Complaints & Recalls
Official Safety Recalls - Important!
1 RecallThese are official manufacturer recalls ordered by NHTSA for safety defects. If you own this vehicle, contact your dealer immediately for free repairs.
Bmw Of North America, Llc
Safety Issue:
BMW of North America, LLC (BMW) is recalling certain 2018 BMW 540d xDrive vehicles. The crankshaft sensor may be equipped with incorrect firmware, preventing the sensor from properly processing input from the crankshaft reluctor ring, possibly resulting in a vehicle stall. On September 12, 2018, BMW expanded the recall to a total of 5,309 vehicles including certain 2018-2019 BMW 540d xDrive, 230i M240i, M240i xDrive, X2 sDrive28i, X2 xDrive28i, X1 sDrive28i, X1 xDrive28i, 330i, 330i xDrive, 340i, 340i xDrive, 330i xDrive Gran Turismo, 530i, 530i xDrive, 540i, 540i xDrive, 530e, 530e xDrive, 640i xDrive Gran Turismo, 330e, 2019 430i Gran Coupe, 430i xDrive Gran Coupe, 440i Gran Coupe, 440i xDrive Gran Coupe, 430i, 430i xDrive, 440i, 440i xDrive, 740i, 740i xDrive, MINI Cooper, Cooper S, JCW, MINI Countryman (Cooper, Cooper All4, Cooper S, Cooper S All4, JCW All4), and MINI Clubman (Cooper, Cooper S, Cooper All4, Cooper S All4, JCW All4) vehicles.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Recall Date: Jul 11, 2018
Consumer Complaints
32 ComplaintsBmw Of North America, Llc
Defect Description:
ELECTRICAL SYSTEM
Potential Consequences:
I smelt and saw smoke coming from the back of my vehicle. I pulled over on to the left side of [XXX] bound. Then, I jumped out of the car to check the truck. I didn't see anything, then i popped the hood and still did not see anything visible. I then went back to the trunk to check it again, and that is when I saw flames pop out from the back seat area. It was in the area where the back de-frost wires and some other wires are as well. Thank you, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Corrective Action:
I smelt and saw smoke coming from the back of my vehicle. I pulled over on to the left side of [XXX] bound. Then, I jumped out of the car to check the truck. I didn't see anything, then i popped the hood and still did not see anything visible. I then went back to the trunk to check it again, and that is when I saw flames pop out from the back seat area. It was in the area where the back de-frost wires and some other wires are as well. Thank you, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Additional Notes:
I smelt and saw smoke coming from the back of my vehicle. I pulled over on to the left side of [XXX] bound. Then, I jumped out of the car to check the truck. I didn't see anything, then i popped the hood and still did not see anything visible. I then went back to the trunk to check it again, and that is when I saw flames pop out from the back seat area. It was in the area where the back de-frost wires and some other wires are as well. Thank you, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Mfg Campaign: 11667410
Recall Date: Jun 17, 2025
Bmw Of North America, Llc
Defect Description:
ENGINE
Potential Consequences:
My 330i 2018 bmw has a cracked in the oil housing unit. This is due to bmw putting plastic parts instead of aluminum. After researching this I found thousand of people complaining about the sane thing. The car overheats and sometimes the oil gets mixed into the coolsnt system b causes more damage. This seems to happen on cars with mileage between 60-70 on engines B46, B48 n B58z
Corrective Action:
My 330i 2018 bmw has a cracked in the oil housing unit. This is due to bmw putting plastic parts instead of aluminum. After researching this I found thousand of people complaining about the sane thing. The car overheats and sometimes the oil gets mixed into the coolsnt system b causes more damage. This seems to happen on cars with mileage between 60-70 on engines B46, B48 n B58z
Additional Notes:
My 330i 2018 bmw has a cracked in the oil housing unit. This is due to bmw putting plastic parts instead of aluminum. After researching this I found thousand of people complaining about the sane thing. The car overheats and sometimes the oil gets mixed into the coolsnt system b causes more damage. This seems to happen on cars with mileage between 60-70 on engines B46, B48 n B58z
Mfg Campaign: 11655822
Recall Date: Apr 21, 2025
Bmw Of North America, Llc
Defect Description:
UNKNOWN OR OTHER
Potential Consequences:
My 330i 2018 bmw has a cracked in the oil housing unit. This is due to bmw putting plastic parts instead of aluminum. After researching this I found thousand of people complaining about the sane thing. The car overheats and sometimes the oil gets mixed into the coolsnt system b causes more damage. This seems to happen on cars with mileage between 60-70 on engines B46, B48 n B58z
Corrective Action:
My 330i 2018 bmw has a cracked in the oil housing unit. This is due to bmw putting plastic parts instead of aluminum. After researching this I found thousand of people complaining about the sane thing. The car overheats and sometimes the oil gets mixed into the coolsnt system b causes more damage. This seems to happen on cars with mileage between 60-70 on engines B46, B48 n B58z
Additional Notes:
My 330i 2018 bmw has a cracked in the oil housing unit. This is due to bmw putting plastic parts instead of aluminum. After researching this I found thousand of people complaining about the sane thing. The car overheats and sometimes the oil gets mixed into the coolsnt system b causes more damage. This seems to happen on cars with mileage between 60-70 on engines B46, B48 n B58z
Mfg Campaign: 11655822
Recall Date: Apr 21, 2025
Bmw Of North America, Llc
Defect Description:
ENGINE
Potential Consequences:
Oil Filter Housing failed and coolant gushes all out which makes the car undrivable and risk of engine overheating and failure.
Corrective Action:
Oil Filter Housing failed and coolant gushes all out which makes the car undrivable and risk of engine overheating and failure.
Additional Notes:
Oil Filter Housing failed and coolant gushes all out which makes the car undrivable and risk of engine overheating and failure.
Mfg Campaign: 11646108
Recall Date: Mar 3, 2025
Bmw Of North America, Llc
Defect Description:
FUEL SYSTEM, DIESEL
Potential Consequences:
The contact owns a 2018 BMW 330I. The contact stated that while driving at various speeds, the engine overheating message was displayed on the instrument panel with the temperature gauge rising to hot(H). The vehicle was taken to an independent mechanic where the coolant reservoir was topped off however, the failure persisted. The contact then received notification of NHTSA Campaign Number: 21V907000 (Fuel System, Diesel) which was linked to the failure. The vehicle was taken to the dealer where the recall repair was performed. The contact stated that recently the vehicle began to leak coolant. The vehicle was taken back to the dealer and the contact was informed that the manifold needed to be taken off to perform a diagnostic test. The contact was informed that the oil filter housing unit and the water pump both needed to be replaced. The manufacturer was notified of the failure and transferred the contact to the NHTSA Hotline to report the failure. The vehicle remained in the possession of the dealer unrepaired. The failure mileage was approximately 60,150.
Corrective Action:
The contact owns a 2018 BMW 330I. The contact stated that while driving at various speeds, the engine overheating message was displayed on the instrument panel with the temperature gauge rising to hot(H). The vehicle was taken to an independent mechanic where the coolant reservoir was topped off however, the failure persisted. The contact then received notification of NHTSA Campaign Number: 21V907000 (Fuel System, Diesel) which was linked to the failure. The vehicle was taken to the dealer where the recall repair was performed. The contact stated that recently the vehicle began to leak coolant. The vehicle was taken back to the dealer and the contact was informed that the manifold needed to be taken off to perform a diagnostic test. The contact was informed that the oil filter housing unit and the water pump both needed to be replaced. The manufacturer was notified of the failure and transferred the contact to the NHTSA Hotline to report the failure. The vehicle remained in the possession of the dealer unrepaired. The failure mileage was approximately 60,150.
Additional Notes:
The contact owns a 2018 BMW 330I. The contact stated that while driving at various speeds, the engine overheating message was displayed on the instrument panel with the temperature gauge rising to hot(H). The vehicle was taken to an independent mechanic where the coolant reservoir was topped off however, the failure persisted. The contact then received notification of NHTSA Campaign Number: 21V907000 (Fuel System, Diesel) which was linked to the failure. The vehicle was taken to the dealer where the recall repair was performed. The contact stated that recently the vehicle began to leak coolant. The vehicle was taken back to the dealer and the contact was informed that the manifold needed to be taken off to perform a diagnostic test. The contact was informed that the oil filter housing unit and the water pump both needed to be replaced. The manufacturer was notified of the failure and transferred the contact to the NHTSA Hotline to report the failure. The vehicle remained in the possession of the dealer unrepaired. The failure mileage was approximately 60,150.
Mfg Campaign: 11641715
Recall Date: Feb 10, 2025
Bmw Of North America, Llc
Defect Description:
ENGINE
Potential Consequences:
The vehicle gave a warning that the engine coolant was low and to power down before it overheated. Upon taking it to the dealer, it was discovered that the oil housing unit was defective. After doing online research, this is a very common issue with this part. I had a previous vehicle with a similar issue that caused the vehicle to shut down in traffic from overheating.
Corrective Action:
The vehicle gave a warning that the engine coolant was low and to power down before it overheated. Upon taking it to the dealer, it was discovered that the oil housing unit was defective. After doing online research, this is a very common issue with this part. I had a previous vehicle with a similar issue that caused the vehicle to shut down in traffic from overheating.
Additional Notes:
The vehicle gave a warning that the engine coolant was low and to power down before it overheated. Upon taking it to the dealer, it was discovered that the oil housing unit was defective. After doing online research, this is a very common issue with this part. I had a previous vehicle with a similar issue that caused the vehicle to shut down in traffic from overheating.
Mfg Campaign: 11636332
Recall Date: Jan 16, 2025
Bmw Of North America, Llc
Defect Description:
ENGINE
Potential Consequences:
On 12/03/2024, while traveling at approximately 35mph, the "top off coolant" light came on. After traveling for approximately 10 more minutes, in route to get coolant, a warning message came on the screen advising to drive cautiously to prevent engine scorching. The vehicle then began to slightly lose power while traveling on a busy road. The vehicle was then shut down and towed to BMW dealership. During the tow, it was discovered that coolant was leaking from the center area of the engine block. The manufacturers dealership service rep advised that the technicians discovered that the oil filter housing needed to be replaced. They also found that the coolant pump also needed to be replaced. The rep advised that the coolant seal on the oil filter housing had worn down and caused the coolant leak. He also advised that the coolant pump needed to be replaced, as it was also leaking. It was later discovered because the valve that the pressure propelled, hot coolant flows through in the oil filter housing is made of plastic, it often wears down and coolant leaks out heavily. The water pump is also effected by the part manufacturing issue. In addition to receiving a $4,270.42 invoice for repairs today, we just recently purchased the $199.00 BMW Vehicle Check Service from the dealership on 9/23/2024. At that time, we were advised there were no issues with the vehicle. We have sense learned that there have been multiple recalls on various BMW models for this exact same issue. However, the VIN on my vehicle has not yet been identified for recall. Had this issue gone on for mere moments more, the engine could have caught fire, and or, a catastrophic crash could have ensued, effecting any driver on the road.
Corrective Action:
On 12/03/2024, while traveling at approximately 35mph, the "top off coolant" light came on. After traveling for approximately 10 more minutes, in route to get coolant, a warning message came on the screen advising to drive cautiously to prevent engine scorching. The vehicle then began to slightly lose power while traveling on a busy road. The vehicle was then shut down and towed to BMW dealership. During the tow, it was discovered that coolant was leaking from the center area of the engine block. The manufacturers dealership service rep advised that the technicians discovered that the oil filter housing needed to be replaced. They also found that the coolant pump also needed to be replaced. The rep advised that the coolant seal on the oil filter housing had worn down and caused the coolant leak. He also advised that the coolant pump needed to be replaced, as it was also leaking. It was later discovered because the valve that the pressure propelled, hot coolant flows through in the oil filter housing is made of plastic, it often wears down and coolant leaks out heavily. The water pump is also effected by the part manufacturing issue. In addition to receiving a $4,270.42 invoice for repairs today, we just recently purchased the $199.00 BMW Vehicle Check Service from the dealership on 9/23/2024. At that time, we were advised there were no issues with the vehicle. We have sense learned that there have been multiple recalls on various BMW models for this exact same issue. However, the VIN on my vehicle has not yet been identified for recall. Had this issue gone on for mere moments more, the engine could have caught fire, and or, a catastrophic crash could have ensued, effecting any driver on the road.
Additional Notes:
On 12/03/2024, while traveling at approximately 35mph, the "top off coolant" light came on. After traveling for approximately 10 more minutes, in route to get coolant, a warning message came on the screen advising to drive cautiously to prevent engine scorching. The vehicle then began to slightly lose power while traveling on a busy road. The vehicle was then shut down and towed to BMW dealership. During the tow, it was discovered that coolant was leaking from the center area of the engine block. The manufacturers dealership service rep advised that the technicians discovered that the oil filter housing needed to be replaced. They also found that the coolant pump also needed to be replaced. The rep advised that the coolant seal on the oil filter housing had worn down and caused the coolant leak. He also advised that the coolant pump needed to be replaced, as it was also leaking. It was later discovered because the valve that the pressure propelled, hot coolant flows through in the oil filter housing is made of plastic, it often wears down and coolant leaks out heavily. The water pump is also effected by the part manufacturing issue. In addition to receiving a $4,270.42 invoice for repairs today, we just recently purchased the $199.00 BMW Vehicle Check Service from the dealership on 9/23/2024. At that time, we were advised there were no issues with the vehicle. We have sense learned that there have been multiple recalls on various BMW models for this exact same issue. However, the VIN on my vehicle has not yet been identified for recall. Had this issue gone on for mere moments more, the engine could have caught fire, and or, a catastrophic crash could have ensued, effecting any driver on the road.
Mfg Campaign: 11628725
Recall Date: Dec 4, 2024
Bmw Of North America, Llc
Defect Description:
FUEL/PROPULSION SYSTEM
Potential Consequences:
Coolant fluid exits from the expansion tank into the overflow leaving no fluid in the expansion tank. Then it causes and overflow/steam to burst out of the overflow tank. Then the coolant is low notification comes on which warrants to replace the coolant fluid. Took it to a few BMW dealers. They've did a flush, replace expansion tank, and water pump, also tested the pressure several times at 2 different BMW dealerships. I leave the dealership broker and with the same problem starting again within that week. This has been a constant issue which never seems to be fixed by any BMW dealer.
Corrective Action:
Coolant fluid exits from the expansion tank into the overflow leaving no fluid in the expansion tank. Then it causes and overflow/steam to burst out of the overflow tank. Then the coolant is low notification comes on which warrants to replace the coolant fluid. Took it to a few BMW dealers. They've did a flush, replace expansion tank, and water pump, also tested the pressure several times at 2 different BMW dealerships. I leave the dealership broker and with the same problem starting again within that week. This has been a constant issue which never seems to be fixed by any BMW dealer.
Additional Notes:
Coolant fluid exits from the expansion tank into the overflow leaving no fluid in the expansion tank. Then it causes and overflow/steam to burst out of the overflow tank. Then the coolant is low notification comes on which warrants to replace the coolant fluid. Took it to a few BMW dealers. They've did a flush, replace expansion tank, and water pump, also tested the pressure several times at 2 different BMW dealerships. I leave the dealership broker and with the same problem starting again within that week. This has been a constant issue which never seems to be fixed by any BMW dealer.
Mfg Campaign: 11626777
Recall Date: Nov 22, 2024
Bmw Of North America, Llc
Defect Description:
UNKNOWN OR OTHER
Potential Consequences:
Car coolant is leaking due to a bad plastic coolant vent line. I had this issue in January 2023 where it was covered under a recall. I tried contacting the bmw dealership who fixed this recall and they stated there was no current recall. Although is the same issue again.
Corrective Action:
Car coolant is leaking due to a bad plastic coolant vent line. I had this issue in January 2023 where it was covered under a recall. I tried contacting the bmw dealership who fixed this recall and they stated there was no current recall. Although is the same issue again.
Additional Notes:
Car coolant is leaking due to a bad plastic coolant vent line. I had this issue in January 2023 where it was covered under a recall. I tried contacting the bmw dealership who fixed this recall and they stated there was no current recall. Although is the same issue again.
Mfg Campaign: 11608828
Recall Date: Aug 15, 2024
Bmw Of North America, Llc
Defect Description:
FUEL/PROPULSION SYSTEM
Potential Consequences:
My 2018 BMW 330i has the same problem that the recall for the fuel sensor level on 2018 BMW M5! I broke down on the side of the interstate and had it towed to BMW and they said it was the fuel sensor reading more than it should and wanted to charge almost 3,000 to fix it. There are similarities to the other recalls and my vehicle should also be included in that recall. I had to pay 300.00 just for them looking at it. I found it odd the sensor would do that and my investigation has brought me here. There was no warning and I was stranded on the interstate
Corrective Action:
My 2018 BMW 330i has the same problem that the recall for the fuel sensor level on 2018 BMW M5! I broke down on the side of the interstate and had it towed to BMW and they said it was the fuel sensor reading more than it should and wanted to charge almost 3,000 to fix it. There are similarities to the other recalls and my vehicle should also be included in that recall. I had to pay 300.00 just for them looking at it. I found it odd the sensor would do that and my investigation has brought me here. There was no warning and I was stranded on the interstate
Additional Notes:
My 2018 BMW 330i has the same problem that the recall for the fuel sensor level on 2018 BMW M5! I broke down on the side of the interstate and had it towed to BMW and they said it was the fuel sensor reading more than it should and wanted to charge almost 3,000 to fix it. There are similarities to the other recalls and my vehicle should also be included in that recall. I had to pay 300.00 just for them looking at it. I found it odd the sensor would do that and my investigation has brought me here. There was no warning and I was stranded on the interstate
Mfg Campaign: 11587129
Recall Date: May 6, 2024
Bmw Of North America, Llc
Defect Description:
POWER TRAIN
Potential Consequences:
Multiple codes came on right after I had gotten my thermostat and my water pump fixed. However it ended up being that there was more leaks throughout the rest of the car. The car has currently cost me $3400 to fix and it’s still not fixed because nobody can figure out where the actual leak is coming from. The coolant is leaking and nobody can figure out where, it’s been having jerking issues since it started leaking and I read on other Bmw’s that the coolant leaks into the head gasket, causing the engine to blow
Corrective Action:
Multiple codes came on right after I had gotten my thermostat and my water pump fixed. However it ended up being that there was more leaks throughout the rest of the car. The car has currently cost me $3400 to fix and it’s still not fixed because nobody can figure out where the actual leak is coming from. The coolant is leaking and nobody can figure out where, it’s been having jerking issues since it started leaking and I read on other Bmw’s that the coolant leaks into the head gasket, causing the engine to blow
Additional Notes:
Multiple codes came on right after I had gotten my thermostat and my water pump fixed. However it ended up being that there was more leaks throughout the rest of the car. The car has currently cost me $3400 to fix and it’s still not fixed because nobody can figure out where the actual leak is coming from. The coolant is leaking and nobody can figure out where, it’s been having jerking issues since it started leaking and I read on other Bmw’s that the coolant leaks into the head gasket, causing the engine to blow
Mfg Campaign: 11569599
Recall Date: Feb 2, 2024
Bmw Of North America, Llc
Defect Description:
ENGINE
Potential Consequences:
Multiple codes came on right after I had gotten my thermostat and my water pump fixed. However it ended up being that there was more leaks throughout the rest of the car. The car has currently cost me $3400 to fix and it’s still not fixed because nobody can figure out where the actual leak is coming from. The coolant is leaking and nobody can figure out where, it’s been having jerking issues since it started leaking and I read on other Bmw’s that the coolant leaks into the head gasket, causing the engine to blow
Corrective Action:
Multiple codes came on right after I had gotten my thermostat and my water pump fixed. However it ended up being that there was more leaks throughout the rest of the car. The car has currently cost me $3400 to fix and it’s still not fixed because nobody can figure out where the actual leak is coming from. The coolant is leaking and nobody can figure out where, it’s been having jerking issues since it started leaking and I read on other Bmw’s that the coolant leaks into the head gasket, causing the engine to blow
Additional Notes:
Multiple codes came on right after I had gotten my thermostat and my water pump fixed. However it ended up being that there was more leaks throughout the rest of the car. The car has currently cost me $3400 to fix and it’s still not fixed because nobody can figure out where the actual leak is coming from. The coolant is leaking and nobody can figure out where, it’s been having jerking issues since it started leaking and I read on other Bmw’s that the coolant leaks into the head gasket, causing the engine to blow
Mfg Campaign: 11569599
Recall Date: Feb 2, 2024
Bmw Of North America, Llc
Defect Description:
UNKNOWN OR OTHER
Potential Consequences:
Multiple codes came on right after I had gotten my thermostat and my water pump fixed. However it ended up being that there was more leaks throughout the rest of the car. The car has currently cost me $3400 to fix and it’s still not fixed because nobody can figure out where the actual leak is coming from. The coolant is leaking and nobody can figure out where, it’s been having jerking issues since it started leaking and I read on other Bmw’s that the coolant leaks into the head gasket, causing the engine to blow
Corrective Action:
Multiple codes came on right after I had gotten my thermostat and my water pump fixed. However it ended up being that there was more leaks throughout the rest of the car. The car has currently cost me $3400 to fix and it’s still not fixed because nobody can figure out where the actual leak is coming from. The coolant is leaking and nobody can figure out where, it’s been having jerking issues since it started leaking and I read on other Bmw’s that the coolant leaks into the head gasket, causing the engine to blow
Additional Notes:
Multiple codes came on right after I had gotten my thermostat and my water pump fixed. However it ended up being that there was more leaks throughout the rest of the car. The car has currently cost me $3400 to fix and it’s still not fixed because nobody can figure out where the actual leak is coming from. The coolant is leaking and nobody can figure out where, it’s been having jerking issues since it started leaking and I read on other Bmw’s that the coolant leaks into the head gasket, causing the engine to blow
Mfg Campaign: 11569599
Recall Date: Feb 2, 2024
Bmw Of North America, Llc
Defect Description:
ENGINE
Potential Consequences:
At around 65k miles multiple plastic engine coolant connectors and hoses crack and fail. 5 locations at the same time! Coolant pump leaks. I went to an independent repair shop for a second opinion and repairs for $2,400 so far. Cheaper than the BMW service department. There was a recall done 2 years ago for 1 hose I believe. The entire cooling system should be recalled. We could be stranded somewhere in a bad situation and the engine could be destroyed if overheated. Awful and bad design.
Corrective Action:
At around 65k miles multiple plastic engine coolant connectors and hoses crack and fail. 5 locations at the same time! Coolant pump leaks. I went to an independent repair shop for a second opinion and repairs for $2,400 so far. Cheaper than the BMW service department. There was a recall done 2 years ago for 1 hose I believe. The entire cooling system should be recalled. We could be stranded somewhere in a bad situation and the engine could be destroyed if overheated. Awful and bad design.
Additional Notes:
At around 65k miles multiple plastic engine coolant connectors and hoses crack and fail. 5 locations at the same time! Coolant pump leaks. I went to an independent repair shop for a second opinion and repairs for $2,400 so far. Cheaper than the BMW service department. There was a recall done 2 years ago for 1 hose I believe. The entire cooling system should be recalled. We could be stranded somewhere in a bad situation and the engine could be destroyed if overheated. Awful and bad design.
Mfg Campaign: 11565602
Recall Date: Jan 15, 2024
Bmw Of North America, Llc
Defect Description:
ELECTRICAL SYSTEM:PROPULSION SYSTEM:TRACTION BATTERY:THERMAL MANAGEMENT:FLUID/COOLANT
Potential Consequences:
The contact owned a 2018 BMW 330I. The vehicle was taken to a local dealer for a Manufacturers Recall: 0017150200 related to the Coolant Leak to be completed. The contact stated that after driving 7 miles to her home at 35 MPH, there was smoke coming from the engine compartment. All the warning lights illuminated. The vehicle was powered off and the smoke extinguished on its own. A fire report was not filed. There were no visible flames. The local dealer was called and the vehicle was towed back to the dealer where it was confirmed that the pressure test was not completed and there was no coolant in the vehicle. The dealer informed the caller that the struts needed to be replaced however the coolant failure was repaired. The vehicle was repaired for the coolant failure however the contact mentioned that the vehicle was not performing as designed. The manufacturer was not notified of the failure. The failure mileage was 51,086.
Corrective Action:
The contact owned a 2018 BMW 330I. The vehicle was taken to a local dealer for a Manufacturers Recall: 0017150200 related to the Coolant Leak to be completed. The contact stated that after driving 7 miles to her home at 35 MPH, there was smoke coming from the engine compartment. All the warning lights illuminated. The vehicle was powered off and the smoke extinguished on its own. A fire report was not filed. There were no visible flames. The local dealer was called and the vehicle was towed back to the dealer where it was confirmed that the pressure test was not completed and there was no coolant in the vehicle. The dealer informed the caller that the struts needed to be replaced however the coolant failure was repaired. The vehicle was repaired for the coolant failure however the contact mentioned that the vehicle was not performing as designed. The manufacturer was not notified of the failure. The failure mileage was 51,086.
Additional Notes:
The contact owned a 2018 BMW 330I. The vehicle was taken to a local dealer for a Manufacturers Recall: 0017150200 related to the Coolant Leak to be completed. The contact stated that after driving 7 miles to her home at 35 MPH, there was smoke coming from the engine compartment. All the warning lights illuminated. The vehicle was powered off and the smoke extinguished on its own. A fire report was not filed. There were no visible flames. The local dealer was called and the vehicle was towed back to the dealer where it was confirmed that the pressure test was not completed and there was no coolant in the vehicle. The dealer informed the caller that the struts needed to be replaced however the coolant failure was repaired. The vehicle was repaired for the coolant failure however the contact mentioned that the vehicle was not performing as designed. The manufacturer was not notified of the failure. The failure mileage was 51,086.
Mfg Campaign: 11563082
Recall Date: Jan 2, 2024
Bmw Of North America, Llc
Defect Description:
ENGINE
Potential Consequences:
My oil filter housing failed at about 53,000 miles. While driving to work I got a low coolant warning and pulled over to see coolant dumping out of my car. The low coolant warning only comes on when the expansion tank is almost completely empty which can lead to oil and coolant mixing and overheating which will lead to premature engine damage without any early warning signs. I’ve read through forums and everyone on there has their oil filter housing fail at the same time, (around 50-60k miles). This is a huge issue in the community and BMW wants to charge almost 3,500 to replace it with their “revised part”. The housing has been revised 3 times now and so the manufacturer should replace these failed designs with the new revised ones. There’s already been a recall on the B48 engine for the plastic cooling line that leads into the head of the engine and it looks like the oil filter housing is the next biggest common failure. I tried to upload a screenshot from the service center at BMW with the quote and failure but it’s not working on my mobile.
Corrective Action:
My oil filter housing failed at about 53,000 miles. While driving to work I got a low coolant warning and pulled over to see coolant dumping out of my car. The low coolant warning only comes on when the expansion tank is almost completely empty which can lead to oil and coolant mixing and overheating which will lead to premature engine damage without any early warning signs. I’ve read through forums and everyone on there has their oil filter housing fail at the same time, (around 50-60k miles). This is a huge issue in the community and BMW wants to charge almost 3,500 to replace it with their “revised part”. The housing has been revised 3 times now and so the manufacturer should replace these failed designs with the new revised ones. There’s already been a recall on the B48 engine for the plastic cooling line that leads into the head of the engine and it looks like the oil filter housing is the next biggest common failure. I tried to upload a screenshot from the service center at BMW with the quote and failure but it’s not working on my mobile.
Additional Notes:
My oil filter housing failed at about 53,000 miles. While driving to work I got a low coolant warning and pulled over to see coolant dumping out of my car. The low coolant warning only comes on when the expansion tank is almost completely empty which can lead to oil and coolant mixing and overheating which will lead to premature engine damage without any early warning signs. I’ve read through forums and everyone on there has their oil filter housing fail at the same time, (around 50-60k miles). This is a huge issue in the community and BMW wants to charge almost 3,500 to replace it with their “revised part”. The housing has been revised 3 times now and so the manufacturer should replace these failed designs with the new revised ones. There’s already been a recall on the B48 engine for the plastic cooling line that leads into the head of the engine and it looks like the oil filter housing is the next biggest common failure. I tried to upload a screenshot from the service center at BMW with the quote and failure but it’s not working on my mobile.
Mfg Campaign: 11562328
Recall Date: Dec 28, 2023
Bmw Of North America, Llc
Defect Description:
SEAT BELTS
Potential Consequences:
CUSTOMER REAR PASSENGER SETBELT DOESNT LATCH
Corrective Action:
CUSTOMER REAR PASSENGER SETBELT DOESNT LATCH
Additional Notes:
CUSTOMER REAR PASSENGER SETBELT DOESNT LATCH
Mfg Campaign: 11504837
Recall Date: Feb 1, 2023
Bmw Of North America, Llc
Defect Description:
VEHICLE SPEED CONTROL
Potential Consequences:
The car's cruise control's rocker switch got stuck causing the vehicle's speed to increase continually. The rocker switch allows driver to increase or decrease speed when the cruise control is activated. The rocker switch permits speed increase in increments of 1 mph or 5 mph. If pressed up until a resistance point, the speed increases by 1 mph; if pressed beyond the resistance point, it increases by 5 mph. In my instance, I was on cruise control at 61 mph (in a 55 zone, where traffic was also moving in the 60's). I wanted to increase speed by 3-4 mph using the rocker switch to safely complete an overtake. However, the rocker switch got stuck and caused the car's peed to increase past 80mph. I almost missed hitting the car ahead of me.
Corrective Action:
The car's cruise control's rocker switch got stuck causing the vehicle's speed to increase continually. The rocker switch allows driver to increase or decrease speed when the cruise control is activated. The rocker switch permits speed increase in increments of 1 mph or 5 mph. If pressed up until a resistance point, the speed increases by 1 mph; if pressed beyond the resistance point, it increases by 5 mph. In my instance, I was on cruise control at 61 mph (in a 55 zone, where traffic was also moving in the 60's). I wanted to increase speed by 3-4 mph using the rocker switch to safely complete an overtake. However, the rocker switch got stuck and caused the car's peed to increase past 80mph. I almost missed hitting the car ahead of me.
Additional Notes:
The car's cruise control's rocker switch got stuck causing the vehicle's speed to increase continually. The rocker switch allows driver to increase or decrease speed when the cruise control is activated. The rocker switch permits speed increase in increments of 1 mph or 5 mph. If pressed up until a resistance point, the speed increases by 1 mph; if pressed beyond the resistance point, it increases by 5 mph. In my instance, I was on cruise control at 61 mph (in a 55 zone, where traffic was also moving in the 60's). I wanted to increase speed by 3-4 mph using the rocker switch to safely complete an overtake. However, the rocker switch got stuck and caused the car's peed to increase past 80mph. I almost missed hitting the car ahead of me.
Mfg Campaign: 11502140
Recall Date: Jan 17, 2023
Bmw Of North America, Llc
Defect Description:
ENGINE
Potential Consequences:
On January 19, 2022 I was driving and then smoked filled inside my car and the outside engine was smoking and a light came on that said check coolant. BMW service took me in that day and they said my coolant broke. They removed it and replaced it. They did not understand how the coolant broke but I paid for the service and parts and moved forward. On November 25, 2022 I went into the same BMW service center to get a routine car service and they stated there was a recall and they would replace my coolant for free. (After I told them I paid for it ($699.63) . They insisted I replace it for free again and reach out to BMW corporate for a reimbursement of previous service. I received a call yesterday stating they would not replace it and reach out and file a report with NHTA.
Corrective Action:
On January 19, 2022 I was driving and then smoked filled inside my car and the outside engine was smoking and a light came on that said check coolant. BMW service took me in that day and they said my coolant broke. They removed it and replaced it. They did not understand how the coolant broke but I paid for the service and parts and moved forward. On November 25, 2022 I went into the same BMW service center to get a routine car service and they stated there was a recall and they would replace my coolant for free. (After I told them I paid for it ($699.63) . They insisted I replace it for free again and reach out to BMW corporate for a reimbursement of previous service. I received a call yesterday stating they would not replace it and reach out and file a report with NHTA.
Additional Notes:
On January 19, 2022 I was driving and then smoked filled inside my car and the outside engine was smoking and a light came on that said check coolant. BMW service took me in that day and they said my coolant broke. They removed it and replaced it. They did not understand how the coolant broke but I paid for the service and parts and moved forward. On November 25, 2022 I went into the same BMW service center to get a routine car service and they stated there was a recall and they would replace my coolant for free. (After I told them I paid for it ($699.63) . They insisted I replace it for free again and reach out to BMW corporate for a reimbursement of previous service. I received a call yesterday stating they would not replace it and reach out and file a report with NHTA.
Mfg Campaign: 11497221
Recall Date: Dec 13, 2022
Bmw Of North America, Llc
Defect Description:
FUEL/PROPULSION SYSTEM
Potential Consequences:
On January 19, 2022 I was driving and then smoked filled inside my car and the outside engine was smoking and a light came on that said check coolant. BMW service took me in that day and they said my coolant broke. They removed it and replaced it. They did not understand how the coolant broke but I paid for the service and parts and moved forward. On November 25, 2022 I went into the same BMW service center to get a routine car service and they stated there was a recall and they would replace my coolant for free. (After I told them I paid for it ($699.63) . They insisted I replace it for free again and reach out to BMW corporate for a reimbursement of previous service. I received a call yesterday stating they would not replace it and reach out and file a report with NHTA.
Corrective Action:
On January 19, 2022 I was driving and then smoked filled inside my car and the outside engine was smoking and a light came on that said check coolant. BMW service took me in that day and they said my coolant broke. They removed it and replaced it. They did not understand how the coolant broke but I paid for the service and parts and moved forward. On November 25, 2022 I went into the same BMW service center to get a routine car service and they stated there was a recall and they would replace my coolant for free. (After I told them I paid for it ($699.63) . They insisted I replace it for free again and reach out to BMW corporate for a reimbursement of previous service. I received a call yesterday stating they would not replace it and reach out and file a report with NHTA.
Additional Notes:
On January 19, 2022 I was driving and then smoked filled inside my car and the outside engine was smoking and a light came on that said check coolant. BMW service took me in that day and they said my coolant broke. They removed it and replaced it. They did not understand how the coolant broke but I paid for the service and parts and moved forward. On November 25, 2022 I went into the same BMW service center to get a routine car service and they stated there was a recall and they would replace my coolant for free. (After I told them I paid for it ($699.63) . They insisted I replace it for free again and reach out to BMW corporate for a reimbursement of previous service. I received a call yesterday stating they would not replace it and reach out and file a report with NHTA.
Mfg Campaign: 11497221
Recall Date: Dec 13, 2022
Need Legal Help?
Featured Attorneys
Barry Edzant
Edzant Price LLC
Valencia, CA • 36 yrs
Focus: Lemon Law, Personal Injury
Recent Articles
Jeep Grand Cherokee Head Restraint Problem
Chrysler (FCA US, LLC) has announced a safety issue affecting certain 2023–2024 Jeep Grand Ch ...
Aug 1, 2025