been going on for the past six (6) months.
Mfg Campaign: 11519252
Recall Date: Apr 27, 2023
Need Legal Help?
Featured Attorneys
Barry Edzant
Edzant Price LLC
Valencia, CA • 36 yrs
Focus: Lemon Law, Personal Injury
Recent Articles
Jeep Grand Cherokee Head Restraint Problem
Chrysler (FCA US, LLC) has announced a safety issue affecting certain 2023–2024 Jeep Grand Ch ...
Aug 1, 2025Fuel Injector Problem: 2021-2024 Ford Bronco Sport and 2020-2022 Ford Escape
If you own a 2021-2024 Ford Bronco Sport or 2020-2022 Ford Escape equipped with a 1.5L Dragon GTDI e ...
Jul 28, 2025Airbag Problem Affects 2022-2025 Chrysler Pacifica and Voyager Vehicles
If you own a Chrysler Pacifica or Voyager, your vehicle may be equipped with defective side curtain ...
Jul 24, 2025