Complaints & Recalls
Official Safety Recalls - Important!
54 RecallsThese are official manufacturer recalls ordered by NHTSA for safety defects. If you own this vehicle, contact your dealer immediately for free repairs.
Ford Motor Company
Safety Issue:
Ford Motor Company (Ford) is recalling certain 2021-2023 Bronco, Explorer, Lincoln Aviator, F-250 SD, F-350 SD, F-450 SD, F-550 SD, 2021-2022 Lincoln Navigator, Mustang, F-150, and 2022 Expedition vehicles. The low-pressure fuel pump may fail, which can result in an engine stall while driving.
Potential Risk:
FREE Recall Solution:
Mfg Campaign: 25S75
Ford Motor Company
Safety Issue:
Ford Motor Company (Ford) is recalling certain 2021-2022 Bronco vehicles equipped with 8-inch SYNC infotainment screens that were repaired incorrectly under recall 22V-825. The rearview camera image may still be displayed after a backing event has ended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 888-327-4236 (TTY 888-275-9171) or go to nhtsa.gov.
Mfg Campaign: 25C14
Recall Date: May 9, 2025
Ford Motor Company
Safety Issue:
Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco, F-150, 2021-2024 Edge, 2023-2024 Escape, F-250, F-350, F-450, F-550, F-600, 2022-2024 Expedition, 2022-2025 Transit, 2021-2023 Mach-E, 2024 Ranger, Mustang, 2021-2023 Lincoln Nautilus, 2022-2024 Navigator, and 2023-2024 Corsair vehicles. A software error may cause the rearview camera image to delay, freeze, or not display when the vehicle is in reverse.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 888-327-4236 (TTY 888-275-9171) or go to nhtsa.gov.
Mfg Campaign: 25S49
Ford Motor Company
Safety Issue:
Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco vehicles. The rear shock absorbers may corrode and fail, resulting in detachment of the external reservoir.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153) or go to nhtsa.gov.
Mfg Campaign: 25S01
Ford Motor Company
Safety Issue:
Ford Motor Company (Ford) is recalling certain 2021-2022 Bronco, F-150, Edge, Explorer, Lincoln Nautilus, and Lincoln Aviator vehicles equipped with either a 2.7L or 3.0L Nano EcoBoost engine. The engine intake valves may break while driving, which can result in engine failure and a loss of drive power.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Mfg Campaign: 24S55
Recall Date: Aug 23, 2024
Ford Motor Company
Safety Issue:
Ford Motor Company (Ford) is recalling certain 2020-2023 Lincoln Aviator, 2018-2021 Lincoln Navigator, 2022-2023 Ford Transit, and 2021 Ford Bronco vehicles. The rearview camera, or 360-degree view camera if equipped, may not display a rearview image when the vehicle is placed in reverse.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Mfg Campaign: 23S48
Recall Date: Aug 25, 2023
Ford Motor Company
Safety Issue:
Ford Motor Company (Ford) is recalling certain 2021-2023 Bronco vehicles built with the 5-Door body style. The first-row seat belt latch plates may be difficult to access from their stowed position. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Mfg Campaign: 23C16
Recall Date: May 18, 2023
Ford Motor Company
Safety Issue:
Ford Motor Company (Ford) is recalling certain 2021-2022 Bronco vehicles equipped with 8-inch SYNC infotainment screens that were previously remedied under recall 22V-825. The rearview camera image may still be displayed after a backing event has ended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Mfg Campaign: 23C05
Recall Date: Mar 10, 2023
Ford Motor Company
Safety Issue:
Ford Motor Company (Ford) is recalling certain 2021-2022 Bronco vehicles. The right or left side impact sensors may not be properly secured to the vehicle.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Mfg Campaign: 22S77
Recall Date: Dec 14, 2022
Ford Motor Company
Safety Issue:
Ford Motor Company (Ford) is recalling certain 2021-2022 Bronco vehicles equipped with rearview camera systems and 8-inch screen displays. The rearview camera image may still be displayed after a backing event has ended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Mfg Campaign: 22C27
Recall Date: Nov 3, 2022
Ford Motor Company
Safety Issue:
Ford Motor Company (Ford) is recalling certain four-door 2021-2022 Bronco vehicles. The passenger-side rear door may be opened from inside of the vehicle when the child safety lock is in the "ON" position.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Mfg Campaign: 22S44
Recall Date: Jun 10, 2022
Ford Motor Company
Safety Issue:
Ford Motor Company (Ford) is recalling certain 2021 Ranger and Bronco vehicles. The cruise control radar module was misaligned during production.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Mfg Campaign: 21S52
Recall Date: Dec 16, 2021
Ford Motor Company
Safety Issue:
Ford Motor Company (Ford) is recalling certain 2021 Bronco vehicles. During passenger air bag deployment, an air bag vent could open prematurely and result in an improper deployment. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Mfg Campaign: 21C23
Recall Date: Oct 1, 2021
Consumer Complaints
225 ComplaintsFord Motor Company
Defect Description:
FUEL/PROPULSION SYSTEM
Potential Consequences:
On June 9, 2022, while traveling on an Interstate Highway at about 80 mph, the engine sputtered and died without any warning light activation. The vehicle failure caused an extremely unsafe condition which caused me to navigate without power, in moderate traffic, from the #1 lane, across the #2 lane and onto the shoulder. The failure caused me to perform this high risk maneuver in front of an approaching big rig traveling in the #2 lane. The vehicle was towed to the nearest Ford dealership where an inspection determined the fuel pump had failed. The fuel pump was replaced but the dealership did not know if the replacement had been redesigned to prevent such catastrophic failures in the future. The loss of power was sudden and immediate without any prior warning messages and/or warning lamp activation.
Corrective Action:
On June 9, 2022, while traveling on an Interstate Highway at about 80 mph, the engine sputtered and died without any warning light activation. The vehicle failure caused an extremely unsafe condition which caused me to navigate without power, in moderate traffic, from the #1 lane, across the #2 lane and onto the shoulder. The failure caused me to perform this high risk maneuver in front of an approaching big rig traveling in the #2 lane. The vehicle was towed to the nearest Ford dealership where an inspection determined the fuel pump had failed. The fuel pump was replaced but the dealership did not know if the replacement had been redesigned to prevent such catastrophic failures in the future. The loss of power was sudden and immediate without any prior warning messages and/or warning lamp activation.
Additional Notes:
On June 9, 2022, while traveling on an Interstate Highway at about 80 mph, the engine sputtered and died without any warning light activation. The vehicle failure caused an extremely unsafe condition which caused me to navigate without power, in moderate traffic, from the #1 lane, across the #2 lane and onto the shoulder. The failure caused me to perform this high risk maneuver in front of an approaching big rig traveling in the #2 lane. The vehicle was towed to the nearest Ford dealership where an inspection determined the fuel pump had failed. The fuel pump was replaced but the dealership did not know if the replacement had been redesigned to prevent such catastrophic failures in the future. The loss of power was sudden and immediate without any prior warning messages and/or warning lamp activation.
Mfg Campaign: 11470405
Recall Date: Jun 22, 2022
Ford Motor Company
Defect Description:
ENGINE
Potential Consequences:
About 1 hour into our trip the vehicle started to shutter while at highway speed, no warning lamps or notices were indicated when the shutter started and I assumed it was a road vibration. We came to a stop sign about 2-3 miles after the shutter was noticed and the vehicle stalled at the intersection and would not restart. At that point the check engine light, in dash notifications and Fordpass app notices indicated a serious mechanical malfunction. The vehicle needed to be put in neutral and pushed to the side of the road by me and my son to clear the intersection. Ford roadside assistance was contacted and a tow truck was dispatched to take the vehicle to the closest dealership. We sat at the side of the road for 2 hours waiting on the ford dispatched tow truck. The vehicle was towed to Ford of Clermonth. The Ford of Clermont, Florida service department ran diagnostics on the vehicle the next morning(12/06/21). The Ford service technician, following Ford's diagnostic directions, determined there was catastrophic engine failure and Ford immediately authorized an engine replacement. As per the attached service invoice the Ford Service technicians determined it was a valve failure that caused the engine failure.
Corrective Action:
About 1 hour into our trip the vehicle started to shutter while at highway speed, no warning lamps or notices were indicated when the shutter started and I assumed it was a road vibration. We came to a stop sign about 2-3 miles after the shutter was noticed and the vehicle stalled at the intersection and would not restart. At that point the check engine light, in dash notifications and Fordpass app notices indicated a serious mechanical malfunction. The vehicle needed to be put in neutral and pushed to the side of the road by me and my son to clear the intersection. Ford roadside assistance was contacted and a tow truck was dispatched to take the vehicle to the closest dealership. We sat at the side of the road for 2 hours waiting on the ford dispatched tow truck. The vehicle was towed to Ford of Clermonth. The Ford of Clermont, Florida service department ran diagnostics on the vehicle the next morning(12/06/21). The Ford service technician, following Ford's diagnostic directions, determined there was catastrophic engine failure and Ford immediately authorized an engine replacement. As per the attached service invoice the Ford Service technicians determined it was a valve failure that caused the engine failure.
Additional Notes:
About 1 hour into our trip the vehicle started to shutter while at highway speed, no warning lamps or notices were indicated when the shutter started and I assumed it was a road vibration. We came to a stop sign about 2-3 miles after the shutter was noticed and the vehicle stalled at the intersection and would not restart. At that point the check engine light, in dash notifications and Fordpass app notices indicated a serious mechanical malfunction. The vehicle needed to be put in neutral and pushed to the side of the road by me and my son to clear the intersection. Ford roadside assistance was contacted and a tow truck was dispatched to take the vehicle to the closest dealership. We sat at the side of the road for 2 hours waiting on the ford dispatched tow truck. The vehicle was towed to Ford of Clermonth. The Ford of Clermont, Florida service department ran diagnostics on the vehicle the next morning(12/06/21). The Ford service technician, following Ford's diagnostic directions, determined there was catastrophic engine failure and Ford immediately authorized an engine replacement. As per the attached service invoice the Ford Service technicians determined it was a valve failure that caused the engine failure.
Mfg Campaign: 11468924
Recall Date: Jun 13, 2022
Ford Motor Company
Defect Description:
ENGINE
Potential Consequences:
According the the service department at the Dealership, the valves on my vehicle's engine failed and caused a complete engine failure.
Corrective Action:
According the the service department at the Dealership, the valves on my vehicle's engine failed and caused a complete engine failure.
Additional Notes:
According the the service department at the Dealership, the valves on my vehicle's engine failed and caused a complete engine failure.
Mfg Campaign: 11469069
Recall Date: Jun 13, 2022
Ford Motor Company
Defect Description:
ENGINE
Potential Consequences:
Engine completely destroyed with no notice at 4600 miles destroyed itself in less than three minutes while driving. New engine replaced
Corrective Action:
Engine completely destroyed with no notice at 4600 miles destroyed itself in less than three minutes while driving. New engine replaced
Additional Notes:
Engine completely destroyed with no notice at 4600 miles destroyed itself in less than three minutes while driving. New engine replaced
Mfg Campaign: 11468883
Recall Date: Jun 12, 2022
Ford Motor Company
Defect Description:
ENGINE
Potential Consequences:
Engine died, won’t start again
Corrective Action:
Engine died, won’t start again
Additional Notes:
Engine died, won’t start again
Mfg Campaign: 11468566
Recall Date: Jun 10, 2022
Ford Motor Company
Defect Description:
ENGINE
Potential Consequences:
8:28pm 6.8.2022 - Bronco was towing 1 boat on a single axle trailer (total weight less than 3000lbs). - First soft top convertible roof panel was open - Music playing at medium volume to drown out adjacent highway noise - Heading NE on the Highway 820 feeder road. - Stopped at stop sign at intersection of Cahoba Drive. - Pulled out of intersection and was traveling on a slight uphill at 18pmh - Interior of vehicle smelled sweet and we noticed white smoke filling behind the vehicle - Warning lights for Battery (red battery) and Service (wrench) came on and then a warning to stop vehicle and restart engine. This coincided with a sudden decrease in power. - Pulled to the side of the road to a safe position and powered off the engine, allowed several minutes for it to cool then attempted to restart the engine with no luck. Service (wrench) light turned off and Check Engine light came on. - Open hood to allow engine too continue to cool and to check for exterior engine damage. - Documented current state of vehicle with photos. - Had Ford tow to Grapevine Ford in Grapevine, TX. 8am 6.9.2022 - Service Advisor reached out to confirm vehicle was in shop and would be looked at this week. - I advised that based on the engine build date on the engine sticker, this vehicle was in the batch of potentially faulty valves from the Lima facility. He said he and Ford had no knowledge of potentially faulty valves and that the tech would perform the necessary checks. 10am 6.10.2022 - Service Advisor & Manager reached out to advise that one spark plug was sheared off and that the engine would need to be replaced and possibly the turbos; FoMoCo would confirm what to replace. They actively avoided any discussion of the valves and did not respond when I mentioned them. I verbally requested copies of all videos/photos/reports related to my vehicle and access to parts. 1pm - I requested via text message to Scott Service Advisor access to the my request above. Dealer to follow up next week
Corrective Action:
8:28pm 6.8.2022 - Bronco was towing 1 boat on a single axle trailer (total weight less than 3000lbs). - First soft top convertible roof panel was open - Music playing at medium volume to drown out adjacent highway noise - Heading NE on the Highway 820 feeder road. - Stopped at stop sign at intersection of Cahoba Drive. - Pulled out of intersection and was traveling on a slight uphill at 18pmh - Interior of vehicle smelled sweet and we noticed white smoke filling behind the vehicle - Warning lights for Battery (red battery) and Service (wrench) came on and then a warning to stop vehicle and restart engine. This coincided with a sudden decrease in power. - Pulled to the side of the road to a safe position and powered off the engine, allowed several minutes for it to cool then attempted to restart the engine with no luck. Service (wrench) light turned off and Check Engine light came on. - Open hood to allow engine too continue to cool and to check for exterior engine damage. - Documented current state of vehicle with photos. - Had Ford tow to Grapevine Ford in Grapevine, TX. 8am 6.9.2022 - Service Advisor reached out to confirm vehicle was in shop and would be looked at this week. - I advised that based on the engine build date on the engine sticker, this vehicle was in the batch of potentially faulty valves from the Lima facility. He said he and Ford had no knowledge of potentially faulty valves and that the tech would perform the necessary checks. 10am 6.10.2022 - Service Advisor & Manager reached out to advise that one spark plug was sheared off and that the engine would need to be replaced and possibly the turbos; FoMoCo would confirm what to replace. They actively avoided any discussion of the valves and did not respond when I mentioned them. I verbally requested copies of all videos/photos/reports related to my vehicle and access to parts. 1pm - I requested via text message to Scott Service Advisor access to the my request above. Dealer to follow up next week
Additional Notes:
8:28pm 6.8.2022 - Bronco was towing 1 boat on a single axle trailer (total weight less than 3000lbs). - First soft top convertible roof panel was open - Music playing at medium volume to drown out adjacent highway noise - Heading NE on the Highway 820 feeder road. - Stopped at stop sign at intersection of Cahoba Drive. - Pulled out of intersection and was traveling on a slight uphill at 18pmh - Interior of vehicle smelled sweet and we noticed white smoke filling behind the vehicle - Warning lights for Battery (red battery) and Service (wrench) came on and then a warning to stop vehicle and restart engine. This coincided with a sudden decrease in power. - Pulled to the side of the road to a safe position and powered off the engine, allowed several minutes for it to cool then attempted to restart the engine with no luck. Service (wrench) light turned off and Check Engine light came on. - Open hood to allow engine too continue to cool and to check for exterior engine damage. - Documented current state of vehicle with photos. - Had Ford tow to Grapevine Ford in Grapevine, TX. 8am 6.9.2022 - Service Advisor reached out to confirm vehicle was in shop and would be looked at this week. - I advised that based on the engine build date on the engine sticker, this vehicle was in the batch of potentially faulty valves from the Lima facility. He said he and Ford had no knowledge of potentially faulty valves and that the tech would perform the necessary checks. 10am 6.10.2022 - Service Advisor & Manager reached out to advise that one spark plug was sheared off and that the engine would need to be replaced and possibly the turbos; FoMoCo would confirm what to replace. They actively avoided any discussion of the valves and did not respond when I mentioned them. I verbally requested copies of all videos/photos/reports related to my vehicle and access to parts. 1pm - I requested via text message to Scott Service Advisor access to the my request above. Dealer to follow up next week
Mfg Campaign: 11468654
Recall Date: Jun 10, 2022
Ford Motor Company
Defect Description:
ELECTRICAL SYSTEM
Potential Consequences:
1. Vehicle Issue. -At approximately 2k miles while driving through severe weather in the Rocky Mountains my New Bronco lost ALL electronic driving systems that controlled driving modes including 4 wheel drive modes(GOAT) along with safety systems such as traction control, sensor systems, and cruise control. I was forced to drive through a white out in Rocky Mountains with 2 wheel drive due to the electronic GOAT modes failing. This was a dangerous situation as the systems I was relying on failed me when I needed them most. These systems failed off and on for the next three months before mysteriously subsiding. 2. Attempts to resolve. - Took vehicle to Ford dealer to identify issue and they said there was no record of these failures in the code system which is extremely concerning. If I had gone off the road and injured myself and or died Ford would attempt to say there was no electronic failure when in fact there was a significant electronic failure of ALL traction systems. Fortunately I took video and photo evidence of the electronic failures. Alarmingly, these failures are not being recorded within the vehicle.
Corrective Action:
1. Vehicle Issue. -At approximately 2k miles while driving through severe weather in the Rocky Mountains my New Bronco lost ALL electronic driving systems that controlled driving modes including 4 wheel drive modes(GOAT) along with safety systems such as traction control, sensor systems, and cruise control. I was forced to drive through a white out in Rocky Mountains with 2 wheel drive due to the electronic GOAT modes failing. This was a dangerous situation as the systems I was relying on failed me when I needed them most. These systems failed off and on for the next three months before mysteriously subsiding. 2. Attempts to resolve. - Took vehicle to Ford dealer to identify issue and they said there was no record of these failures in the code system which is extremely concerning. If I had gone off the road and injured myself and or died Ford would attempt to say there was no electronic failure when in fact there was a significant electronic failure of ALL traction systems. Fortunately I took video and photo evidence of the electronic failures. Alarmingly, these failures are not being recorded within the vehicle.
Additional Notes:
1. Vehicle Issue. -At approximately 2k miles while driving through severe weather in the Rocky Mountains my New Bronco lost ALL electronic driving systems that controlled driving modes including 4 wheel drive modes(GOAT) along with safety systems such as traction control, sensor systems, and cruise control. I was forced to drive through a white out in Rocky Mountains with 2 wheel drive due to the electronic GOAT modes failing. This was a dangerous situation as the systems I was relying on failed me when I needed them most. These systems failed off and on for the next three months before mysteriously subsiding. 2. Attempts to resolve. - Took vehicle to Ford dealer to identify issue and they said there was no record of these failures in the code system which is extremely concerning. If I had gone off the road and injured myself and or died Ford would attempt to say there was no electronic failure when in fact there was a significant electronic failure of ALL traction systems. Fortunately I took video and photo evidence of the electronic failures. Alarmingly, these failures are not being recorded within the vehicle.
Mfg Campaign: 11468409
Recall Date: Jun 9, 2022
Ford Motor Company
Defect Description:
VEHICLE SPEED CONTROL
Potential Consequences:
1. Vehicle Issue. -At approximately 2k miles while driving through severe weather in the Rocky Mountains my New Bronco lost ALL electronic driving systems that controlled driving modes including 4 wheel drive modes(GOAT) along with safety systems such as traction control, sensor systems, and cruise control. I was forced to drive through a white out in Rocky Mountains with 2 wheel drive due to the electronic GOAT modes failing. This was a dangerous situation as the systems I was relying on failed me when I needed them most. These systems failed off and on for the next three months before mysteriously subsiding. 2. Attempts to resolve. - Took vehicle to Ford dealer to identify issue and they said there was no record of these failures in the code system which is extremely concerning. If I had gone off the road and injured myself and or died Ford would attempt to say there was no electronic failure when in fact there was a significant electronic failure of ALL traction systems. Fortunately I took video and photo evidence of the electronic failures. Alarmingly, these failures are not being recorded within the vehicle.
Corrective Action:
1. Vehicle Issue. -At approximately 2k miles while driving through severe weather in the Rocky Mountains my New Bronco lost ALL electronic driving systems that controlled driving modes including 4 wheel drive modes(GOAT) along with safety systems such as traction control, sensor systems, and cruise control. I was forced to drive through a white out in Rocky Mountains with 2 wheel drive due to the electronic GOAT modes failing. This was a dangerous situation as the systems I was relying on failed me when I needed them most. These systems failed off and on for the next three months before mysteriously subsiding. 2. Attempts to resolve. - Took vehicle to Ford dealer to identify issue and they said there was no record of these failures in the code system which is extremely concerning. If I had gone off the road and injured myself and or died Ford would attempt to say there was no electronic failure when in fact there was a significant electronic failure of ALL traction systems. Fortunately I took video and photo evidence of the electronic failures. Alarmingly, these failures are not being recorded within the vehicle.
Additional Notes:
1. Vehicle Issue. -At approximately 2k miles while driving through severe weather in the Rocky Mountains my New Bronco lost ALL electronic driving systems that controlled driving modes including 4 wheel drive modes(GOAT) along with safety systems such as traction control, sensor systems, and cruise control. I was forced to drive through a white out in Rocky Mountains with 2 wheel drive due to the electronic GOAT modes failing. This was a dangerous situation as the systems I was relying on failed me when I needed them most. These systems failed off and on for the next three months before mysteriously subsiding. 2. Attempts to resolve. - Took vehicle to Ford dealer to identify issue and they said there was no record of these failures in the code system which is extremely concerning. If I had gone off the road and injured myself and or died Ford would attempt to say there was no electronic failure when in fact there was a significant electronic failure of ALL traction systems. Fortunately I took video and photo evidence of the electronic failures. Alarmingly, these failures are not being recorded within the vehicle.
Mfg Campaign: 11468409
Recall Date: Jun 9, 2022
Ford Motor Company
Defect Description:
ENGINE
Potential Consequences:
The contact owns a 2021 Ford Bronco. The contact stated that while driving at an undisclosed speed, the vehicle made clicking sounds and then lost motive power. The check engine warning light was illuminated. The vehicle was towed to the dealer where it was diagnosed with engine failure. The dealer informed the contact that the engine needed to be replaced. The vehicle was not yet repaired and remained at the dealer. The manufacturer was made aware of the failure. The failure mileage was 923.
Corrective Action:
The contact owns a 2021 Ford Bronco. The contact stated that while driving at an undisclosed speed, the vehicle made clicking sounds and then lost motive power. The check engine warning light was illuminated. The vehicle was towed to the dealer where it was diagnosed with engine failure. The dealer informed the contact that the engine needed to be replaced. The vehicle was not yet repaired and remained at the dealer. The manufacturer was made aware of the failure. The failure mileage was 923.
Additional Notes:
The contact owns a 2021 Ford Bronco. The contact stated that while driving at an undisclosed speed, the vehicle made clicking sounds and then lost motive power. The check engine warning light was illuminated. The vehicle was towed to the dealer where it was diagnosed with engine failure. The dealer informed the contact that the engine needed to be replaced. The vehicle was not yet repaired and remained at the dealer. The manufacturer was made aware of the failure. The failure mileage was 923.
Mfg Campaign: 11468268
Recall Date: Jun 8, 2022
Ford Motor Company
Defect Description:
ENGINE
Potential Consequences:
While pulling up to a yield sign the vehicle lost all power and shut off causing it roll past the yield sign and come to a stop in traffic blocking the roadway. The vehicle was towed to the Ford dealership and after being diagnosed it had a broken valve that caused catastrophic failure to the engines head and caused the head of the engine to be replaced
Corrective Action:
While pulling up to a yield sign the vehicle lost all power and shut off causing it roll past the yield sign and come to a stop in traffic blocking the roadway. The vehicle was towed to the Ford dealership and after being diagnosed it had a broken valve that caused catastrophic failure to the engines head and caused the head of the engine to be replaced
Additional Notes:
While pulling up to a yield sign the vehicle lost all power and shut off causing it roll past the yield sign and come to a stop in traffic blocking the roadway. The vehicle was towed to the Ford dealership and after being diagnosed it had a broken valve that caused catastrophic failure to the engines head and caused the head of the engine to be replaced
Mfg Campaign: 11467964
Recall Date: Jun 7, 2022
Ford Motor Company
Defect Description:
UNKNOWN OR OTHER
Potential Consequences:
Loud grinding noise coming from transmission at 800 miles
Corrective Action:
Loud grinding noise coming from transmission at 800 miles
Additional Notes:
Loud grinding noise coming from transmission at 800 miles
Mfg Campaign: 11467446
Recall Date: Jun 3, 2022
Ford Motor Company
Defect Description:
POWER TRAIN:AUTOMATIC TRANSMISSION
Potential Consequences:
Loud grinding noise coming from transmission at 800 miles
Corrective Action:
Loud grinding noise coming from transmission at 800 miles
Additional Notes:
Loud grinding noise coming from transmission at 800 miles
Mfg Campaign: 11467446
Recall Date: Jun 3, 2022
Ford Motor Company
Defect Description:
VISIBILITY:WINDSHIELD
Potential Consequences:
The contact owns a 2021 Ford Bronco. While starting the vehicle the contact became aware of a line crack on the front of the windshield. The vehicle was not taken to be diagnosed or repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 7,337.
Corrective Action:
The contact owns a 2021 Ford Bronco. While starting the vehicle the contact became aware of a line crack on the front of the windshield. The vehicle was not taken to be diagnosed or repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 7,337.
Additional Notes:
The contact owns a 2021 Ford Bronco. While starting the vehicle the contact became aware of a line crack on the front of the windshield. The vehicle was not taken to be diagnosed or repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 7,337.
Mfg Campaign: 11467210
Recall Date: Jun 2, 2022
Ford Motor Company
Defect Description:
SERVICE BRAKES
Potential Consequences:
-I bought the Ford Bronco to Flat-tow behind my Motorhome. (All 4 wheels on the ground) -Per Ford this is permitted, they outline a procedure in the owner's manual on how this must be performed. -At least 48 states require a supplemental braking system on towed vehicle. -The Bronco has an Electronic Break Booster (EBB) -When the Bronco is placed in the Flat - tow mode, the last step is to turn the key off. -Ford has set a timer (30 to 45 minutes) to shut down power to the EBB, when the key is turned off. -After timer expires, the brakes have no boost. This causes any after-market braking system installed on the Bronco to be useless. -In these circumstances, The Bronco is providing no help to the motorhome for braking, causing longer braking distances. Also, If the Bronco were to become detached from the motorhome, the emergency braking system that should come on and stop the vehicle, would not work. Could cause injury or death by having a runaway. -Ford has been unresponsive in attempts to remedy the situation.
Corrective Action:
-I bought the Ford Bronco to Flat-tow behind my Motorhome. (All 4 wheels on the ground) -Per Ford this is permitted, they outline a procedure in the owner's manual on how this must be performed. -At least 48 states require a supplemental braking system on towed vehicle. -The Bronco has an Electronic Break Booster (EBB) -When the Bronco is placed in the Flat - tow mode, the last step is to turn the key off. -Ford has set a timer (30 to 45 minutes) to shut down power to the EBB, when the key is turned off. -After timer expires, the brakes have no boost. This causes any after-market braking system installed on the Bronco to be useless. -In these circumstances, The Bronco is providing no help to the motorhome for braking, causing longer braking distances. Also, If the Bronco were to become detached from the motorhome, the emergency braking system that should come on and stop the vehicle, would not work. Could cause injury or death by having a runaway. -Ford has been unresponsive in attempts to remedy the situation.
Additional Notes:
-I bought the Ford Bronco to Flat-tow behind my Motorhome. (All 4 wheels on the ground) -Per Ford this is permitted, they outline a procedure in the owner's manual on how this must be performed. -At least 48 states require a supplemental braking system on towed vehicle. -The Bronco has an Electronic Break Booster (EBB) -When the Bronco is placed in the Flat - tow mode, the last step is to turn the key off. -Ford has set a timer (30 to 45 minutes) to shut down power to the EBB, when the key is turned off. -After timer expires, the brakes have no boost. This causes any after-market braking system installed on the Bronco to be useless. -In these circumstances, The Bronco is providing no help to the motorhome for braking, causing longer braking distances. Also, If the Bronco were to become detached from the motorhome, the emergency braking system that should come on and stop the vehicle, would not work. Could cause injury or death by having a runaway. -Ford has been unresponsive in attempts to remedy the situation.
Mfg Campaign: 11465923
Recall Date: May 24, 2022
Ford Motor Company
Defect Description:
POWER TRAIN
Potential Consequences:
Transmission broke at 4,884 miles reversing out of the driveway. The driveway has no grade and never sits on a hill.
Corrective Action:
Transmission broke at 4,884 miles reversing out of the driveway. The driveway has no grade and never sits on a hill.
Additional Notes:
Transmission broke at 4,884 miles reversing out of the driveway. The driveway has no grade and never sits on a hill.
Mfg Campaign: 11465356
Recall Date: May 19, 2022
Ford Motor Company
Defect Description:
ENGINE
Potential Consequences:
Engine failure. My wife was driving the vehicle and was enveloped in smoke and the engine stopped and she was stuck in the middle lane of a busy road in rush hour. A dangerous section of road a few miles from our house. I drove down and gave her my SUV and then called AAA who towed it to the dealership. The motor was dead. The vehicle was towed to Future Ford of Sacramento. They then diagnosed it a few days later and informed us that it is a complete engine failure and that it will take several months to get the vehicle back to us. There were no warning lights or any warning prior to the engine stopping and a large amount of smoke to the point that my wife thought the whole vehicle was on fire. Four people stopped to help her and get her to the side of the road.
Corrective Action:
Engine failure. My wife was driving the vehicle and was enveloped in smoke and the engine stopped and she was stuck in the middle lane of a busy road in rush hour. A dangerous section of road a few miles from our house. I drove down and gave her my SUV and then called AAA who towed it to the dealership. The motor was dead. The vehicle was towed to Future Ford of Sacramento. They then diagnosed it a few days later and informed us that it is a complete engine failure and that it will take several months to get the vehicle back to us. There were no warning lights or any warning prior to the engine stopping and a large amount of smoke to the point that my wife thought the whole vehicle was on fire. Four people stopped to help her and get her to the side of the road.
Additional Notes:
Engine failure. My wife was driving the vehicle and was enveloped in smoke and the engine stopped and she was stuck in the middle lane of a busy road in rush hour. A dangerous section of road a few miles from our house. I drove down and gave her my SUV and then called AAA who towed it to the dealership. The motor was dead. The vehicle was towed to Future Ford of Sacramento. They then diagnosed it a few days later and informed us that it is a complete engine failure and that it will take several months to get the vehicle back to us. There were no warning lights or any warning prior to the engine stopping and a large amount of smoke to the point that my wife thought the whole vehicle was on fire. Four people stopped to help her and get her to the side of the road.
Mfg Campaign: 11464516
Recall Date: May 13, 2022
Ford Motor Company
Defect Description:
ENGINE
Potential Consequences:
at 2,000 miles the engine dropped a valve. Vehicle has already received a new engine. Vehicle shut off running down the interstate. safety was had to coast to shoulder and wait on tow truck.
Corrective Action:
at 2,000 miles the engine dropped a valve. Vehicle has already received a new engine. Vehicle shut off running down the interstate. safety was had to coast to shoulder and wait on tow truck.
Additional Notes:
at 2,000 miles the engine dropped a valve. Vehicle has already received a new engine. Vehicle shut off running down the interstate. safety was had to coast to shoulder and wait on tow truck.
Mfg Campaign: 11463199
Recall Date: May 3, 2022
Ford Motor Company
Defect Description:
ENGINE
Potential Consequences:
On Monday, March 7, 2021, my Ford Bronco First Edition with the 2.7 engine experienced catastrophic engine failure. I was driving near my home when my vehicle stopped running. I did feel a strange pull in my steering and tires; but I was also driving on ice and assumed it was the traction control system at play. I was wrong. It was my engine losing compression and my engine failing. My dash lit up with a series of errors (all in quick succession and could not catch them all) and my vehicle lost all power and control. As mentioned above, I was driving on ice covered roads and had difficulty steering. I attempted to pull off the road and into a parking lot; however, the drive sloped up and I could not get clear of the entryway. I had to stop blocking the entrance to the veterinarian's parking lot. To increase the risk here, my vehicle was not visible from traffic turning in because of snow banks that were taller than my vehicle. I want to stress how incredibly lucky I was that this happened close to home. I went on a road trip and had returned home the night before. We had contemplated taking the Bronco. If we had, we would have broken down on the Parks Highway in Alaska. This highway is remote at most times with spotty cell service. The risks of having broken down in subzero temperatures with zero help was extremely high in my area. I also consider myself extremely lucky that I had a friend that was able to come move my vehicle from blocking the business entrance. When I used the Ford app to get a tow, it quoted me 7 hours. I did call and complain that that was unacceptable. The vehicle was towed to the dealership and catastrophic engine failure was determined with a faulty valve being the contributing factor. This is a known valve issue and I have included my engine build date sticker in the photos. I included a photo of my Bronco being loaded on the tow truck showing the ice roads and snow bank blocking my car from view.
Corrective Action:
On Monday, March 7, 2021, my Ford Bronco First Edition with the 2.7 engine experienced catastrophic engine failure. I was driving near my home when my vehicle stopped running. I did feel a strange pull in my steering and tires; but I was also driving on ice and assumed it was the traction control system at play. I was wrong. It was my engine losing compression and my engine failing. My dash lit up with a series of errors (all in quick succession and could not catch them all) and my vehicle lost all power and control. As mentioned above, I was driving on ice covered roads and had difficulty steering. I attempted to pull off the road and into a parking lot; however, the drive sloped up and I could not get clear of the entryway. I had to stop blocking the entrance to the veterinarian's parking lot. To increase the risk here, my vehicle was not visible from traffic turning in because of snow banks that were taller than my vehicle. I want to stress how incredibly lucky I was that this happened close to home. I went on a road trip and had returned home the night before. We had contemplated taking the Bronco. If we had, we would have broken down on the Parks Highway in Alaska. This highway is remote at most times with spotty cell service. The risks of having broken down in subzero temperatures with zero help was extremely high in my area. I also consider myself extremely lucky that I had a friend that was able to come move my vehicle from blocking the business entrance. When I used the Ford app to get a tow, it quoted me 7 hours. I did call and complain that that was unacceptable. The vehicle was towed to the dealership and catastrophic engine failure was determined with a faulty valve being the contributing factor. This is a known valve issue and I have included my engine build date sticker in the photos. I included a photo of my Bronco being loaded on the tow truck showing the ice roads and snow bank blocking my car from view.
Additional Notes:
On Monday, March 7, 2021, my Ford Bronco First Edition with the 2.7 engine experienced catastrophic engine failure. I was driving near my home when my vehicle stopped running. I did feel a strange pull in my steering and tires; but I was also driving on ice and assumed it was the traction control system at play. I was wrong. It was my engine losing compression and my engine failing. My dash lit up with a series of errors (all in quick succession and could not catch them all) and my vehicle lost all power and control. As mentioned above, I was driving on ice covered roads and had difficulty steering. I attempted to pull off the road and into a parking lot; however, the drive sloped up and I could not get clear of the entryway. I had to stop blocking the entrance to the veterinarian's parking lot. To increase the risk here, my vehicle was not visible from traffic turning in because of snow banks that were taller than my vehicle. I want to stress how incredibly lucky I was that this happened close to home. I went on a road trip and had returned home the night before. We had contemplated taking the Bronco. If we had, we would have broken down on the Parks Highway in Alaska. This highway is remote at most times with spotty cell service. The risks of having broken down in subzero temperatures with zero help was extremely high in my area. I also consider myself extremely lucky that I had a friend that was able to come move my vehicle from blocking the business entrance. When I used the Ford app to get a tow, it quoted me 7 hours. I did call and complain that that was unacceptable. The vehicle was towed to the dealership and catastrophic engine failure was determined with a faulty valve being the contributing factor. This is a known valve issue and I have included my engine build date sticker in the photos. I included a photo of my Bronco being loaded on the tow truck showing the ice roads and snow bank blocking my car from view.
Mfg Campaign: 11463296
Recall Date: May 3, 2022
Ford Motor Company
Defect Description:
SERVICE BRAKES
Potential Consequences:
Flat Towing 2021 Ford Bronco with 2.7 V6 engine. After connecting my Bronco to the motorhome and putting it in the tow mode the following will occur. About 45 mins after turning the ignition off and closing the doors the EBB (Electronic Brake Boost) in the Bronco shuts down leaving the Bronco without any brake boost and leaves the supplemental brake system ineffective. When first connecting the Bronco to the motorhome the brake boost is active and the supplemental brake system must be set to match, or it will lock up the brakes on the Bronco when you stop. After the boost shuts down the supplemental brake system cannot apply enough force to the Bronco brakes to assist in stopping and all at once it takes a much greater distance to stop the motorhome than it did when the boost was working. This is extremely dangerous as a break-a-way tow vehicle would have no brakes and become a missile, or the additional weight with no assisted braking could cause a 40,000lb Class A RV to lose it's brakes down a steep grade.
Corrective Action:
Flat Towing 2021 Ford Bronco with 2.7 V6 engine. After connecting my Bronco to the motorhome and putting it in the tow mode the following will occur. About 45 mins after turning the ignition off and closing the doors the EBB (Electronic Brake Boost) in the Bronco shuts down leaving the Bronco without any brake boost and leaves the supplemental brake system ineffective. When first connecting the Bronco to the motorhome the brake boost is active and the supplemental brake system must be set to match, or it will lock up the brakes on the Bronco when you stop. After the boost shuts down the supplemental brake system cannot apply enough force to the Bronco brakes to assist in stopping and all at once it takes a much greater distance to stop the motorhome than it did when the boost was working. This is extremely dangerous as a break-a-way tow vehicle would have no brakes and become a missile, or the additional weight with no assisted braking could cause a 40,000lb Class A RV to lose it's brakes down a steep grade.
Additional Notes:
Flat Towing 2021 Ford Bronco with 2.7 V6 engine. After connecting my Bronco to the motorhome and putting it in the tow mode the following will occur. About 45 mins after turning the ignition off and closing the doors the EBB (Electronic Brake Boost) in the Bronco shuts down leaving the Bronco without any brake boost and leaves the supplemental brake system ineffective. When first connecting the Bronco to the motorhome the brake boost is active and the supplemental brake system must be set to match, or it will lock up the brakes on the Bronco when you stop. After the boost shuts down the supplemental brake system cannot apply enough force to the Bronco brakes to assist in stopping and all at once it takes a much greater distance to stop the motorhome than it did when the boost was working. This is extremely dangerous as a break-a-way tow vehicle would have no brakes and become a missile, or the additional weight with no assisted braking could cause a 40,000lb Class A RV to lose it's brakes down a steep grade.
Mfg Campaign: 11461791
Recall Date: Apr 22, 2022
Ford Motor Company
Defect Description:
ENGINE
Potential Consequences:
CONSTITUENT WRITES IN REGARD TO THEIR 2021 FORD BRONCO. CONSTITUENT STATED THAT THE ENGINE HAS A KNOWN DEFECT IN THE VALVES CAUSING CATASTROPHIC ENGINE FAILURE.
Corrective Action:
CONSTITUENT WRITES IN REGARD TO THEIR 2021 FORD BRONCO. CONSTITUENT STATED THAT THE ENGINE HAS A KNOWN DEFECT IN THE VALVES CAUSING CATASTROPHIC ENGINE FAILURE.
Additional Notes:
CONSTITUENT WRITES IN REGARD TO THEIR 2021 FORD BRONCO. CONSTITUENT STATED THAT THE ENGINE HAS A KNOWN DEFECT IN THE VALVES CAUSING CATASTROPHIC ENGINE FAILURE.
Mfg Campaign: 11461178
Recall Date: Apr 18, 2022
Need Legal Help?
Featured Attorneys
Barry Edzant
Edzant Price LLC
Valencia, CA • 36 yrs
Focus: Lemon Law, Personal Injury