Complaints & Recalls
Official Safety Recalls - Important!
1 RecallThese are official manufacturer recalls ordered by NHTSA for safety defects. If you own this vehicle, contact your dealer immediately for free repairs.
Hyundai Motor America
Safety Issue:
Hyundai Motor America (Hyundai) is recalling certain 2019-2020 Elantra, 2019-2021 Kona and Veloster vehicles equipped with 2.0L Nu MPI engines. The piston oil rings may not have been properly heat-treated, which could result in engine damage.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Mfg Campaign: 203
Recall Date: Apr 28, 2021
Consumer Complaints
186 ComplaintsHyundai Motor America
Defect Description:
ENGINE
Potential Consequences:
The contact owns a 2019 Hyundai Kona. The contact stated that the vehicle had failed to start after several attempts. The vehicle was towed to an independent mechanic, where it was diagnosed that the engine had failed and needed to be replaced. Additionally, the mechanic informed the contact that the engine oil was 4 quarts low; however, the contact stated that an oil change had recently been performed on the vehicle. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 21V301000 (Engine). The dealer and manufacturer were notified of the failure and informed the contact that the VIN was not included in the recall, and the vehicle was not covered under an extended warranty. The failure mileage was approximately 137,578.
Corrective Action:
The contact owns a 2019 Hyundai Kona. The contact stated that the vehicle had failed to start after several attempts. The vehicle was towed to an independent mechanic, where it was diagnosed that the engine had failed and needed to be replaced. Additionally, the mechanic informed the contact that the engine oil was 4 quarts low; however, the contact stated that an oil change had recently been performed on the vehicle. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 21V301000 (Engine). The dealer and manufacturer were notified of the failure and informed the contact that the VIN was not included in the recall, and the vehicle was not covered under an extended warranty. The failure mileage was approximately 137,578.
Additional Notes:
The contact owns a 2019 Hyundai Kona. The contact stated that the vehicle had failed to start after several attempts. The vehicle was towed to an independent mechanic, where it was diagnosed that the engine had failed and needed to be replaced. Additionally, the mechanic informed the contact that the engine oil was 4 quarts low; however, the contact stated that an oil change had recently been performed on the vehicle. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 21V301000 (Engine). The dealer and manufacturer were notified of the failure and informed the contact that the VIN was not included in the recall, and the vehicle was not covered under an extended warranty. The failure mileage was approximately 137,578.
Mfg Campaign: 11637672
Recall Date: Jan 22, 2025
Hyundai Motor America
Defect Description:
ELECTRICAL SYSTEM
Potential Consequences:
1. Driver’s side door locked up and it is impossible to unlock from the inside of the car manually or electrically. The door cannot be manually opened up from the outside OR the inside of the car. 2. My safety has been put at risk because of not being able to exit the car in case of an emergency. 3. Not yet. I have an appointment on 1/15/25 to get it looked at. 4. The car part has not been officially inspected by anyone yet. 5. No warning lamps appeared prior to this part failing.
Corrective Action:
1. Driver’s side door locked up and it is impossible to unlock from the inside of the car manually or electrically. The door cannot be manually opened up from the outside OR the inside of the car. 2. My safety has been put at risk because of not being able to exit the car in case of an emergency. 3. Not yet. I have an appointment on 1/15/25 to get it looked at. 4. The car part has not been officially inspected by anyone yet. 5. No warning lamps appeared prior to this part failing.
Additional Notes:
1. Driver’s side door locked up and it is impossible to unlock from the inside of the car manually or electrically. The door cannot be manually opened up from the outside OR the inside of the car. 2. My safety has been put at risk because of not being able to exit the car in case of an emergency. 3. Not yet. I have an appointment on 1/15/25 to get it looked at. 4. The car part has not been officially inspected by anyone yet. 5. No warning lamps appeared prior to this part failing.
Mfg Campaign: 11635742
Recall Date: Jan 13, 2025
Hyundai Motor America
Defect Description:
ENGINE
Potential Consequences:
On Christmas, Wednesday 25, 2024, my husband and son were in the car with the husband's driving and they heard a knocking sound as if going from the engine, and the car was losing power; there was no the "check engine sign" but it was remembered that few days before that there was the oil lamp sign lighting up for seconds and then disappearing, and also, the blind spot signal not working. So, we brought the car to our local mechanic, and he inspected the engine and said that the left back cylinder is broken. I called the Hyundai corporation and they advised to bring the car to the Hyundai repair shop- the car was then inspected in the shop - found some " lower rod bearing failure" but the Hyundai denied a Goodwill claim because of some maintenance neglect which has not been true - they had all our oil change receipts - I am the original owner - bought the car in finance and overall paid it off in 5 years - the car cost me 30K brand new- we were changing oil as soon as the message for the need to change oil would come up - every 5 - 5.5 K miles, all the records have been sent to the corporation, they have just said " neglect" out of the blue...They have denied the Goodwill engine replacement based on that falsely stated "neglect." I see there have been recalls for the oil ring piston issues in Konas including 2019 - for the engines 2.0L Nu MPI- the cylinders would start knocking from some overheat of the ring. Our engine is 1.6 GTI - but the engines are related, and our problem seems to be the same as in that 2.0L Nu MPI engine. Please, look for the similar cases for those Kona GTI Turbo engines for 2019- the one we have, seems that our Kona is fitting into the profile of those defected engines and the recalls like the one under the number 21V 301 203. Please, help!
Corrective Action:
On Christmas, Wednesday 25, 2024, my husband and son were in the car with the husband's driving and they heard a knocking sound as if going from the engine, and the car was losing power; there was no the "check engine sign" but it was remembered that few days before that there was the oil lamp sign lighting up for seconds and then disappearing, and also, the blind spot signal not working. So, we brought the car to our local mechanic, and he inspected the engine and said that the left back cylinder is broken. I called the Hyundai corporation and they advised to bring the car to the Hyundai repair shop- the car was then inspected in the shop - found some " lower rod bearing failure" but the Hyundai denied a Goodwill claim because of some maintenance neglect which has not been true - they had all our oil change receipts - I am the original owner - bought the car in finance and overall paid it off in 5 years - the car cost me 30K brand new- we were changing oil as soon as the message for the need to change oil would come up - every 5 - 5.5 K miles, all the records have been sent to the corporation, they have just said " neglect" out of the blue...They have denied the Goodwill engine replacement based on that falsely stated "neglect." I see there have been recalls for the oil ring piston issues in Konas including 2019 - for the engines 2.0L Nu MPI- the cylinders would start knocking from some overheat of the ring. Our engine is 1.6 GTI - but the engines are related, and our problem seems to be the same as in that 2.0L Nu MPI engine. Please, look for the similar cases for those Kona GTI Turbo engines for 2019- the one we have, seems that our Kona is fitting into the profile of those defected engines and the recalls like the one under the number 21V 301 203. Please, help!
Additional Notes:
On Christmas, Wednesday 25, 2024, my husband and son were in the car with the husband's driving and they heard a knocking sound as if going from the engine, and the car was losing power; there was no the "check engine sign" but it was remembered that few days before that there was the oil lamp sign lighting up for seconds and then disappearing, and also, the blind spot signal not working. So, we brought the car to our local mechanic, and he inspected the engine and said that the left back cylinder is broken. I called the Hyundai corporation and they advised to bring the car to the Hyundai repair shop- the car was then inspected in the shop - found some " lower rod bearing failure" but the Hyundai denied a Goodwill claim because of some maintenance neglect which has not been true - they had all our oil change receipts - I am the original owner - bought the car in finance and overall paid it off in 5 years - the car cost me 30K brand new- we were changing oil as soon as the message for the need to change oil would come up - every 5 - 5.5 K miles, all the records have been sent to the corporation, they have just said " neglect" out of the blue...They have denied the Goodwill engine replacement based on that falsely stated "neglect." I see there have been recalls for the oil ring piston issues in Konas including 2019 - for the engines 2.0L Nu MPI- the cylinders would start knocking from some overheat of the ring. Our engine is 1.6 GTI - but the engines are related, and our problem seems to be the same as in that 2.0L Nu MPI engine. Please, look for the similar cases for those Kona GTI Turbo engines for 2019- the one we have, seems that our Kona is fitting into the profile of those defected engines and the recalls like the one under the number 21V 301 203. Please, help!
Mfg Campaign: 11635372
Recall Date: Jan 10, 2025
Hyundai Motor America
Defect Description:
ENGINE
Potential Consequences:
My 2019 Kona seems to have the same o-rings that are in the hybrid model. It keeps stalling and losing oil consistently. This engine is no good and needs to be replaced!
Corrective Action:
My 2019 Kona seems to have the same o-rings that are in the hybrid model. It keeps stalling and losing oil consistently. This engine is no good and needs to be replaced!
Additional Notes:
My 2019 Kona seems to have the same o-rings that are in the hybrid model. It keeps stalling and losing oil consistently. This engine is no good and needs to be replaced!
Mfg Campaign: 11634347
Recall Date: Jan 6, 2025
Hyundai Motor America
Defect Description:
ENGINE
Potential Consequences:
It seems to be an issue with the camshaft and/or timing. It has a permanent diagnostic trouble code for p0017 and p0014 (two issues that they have claimed to have fixed twice now by replacing my engine). Due to this issue, I was stranded on the side of a busy road for multiple hours at night way back in March. This issue has been repeatedly “fixed” but the code readers keep showing it and the check engine light has never turned off. Hyundai of Danbury has looked at it multiple times and has replaced the engine twice in an attempt to fix it. However, both times I got engines with the same issue. Both times I brought it to a Hyundai Dealership to be fixed. There was no warning when my car broke down the first time. It just stopped in the middle of a busy road. No noise or smell or smoke. Once I got it towed to Danbury Hyundai, they replaced the engine (March 3 - April 24) and it started up again but the check engine light was on. It has been replaced twice and both times the light was on. It was replaced a second time between July 3rd and October 20th. I only have one car and needed friends and family to bring me to and from work (1 hour away) every day while the dealership worked on my car. A camshaft or timing issue should not take 5 months to fix.
Corrective Action:
It seems to be an issue with the camshaft and/or timing. It has a permanent diagnostic trouble code for p0017 and p0014 (two issues that they have claimed to have fixed twice now by replacing my engine). Due to this issue, I was stranded on the side of a busy road for multiple hours at night way back in March. This issue has been repeatedly “fixed” but the code readers keep showing it and the check engine light has never turned off. Hyundai of Danbury has looked at it multiple times and has replaced the engine twice in an attempt to fix it. However, both times I got engines with the same issue. Both times I brought it to a Hyundai Dealership to be fixed. There was no warning when my car broke down the first time. It just stopped in the middle of a busy road. No noise or smell or smoke. Once I got it towed to Danbury Hyundai, they replaced the engine (March 3 - April 24) and it started up again but the check engine light was on. It has been replaced twice and both times the light was on. It was replaced a second time between July 3rd and October 20th. I only have one car and needed friends and family to bring me to and from work (1 hour away) every day while the dealership worked on my car. A camshaft or timing issue should not take 5 months to fix.
Additional Notes:
It seems to be an issue with the camshaft and/or timing. It has a permanent diagnostic trouble code for p0017 and p0014 (two issues that they have claimed to have fixed twice now by replacing my engine). Due to this issue, I was stranded on the side of a busy road for multiple hours at night way back in March. This issue has been repeatedly “fixed” but the code readers keep showing it and the check engine light has never turned off. Hyundai of Danbury has looked at it multiple times and has replaced the engine twice in an attempt to fix it. However, both times I got engines with the same issue. Both times I brought it to a Hyundai Dealership to be fixed. There was no warning when my car broke down the first time. It just stopped in the middle of a busy road. No noise or smell or smoke. Once I got it towed to Danbury Hyundai, they replaced the engine (March 3 - April 24) and it started up again but the check engine light was on. It has been replaced twice and both times the light was on. It was replaced a second time between July 3rd and October 20th. I only have one car and needed friends and family to bring me to and from work (1 hour away) every day while the dealership worked on my car. A camshaft or timing issue should not take 5 months to fix.
Mfg Campaign: 11630759
Recall Date: Dec 14, 2024
Hyundai Motor America
Defect Description:
ENGINE AND ENGINE COOLING
Potential Consequences:
The contact owns a 2019 Hyundai Kona. The contact stated upon starting the vehicle, the vehicle made an abnormal sound. Additionally, the contact stated while driving at various speeds, the vehicle made an abnormal knocking and clicking sound. The contact stated that the vehicle had experienced engine hesitation intermittently, and the failure became permanent. The contact stated that the vehicle was experiencing excessive oil consumption. The contact had noticed that the oil level was significantly low, and the oil was significantly black at 500 miles after an oil change. The contact stated that on other occasions, the oil was significantly black while at the normal full. The contact stated that while his wife was driving 20 MPH uphill, the vehicle stalled and started rolling backwards. Several unknown warning lights were illuminated. The vehicle lost power steering and braking functionality, causing the driver to lose control of the vehicle. The vehicle then slowly rolled back off the road and struck a small tree. The contact did not sustain any injuries. The vehicle was restarted after an hour and half. The contact stated that the vehicle stalled while driving 10 MPH on another occasion and was able to restart after 15 minutes. The vehicle was taken to the dealer, where the fault codes were cleared; however, the failure persisted. The vehicle was taken to the dealer, where DTC: P0301 was retrieved. The dealer diagnosed that cylinder #1 had a misfire due to the valve cover gasket leaking oil into cylinder #1. The dealer determined that the valve cover gasket, the spark plugs, and the oil filter needed to be replaced. Additionally, the dealer recommended an engine restoration and fuel induction service. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 21V301000 (Engine); however, the VIN was not included. The manufacturer was notified of the failure and a case was opened. The failure mileage was approximately 40,000.
Corrective Action:
The contact owns a 2019 Hyundai Kona. The contact stated upon starting the vehicle, the vehicle made an abnormal sound. Additionally, the contact stated while driving at various speeds, the vehicle made an abnormal knocking and clicking sound. The contact stated that the vehicle had experienced engine hesitation intermittently, and the failure became permanent. The contact stated that the vehicle was experiencing excessive oil consumption. The contact had noticed that the oil level was significantly low, and the oil was significantly black at 500 miles after an oil change. The contact stated that on other occasions, the oil was significantly black while at the normal full. The contact stated that while his wife was driving 20 MPH uphill, the vehicle stalled and started rolling backwards. Several unknown warning lights were illuminated. The vehicle lost power steering and braking functionality, causing the driver to lose control of the vehicle. The vehicle then slowly rolled back off the road and struck a small tree. The contact did not sustain any injuries. The vehicle was restarted after an hour and half. The contact stated that the vehicle stalled while driving 10 MPH on another occasion and was able to restart after 15 minutes. The vehicle was taken to the dealer, where the fault codes were cleared; however, the failure persisted. The vehicle was taken to the dealer, where DTC: P0301 was retrieved. The dealer diagnosed that cylinder #1 had a misfire due to the valve cover gasket leaking oil into cylinder #1. The dealer determined that the valve cover gasket, the spark plugs, and the oil filter needed to be replaced. Additionally, the dealer recommended an engine restoration and fuel induction service. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 21V301000 (Engine); however, the VIN was not included. The manufacturer was notified of the failure and a case was opened. The failure mileage was approximately 40,000.
Additional Notes:
The contact owns a 2019 Hyundai Kona. The contact stated upon starting the vehicle, the vehicle made an abnormal sound. Additionally, the contact stated while driving at various speeds, the vehicle made an abnormal knocking and clicking sound. The contact stated that the vehicle had experienced engine hesitation intermittently, and the failure became permanent. The contact stated that the vehicle was experiencing excessive oil consumption. The contact had noticed that the oil level was significantly low, and the oil was significantly black at 500 miles after an oil change. The contact stated that on other occasions, the oil was significantly black while at the normal full. The contact stated that while his wife was driving 20 MPH uphill, the vehicle stalled and started rolling backwards. Several unknown warning lights were illuminated. The vehicle lost power steering and braking functionality, causing the driver to lose control of the vehicle. The vehicle then slowly rolled back off the road and struck a small tree. The contact did not sustain any injuries. The vehicle was restarted after an hour and half. The contact stated that the vehicle stalled while driving 10 MPH on another occasion and was able to restart after 15 minutes. The vehicle was taken to the dealer, where the fault codes were cleared; however, the failure persisted. The vehicle was taken to the dealer, where DTC: P0301 was retrieved. The dealer diagnosed that cylinder #1 had a misfire due to the valve cover gasket leaking oil into cylinder #1. The dealer determined that the valve cover gasket, the spark plugs, and the oil filter needed to be replaced. Additionally, the dealer recommended an engine restoration and fuel induction service. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 21V301000 (Engine); however, the VIN was not included. The manufacturer was notified of the failure and a case was opened. The failure mileage was approximately 40,000.
Mfg Campaign: 11628840
Recall Date: Dec 4, 2024
Hyundai Motor America
Defect Description:
ENGINE
Potential Consequences:
The contact owns a 2019 Hyundai Kona. The contact stated upon starting the vehicle, the vehicle made an abnormal sound. Additionally, the contact stated while driving at various speeds, the vehicle made an abnormal knocking and clicking sound. The contact stated that the vehicle had experienced engine hesitation intermittently, and the failure became permanent. The contact stated that the vehicle was experiencing excessive oil consumption. The contact had noticed that the oil level was significantly low, and the oil was significantly black at 500 miles after an oil change. The contact stated that on other occasions, the oil was significantly black while at the normal full. The contact stated that while his wife was driving 20 MPH uphill, the vehicle stalled and started rolling backwards. Several unknown warning lights were illuminated. The vehicle lost power steering and braking functionality, causing the driver to lose control of the vehicle. The vehicle then slowly rolled back off the road and struck a small tree. The contact did not sustain any injuries. The vehicle was restarted after an hour and half. The contact stated that the vehicle stalled while driving 10 MPH on another occasion and was able to restart after 15 minutes. The vehicle was taken to the dealer, where the fault codes were cleared; however, the failure persisted. The vehicle was taken to the dealer, where DTC: P0301 was retrieved. The dealer diagnosed that cylinder #1 had a misfire due to the valve cover gasket leaking oil into cylinder #1. The dealer determined that the valve cover gasket, the spark plugs, and the oil filter needed to be replaced. Additionally, the dealer recommended an engine restoration and fuel induction service. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 21V301000 (Engine); however, the VIN was not included. The manufacturer was notified of the failure and a case was opened. The failure mileage was approximately 40,000.
Corrective Action:
The contact owns a 2019 Hyundai Kona. The contact stated upon starting the vehicle, the vehicle made an abnormal sound. Additionally, the contact stated while driving at various speeds, the vehicle made an abnormal knocking and clicking sound. The contact stated that the vehicle had experienced engine hesitation intermittently, and the failure became permanent. The contact stated that the vehicle was experiencing excessive oil consumption. The contact had noticed that the oil level was significantly low, and the oil was significantly black at 500 miles after an oil change. The contact stated that on other occasions, the oil was significantly black while at the normal full. The contact stated that while his wife was driving 20 MPH uphill, the vehicle stalled and started rolling backwards. Several unknown warning lights were illuminated. The vehicle lost power steering and braking functionality, causing the driver to lose control of the vehicle. The vehicle then slowly rolled back off the road and struck a small tree. The contact did not sustain any injuries. The vehicle was restarted after an hour and half. The contact stated that the vehicle stalled while driving 10 MPH on another occasion and was able to restart after 15 minutes. The vehicle was taken to the dealer, where the fault codes were cleared; however, the failure persisted. The vehicle was taken to the dealer, where DTC: P0301 was retrieved. The dealer diagnosed that cylinder #1 had a misfire due to the valve cover gasket leaking oil into cylinder #1. The dealer determined that the valve cover gasket, the spark plugs, and the oil filter needed to be replaced. Additionally, the dealer recommended an engine restoration and fuel induction service. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 21V301000 (Engine); however, the VIN was not included. The manufacturer was notified of the failure and a case was opened. The failure mileage was approximately 40,000.
Additional Notes:
The contact owns a 2019 Hyundai Kona. The contact stated upon starting the vehicle, the vehicle made an abnormal sound. Additionally, the contact stated while driving at various speeds, the vehicle made an abnormal knocking and clicking sound. The contact stated that the vehicle had experienced engine hesitation intermittently, and the failure became permanent. The contact stated that the vehicle was experiencing excessive oil consumption. The contact had noticed that the oil level was significantly low, and the oil was significantly black at 500 miles after an oil change. The contact stated that on other occasions, the oil was significantly black while at the normal full. The contact stated that while his wife was driving 20 MPH uphill, the vehicle stalled and started rolling backwards. Several unknown warning lights were illuminated. The vehicle lost power steering and braking functionality, causing the driver to lose control of the vehicle. The vehicle then slowly rolled back off the road and struck a small tree. The contact did not sustain any injuries. The vehicle was restarted after an hour and half. The contact stated that the vehicle stalled while driving 10 MPH on another occasion and was able to restart after 15 minutes. The vehicle was taken to the dealer, where the fault codes were cleared; however, the failure persisted. The vehicle was taken to the dealer, where DTC: P0301 was retrieved. The dealer diagnosed that cylinder #1 had a misfire due to the valve cover gasket leaking oil into cylinder #1. The dealer determined that the valve cover gasket, the spark plugs, and the oil filter needed to be replaced. Additionally, the dealer recommended an engine restoration and fuel induction service. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 21V301000 (Engine); however, the VIN was not included. The manufacturer was notified of the failure and a case was opened. The failure mileage was approximately 40,000.
Mfg Campaign: 11628840
Recall Date: Dec 4, 2024
Hyundai Motor America
Defect Description:
UNKNOWN OR OTHER
Potential Consequences:
Sunroof on Hyundai Kona spontaneously exploded in cold weather driving on the freeway early in the morning after being parked in the warm garage overnight. Read about a class action lawsuit for Hyundai panoramic sunroofs but Kona is a standard sunroof; however, cases seem the same in terms of spontaneous explosion.
Corrective Action:
Sunroof on Hyundai Kona spontaneously exploded in cold weather driving on the freeway early in the morning after being parked in the warm garage overnight. Read about a class action lawsuit for Hyundai panoramic sunroofs but Kona is a standard sunroof; however, cases seem the same in terms of spontaneous explosion.
Additional Notes:
Sunroof on Hyundai Kona spontaneously exploded in cold weather driving on the freeway early in the morning after being parked in the warm garage overnight. Read about a class action lawsuit for Hyundai panoramic sunroofs but Kona is a standard sunroof; however, cases seem the same in terms of spontaneous explosion.
Mfg Campaign: 11628376
Recall Date: Dec 2, 2024
Hyundai Motor America
Defect Description:
POWER TRAIN
Potential Consequences:
As I was driving home, my Kona started slowing down until it totally stopped. I tried the the gas pedal again but it didn’t move, electrical was on, no warning lights. I turned my Kona off, turned it back on again and drove the rest of way home. I was lucky I was on an empty road no other cars behind me as I drive everyday to and from work. I called Hyundai dealer next morning about the problem ,he did asked if I had heard a knocking sound. I said yes ,the week or so I heard a knocking sound twice but not for long, seemed to have disappeared. I didn’t want to drive the car to the dealer afraid it would stop on the highway so I had it towed. Service person said he would check if it is under warranty but there is no recall on my Kona.
Corrective Action:
As I was driving home, my Kona started slowing down until it totally stopped. I tried the the gas pedal again but it didn’t move, electrical was on, no warning lights. I turned my Kona off, turned it back on again and drove the rest of way home. I was lucky I was on an empty road no other cars behind me as I drive everyday to and from work. I called Hyundai dealer next morning about the problem ,he did asked if I had heard a knocking sound. I said yes ,the week or so I heard a knocking sound twice but not for long, seemed to have disappeared. I didn’t want to drive the car to the dealer afraid it would stop on the highway so I had it towed. Service person said he would check if it is under warranty but there is no recall on my Kona.
Additional Notes:
As I was driving home, my Kona started slowing down until it totally stopped. I tried the the gas pedal again but it didn’t move, electrical was on, no warning lights. I turned my Kona off, turned it back on again and drove the rest of way home. I was lucky I was on an empty road no other cars behind me as I drive everyday to and from work. I called Hyundai dealer next morning about the problem ,he did asked if I had heard a knocking sound. I said yes ,the week or so I heard a knocking sound twice but not for long, seemed to have disappeared. I didn’t want to drive the car to the dealer afraid it would stop on the highway so I had it towed. Service person said he would check if it is under warranty but there is no recall on my Kona.
Mfg Campaign: 11623250
Recall Date: Nov 2, 2024
Hyundai Motor America
Defect Description:
ELECTRICAL SYSTEM
Potential Consequences:
As I was driving home, my Kona started slowing down until it totally stopped. I tried the the gas pedal again but it didn’t move, electrical was on, no warning lights. I turned my Kona off, turned it back on again and drove the rest of way home. I was lucky I was on an empty road no other cars behind me as I drive everyday to and from work. I called Hyundai dealer next morning about the problem ,he did asked if I had heard a knocking sound. I said yes ,the week or so I heard a knocking sound twice but not for long, seemed to have disappeared. I didn’t want to drive the car to the dealer afraid it would stop on the highway so I had it towed. Service person said he would check if it is under warranty but there is no recall on my Kona.
Corrective Action:
As I was driving home, my Kona started slowing down until it totally stopped. I tried the the gas pedal again but it didn’t move, electrical was on, no warning lights. I turned my Kona off, turned it back on again and drove the rest of way home. I was lucky I was on an empty road no other cars behind me as I drive everyday to and from work. I called Hyundai dealer next morning about the problem ,he did asked if I had heard a knocking sound. I said yes ,the week or so I heard a knocking sound twice but not for long, seemed to have disappeared. I didn’t want to drive the car to the dealer afraid it would stop on the highway so I had it towed. Service person said he would check if it is under warranty but there is no recall on my Kona.
Additional Notes:
As I was driving home, my Kona started slowing down until it totally stopped. I tried the the gas pedal again but it didn’t move, electrical was on, no warning lights. I turned my Kona off, turned it back on again and drove the rest of way home. I was lucky I was on an empty road no other cars behind me as I drive everyday to and from work. I called Hyundai dealer next morning about the problem ,he did asked if I had heard a knocking sound. I said yes ,the week or so I heard a knocking sound twice but not for long, seemed to have disappeared. I didn’t want to drive the car to the dealer afraid it would stop on the highway so I had it towed. Service person said he would check if it is under warranty but there is no recall on my Kona.
Mfg Campaign: 11623250
Recall Date: Nov 2, 2024
Hyundai Motor America
Defect Description:
FUEL/PROPULSION SYSTEM
Potential Consequences:
One day after I filled my gas tank, I noticed a strong gasoline smell outside the car. The next morning, I noticed a huge puddle on the pavement under the fuel tank. At least a gallon of gasoline must have leaked out overnight while the car was parked. I also noticed that gasoline continued to drip down from the fuel tank to the ground. I then had the car towed to the mechanic and they discovered a crack in the mounting flange on the top of the plastic fuel pump. The car was not in a collision and there was no external force that could have caused the fuel pump to crack and leak.
Corrective Action:
One day after I filled my gas tank, I noticed a strong gasoline smell outside the car. The next morning, I noticed a huge puddle on the pavement under the fuel tank. At least a gallon of gasoline must have leaked out overnight while the car was parked. I also noticed that gasoline continued to drip down from the fuel tank to the ground. I then had the car towed to the mechanic and they discovered a crack in the mounting flange on the top of the plastic fuel pump. The car was not in a collision and there was no external force that could have caused the fuel pump to crack and leak.
Additional Notes:
One day after I filled my gas tank, I noticed a strong gasoline smell outside the car. The next morning, I noticed a huge puddle on the pavement under the fuel tank. At least a gallon of gasoline must have leaked out overnight while the car was parked. I also noticed that gasoline continued to drip down from the fuel tank to the ground. I then had the car towed to the mechanic and they discovered a crack in the mounting flange on the top of the plastic fuel pump. The car was not in a collision and there was no external force that could have caused the fuel pump to crack and leak.
Mfg Campaign: 11623149
Recall Date: Nov 1, 2024
Hyundai Motor America
Defect Description:
ENGINE
Potential Consequences:
In line with NHTSA recall notice 21V301000, affecting 2019 Hyundai Kona's for piston oil ring defects, I believe the Date of Manufacture (DoM) range should be extended. Currently, the recall notice indicates vehicles manufactured between 11/2/2018 and 9/1/2020 are impacted, however my vehicle, with the indicated VIN, was manufactured 10/31/2018, two days before the indicated start date on this recall notice. My vehicle has been experiencing many of the same indicated symptoms of the faulty piston oil ring, such as abnormal knocking/rattling from the engine during acceleration, hesitation and engine dying randomly (while in motion), and significant oil consumption (half of the engine's capacity in just 2-3K miles. Given the symptom matches and the fact that my vehicle's DoM is within 2 days of the indicated recall start point, I believe it should be included in the above mentioned recall notice.
Corrective Action:
In line with NHTSA recall notice 21V301000, affecting 2019 Hyundai Kona's for piston oil ring defects, I believe the Date of Manufacture (DoM) range should be extended. Currently, the recall notice indicates vehicles manufactured between 11/2/2018 and 9/1/2020 are impacted, however my vehicle, with the indicated VIN, was manufactured 10/31/2018, two days before the indicated start date on this recall notice. My vehicle has been experiencing many of the same indicated symptoms of the faulty piston oil ring, such as abnormal knocking/rattling from the engine during acceleration, hesitation and engine dying randomly (while in motion), and significant oil consumption (half of the engine's capacity in just 2-3K miles. Given the symptom matches and the fact that my vehicle's DoM is within 2 days of the indicated recall start point, I believe it should be included in the above mentioned recall notice.
Additional Notes:
In line with NHTSA recall notice 21V301000, affecting 2019 Hyundai Kona's for piston oil ring defects, I believe the Date of Manufacture (DoM) range should be extended. Currently, the recall notice indicates vehicles manufactured between 11/2/2018 and 9/1/2020 are impacted, however my vehicle, with the indicated VIN, was manufactured 10/31/2018, two days before the indicated start date on this recall notice. My vehicle has been experiencing many of the same indicated symptoms of the faulty piston oil ring, such as abnormal knocking/rattling from the engine during acceleration, hesitation and engine dying randomly (while in motion), and significant oil consumption (half of the engine's capacity in just 2-3K miles. Given the symptom matches and the fact that my vehicle's DoM is within 2 days of the indicated recall start point, I believe it should be included in the above mentioned recall notice.
Mfg Campaign: 11622975
Recall Date: Oct 31, 2024
Hyundai Motor America
Defect Description:
ENGINE AND ENGINE COOLING
Potential Consequences:
The contact owns a 2019 Hyundai Kona. The contact stated while driving 45 MPH, the accelerator pedal was depressed; however, the vehicle was losing motive power. The contact stated that the vehicle then stalled. The contact pulled over and waited approximately 20 minutes before restarting the vehicle. The contact stated that the failure was intermittent but had occurred at various speeds. The contact stated that the check engine warning light only recently illuminated. Additionally, the contact stated that the vehicle had to be taken for an oil change monthly. The contact stated that there was no indication of an oil leak on the driveway. The contact had taken the vehicle to a local dealer however, the dealer was unable to duplicate the failure. The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 117,000.
Corrective Action:
The contact owns a 2019 Hyundai Kona. The contact stated while driving 45 MPH, the accelerator pedal was depressed; however, the vehicle was losing motive power. The contact stated that the vehicle then stalled. The contact pulled over and waited approximately 20 minutes before restarting the vehicle. The contact stated that the failure was intermittent but had occurred at various speeds. The contact stated that the check engine warning light only recently illuminated. Additionally, the contact stated that the vehicle had to be taken for an oil change monthly. The contact stated that there was no indication of an oil leak on the driveway. The contact had taken the vehicle to a local dealer however, the dealer was unable to duplicate the failure. The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 117,000.
Additional Notes:
The contact owns a 2019 Hyundai Kona. The contact stated while driving 45 MPH, the accelerator pedal was depressed; however, the vehicle was losing motive power. The contact stated that the vehicle then stalled. The contact pulled over and waited approximately 20 minutes before restarting the vehicle. The contact stated that the failure was intermittent but had occurred at various speeds. The contact stated that the check engine warning light only recently illuminated. Additionally, the contact stated that the vehicle had to be taken for an oil change monthly. The contact stated that there was no indication of an oil leak on the driveway. The contact had taken the vehicle to a local dealer however, the dealer was unable to duplicate the failure. The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 117,000.
Mfg Campaign: 11612994
Recall Date: Sep 6, 2024
Hyundai Motor America
Defect Description:
ENGINE
Potential Consequences:
My engine seems to have failed due to bad oil piston rings and Hyundai/ the dealership refused to look at it for that and denied my claim. Almost 3 weeks ago, my check engine light came on after (solid) after getting gas. It was running fine and I had an oil change appointment that Saturday so it should be good (I had a coupon expiring, so I was taking it in like 400 miles early for it's oil change). The car started losing a little bit power throughout the week- it didn't have the get up and go it usually does. On Saturday, first thing in the morning, on my way to my 8 am oil change, my car started a little rough (it had never done that before). I drive like 5 miles, then all of a sudden my car stutters, 2 blocks later dies, it restarted fine, but made a horrible noise. I drove it the block to the oil change place and my car was completely out of oil. No oil light ever came on and I have never been less than a quart (more than acceptable) at an oil change. There was no visible oil leak in my parking spot. It was towed to the dealership and the engine is blown. There has never been any visible oil leak and I have all records on carfax imputed by the mechanics.
Corrective Action:
My engine seems to have failed due to bad oil piston rings and Hyundai/ the dealership refused to look at it for that and denied my claim. Almost 3 weeks ago, my check engine light came on after (solid) after getting gas. It was running fine and I had an oil change appointment that Saturday so it should be good (I had a coupon expiring, so I was taking it in like 400 miles early for it's oil change). The car started losing a little bit power throughout the week- it didn't have the get up and go it usually does. On Saturday, first thing in the morning, on my way to my 8 am oil change, my car started a little rough (it had never done that before). I drive like 5 miles, then all of a sudden my car stutters, 2 blocks later dies, it restarted fine, but made a horrible noise. I drove it the block to the oil change place and my car was completely out of oil. No oil light ever came on and I have never been less than a quart (more than acceptable) at an oil change. There was no visible oil leak in my parking spot. It was towed to the dealership and the engine is blown. There has never been any visible oil leak and I have all records on carfax imputed by the mechanics.
Additional Notes:
My engine seems to have failed due to bad oil piston rings and Hyundai/ the dealership refused to look at it for that and denied my claim. Almost 3 weeks ago, my check engine light came on after (solid) after getting gas. It was running fine and I had an oil change appointment that Saturday so it should be good (I had a coupon expiring, so I was taking it in like 400 miles early for it's oil change). The car started losing a little bit power throughout the week- it didn't have the get up and go it usually does. On Saturday, first thing in the morning, on my way to my 8 am oil change, my car started a little rough (it had never done that before). I drive like 5 miles, then all of a sudden my car stutters, 2 blocks later dies, it restarted fine, but made a horrible noise. I drove it the block to the oil change place and my car was completely out of oil. No oil light ever came on and I have never been less than a quart (more than acceptable) at an oil change. There was no visible oil leak in my parking spot. It was towed to the dealership and the engine is blown. There has never been any visible oil leak and I have all records on carfax imputed by the mechanics.
Mfg Campaign: 11611868
Recall Date: Aug 30, 2024
Hyundai Motor America
Defect Description:
ENGINE
Potential Consequences:
My vehicle starting stalling when driving at low speeds. It goes completely idle, I have to put it in park and restart the car. This happens when I am turning, have to slow down for traffic, etc. No engine light came on when this first started happening a few months ago, but now an engine light has popped on. It is available for inspection.
Corrective Action:
My vehicle starting stalling when driving at low speeds. It goes completely idle, I have to put it in park and restart the car. This happens when I am turning, have to slow down for traffic, etc. No engine light came on when this first started happening a few months ago, but now an engine light has popped on. It is available for inspection.
Additional Notes:
My vehicle starting stalling when driving at low speeds. It goes completely idle, I have to put it in park and restart the car. This happens when I am turning, have to slow down for traffic, etc. No engine light came on when this first started happening a few months ago, but now an engine light has popped on. It is available for inspection.
Mfg Campaign: 11611488
Recall Date: Aug 28, 2024
Hyundai Motor America
Defect Description:
ENGINE
Potential Consequences:
Transmission need to be replaced.
Corrective Action:
Transmission need to be replaced.
Additional Notes:
Transmission need to be replaced.
Mfg Campaign: 11610868
Recall Date: Aug 26, 2024
Hyundai Motor America
Defect Description:
ELECTRICAL SYSTEM
Potential Consequences:
Transmission need to be replaced.
Corrective Action:
Transmission need to be replaced.
Additional Notes:
Transmission need to be replaced.
Mfg Campaign: 11610868
Recall Date: Aug 26, 2024
Hyundai Motor America
Defect Description:
ENGINE
Potential Consequences:
The contact owns a 2019 Hyundai Kona. The contact stated while driving at an undisclosed speed, the vehicle stopped in the middle of the road. The check engine warning light was illuminated. The contact stated that the vehicle was almost rear-ended. The vehicle was taken to an independent mechanic where it was diagnosed with engine failure. The contact was advised to take the vehicle back to the dealer. The vehicle was taken back to the dealer; however, the failure was not duplicated. The contact stated that an oil consumption test was completed; however, the contact stated that the vehicle was in worse condition. The manufacturer was not made aware of the failure. The failure mileage was approximately 36,500.
Corrective Action:
The contact owns a 2019 Hyundai Kona. The contact stated while driving at an undisclosed speed, the vehicle stopped in the middle of the road. The check engine warning light was illuminated. The contact stated that the vehicle was almost rear-ended. The vehicle was taken to an independent mechanic where it was diagnosed with engine failure. The contact was advised to take the vehicle back to the dealer. The vehicle was taken back to the dealer; however, the failure was not duplicated. The contact stated that an oil consumption test was completed; however, the contact stated that the vehicle was in worse condition. The manufacturer was not made aware of the failure. The failure mileage was approximately 36,500.
Additional Notes:
The contact owns a 2019 Hyundai Kona. The contact stated while driving at an undisclosed speed, the vehicle stopped in the middle of the road. The check engine warning light was illuminated. The contact stated that the vehicle was almost rear-ended. The vehicle was taken to an independent mechanic where it was diagnosed with engine failure. The contact was advised to take the vehicle back to the dealer. The vehicle was taken back to the dealer; however, the failure was not duplicated. The contact stated that an oil consumption test was completed; however, the contact stated that the vehicle was in worse condition. The manufacturer was not made aware of the failure. The failure mileage was approximately 36,500.
Mfg Campaign: 11606166
Recall Date: Aug 2, 2024
Hyundai Motor America
Defect Description:
FUEL/PROPULSION SYSTEM
Potential Consequences:
engine light began flashing while driving. Stopped vehicle and turned off engine. Vehicle would not restart. Mechanic says there is no compression and I need a new engine. I contacted the manufacturer who advised my engine was subject to recall but since I am a second owner and the first owner did not get the engine replaced there is nothing I can do.
Corrective Action:
engine light began flashing while driving. Stopped vehicle and turned off engine. Vehicle would not restart. Mechanic says there is no compression and I need a new engine. I contacted the manufacturer who advised my engine was subject to recall but since I am a second owner and the first owner did not get the engine replaced there is nothing I can do.
Additional Notes:
engine light began flashing while driving. Stopped vehicle and turned off engine. Vehicle would not restart. Mechanic says there is no compression and I need a new engine. I contacted the manufacturer who advised my engine was subject to recall but since I am a second owner and the first owner did not get the engine replaced there is nothing I can do.
Mfg Campaign: 11603972
Recall Date: Jul 23, 2024
Hyundai Motor America
Defect Description:
ELECTRICAL SYSTEM
Potential Consequences:
Driving on the highway [XXX] ) during rain. Traffic moving stop and go slow. Before I knew what had happened, my car hit the back bumper of a Chevy Suburban. My car gave no auto warning, the windshield wipers barely worked, and I believe the electric systems had stopped. Radio and air-conditioning. [XXX] My car bumper and grill were messed up. And I received pain in my right shoulder. The Suburban had a trailer hook-up jammed inside my front bumper grill; my vehicle received all the damage. The other driver's vehicle had no harm. My vehicle damage to the car was over a thousand dollars. And I was left with a shoulder injury. Car insurance paid for the damage to my 2019 Hyundai Kona SUV's all-wheel drive, with me paying a portion. After work was completed, all the electrical systems, including air conditioning, lights, wipers, and radio, didn't work. Fuse work was checked and found, but no power was getting into the system to operate functions that required electricity. The car started up, but the side lights but not the front lights, air conditioning, and the issue of tight steering now. The car tech stated they only installed a new bumper, and the grill did not work on the areas that are now not working. Tech said the lights and wipers were working but are not working now. Driving the vehicle will be limited based on these issues. The fuses appear good, but no power is getting into the box that powers the various items that are not working. I believe this car is a Lemon, and the dealership was aware of these issues and never told me the car had recalls. According to the internet, the tech who replaced my bumper stated that these issues are what the 2019 Hyundai Kona vehicle. Today (7-22-24), I drove my car from the auto shop with a new bumper and with hesitation and fear because the wipers and lights were not working, the air conditioning was out, and it is about to rain. The tech stated they were working earlier but are not working now. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMA
Corrective Action:
Driving on the highway [XXX] ) during rain. Traffic moving stop and go slow. Before I knew what had happened, my car hit the back bumper of a Chevy Suburban. My car gave no auto warning, the windshield wipers barely worked, and I believe the electric systems had stopped. Radio and air-conditioning. [XXX] My car bumper and grill were messed up. And I received pain in my right shoulder. The Suburban had a trailer hook-up jammed inside my front bumper grill; my vehicle received all the damage. The other driver's vehicle had no harm. My vehicle damage to the car was over a thousand dollars. And I was left with a shoulder injury. Car insurance paid for the damage to my 2019 Hyundai Kona SUV's all-wheel drive, with me paying a portion. After work was completed, all the electrical systems, including air conditioning, lights, wipers, and radio, didn't work. Fuse work was checked and found, but no power was getting into the system to operate functions that required electricity. The car started up, but the side lights but not the front lights, air conditioning, and the issue of tight steering now. The car tech stated they only installed a new bumper, and the grill did not work on the areas that are now not working. Tech said the lights and wipers were working but are not working now. Driving the vehicle will be limited based on these issues. The fuses appear good, but no power is getting into the box that powers the various items that are not working. I believe this car is a Lemon, and the dealership was aware of these issues and never told me the car had recalls. According to the internet, the tech who replaced my bumper stated that these issues are what the 2019 Hyundai Kona vehicle. Today (7-22-24), I drove my car from the auto shop with a new bumper and with hesitation and fear because the wipers and lights were not working, the air conditioning was out, and it is about to rain. The tech stated they were working earlier but are not working now. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMA
Additional Notes:
Driving on the highway [XXX] ) during rain. Traffic moving stop and go slow. Before I knew what had happened, my car hit the back bumper of a Chevy Suburban. My car gave no auto warning, the windshield wipers barely worked, and I believe the electric systems had stopped. Radio and air-conditioning. [XXX] My car bumper and grill were messed up. And I received pain in my right shoulder. The Suburban had a trailer hook-up jammed inside my front bumper grill; my vehicle received all the damage. The other driver's vehicle had no harm. My vehicle damage to the car was over a thousand dollars. And I was left with a shoulder injury. Car insurance paid for the damage to my 2019 Hyundai Kona SUV's all-wheel drive, with me paying a portion. After work was completed, all the electrical systems, including air conditioning, lights, wipers, and radio, didn't work. Fuse work was checked and found, but no power was getting into the system to operate functions that required electricity. The car started up, but the side lights but not the front lights, air conditioning, and the issue of tight steering now. The car tech stated they only installed a new bumper, and the grill did not work on the areas that are now not working. Tech said the lights and wipers were working but are not working now. Driving the vehicle will be limited based on these issues. The fuses appear good, but no power is getting into the box that powers the various items that are not working. I believe this car is a Lemon, and the dealership was aware of these issues and never told me the car had recalls. According to the internet, the tech who replaced my bumper stated that these issues are what the 2019 Hyundai Kona vehicle. Today (7-22-24), I drove my car from the auto shop with a new bumper and with hesitation and fear because the wipers and lights were not working, the air conditioning was out, and it is about to rain. The tech stated they were working earlier but are not working now. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMA
Mfg Campaign: 11603909
Recall Date: Jul 22, 2024
Need Legal Help?
Featured Attorneys
Barry Edzant
Edzant Price LLC
Valencia, CA • 36 yrs
Focus: Lemon Law, Personal Injury