Complaints & Recalls
Official Safety Recalls - Important!
23 RecallsThese are official manufacturer recalls ordered by NHTSA for safety defects. If you own this vehicle, contact your dealer immediately for free repairs.
Ford Motor Company
Safety Issue:
Ford Motor Company (Ford) is recalling certain 2016-2017 Explorer vehicles. The driver and front passenger B-Pillar door trim may detach while driving.
Potential Risk:
FREE Recall Solution:
Mfg Campaign: 25S53
Ford Motor Company
Safety Issue:
Ford Motor Company (Ford) is recalling certain 2011-2019 Explorer vehicles. The A-pillar trim retention clips may not be properly engaged, allowing the trim to detach.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Mfg Campaign: 24S02
Recall Date: Jan 19, 2024
Ford Motor Company
Safety Issue:
Ford Motor Company (Ford) is recalling certain 2013-2017 Explorer vehicles originally sold, or ever registered, in Connecticut, Delaware, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, Wisconsin, and the District of Columbia. Exposure to road salt can cause the cross-axis ball joint to corrode and seize, resulting in a fracture of the outboard section of the rear suspension toe link.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Mfg Campaign: 21S32
Recall Date: Jul 15, 2021
Ford Motor Company
Safety Issue:
Ford Motor Company (Ford) is recalling certain 2016-2019 Explorer vehicles. The retention pins could loosen and allow the roof rail covers to detach from the vehicle.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Mfg Campaign: 21S22
Recall Date: May 5, 2021
Ford Motor Company
Safety Issue:
Ford Motor Company (Ford) is recalling certain 2014-2016 Explorer, 2014-2015 Taurus and 2014 Edge vehicles equipped with 2.0L or 2.3L engines and front wheel drive. The support bracket for the front drive axle halfshaft may fail.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Mfg Campaign: 20S63
Recall Date: Nov 10, 2020
Ford Motor Company
Safety Issue:
Ford Motor Company (Ford) is recalling certain 2013-2017 Explorer vehicles originally sold, or currently registered in Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, and Wisconsin that were previously repaired under a prior recall numbers 16V-245 or 19V-435. The outboard section of a rear suspension toe link may fracture.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Mfg Campaign: 20S62
Recall Date: Oct 30, 2020
Ford Motor Company
Safety Issue:
Ford Motor Company (Ford) is recalling certain 2011-2017 Explorer vehicles. The rear suspension toe links may fracture due to stress on the rear suspension.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Mfg Campaign: 19S17
Recall Date: Jun 10, 2019
Ford Motor Company
Safety Issue:
Ford Motor Company (Ford) is recalling certain 2016 F-150 and Explorer vehicles. Loose power seat adjuster pivot bolts may cause the front seat cushions to detach and not properly restrain the seat occupant in the event of a crash.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Mfg Campaign: 17S40
Recall Date: Nov 29, 2017
Ford Motor Company
Safety Issue:
Ford Motor Company (Ford) is recalling certain Wheel Hub Bearing assemblies, part number HB5Z-1104-C, incorrectly listed as being for installation on the rear axles of 2011-2017 Ford Explorer 4X2 vehicles. These bearings assemblies were manufactured without a self retention feature, possibly resulting in the separation of the wheel or wheel end.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Recall Date: Aug 28, 2017
Ford Motor Company
Safety Issue:
Ford Motor Company (Ford) is recalling certain model year 2016 Ford Explorer and F-150 vehicles equipped with a manual recline driver's seat. The seat back frame may have insufficient welds which may not meet the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Mfg Campaign: 16C11
Recall Date: Jun 28, 2016
Ford Motor Company
Safety Issue:
Ford Motor Company (Ford) is recalling certain model year 2015-2016 Lincoln MKC vehicles manufactured November 25, 2013, to January 25, 2016, and 2016 Ford Explorer vehicles manufactured October 20, 2014, to January 28, 2016. The affected vehicles are equipped with 2.3L GTDI engines and engine block heaters. These engine block heaters have elements that may overheat while plugged in.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Mfg Campaign: 16S14
Recall Date: Mar 31, 2016
Ford Motor Company
Safety Issue:
Ford Motor Company (Ford) is recalling certain model year 2015 Ford Taurus, Lincoln MKS, and 2016 Ford Explorer vehicles manufactured on July 24, 2015. During vehicle production, the fuel tank attachment bolts may not have been properly tightened. As a result, the fuel tank straps may fracture and the fuel tank could separate from the vehicle.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Mfg Campaign: 15S26
Recall Date: Sep 28, 2015
Ford Motor Company
Safety Issue:
Ford Motor Company (Ford) is recalling certain model year 2015 Ford Taurus, Ford Flex, and Lincoln MKS vehicles manufactured May 4, 2015, to May 23, 2015, Lincoln MKT vehicles manufactured May 4, 2015, to May 21, 2015, and 2015-2016 Ford Explorer vehicles manufactured May 4, 2015, to May 23, 2015. The affected vehicles have a parking brake that may not fully engage when applied. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 135, "Light Vehicle Brake Systems."
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Mfg Campaign: 15C07
Recall Date: Jul 24, 2015
Consumer Complaints
2.8K ComplaintsFord Motor Company
Defect Description:
UNKNOWN OR OTHER
Potential Consequences:
when traveling at highway speed the side fins fly off. i have had them replaced 3 times now at dealership. thank God there was not someone behind me - especially on a motor cycle it could of killed them
Corrective Action:
when traveling at highway speed the side fins fly off. i have had them replaced 3 times now at dealership. thank God there was not someone behind me - especially on a motor cycle it could of killed them
Additional Notes:
when traveling at highway speed the side fins fly off. i have had them replaced 3 times now at dealership. thank God there was not someone behind me - especially on a motor cycle it could of killed them
Mfg Campaign: 11556847
Recall Date: Nov 26, 2023
Ford Motor Company
Defect Description:
SUSPENSION
Potential Consequences:
I [XXX] went with my mom [XXX] to buy a vehicle off of [XXX] . It was a 2016 ford explorer. I payed 13,000. The began to lose control when driving on a bumpy road and while braking I took the car to a Ford dealer and had some repairs, but they didn’t find the problem. I used the car sparingly and within two weeks it got much worse. Very unsafe to drive I brought it to another Ford dealership and I paid for substantial repairs for the suspension. The first time I drove it on a bumpy the car lost control again. I managed to regain control and drive it to the side of the road and had someone pick up the car. I went to trade the car in and learned the vehicle had been in two accidents and was reported as a total loss. Per the Carfax report. We were never told it was a salvaged vehicle or we would never purchased it for our family vehicle. The vehicle is too unsafe to put back on the road. I bought a 2017 Ford Explorer at a dealership and traded in the 2016 Ford Explorer at a significant loss. The vehicle was in my possession for approx. two months where it spent most of the time in different Ford repaid shops INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Corrective Action:
I [XXX] went with my mom [XXX] to buy a vehicle off of [XXX] . It was a 2016 ford explorer. I payed 13,000. The began to lose control when driving on a bumpy road and while braking I took the car to a Ford dealer and had some repairs, but they didn’t find the problem. I used the car sparingly and within two weeks it got much worse. Very unsafe to drive I brought it to another Ford dealership and I paid for substantial repairs for the suspension. The first time I drove it on a bumpy the car lost control again. I managed to regain control and drive it to the side of the road and had someone pick up the car. I went to trade the car in and learned the vehicle had been in two accidents and was reported as a total loss. Per the Carfax report. We were never told it was a salvaged vehicle or we would never purchased it for our family vehicle. The vehicle is too unsafe to put back on the road. I bought a 2017 Ford Explorer at a dealership and traded in the 2016 Ford Explorer at a significant loss. The vehicle was in my possession for approx. two months where it spent most of the time in different Ford repaid shops INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Additional Notes:
I [XXX] went with my mom [XXX] to buy a vehicle off of [XXX] . It was a 2016 ford explorer. I payed 13,000. The began to lose control when driving on a bumpy road and while braking I took the car to a Ford dealer and had some repairs, but they didn’t find the problem. I used the car sparingly and within two weeks it got much worse. Very unsafe to drive I brought it to another Ford dealership and I paid for substantial repairs for the suspension. The first time I drove it on a bumpy the car lost control again. I managed to regain control and drive it to the side of the road and had someone pick up the car. I went to trade the car in and learned the vehicle had been in two accidents and was reported as a total loss. Per the Carfax report. We were never told it was a salvaged vehicle or we would never purchased it for our family vehicle. The vehicle is too unsafe to put back on the road. I bought a 2017 Ford Explorer at a dealership and traded in the 2016 Ford Explorer at a significant loss. The vehicle was in my possession for approx. two months where it spent most of the time in different Ford repaid shops INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Mfg Campaign: 11556734
Recall Date: Nov 25, 2023
Ford Motor Company
Defect Description:
WHEELS
Potential Consequences:
I [XXX] went with my mom [XXX] to buy a vehicle off of [XXX] . It was a 2016 ford explorer. I payed 13,000. The began to lose control when driving on a bumpy road and while braking I took the car to a Ford dealer and had some repairs, but they didn’t find the problem. I used the car sparingly and within two weeks it got much worse. Very unsafe to drive I brought it to another Ford dealership and I paid for substantial repairs for the suspension. The first time I drove it on a bumpy the car lost control again. I managed to regain control and drive it to the side of the road and had someone pick up the car. I went to trade the car in and learned the vehicle had been in two accidents and was reported as a total loss. Per the Carfax report. We were never told it was a salvaged vehicle or we would never purchased it for our family vehicle. The vehicle is too unsafe to put back on the road. I bought a 2017 Ford Explorer at a dealership and traded in the 2016 Ford Explorer at a significant loss. The vehicle was in my possession for approx. two months where it spent most of the time in different Ford repaid shops INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Corrective Action:
I [XXX] went with my mom [XXX] to buy a vehicle off of [XXX] . It was a 2016 ford explorer. I payed 13,000. The began to lose control when driving on a bumpy road and while braking I took the car to a Ford dealer and had some repairs, but they didn’t find the problem. I used the car sparingly and within two weeks it got much worse. Very unsafe to drive I brought it to another Ford dealership and I paid for substantial repairs for the suspension. The first time I drove it on a bumpy the car lost control again. I managed to regain control and drive it to the side of the road and had someone pick up the car. I went to trade the car in and learned the vehicle had been in two accidents and was reported as a total loss. Per the Carfax report. We were never told it was a salvaged vehicle or we would never purchased it for our family vehicle. The vehicle is too unsafe to put back on the road. I bought a 2017 Ford Explorer at a dealership and traded in the 2016 Ford Explorer at a significant loss. The vehicle was in my possession for approx. two months where it spent most of the time in different Ford repaid shops INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Additional Notes:
I [XXX] went with my mom [XXX] to buy a vehicle off of [XXX] . It was a 2016 ford explorer. I payed 13,000. The began to lose control when driving on a bumpy road and while braking I took the car to a Ford dealer and had some repairs, but they didn’t find the problem. I used the car sparingly and within two weeks it got much worse. Very unsafe to drive I brought it to another Ford dealership and I paid for substantial repairs for the suspension. The first time I drove it on a bumpy the car lost control again. I managed to regain control and drive it to the side of the road and had someone pick up the car. I went to trade the car in and learned the vehicle had been in two accidents and was reported as a total loss. Per the Carfax report. We were never told it was a salvaged vehicle or we would never purchased it for our family vehicle. The vehicle is too unsafe to put back on the road. I bought a 2017 Ford Explorer at a dealership and traded in the 2016 Ford Explorer at a significant loss. The vehicle was in my possession for approx. two months where it spent most of the time in different Ford repaid shops INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Mfg Campaign: 11556734
Recall Date: Nov 25, 2023
Ford Motor Company
Defect Description:
STEERING
Potential Consequences:
I [XXX] went with my mom [XXX] to buy a vehicle off of [XXX] . It was a 2016 ford explorer. I payed 13,000. The began to lose control when driving on a bumpy road and while braking I took the car to a Ford dealer and had some repairs, but they didn’t find the problem. I used the car sparingly and within two weeks it got much worse. Very unsafe to drive I brought it to another Ford dealership and I paid for substantial repairs for the suspension. The first time I drove it on a bumpy the car lost control again. I managed to regain control and drive it to the side of the road and had someone pick up the car. I went to trade the car in and learned the vehicle had been in two accidents and was reported as a total loss. Per the Carfax report. We were never told it was a salvaged vehicle or we would never purchased it for our family vehicle. The vehicle is too unsafe to put back on the road. I bought a 2017 Ford Explorer at a dealership and traded in the 2016 Ford Explorer at a significant loss. The vehicle was in my possession for approx. two months where it spent most of the time in different Ford repaid shops INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Corrective Action:
I [XXX] went with my mom [XXX] to buy a vehicle off of [XXX] . It was a 2016 ford explorer. I payed 13,000. The began to lose control when driving on a bumpy road and while braking I took the car to a Ford dealer and had some repairs, but they didn’t find the problem. I used the car sparingly and within two weeks it got much worse. Very unsafe to drive I brought it to another Ford dealership and I paid for substantial repairs for the suspension. The first time I drove it on a bumpy the car lost control again. I managed to regain control and drive it to the side of the road and had someone pick up the car. I went to trade the car in and learned the vehicle had been in two accidents and was reported as a total loss. Per the Carfax report. We were never told it was a salvaged vehicle or we would never purchased it for our family vehicle. The vehicle is too unsafe to put back on the road. I bought a 2017 Ford Explorer at a dealership and traded in the 2016 Ford Explorer at a significant loss. The vehicle was in my possession for approx. two months where it spent most of the time in different Ford repaid shops INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Additional Notes:
I [XXX] went with my mom [XXX] to buy a vehicle off of [XXX] . It was a 2016 ford explorer. I payed 13,000. The began to lose control when driving on a bumpy road and while braking I took the car to a Ford dealer and had some repairs, but they didn’t find the problem. I used the car sparingly and within two weeks it got much worse. Very unsafe to drive I brought it to another Ford dealership and I paid for substantial repairs for the suspension. The first time I drove it on a bumpy the car lost control again. I managed to regain control and drive it to the side of the road and had someone pick up the car. I went to trade the car in and learned the vehicle had been in two accidents and was reported as a total loss. Per the Carfax report. We were never told it was a salvaged vehicle or we would never purchased it for our family vehicle. The vehicle is too unsafe to put back on the road. I bought a 2017 Ford Explorer at a dealership and traded in the 2016 Ford Explorer at a significant loss. The vehicle was in my possession for approx. two months where it spent most of the time in different Ford repaid shops INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Mfg Campaign: 11556734
Recall Date: Nov 25, 2023
Ford Motor Company
Defect Description:
ENGINE AND ENGINE COOLING
Potential Consequences:
The contact owns a 2016 Ford Explorer. The contact stated while driving approximately 60 MPH, the vehicle was not accelerating as needed with the accelerator pedal depressed. The contact stated that the check engine warning light illuminated, then flashed several times and then turned off. The contact stated that the loss of motive power failure was intermittent but had reoccurred. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that the water pump and timing belt needed to be replaced. The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 153,000.
Corrective Action:
The contact owns a 2016 Ford Explorer. The contact stated while driving approximately 60 MPH, the vehicle was not accelerating as needed with the accelerator pedal depressed. The contact stated that the check engine warning light illuminated, then flashed several times and then turned off. The contact stated that the loss of motive power failure was intermittent but had reoccurred. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that the water pump and timing belt needed to be replaced. The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 153,000.
Additional Notes:
The contact owns a 2016 Ford Explorer. The contact stated while driving approximately 60 MPH, the vehicle was not accelerating as needed with the accelerator pedal depressed. The contact stated that the check engine warning light illuminated, then flashed several times and then turned off. The contact stated that the loss of motive power failure was intermittent but had reoccurred. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that the water pump and timing belt needed to be replaced. The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 153,000.
Mfg Campaign: 11556410
Recall Date: Nov 22, 2023
Ford Motor Company
Defect Description:
SUSPENSION
Potential Consequences:
The rear toe suspension link failed on my Ford 2016 Explorer Sport for the 4th time on 10/20/2023 while I was driving. I heard a pop and lost total control of my vehicle. My vehicle immediately veered right going down an embankment. Thankfully trees where there to stop the vehicle from going into a roll. My safety was put at risk. I could of died. I have sustained injuries physically and mentally fromt he crash. My children were just in that car, I had just dropped them off at school an hour prior. No warning lamps. The police only did an accident report. My insurance has been contacting me about the noise I heard right before loosing all control. The rear suspension toe link has been recalled and fixed three times prior to this happening. This is the forth time this part has broke on me. This time I am lucky to walk away.
Corrective Action:
The rear toe suspension link failed on my Ford 2016 Explorer Sport for the 4th time on 10/20/2023 while I was driving. I heard a pop and lost total control of my vehicle. My vehicle immediately veered right going down an embankment. Thankfully trees where there to stop the vehicle from going into a roll. My safety was put at risk. I could of died. I have sustained injuries physically and mentally fromt he crash. My children were just in that car, I had just dropped them off at school an hour prior. No warning lamps. The police only did an accident report. My insurance has been contacting me about the noise I heard right before loosing all control. The rear suspension toe link has been recalled and fixed three times prior to this happening. This is the forth time this part has broke on me. This time I am lucky to walk away.
Additional Notes:
The rear toe suspension link failed on my Ford 2016 Explorer Sport for the 4th time on 10/20/2023 while I was driving. I heard a pop and lost total control of my vehicle. My vehicle immediately veered right going down an embankment. Thankfully trees where there to stop the vehicle from going into a roll. My safety was put at risk. I could of died. I have sustained injuries physically and mentally fromt he crash. My children were just in that car, I had just dropped them off at school an hour prior. No warning lamps. The police only did an accident report. My insurance has been contacting me about the noise I heard right before loosing all control. The rear suspension toe link has been recalled and fixed three times prior to this happening. This is the forth time this part has broke on me. This time I am lucky to walk away.
Mfg Campaign: 11556061
Recall Date: Nov 20, 2023
Ford Motor Company
Defect Description:
VEHICLE SPEED CONTROL
Potential Consequences:
I was stopped at a major intersection (very busy) at a red light when my car quit. I tried to restart the car but nothing happened. I was at the bottom of a hill, which has a turn not long before you reach this intersection, the speed limit is 45 mph but its normal for cars to average 50-60 mph. I put my flashers on and called AAA. Cars were piling up behind me trying to get in the other lane, horns were blowing, it was a dangerous situation! I had to remain in my car as it was not safe to get out and try to get to the side of the road. After about 15 minutes I tried to start the car again, I was able to get it going and remove myself from an unsafe situation. The car was not running properly, it was "bucking" and trying to stall, fortunately I was able to get to a safe area to pull over and get it towed. The above was written by my wife, I was not there. I am a retired Staff Engineer for a major OE and have authored many Recalls over my 35 years. This issue is a dangerous pattern failure that Ford issued a Stop Sale for. The failed part, the ETB located on the Throttle body is used on multible models with exactly the same failure. How this hasn't been recalled is amazing. This is a known safety problem, pattern failure of the ETB across madels lines that use that engine (3.5). My car is safe now but what about the ones that will failure tomorrow?
Corrective Action:
I was stopped at a major intersection (very busy) at a red light when my car quit. I tried to restart the car but nothing happened. I was at the bottom of a hill, which has a turn not long before you reach this intersection, the speed limit is 45 mph but its normal for cars to average 50-60 mph. I put my flashers on and called AAA. Cars were piling up behind me trying to get in the other lane, horns were blowing, it was a dangerous situation! I had to remain in my car as it was not safe to get out and try to get to the side of the road. After about 15 minutes I tried to start the car again, I was able to get it going and remove myself from an unsafe situation. The car was not running properly, it was "bucking" and trying to stall, fortunately I was able to get to a safe area to pull over and get it towed. The above was written by my wife, I was not there. I am a retired Staff Engineer for a major OE and have authored many Recalls over my 35 years. This issue is a dangerous pattern failure that Ford issued a Stop Sale for. The failed part, the ETB located on the Throttle body is used on multible models with exactly the same failure. How this hasn't been recalled is amazing. This is a known safety problem, pattern failure of the ETB across madels lines that use that engine (3.5). My car is safe now but what about the ones that will failure tomorrow?
Additional Notes:
I was stopped at a major intersection (very busy) at a red light when my car quit. I tried to restart the car but nothing happened. I was at the bottom of a hill, which has a turn not long before you reach this intersection, the speed limit is 45 mph but its normal for cars to average 50-60 mph. I put my flashers on and called AAA. Cars were piling up behind me trying to get in the other lane, horns were blowing, it was a dangerous situation! I had to remain in my car as it was not safe to get out and try to get to the side of the road. After about 15 minutes I tried to start the car again, I was able to get it going and remove myself from an unsafe situation. The car was not running properly, it was "bucking" and trying to stall, fortunately I was able to get to a safe area to pull over and get it towed. The above was written by my wife, I was not there. I am a retired Staff Engineer for a major OE and have authored many Recalls over my 35 years. This issue is a dangerous pattern failure that Ford issued a Stop Sale for. The failed part, the ETB located on the Throttle body is used on multible models with exactly the same failure. How this hasn't been recalled is amazing. This is a known safety problem, pattern failure of the ETB across madels lines that use that engine (3.5). My car is safe now but what about the ones that will failure tomorrow?
Mfg Campaign: 11555649
Recall Date: Nov 17, 2023
Ford Motor Company
Defect Description:
UNKNOWN OR OTHER
Potential Consequences:
I was driving on the highway and heard a loud noise didn’t know what it was until I got home and realized my windshield trim on passenger side was not on there anymore. It had flown off while driving down the highway.
Corrective Action:
I was driving on the highway and heard a loud noise didn’t know what it was until I got home and realized my windshield trim on passenger side was not on there anymore. It had flown off while driving down the highway.
Additional Notes:
I was driving on the highway and heard a loud noise didn’t know what it was until I got home and realized my windshield trim on passenger side was not on there anymore. It had flown off while driving down the highway.
Mfg Campaign: 11555366
Recall Date: Nov 15, 2023
Ford Motor Company
Defect Description:
STRUCTURE
Potential Consequences:
I was driving on the highway and heard a loud noise didn’t know what it was until I got home and realized my windshield trim on passenger side was not on there anymore. It had flown off while driving down the highway.
Corrective Action:
I was driving on the highway and heard a loud noise didn’t know what it was until I got home and realized my windshield trim on passenger side was not on there anymore. It had flown off while driving down the highway.
Additional Notes:
I was driving on the highway and heard a loud noise didn’t know what it was until I got home and realized my windshield trim on passenger side was not on there anymore. It had flown off while driving down the highway.
Mfg Campaign: 11555366
Recall Date: Nov 15, 2023
Ford Motor Company
Defect Description:
UNKNOWN OR OTHER
Potential Consequences:
My side pillar on the passenger side of my 2016 Ford Explorer door came off and I had to buy a new one. Now my A-Pillar on the drivers windshield has come off as I was on the freeway. This is safety issue for me and other drivers who may be struck. I read that this is a known issue with the 5th generation Explorers. I wanted to see if Ford has acknowledged this and has a fix in place for this issue. Thanks
Corrective Action:
My side pillar on the passenger side of my 2016 Ford Explorer door came off and I had to buy a new one. Now my A-Pillar on the drivers windshield has come off as I was on the freeway. This is safety issue for me and other drivers who may be struck. I read that this is a known issue with the 5th generation Explorers. I wanted to see if Ford has acknowledged this and has a fix in place for this issue. Thanks
Additional Notes:
My side pillar on the passenger side of my 2016 Ford Explorer door came off and I had to buy a new one. Now my A-Pillar on the drivers windshield has come off as I was on the freeway. This is safety issue for me and other drivers who may be struck. I read that this is a known issue with the 5th generation Explorers. I wanted to see if Ford has acknowledged this and has a fix in place for this issue. Thanks
Mfg Campaign: 11554907
Recall Date: Nov 13, 2023
Ford Motor Company
Defect Description:
ENGINE
Potential Consequences:
My Explorer engine blew a head gasket while I was driving and I had to maneuver quite a bit to avoid having multiple accidents. I had it towed to a shop and they said the engine was bad and caused by a known problem with Ford Ecoboost engines.
Corrective Action:
My Explorer engine blew a head gasket while I was driving and I had to maneuver quite a bit to avoid having multiple accidents. I had it towed to a shop and they said the engine was bad and caused by a known problem with Ford Ecoboost engines.
Additional Notes:
My Explorer engine blew a head gasket while I was driving and I had to maneuver quite a bit to avoid having multiple accidents. I had it towed to a shop and they said the engine was bad and caused by a known problem with Ford Ecoboost engines.
Mfg Campaign: 11554766
Recall Date: Nov 12, 2023
Ford Motor Company
Defect Description:
STEERING
Potential Consequences:
The steering rack failed while operating the vehicle at approximately 40 mph resulting in a near total loss of steering. It required extreme force to turn the steering wheel to avoid oncoming traffic on a bend in the road before finally moving out of the roadway. The warning message displayed at the time of the fault was "Steering Assist Fault Service Required." The component had to be replaced when it was evaluated by the Ford dealer
Corrective Action:
The steering rack failed while operating the vehicle at approximately 40 mph resulting in a near total loss of steering. It required extreme force to turn the steering wheel to avoid oncoming traffic on a bend in the road before finally moving out of the roadway. The warning message displayed at the time of the fault was "Steering Assist Fault Service Required." The component had to be replaced when it was evaluated by the Ford dealer
Additional Notes:
The steering rack failed while operating the vehicle at approximately 40 mph resulting in a near total loss of steering. It required extreme force to turn the steering wheel to avoid oncoming traffic on a bend in the road before finally moving out of the roadway. The warning message displayed at the time of the fault was "Steering Assist Fault Service Required." The component had to be replaced when it was evaluated by the Ford dealer
Mfg Campaign: 11554383
Recall Date: Nov 9, 2023
Ford Motor Company
Defect Description:
STRUCTURE:BODY
Potential Consequences:
In 2021, driving down the highway, our driver side windshield trim partially broke free and started smacking against the driver side window before breaking off and flying behind the vehicle. Then in July 2023, the passenger side windshield trim broke free on the highway. Appears the rubber seal disintegrates allowing the wind to grab it and rip the plastic trim piece off the vehicle. Currently, the rubber seal on the engine cowl windshield trim is disintegrating also.
Corrective Action:
In 2021, driving down the highway, our driver side windshield trim partially broke free and started smacking against the driver side window before breaking off and flying behind the vehicle. Then in July 2023, the passenger side windshield trim broke free on the highway. Appears the rubber seal disintegrates allowing the wind to grab it and rip the plastic trim piece off the vehicle. Currently, the rubber seal on the engine cowl windshield trim is disintegrating also.
Additional Notes:
In 2021, driving down the highway, our driver side windshield trim partially broke free and started smacking against the driver side window before breaking off and flying behind the vehicle. Then in July 2023, the passenger side windshield trim broke free on the highway. Appears the rubber seal disintegrates allowing the wind to grab it and rip the plastic trim piece off the vehicle. Currently, the rubber seal on the engine cowl windshield trim is disintegrating also.
Mfg Campaign: 11554161
Recall Date: Nov 8, 2023
Ford Motor Company
Defect Description:
STRUCTURE:BODY
Potential Consequences:
Passenger Side windshield molding Trim flew off on the highway speed.
Corrective Action:
Passenger Side windshield molding Trim flew off on the highway speed.
Additional Notes:
Passenger Side windshield molding Trim flew off on the highway speed.
Mfg Campaign: 11553537
Recall Date: Nov 4, 2023
Ford Motor Company
Defect Description:
UNKNOWN OR OTHER
Potential Consequences:
All of the moulding, seals & rubber windshield trim/gasket around the windshield has failed. It has cracked, broken off and much is now missing off the vehicle. Now when I drive the vehicle it makes scary noises due to the cracked/missing moulding/seals. This has created some scary driving situations that almost caused accidents while on highways. Now I worry my windshield will leak and damage the interior. This does not seem to be something that should be happening to my Ford Explorer and why isn't this a recall issue.
Corrective Action:
All of the moulding, seals & rubber windshield trim/gasket around the windshield has failed. It has cracked, broken off and much is now missing off the vehicle. Now when I drive the vehicle it makes scary noises due to the cracked/missing moulding/seals. This has created some scary driving situations that almost caused accidents while on highways. Now I worry my windshield will leak and damage the interior. This does not seem to be something that should be happening to my Ford Explorer and why isn't this a recall issue.
Additional Notes:
All of the moulding, seals & rubber windshield trim/gasket around the windshield has failed. It has cracked, broken off and much is now missing off the vehicle. Now when I drive the vehicle it makes scary noises due to the cracked/missing moulding/seals. This has created some scary driving situations that almost caused accidents while on highways. Now I worry my windshield will leak and damage the interior. This does not seem to be something that should be happening to my Ford Explorer and why isn't this a recall issue.
Mfg Campaign: 11553408
Recall Date: Nov 3, 2023
Ford Motor Company
Defect Description:
VISIBILITY/WIPER
Potential Consequences:
All of the moulding, seals & rubber windshield trim/gasket around the windshield has failed. It has cracked, broken off and much is now missing off the vehicle. Now when I drive the vehicle it makes scary noises due to the cracked/missing moulding/seals. This has created some scary driving situations that almost caused accidents while on highways. Now I worry my windshield will leak and damage the interior. This does not seem to be something that should be happening to my Ford Explorer and why isn't this a recall issue.
Corrective Action:
All of the moulding, seals & rubber windshield trim/gasket around the windshield has failed. It has cracked, broken off and much is now missing off the vehicle. Now when I drive the vehicle it makes scary noises due to the cracked/missing moulding/seals. This has created some scary driving situations that almost caused accidents while on highways. Now I worry my windshield will leak and damage the interior. This does not seem to be something that should be happening to my Ford Explorer and why isn't this a recall issue.
Additional Notes:
All of the moulding, seals & rubber windshield trim/gasket around the windshield has failed. It has cracked, broken off and much is now missing off the vehicle. Now when I drive the vehicle it makes scary noises due to the cracked/missing moulding/seals. This has created some scary driving situations that almost caused accidents while on highways. Now I worry my windshield will leak and damage the interior. This does not seem to be something that should be happening to my Ford Explorer and why isn't this a recall issue.
Mfg Campaign: 11553408
Recall Date: Nov 3, 2023
Ford Motor Company
Defect Description:
POWER TRAIN
Potential Consequences:
The contact owns a 2016 Ford Explorer. The contact stated while driving at an undisclosed speed, she heard an abnormal sound coming from underneath the vehicle, and the vehicle was shifting hard. No warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the gear position sensor. The vehicle was not repaired. The manufacturer was notified of the failure but referred the contact to the NHTSA Hotline for assistance. The failure mileage was 12,000.
Corrective Action:
The contact owns a 2016 Ford Explorer. The contact stated while driving at an undisclosed speed, she heard an abnormal sound coming from underneath the vehicle, and the vehicle was shifting hard. No warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the gear position sensor. The vehicle was not repaired. The manufacturer was notified of the failure but referred the contact to the NHTSA Hotline for assistance. The failure mileage was 12,000.
Additional Notes:
The contact owns a 2016 Ford Explorer. The contact stated while driving at an undisclosed speed, she heard an abnormal sound coming from underneath the vehicle, and the vehicle was shifting hard. No warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the gear position sensor. The vehicle was not repaired. The manufacturer was notified of the failure but referred the contact to the NHTSA Hotline for assistance. The failure mileage was 12,000.
Mfg Campaign: 11553498
Recall Date: Nov 3, 2023
Ford Motor Company
Defect Description:
AIR BAGS
Potential Consequences:
Back up camera went out and later came on. Today we have been driving the last hour with airbag indicator on. Camera incident was 10-29-2023.
Corrective Action:
Back up camera went out and later came on. Today we have been driving the last hour with airbag indicator on. Camera incident was 10-29-2023.
Additional Notes:
Back up camera went out and later came on. Today we have been driving the last hour with airbag indicator on. Camera incident was 10-29-2023.
Mfg Campaign: 11553254
Recall Date: Nov 2, 2023
Ford Motor Company
Defect Description:
LANE DEPARTURE: BLIND SPOT DETECTION
Potential Consequences:
Back up camera went out and later came on. Today we have been driving the last hour with airbag indicator on. Camera incident was 10-29-2023.
Corrective Action:
Back up camera went out and later came on. Today we have been driving the last hour with airbag indicator on. Camera incident was 10-29-2023.
Additional Notes:
Back up camera went out and later came on. Today we have been driving the last hour with airbag indicator on. Camera incident was 10-29-2023.
Mfg Campaign: 11553254
Recall Date: Nov 2, 2023
Ford Motor Company
Defect Description:
BACK OVER PREVENTION: SENSING SYSTEM: CAMERA
Potential Consequences:
Back up camera went out and later came on. Today we have been driving the last hour with airbag indicator on. Camera incident was 10-29-2023.
Corrective Action:
Back up camera went out and later came on. Today we have been driving the last hour with airbag indicator on. Camera incident was 10-29-2023.
Additional Notes:
Back up camera went out and later came on. Today we have been driving the last hour with airbag indicator on. Camera incident was 10-29-2023.
Mfg Campaign: 11553254
Recall Date: Nov 2, 2023
Need Legal Help?
Featured Attorneys
Barry Edzant
Edzant Price LLC
Valencia, CA • 36 yrs
Focus: Lemon Law, Personal Injury