Complaints & Recalls
Official Safety Recalls - Important!
23 RecallsThese are official manufacturer recalls ordered by NHTSA for safety defects. If you own this vehicle, contact your dealer immediately for free repairs.
Ford Motor Company
Safety Issue:
Ford Motor Company (Ford) is recalling certain 2016-2017 Explorer vehicles. The driver and front passenger B-Pillar door trim may detach while driving.
Potential Risk:
FREE Recall Solution:
Mfg Campaign: 25S53
Ford Motor Company
Safety Issue:
Ford Motor Company (Ford) is recalling certain 2011-2019 Explorer vehicles. The A-pillar trim retention clips may not be properly engaged, allowing the trim to detach.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Mfg Campaign: 24S02
Recall Date: Jan 19, 2024
Ford Motor Company
Safety Issue:
Ford Motor Company (Ford) is recalling certain 2013-2017 Explorer vehicles originally sold, or ever registered, in Connecticut, Delaware, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, Wisconsin, and the District of Columbia. Exposure to road salt can cause the cross-axis ball joint to corrode and seize, resulting in a fracture of the outboard section of the rear suspension toe link.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Mfg Campaign: 21S32
Recall Date: Jul 15, 2021
Ford Motor Company
Safety Issue:
Ford Motor Company (Ford) is recalling certain 2016-2019 Explorer vehicles. The retention pins could loosen and allow the roof rail covers to detach from the vehicle.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Mfg Campaign: 21S22
Recall Date: May 5, 2021
Ford Motor Company
Safety Issue:
Ford Motor Company (Ford) is recalling certain 2014-2016 Explorer, 2014-2015 Taurus and 2014 Edge vehicles equipped with 2.0L or 2.3L engines and front wheel drive. The support bracket for the front drive axle halfshaft may fail.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Mfg Campaign: 20S63
Recall Date: Nov 10, 2020
Ford Motor Company
Safety Issue:
Ford Motor Company (Ford) is recalling certain 2013-2017 Explorer vehicles originally sold, or currently registered in Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, and Wisconsin that were previously repaired under a prior recall numbers 16V-245 or 19V-435. The outboard section of a rear suspension toe link may fracture.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Mfg Campaign: 20S62
Recall Date: Oct 30, 2020
Ford Motor Company
Safety Issue:
Ford Motor Company (Ford) is recalling certain 2011-2017 Explorer vehicles. The rear suspension toe links may fracture due to stress on the rear suspension.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Mfg Campaign: 19S17
Recall Date: Jun 10, 2019
Ford Motor Company
Safety Issue:
Ford Motor Company (Ford) is recalling certain 2016 F-150 and Explorer vehicles. Loose power seat adjuster pivot bolts may cause the front seat cushions to detach and not properly restrain the seat occupant in the event of a crash.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Mfg Campaign: 17S40
Recall Date: Nov 29, 2017
Ford Motor Company
Safety Issue:
Ford Motor Company (Ford) is recalling certain Wheel Hub Bearing assemblies, part number HB5Z-1104-C, incorrectly listed as being for installation on the rear axles of 2011-2017 Ford Explorer 4X2 vehicles. These bearings assemblies were manufactured without a self retention feature, possibly resulting in the separation of the wheel or wheel end.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Recall Date: Aug 28, 2017
Ford Motor Company
Safety Issue:
Ford Motor Company (Ford) is recalling certain model year 2016 Ford Explorer and F-150 vehicles equipped with a manual recline driver's seat. The seat back frame may have insufficient welds which may not meet the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Mfg Campaign: 16C11
Recall Date: Jun 28, 2016
Ford Motor Company
Safety Issue:
Ford Motor Company (Ford) is recalling certain model year 2015-2016 Lincoln MKC vehicles manufactured November 25, 2013, to January 25, 2016, and 2016 Ford Explorer vehicles manufactured October 20, 2014, to January 28, 2016. The affected vehicles are equipped with 2.3L GTDI engines and engine block heaters. These engine block heaters have elements that may overheat while plugged in.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Mfg Campaign: 16S14
Recall Date: Mar 31, 2016
Ford Motor Company
Safety Issue:
Ford Motor Company (Ford) is recalling certain model year 2015 Ford Taurus, Lincoln MKS, and 2016 Ford Explorer vehicles manufactured on July 24, 2015. During vehicle production, the fuel tank attachment bolts may not have been properly tightened. As a result, the fuel tank straps may fracture and the fuel tank could separate from the vehicle.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Mfg Campaign: 15S26
Recall Date: Sep 28, 2015
Ford Motor Company
Safety Issue:
Ford Motor Company (Ford) is recalling certain model year 2015 Ford Taurus, Ford Flex, and Lincoln MKS vehicles manufactured May 4, 2015, to May 23, 2015, Lincoln MKT vehicles manufactured May 4, 2015, to May 21, 2015, and 2015-2016 Ford Explorer vehicles manufactured May 4, 2015, to May 23, 2015. The affected vehicles have a parking brake that may not fully engage when applied. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 135, "Light Vehicle Brake Systems."
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Mfg Campaign: 15C07
Recall Date: Jul 24, 2015
Consumer Complaints
2.8K ComplaintsFord Motor Company
Defect Description:
STEERING
Potential Consequences:
Rack and pinion steering assembly failed. Had to replace epas gear assembly and pmi module.
Corrective Action:
Rack and pinion steering assembly failed. Had to replace epas gear assembly and pmi module.
Additional Notes:
Rack and pinion steering assembly failed. Had to replace epas gear assembly and pmi module.
Mfg Campaign: 11535807
Recall Date: Aug 1, 2023
Ford Motor Company
Defect Description:
STEERING
Potential Consequences:
Steering issue with our 2016 Ford Explorer. While driving at 60 mph steering without warning became very difficult to control and lost the ability to easier turn the wheel. We were in a slight curve and it was very difficult to steer back to the middle of the road. We had it looked at by a local Ford dealer and were told the electric power assist had failed and caused other electrical issues. If this would have happened in a new high speed off ramp we frequently are on I strongly believe we would have hit the side barrier due to the loss of steering control.
Corrective Action:
Steering issue with our 2016 Ford Explorer. While driving at 60 mph steering without warning became very difficult to control and lost the ability to easier turn the wheel. We were in a slight curve and it was very difficult to steer back to the middle of the road. We had it looked at by a local Ford dealer and were told the electric power assist had failed and caused other electrical issues. If this would have happened in a new high speed off ramp we frequently are on I strongly believe we would have hit the side barrier due to the loss of steering control.
Additional Notes:
Steering issue with our 2016 Ford Explorer. While driving at 60 mph steering without warning became very difficult to control and lost the ability to easier turn the wheel. We were in a slight curve and it was very difficult to steer back to the middle of the road. We had it looked at by a local Ford dealer and were told the electric power assist had failed and caused other electrical issues. If this would have happened in a new high speed off ramp we frequently are on I strongly believe we would have hit the side barrier due to the loss of steering control.
Mfg Campaign: 11535591
Recall Date: Jul 31, 2023
Ford Motor Company
Defect Description:
STRUCTURE:BODY
Potential Consequences:
On 07/30/2023 The right passenger front windshield trim plus rubber stripping flew off our 2016 Ford Explorer XL. We were travelling 60 mph down a mountain area from San Diego, CA heading into Yuma, AZ. The noise of the trim was so loud hitting the windshield then the windshield panel blew off and the windshield stripping blew off. We made sure no one was behind us as it could have caused damage if the cover would have hit car behind us. Vehicle inspection yearly and no signs of any areas of concern. No warning or signs of this part coming off.
Corrective Action:
On 07/30/2023 The right passenger front windshield trim plus rubber stripping flew off our 2016 Ford Explorer XL. We were travelling 60 mph down a mountain area from San Diego, CA heading into Yuma, AZ. The noise of the trim was so loud hitting the windshield then the windshield panel blew off and the windshield stripping blew off. We made sure no one was behind us as it could have caused damage if the cover would have hit car behind us. Vehicle inspection yearly and no signs of any areas of concern. No warning or signs of this part coming off.
Additional Notes:
On 07/30/2023 The right passenger front windshield trim plus rubber stripping flew off our 2016 Ford Explorer XL. We were travelling 60 mph down a mountain area from San Diego, CA heading into Yuma, AZ. The noise of the trim was so loud hitting the windshield then the windshield panel blew off and the windshield stripping blew off. We made sure no one was behind us as it could have caused damage if the cover would have hit car behind us. Vehicle inspection yearly and no signs of any areas of concern. No warning or signs of this part coming off.
Mfg Campaign: 11535331
Recall Date: Jul 30, 2023
Ford Motor Company
Defect Description:
UNKNOWN OR OTHER
Potential Consequences:
On 07/30/2023 The right passenger front windshield trim plus rubber stripping flew off our 2016 Ford Explorer XL. We were travelling 60 mph down a mountain area from San Diego, CA heading into Yuma, AZ. The noise of the trim was so loud hitting the windshield then the windshield panel blew off and the windshield stripping blew off. We made sure no one was behind us as it could have caused damage if the cover would have hit car behind us. Vehicle inspection yearly and no signs of any areas of concern. No warning or signs of this part coming off.
Corrective Action:
On 07/30/2023 The right passenger front windshield trim plus rubber stripping flew off our 2016 Ford Explorer XL. We were travelling 60 mph down a mountain area from San Diego, CA heading into Yuma, AZ. The noise of the trim was so loud hitting the windshield then the windshield panel blew off and the windshield stripping blew off. We made sure no one was behind us as it could have caused damage if the cover would have hit car behind us. Vehicle inspection yearly and no signs of any areas of concern. No warning or signs of this part coming off.
Additional Notes:
On 07/30/2023 The right passenger front windshield trim plus rubber stripping flew off our 2016 Ford Explorer XL. We were travelling 60 mph down a mountain area from San Diego, CA heading into Yuma, AZ. The noise of the trim was so loud hitting the windshield then the windshield panel blew off and the windshield stripping blew off. We made sure no one was behind us as it could have caused damage if the cover would have hit car behind us. Vehicle inspection yearly and no signs of any areas of concern. No warning or signs of this part coming off.
Mfg Campaign: 11535331
Recall Date: Jul 30, 2023
Ford Motor Company
Defect Description:
ELECTRICAL SYSTEM
Potential Consequences:
I was Driven down in Orlando FL while on vacation and 3 notifications popped up on the screen back to back. I pressed Ok to clear the notifications off the screen because I was Unsure what they meant. I soon lost control of my vehicle and was unable to steer. I ended Up veering into another lane and almost hit another vehicle. My boyfriend grabbed the wheel from the passenger side to help straighten it up. I was Thankful that incident did not harm my family or the other family. I get It towed to PepBoys and they inform me I need A new rack and pinion installed and that was going to run me up to $4500. I was Also told in the same sentence that the part I needed Was out of stock or unavailable pretty much everywhere. I contact Another shop and receive a cheaper quote but still no part is available. I contact Ford and speak to an agent. Not very helpful at all. I mentioned I was looking up the part online and read there are recalls on that. The representative asks for my VIN and she tells me there is a recall however not for my VIN. I’m livid. Here it is going into August and still no parts are available. Ford never will I ever Buy another vehicle with that name on it. Found On Road Dead is basically coming to light.
Corrective Action:
I was Driven down in Orlando FL while on vacation and 3 notifications popped up on the screen back to back. I pressed Ok to clear the notifications off the screen because I was Unsure what they meant. I soon lost control of my vehicle and was unable to steer. I ended Up veering into another lane and almost hit another vehicle. My boyfriend grabbed the wheel from the passenger side to help straighten it up. I was Thankful that incident did not harm my family or the other family. I get It towed to PepBoys and they inform me I need A new rack and pinion installed and that was going to run me up to $4500. I was Also told in the same sentence that the part I needed Was out of stock or unavailable pretty much everywhere. I contact Another shop and receive a cheaper quote but still no part is available. I contact Ford and speak to an agent. Not very helpful at all. I mentioned I was looking up the part online and read there are recalls on that. The representative asks for my VIN and she tells me there is a recall however not for my VIN. I’m livid. Here it is going into August and still no parts are available. Ford never will I ever Buy another vehicle with that name on it. Found On Road Dead is basically coming to light.
Additional Notes:
I was Driven down in Orlando FL while on vacation and 3 notifications popped up on the screen back to back. I pressed Ok to clear the notifications off the screen because I was Unsure what they meant. I soon lost control of my vehicle and was unable to steer. I ended Up veering into another lane and almost hit another vehicle. My boyfriend grabbed the wheel from the passenger side to help straighten it up. I was Thankful that incident did not harm my family or the other family. I get It towed to PepBoys and they inform me I need A new rack and pinion installed and that was going to run me up to $4500. I was Also told in the same sentence that the part I needed Was out of stock or unavailable pretty much everywhere. I contact Another shop and receive a cheaper quote but still no part is available. I contact Ford and speak to an agent. Not very helpful at all. I mentioned I was looking up the part online and read there are recalls on that. The representative asks for my VIN and she tells me there is a recall however not for my VIN. I’m livid. Here it is going into August and still no parts are available. Ford never will I ever Buy another vehicle with that name on it. Found On Road Dead is basically coming to light.
Mfg Campaign: 11534960
Recall Date: Jul 28, 2023
Ford Motor Company
Defect Description:
STEERING
Potential Consequences:
I was Driven down in Orlando FL while on vacation and 3 notifications popped up on the screen back to back. I pressed Ok to clear the notifications off the screen because I was Unsure what they meant. I soon lost control of my vehicle and was unable to steer. I ended Up veering into another lane and almost hit another vehicle. My boyfriend grabbed the wheel from the passenger side to help straighten it up. I was Thankful that incident did not harm my family or the other family. I get It towed to PepBoys and they inform me I need A new rack and pinion installed and that was going to run me up to $4500. I was Also told in the same sentence that the part I needed Was out of stock or unavailable pretty much everywhere. I contact Another shop and receive a cheaper quote but still no part is available. I contact Ford and speak to an agent. Not very helpful at all. I mentioned I was looking up the part online and read there are recalls on that. The representative asks for my VIN and she tells me there is a recall however not for my VIN. I’m livid. Here it is going into August and still no parts are available. Ford never will I ever Buy another vehicle with that name on it. Found On Road Dead is basically coming to light.
Corrective Action:
I was Driven down in Orlando FL while on vacation and 3 notifications popped up on the screen back to back. I pressed Ok to clear the notifications off the screen because I was Unsure what they meant. I soon lost control of my vehicle and was unable to steer. I ended Up veering into another lane and almost hit another vehicle. My boyfriend grabbed the wheel from the passenger side to help straighten it up. I was Thankful that incident did not harm my family or the other family. I get It towed to PepBoys and they inform me I need A new rack and pinion installed and that was going to run me up to $4500. I was Also told in the same sentence that the part I needed Was out of stock or unavailable pretty much everywhere. I contact Another shop and receive a cheaper quote but still no part is available. I contact Ford and speak to an agent. Not very helpful at all. I mentioned I was looking up the part online and read there are recalls on that. The representative asks for my VIN and she tells me there is a recall however not for my VIN. I’m livid. Here it is going into August and still no parts are available. Ford never will I ever Buy another vehicle with that name on it. Found On Road Dead is basically coming to light.
Additional Notes:
I was Driven down in Orlando FL while on vacation and 3 notifications popped up on the screen back to back. I pressed Ok to clear the notifications off the screen because I was Unsure what they meant. I soon lost control of my vehicle and was unable to steer. I ended Up veering into another lane and almost hit another vehicle. My boyfriend grabbed the wheel from the passenger side to help straighten it up. I was Thankful that incident did not harm my family or the other family. I get It towed to PepBoys and they inform me I need A new rack and pinion installed and that was going to run me up to $4500. I was Also told in the same sentence that the part I needed Was out of stock or unavailable pretty much everywhere. I contact Another shop and receive a cheaper quote but still no part is available. I contact Ford and speak to an agent. Not very helpful at all. I mentioned I was looking up the part online and read there are recalls on that. The representative asks for my VIN and she tells me there is a recall however not for my VIN. I’m livid. Here it is going into August and still no parts are available. Ford never will I ever Buy another vehicle with that name on it. Found On Road Dead is basically coming to light.
Mfg Campaign: 11534960
Recall Date: Jul 28, 2023
Ford Motor Company
Defect Description:
ELECTRICAL SYSTEM
Potential Consequences:
The contact owns a 2016 Ford Explorer. The contact stated while driving at undisclosed speeds, the instrument panel intermittently went blank. The vehicle was taken to a dealer for a diagnostic test. The contact was informed that the APIM (Accessory Protocol Interface Module) had failed and needed to be replaced. The dealer provided the contact with an estimate for the repair and agreed to cover half the cost of the repair. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The vehicle was not repaired. The failure mileage was approximately 65,000.
Corrective Action:
The contact owns a 2016 Ford Explorer. The contact stated while driving at undisclosed speeds, the instrument panel intermittently went blank. The vehicle was taken to a dealer for a diagnostic test. The contact was informed that the APIM (Accessory Protocol Interface Module) had failed and needed to be replaced. The dealer provided the contact with an estimate for the repair and agreed to cover half the cost of the repair. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The vehicle was not repaired. The failure mileage was approximately 65,000.
Additional Notes:
The contact owns a 2016 Ford Explorer. The contact stated while driving at undisclosed speeds, the instrument panel intermittently went blank. The vehicle was taken to a dealer for a diagnostic test. The contact was informed that the APIM (Accessory Protocol Interface Module) had failed and needed to be replaced. The dealer provided the contact with an estimate for the repair and agreed to cover half the cost of the repair. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The vehicle was not repaired. The failure mileage was approximately 65,000.
Mfg Campaign: 11534981
Recall Date: Jul 28, 2023
Ford Motor Company
Defect Description:
STRUCTURE
Potential Consequences:
The contact owns a 2016 Ford Explorer. The contact stated while driving approximately 70 MPH, he heard an abnormal vibration coming from the passenger’s side front door. The contact stated that a plastic panel had partially detached from the windshield pillar. The contact stated that the plastic trim was held on by glue. The contact pulled over and removed the trim. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that the passenger’s side and driver's side windshield pillar trim needed to be replaced. The vehicle had not been repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 120,000.
Corrective Action:
The contact owns a 2016 Ford Explorer. The contact stated while driving approximately 70 MPH, he heard an abnormal vibration coming from the passenger’s side front door. The contact stated that a plastic panel had partially detached from the windshield pillar. The contact stated that the plastic trim was held on by glue. The contact pulled over and removed the trim. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that the passenger’s side and driver's side windshield pillar trim needed to be replaced. The vehicle had not been repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 120,000.
Additional Notes:
The contact owns a 2016 Ford Explorer. The contact stated while driving approximately 70 MPH, he heard an abnormal vibration coming from the passenger’s side front door. The contact stated that a plastic panel had partially detached from the windshield pillar. The contact stated that the plastic trim was held on by glue. The contact pulled over and removed the trim. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that the passenger’s side and driver's side windshield pillar trim needed to be replaced. The vehicle had not been repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 120,000.
Mfg Campaign: 11534863
Recall Date: Jul 27, 2023
Ford Motor Company
Defect Description:
STEERING
Potential Consequences:
POWER STEERING RACK - The steering wheel turns hard and does not return to straight on corners without heavy assist. The tires or bearings are loud when turning.
Corrective Action:
POWER STEERING RACK - The steering wheel turns hard and does not return to straight on corners without heavy assist. The tires or bearings are loud when turning.
Additional Notes:
POWER STEERING RACK - The steering wheel turns hard and does not return to straight on corners without heavy assist. The tires or bearings are loud when turning.
Mfg Campaign: 11534552
Recall Date: Jul 26, 2023
Ford Motor Company
Defect Description:
SUSPENSION
Potential Consequences:
Ford Dealer reports 3 toe link recalls are for 2013-2017 Ford Explorer are not on my 2016 Ford Explorer Limited but my toe links are out of spec and unable to be adjusted. Private mechanic (independent service center) reports this condition can lead to a crash. Vehicle was purchased and driven in New Jersey. Vehicle is available for inspection. No warning lights or messages.
Corrective Action:
Ford Dealer reports 3 toe link recalls are for 2013-2017 Ford Explorer are not on my 2016 Ford Explorer Limited but my toe links are out of spec and unable to be adjusted. Private mechanic (independent service center) reports this condition can lead to a crash. Vehicle was purchased and driven in New Jersey. Vehicle is available for inspection. No warning lights or messages.
Additional Notes:
Ford Dealer reports 3 toe link recalls are for 2013-2017 Ford Explorer are not on my 2016 Ford Explorer Limited but my toe links are out of spec and unable to be adjusted. Private mechanic (independent service center) reports this condition can lead to a crash. Vehicle was purchased and driven in New Jersey. Vehicle is available for inspection. No warning lights or messages.
Mfg Campaign: 11534632
Recall Date: Jul 26, 2023
Ford Motor Company
Defect Description:
AIR BAGS
Potential Consequences:
The contact owns a 2016 Ford Explorer. The contact stated that while driving at an undisclosed speed, the air bag warning light illuminated intermittently on the instrument panel, causing the deactivation of all the other air bags. The vehicle was taken to the dealer, who diagnosed failures with the seat belt wiring harness and seat belt pretensioner on the second row. The vehicle was repaired three times for the same failure, but the failure persisted. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was 80,000.
Corrective Action:
The contact owns a 2016 Ford Explorer. The contact stated that while driving at an undisclosed speed, the air bag warning light illuminated intermittently on the instrument panel, causing the deactivation of all the other air bags. The vehicle was taken to the dealer, who diagnosed failures with the seat belt wiring harness and seat belt pretensioner on the second row. The vehicle was repaired three times for the same failure, but the failure persisted. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was 80,000.
Additional Notes:
The contact owns a 2016 Ford Explorer. The contact stated that while driving at an undisclosed speed, the air bag warning light illuminated intermittently on the instrument panel, causing the deactivation of all the other air bags. The vehicle was taken to the dealer, who diagnosed failures with the seat belt wiring harness and seat belt pretensioner on the second row. The vehicle was repaired three times for the same failure, but the failure persisted. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was 80,000.
Mfg Campaign: 11534667
Recall Date: Jul 26, 2023
Ford Motor Company
Defect Description:
STRUCTURE
Potential Consequences:
The contact owns a 2016 Ford Explorer. The contact stated that while driving approximately 70 MPH, the driver’s and passenger’s side windshield trim panel detached. Additionally, while driving, the roof rail detached. The contact called the local dealer, but the vehicle was not diagnosed or repaired. The manufacturer was contacted and referred the contact to NHTSA Hotline. The contact stated that the failure was related to NHTSA Action Number: PE23001 (Structure). The failure mileage was 98,000.
Corrective Action:
The contact owns a 2016 Ford Explorer. The contact stated that while driving approximately 70 MPH, the driver’s and passenger’s side windshield trim panel detached. Additionally, while driving, the roof rail detached. The contact called the local dealer, but the vehicle was not diagnosed or repaired. The manufacturer was contacted and referred the contact to NHTSA Hotline. The contact stated that the failure was related to NHTSA Action Number: PE23001 (Structure). The failure mileage was 98,000.
Additional Notes:
The contact owns a 2016 Ford Explorer. The contact stated that while driving approximately 70 MPH, the driver’s and passenger’s side windshield trim panel detached. Additionally, while driving, the roof rail detached. The contact called the local dealer, but the vehicle was not diagnosed or repaired. The manufacturer was contacted and referred the contact to NHTSA Hotline. The contact stated that the failure was related to NHTSA Action Number: PE23001 (Structure). The failure mileage was 98,000.
Mfg Campaign: 11534267
Recall Date: Jul 25, 2023
Ford Motor Company
Defect Description:
VISIBILITY/WIPER
Potential Consequences:
The windshield trim blew off while driving on the Highway. Happened so fast I couldn’t tell if it blew into the ditch or what happened to it. Could have easily hit a vehicle behind me and cause an accident. Very distracting for the driver as well. I almost veered into other lane with oncoming traffic with how loud and surprising it was.
Corrective Action:
The windshield trim blew off while driving on the Highway. Happened so fast I couldn’t tell if it blew into the ditch or what happened to it. Could have easily hit a vehicle behind me and cause an accident. Very distracting for the driver as well. I almost veered into other lane with oncoming traffic with how loud and surprising it was.
Additional Notes:
The windshield trim blew off while driving on the Highway. Happened so fast I couldn’t tell if it blew into the ditch or what happened to it. Could have easily hit a vehicle behind me and cause an accident. Very distracting for the driver as well. I almost veered into other lane with oncoming traffic with how loud and surprising it was.
Mfg Campaign: 11534096
Recall Date: Jul 24, 2023
Ford Motor Company
Defect Description:
STRUCTURE:BODY
Potential Consequences:
The drivers side windshield trim panel came off of the car while driving down a highway at 55mph. Luckily, there were no other cars on the highway and no further damage or injury occurred.
Corrective Action:
The drivers side windshield trim panel came off of the car while driving down a highway at 55mph. Luckily, there were no other cars on the highway and no further damage or injury occurred.
Additional Notes:
The drivers side windshield trim panel came off of the car while driving down a highway at 55mph. Luckily, there were no other cars on the highway and no further damage or injury occurred.
Mfg Campaign: 11534113
Recall Date: Jul 24, 2023
Ford Motor Company
Defect Description:
STEERING
Potential Consequences:
The contact owns a 2016 Ford Explorer. The contact stated while making a right turn, there was a grinding sound coming from the steering wheel. There was no warning light illuminated. The vehicle was taken to an independent mechanic and the contact was informed that the steering rack had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline. The failure mileage was 96,500.
Corrective Action:
The contact owns a 2016 Ford Explorer. The contact stated while making a right turn, there was a grinding sound coming from the steering wheel. There was no warning light illuminated. The vehicle was taken to an independent mechanic and the contact was informed that the steering rack had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline. The failure mileage was 96,500.
Additional Notes:
The contact owns a 2016 Ford Explorer. The contact stated while making a right turn, there was a grinding sound coming from the steering wheel. There was no warning light illuminated. The vehicle was taken to an independent mechanic and the contact was informed that the steering rack had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline. The failure mileage was 96,500.
Mfg Campaign: 11533632
Recall Date: Jul 21, 2023
Ford Motor Company
Defect Description:
ENGINE AND ENGINE COOLING
Potential Consequences:
The contact owns a 2016 Ford Explorer. The contact stated while cold starting the vehicle, the check engine warning light was illuminated. The contact stated that the vehicle seemed to be operating normally; however, the check engine warning light remained illuminated. The contact stated that after a week with the check engine light remaining illuminated, the vehicle was driven to a local dealer where it was diagnosed and determined that the long block needed to be replaced. The vehicle had not been repaired. The contact researched online and related the failure to manufacturer Customer Satisfaction Program Number: 21N12 - Short Block Replacement After Coolant Intrusion (Engine and Engine Cooling). The manufacturer had been informed of the failure. The failure mileage was approximately 72,000.
Corrective Action:
The contact owns a 2016 Ford Explorer. The contact stated while cold starting the vehicle, the check engine warning light was illuminated. The contact stated that the vehicle seemed to be operating normally; however, the check engine warning light remained illuminated. The contact stated that after a week with the check engine light remaining illuminated, the vehicle was driven to a local dealer where it was diagnosed and determined that the long block needed to be replaced. The vehicle had not been repaired. The contact researched online and related the failure to manufacturer Customer Satisfaction Program Number: 21N12 - Short Block Replacement After Coolant Intrusion (Engine and Engine Cooling). The manufacturer had been informed of the failure. The failure mileage was approximately 72,000.
Additional Notes:
The contact owns a 2016 Ford Explorer. The contact stated while cold starting the vehicle, the check engine warning light was illuminated. The contact stated that the vehicle seemed to be operating normally; however, the check engine warning light remained illuminated. The contact stated that after a week with the check engine light remaining illuminated, the vehicle was driven to a local dealer where it was diagnosed and determined that the long block needed to be replaced. The vehicle had not been repaired. The contact researched online and related the failure to manufacturer Customer Satisfaction Program Number: 21N12 - Short Block Replacement After Coolant Intrusion (Engine and Engine Cooling). The manufacturer had been informed of the failure. The failure mileage was approximately 72,000.
Mfg Campaign: 11533678
Recall Date: Jul 21, 2023
Ford Motor Company
Defect Description:
ENGINE
Potential Consequences:
The contact owns a 2016 Ford Explorer. The contact stated while cold starting the vehicle, the check engine warning light was illuminated. The contact stated that the vehicle seemed to be operating normally; however, the check engine warning light remained illuminated. The contact stated that after a week with the check engine light remaining illuminated, the vehicle was driven to a local dealer where it was diagnosed and determined that the long block needed to be replaced. The vehicle had not been repaired. The contact researched online and related the failure to manufacturer Customer Satisfaction Program Number: 21N12 - Short Block Replacement After Coolant Intrusion (Engine and Engine Cooling). The manufacturer had been informed of the failure. The failure mileage was approximately 72,000.
Corrective Action:
The contact owns a 2016 Ford Explorer. The contact stated while cold starting the vehicle, the check engine warning light was illuminated. The contact stated that the vehicle seemed to be operating normally; however, the check engine warning light remained illuminated. The contact stated that after a week with the check engine light remaining illuminated, the vehicle was driven to a local dealer where it was diagnosed and determined that the long block needed to be replaced. The vehicle had not been repaired. The contact researched online and related the failure to manufacturer Customer Satisfaction Program Number: 21N12 - Short Block Replacement After Coolant Intrusion (Engine and Engine Cooling). The manufacturer had been informed of the failure. The failure mileage was approximately 72,000.
Additional Notes:
The contact owns a 2016 Ford Explorer. The contact stated while cold starting the vehicle, the check engine warning light was illuminated. The contact stated that the vehicle seemed to be operating normally; however, the check engine warning light remained illuminated. The contact stated that after a week with the check engine light remaining illuminated, the vehicle was driven to a local dealer where it was diagnosed and determined that the long block needed to be replaced. The vehicle had not been repaired. The contact researched online and related the failure to manufacturer Customer Satisfaction Program Number: 21N12 - Short Block Replacement After Coolant Intrusion (Engine and Engine Cooling). The manufacturer had been informed of the failure. The failure mileage was approximately 72,000.
Mfg Campaign: 11533678
Recall Date: Jul 21, 2023
Ford Motor Company
Defect Description:
UNKNOWN OR OTHER
Potential Consequences:
While driving on the highway, the passenger side windshield trim flew off hitting my windshield. I've been told by the police that it happens frequently on their vehicles, but never thought it would happen to me. It did. Now. I have to pay for the repair and it could have easily caused an accident, because it scared me so much that I swerved thinking something hit me. Which it did. My own car!
Corrective Action:
While driving on the highway, the passenger side windshield trim flew off hitting my windshield. I've been told by the police that it happens frequently on their vehicles, but never thought it would happen to me. It did. Now. I have to pay for the repair and it could have easily caused an accident, because it scared me so much that I swerved thinking something hit me. Which it did. My own car!
Additional Notes:
While driving on the highway, the passenger side windshield trim flew off hitting my windshield. I've been told by the police that it happens frequently on their vehicles, but never thought it would happen to me. It did. Now. I have to pay for the repair and it could have easily caused an accident, because it scared me so much that I swerved thinking something hit me. Which it did. My own car!
Mfg Campaign: 11533143
Recall Date: Jul 19, 2023
Ford Motor Company
Defect Description:
STEERING
Potential Consequences:
I have had a malfunction with what may be the front right break or steering component. Occasional metal on metal/grinding noise made when making a hard right turn or reversing left. Vehicle had been taken in a few times after purchase (Honda dealership), sound was duplicated but no issue detected by mechanics. Vehicle has been taken to ford and no issue detected. No warning lamps have ever come on.
Corrective Action:
I have had a malfunction with what may be the front right break or steering component. Occasional metal on metal/grinding noise made when making a hard right turn or reversing left. Vehicle had been taken in a few times after purchase (Honda dealership), sound was duplicated but no issue detected by mechanics. Vehicle has been taken to ford and no issue detected. No warning lamps have ever come on.
Additional Notes:
I have had a malfunction with what may be the front right break or steering component. Occasional metal on metal/grinding noise made when making a hard right turn or reversing left. Vehicle had been taken in a few times after purchase (Honda dealership), sound was duplicated but no issue detected by mechanics. Vehicle has been taken to ford and no issue detected. No warning lamps have ever come on.
Mfg Campaign: 11533157
Recall Date: Jul 19, 2023
Ford Motor Company
Defect Description:
SERVICE BRAKES
Potential Consequences:
I have had a malfunction with what may be the front right break or steering component. Occasional metal on metal/grinding noise made when making a hard right turn or reversing left. Vehicle had been taken in a few times after purchase (Honda dealership), sound was duplicated but no issue detected by mechanics. Vehicle has been taken to ford and no issue detected. No warning lamps have ever come on.
Corrective Action:
I have had a malfunction with what may be the front right break or steering component. Occasional metal on metal/grinding noise made when making a hard right turn or reversing left. Vehicle had been taken in a few times after purchase (Honda dealership), sound was duplicated but no issue detected by mechanics. Vehicle has been taken to ford and no issue detected. No warning lamps have ever come on.
Additional Notes:
I have had a malfunction with what may be the front right break or steering component. Occasional metal on metal/grinding noise made when making a hard right turn or reversing left. Vehicle had been taken in a few times after purchase (Honda dealership), sound was duplicated but no issue detected by mechanics. Vehicle has been taken to ford and no issue detected. No warning lamps have ever come on.
Mfg Campaign: 11533157
Recall Date: Jul 19, 2023
Need Legal Help?
Featured Attorneys
Barry Edzant
Edzant Price LLC
Valencia, CA • 36 yrs
Focus: Lemon Law, Personal Injury