Complaints & Recalls
Official Safety Recalls - Important!
8 RecallsThese are official manufacturer recalls ordered by NHTSA for safety defects. If you own this vehicle, contact your dealer immediately for free repairs.
Volvo Car Usa, Llc
Safety Issue:
Volvo Car USA, LLC (Volvo Car) is recalling certain 2020-2021 S90, 2020-2022 S60, V60, XC60, XC90, and 2022 V90 plug-in hybrid vehicles. The high-voltage battery may experience a short circuit within the battery module when the battery is fully charged and the vehicle is parked.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 888-327-4236 (TTY 888-275-9171) or go to nhtsa.gov.
Mfg Campaign: R10312
Recall Date: Mar 20, 2025
Volvo Car Usa, Llc
Safety Issue:
Volvo Car USA, LLC. (Volvo Car) is recalling certain 2019-2024 S60 vehicles. The passenger air bag may not be secured properly, which can cause the air bag to deploy improperly.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Mfg Campaign: R10254
Recall Date: Nov 21, 2023
Volvo Car Usa, Llc
Safety Issue:
Volvo Car USA, LLC (Volvo Car) is recalling certain 2021 XC40, XC 40 Recharge, V60CC, V90, V90CC, XC90, and 2021-2022 V60, XC60, S60 vehicles. The seat belt automatic locking retractors may deactivate early, which can prevent the child restraint system from securing properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Mfg Campaign: R10111
Recall Date: Sep 1, 2021
Consumer Complaints
6 ComplaintsVolvo Car Usa, Llc
Defect Description:
UNKNOWN OR OTHER
Potential Consequences:
Tire has a defect
Corrective Action:
Tire has a defect
Additional Notes:
Tire has a defect
Mfg Campaign: 11676297
Recall Date: Jul 25, 2025
Volvo Car Usa, Llc
Defect Description:
SERVICE BRAKES
Potential Consequences:
I believe that there is a material or design defect in the front brakes of this car that is leading to the premature failure of the front brake rotors. Two sets of front brake rotors have been replaced on the car due to excessive warping in the first 15K miles of operation. I purchased the car in June 2022 as a certified used car with roughly 9K miles on it. As soon as I drove it I could tell the brakes had a problem due to a high vibration level in steering wheel and throughout the car upon brake application above 30 mph. The dealer agreed and replaced the front rotors. The replaced parts were retained by the dealers under Volvo's warranty terms In November 2023, after roughly 4500 miles on the new rotors, the car again developed a noticable, although less severe, steering wheel vibration upon braking. In December 2023, with 6K miles on the front rotors, a dealer (different from the original one) again replaced them under warranty due to warping. I can't speak to the care given in operating the car prior to my acquiring it, but my wife and I are very gentle drivers. For comparison, we owned a 2001 Volvo S80, purchased new, for 16 years and about 120K miles and in that time replaced the front pads once, and never had to replace the rotors.
Corrective Action:
I believe that there is a material or design defect in the front brakes of this car that is leading to the premature failure of the front brake rotors. Two sets of front brake rotors have been replaced on the car due to excessive warping in the first 15K miles of operation. I purchased the car in June 2022 as a certified used car with roughly 9K miles on it. As soon as I drove it I could tell the brakes had a problem due to a high vibration level in steering wheel and throughout the car upon brake application above 30 mph. The dealer agreed and replaced the front rotors. The replaced parts were retained by the dealers under Volvo's warranty terms In November 2023, after roughly 4500 miles on the new rotors, the car again developed a noticable, although less severe, steering wheel vibration upon braking. In December 2023, with 6K miles on the front rotors, a dealer (different from the original one) again replaced them under warranty due to warping. I can't speak to the care given in operating the car prior to my acquiring it, but my wife and I are very gentle drivers. For comparison, we owned a 2001 Volvo S80, purchased new, for 16 years and about 120K miles and in that time replaced the front pads once, and never had to replace the rotors.
Additional Notes:
I believe that there is a material or design defect in the front brakes of this car that is leading to the premature failure of the front brake rotors. Two sets of front brake rotors have been replaced on the car due to excessive warping in the first 15K miles of operation. I purchased the car in June 2022 as a certified used car with roughly 9K miles on it. As soon as I drove it I could tell the brakes had a problem due to a high vibration level in steering wheel and throughout the car upon brake application above 30 mph. The dealer agreed and replaced the front rotors. The replaced parts were retained by the dealers under Volvo's warranty terms In November 2023, after roughly 4500 miles on the new rotors, the car again developed a noticable, although less severe, steering wheel vibration upon braking. In December 2023, with 6K miles on the front rotors, a dealer (different from the original one) again replaced them under warranty due to warping. I can't speak to the care given in operating the car prior to my acquiring it, but my wife and I are very gentle drivers. For comparison, we owned a 2001 Volvo S80, purchased new, for 16 years and about 120K miles and in that time replaced the front pads once, and never had to replace the rotors.
Mfg Campaign: 11560138
Recall Date: Dec 14, 2023
Volvo Car Usa, Llc
Defect Description:
SERVICE BRAKES
Potential Consequences:
My car developed a severe shake in the steering wheel and pulsing in the brake pedal while under braking. The problem has worsened to the point that braking at high speed creates a serious shaking. I took the car to the dealership and they diagnosed the problem as warped rotors. The car started this with less than 15000 miles on the car. The dealer contacted Volvo to fix under warranty due to the defective parts. Volvo declined to fix the rotors because they are a "wear item". This is not normal wear. In fact, during the inspection (10/8) it was noted that the pads still have plenty of life and would not need to be replaced. If the situation were that I had worn out the pads and rotors, I would understand Volvo's position but the warpage is abnormal. When I called in to schedule the initial inspection the technician I spoke with agreed that this is unusual for an S60. When I asked if the rotors would warp again after replacement, I was told by the dealership they have never seen someone come back with warped rotors after replacing them. If it were environmental or driving habits, you would expect this problem to return after replacing the rotors. The warped rotors are a known issue with Volvo. If you search the swedespeed.com website, you will see numerous reports of S60 owners having the same problem. The dealership claims the reason my rotors are warped is because of rust build up causing hot spots and that the car must have sat outside in the rain a long time. This car has been garaged its entire life and is driven daily so rust buildup is not an issue. This rotor and pad combination is defective and fails prematurely.
Corrective Action:
My car developed a severe shake in the steering wheel and pulsing in the brake pedal while under braking. The problem has worsened to the point that braking at high speed creates a serious shaking. I took the car to the dealership and they diagnosed the problem as warped rotors. The car started this with less than 15000 miles on the car. The dealer contacted Volvo to fix under warranty due to the defective parts. Volvo declined to fix the rotors because they are a "wear item". This is not normal wear. In fact, during the inspection (10/8) it was noted that the pads still have plenty of life and would not need to be replaced. If the situation were that I had worn out the pads and rotors, I would understand Volvo's position but the warpage is abnormal. When I called in to schedule the initial inspection the technician I spoke with agreed that this is unusual for an S60. When I asked if the rotors would warp again after replacement, I was told by the dealership they have never seen someone come back with warped rotors after replacing them. If it were environmental or driving habits, you would expect this problem to return after replacing the rotors. The warped rotors are a known issue with Volvo. If you search the swedespeed.com website, you will see numerous reports of S60 owners having the same problem. The dealership claims the reason my rotors are warped is because of rust build up causing hot spots and that the car must have sat outside in the rain a long time. This car has been garaged its entire life and is driven daily so rust buildup is not an issue. This rotor and pad combination is defective and fails prematurely.
Additional Notes:
My car developed a severe shake in the steering wheel and pulsing in the brake pedal while under braking. The problem has worsened to the point that braking at high speed creates a serious shaking. I took the car to the dealership and they diagnosed the problem as warped rotors. The car started this with less than 15000 miles on the car. The dealer contacted Volvo to fix under warranty due to the defective parts. Volvo declined to fix the rotors because they are a "wear item". This is not normal wear. In fact, during the inspection (10/8) it was noted that the pads still have plenty of life and would not need to be replaced. If the situation were that I had worn out the pads and rotors, I would understand Volvo's position but the warpage is abnormal. When I called in to schedule the initial inspection the technician I spoke with agreed that this is unusual for an S60. When I asked if the rotors would warp again after replacement, I was told by the dealership they have never seen someone come back with warped rotors after replacing them. If it were environmental or driving habits, you would expect this problem to return after replacing the rotors. The warped rotors are a known issue with Volvo. If you search the swedespeed.com website, you will see numerous reports of S60 owners having the same problem. The dealership claims the reason my rotors are warped is because of rust build up causing hot spots and that the car must have sat outside in the rain a long time. This car has been garaged its entire life and is driven daily so rust buildup is not an issue. This rotor and pad combination is defective and fails prematurely.
Mfg Campaign: 11494338
Recall Date: Nov 20, 2022
Volvo Car Usa, Llc
Defect Description:
ELECTRICAL SYSTEM
Potential Consequences:
While I was going down a small side street that is a hill, the air conditioning system suddenly went off and immediately the entire car's mechanisms ceased. The engine stopped and the car was unstearable and the brakes were not working. I had my foot on the brake and that was not responsive, the car slid with all electrical systems not working and the brake not holding the car or stopping the movement of the car. I could not start the car to get the engine going.I could not stop nor start the car that slid into a major street that is a thoroughfare for a hospital. I had no control of the car at all. I attempted at least 7 times to start the Volvo that requires keeping your foot on the brake and turning a small switch that is located right next to the cup holder. Nothing would work. I called Volvo On Call who instead of immediately helping told me to call 911 since the car slid into the middle of the major street and it was an emergency regarding my safetly . A police officer came after a few minutes and blocked the traffic. Meanwhile, I was suddenly able by the 9 or 10th time to start the car and move it to the side of the road. The police officer drove in back of me literally a block away from where the Volvo dealer just happened to be located. There were no warning messages prior to the car ceasing. The car is now in the Volvo dealership who upon receiving it said that I must have gotten the ignition switch wet. This is totally false. I did not have any liquids nor should that be a reason why a car suddenly stops and becomes a piece of metal in the middle of the road. What's worse was that there is no emergency brake on this model. My life was in danger and I am lucky that I was not hit. A passenger got out of her car and stood next to mine in the middle of the road with oncoming traffic coming at my driver's side. Volvo dealership is claiming it's the starter switch and it must have shorted. There is a defect and safety problem requiring investigating.
Corrective Action:
While I was going down a small side street that is a hill, the air conditioning system suddenly went off and immediately the entire car's mechanisms ceased. The engine stopped and the car was unstearable and the brakes were not working. I had my foot on the brake and that was not responsive, the car slid with all electrical systems not working and the brake not holding the car or stopping the movement of the car. I could not start the car to get the engine going.I could not stop nor start the car that slid into a major street that is a thoroughfare for a hospital. I had no control of the car at all. I attempted at least 7 times to start the Volvo that requires keeping your foot on the brake and turning a small switch that is located right next to the cup holder. Nothing would work. I called Volvo On Call who instead of immediately helping told me to call 911 since the car slid into the middle of the major street and it was an emergency regarding my safetly . A police officer came after a few minutes and blocked the traffic. Meanwhile, I was suddenly able by the 9 or 10th time to start the car and move it to the side of the road. The police officer drove in back of me literally a block away from where the Volvo dealer just happened to be located. There were no warning messages prior to the car ceasing. The car is now in the Volvo dealership who upon receiving it said that I must have gotten the ignition switch wet. This is totally false. I did not have any liquids nor should that be a reason why a car suddenly stops and becomes a piece of metal in the middle of the road. What's worse was that there is no emergency brake on this model. My life was in danger and I am lucky that I was not hit. A passenger got out of her car and stood next to mine in the middle of the road with oncoming traffic coming at my driver's side. Volvo dealership is claiming it's the starter switch and it must have shorted. There is a defect and safety problem requiring investigating.
Additional Notes:
While I was going down a small side street that is a hill, the air conditioning system suddenly went off and immediately the entire car's mechanisms ceased. The engine stopped and the car was unstearable and the brakes were not working. I had my foot on the brake and that was not responsive, the car slid with all electrical systems not working and the brake not holding the car or stopping the movement of the car. I could not start the car to get the engine going.I could not stop nor start the car that slid into a major street that is a thoroughfare for a hospital. I had no control of the car at all. I attempted at least 7 times to start the Volvo that requires keeping your foot on the brake and turning a small switch that is located right next to the cup holder. Nothing would work. I called Volvo On Call who instead of immediately helping told me to call 911 since the car slid into the middle of the major street and it was an emergency regarding my safetly . A police officer came after a few minutes and blocked the traffic. Meanwhile, I was suddenly able by the 9 or 10th time to start the car and move it to the side of the road. The police officer drove in back of me literally a block away from where the Volvo dealer just happened to be located. There were no warning messages prior to the car ceasing. The car is now in the Volvo dealership who upon receiving it said that I must have gotten the ignition switch wet. This is totally false. I did not have any liquids nor should that be a reason why a car suddenly stops and becomes a piece of metal in the middle of the road. What's worse was that there is no emergency brake on this model. My life was in danger and I am lucky that I was not hit. A passenger got out of her car and stood next to mine in the middle of the road with oncoming traffic coming at my driver's side. Volvo dealership is claiming it's the starter switch and it must have shorted. There is a defect and safety problem requiring investigating.
Mfg Campaign: 11418969
Recall Date: May 29, 2021
Volvo Car Usa, Llc
Defect Description:
ENGINE
Potential Consequences:
While I was going down a small side street that is a hill, the air conditioning system suddenly went off and immediately the entire car's mechanisms ceased. The engine stopped and the car was unstearable and the brakes were not working. I had my foot on the brake and that was not responsive, the car slid with all electrical systems not working and the brake not holding the car or stopping the movement of the car. I could not start the car to get the engine going.I could not stop nor start the car that slid into a major street that is a thoroughfare for a hospital. I had no control of the car at all. I attempted at least 7 times to start the Volvo that requires keeping your foot on the brake and turning a small switch that is located right next to the cup holder. Nothing would work. I called Volvo On Call who instead of immediately helping told me to call 911 since the car slid into the middle of the major street and it was an emergency regarding my safetly . A police officer came after a few minutes and blocked the traffic. Meanwhile, I was suddenly able by the 9 or 10th time to start the car and move it to the side of the road. The police officer drove in back of me literally a block away from where the Volvo dealer just happened to be located. There were no warning messages prior to the car ceasing. The car is now in the Volvo dealership who upon receiving it said that I must have gotten the ignition switch wet. This is totally false. I did not have any liquids nor should that be a reason why a car suddenly stops and becomes a piece of metal in the middle of the road. What's worse was that there is no emergency brake on this model. My life was in danger and I am lucky that I was not hit. A passenger got out of her car and stood next to mine in the middle of the road with oncoming traffic coming at my driver's side. Volvo dealership is claiming it's the starter switch and it must have shorted. There is a defect and safety problem requiring investigating.
Corrective Action:
While I was going down a small side street that is a hill, the air conditioning system suddenly went off and immediately the entire car's mechanisms ceased. The engine stopped and the car was unstearable and the brakes were not working. I had my foot on the brake and that was not responsive, the car slid with all electrical systems not working and the brake not holding the car or stopping the movement of the car. I could not start the car to get the engine going.I could not stop nor start the car that slid into a major street that is a thoroughfare for a hospital. I had no control of the car at all. I attempted at least 7 times to start the Volvo that requires keeping your foot on the brake and turning a small switch that is located right next to the cup holder. Nothing would work. I called Volvo On Call who instead of immediately helping told me to call 911 since the car slid into the middle of the major street and it was an emergency regarding my safetly . A police officer came after a few minutes and blocked the traffic. Meanwhile, I was suddenly able by the 9 or 10th time to start the car and move it to the side of the road. The police officer drove in back of me literally a block away from where the Volvo dealer just happened to be located. There were no warning messages prior to the car ceasing. The car is now in the Volvo dealership who upon receiving it said that I must have gotten the ignition switch wet. This is totally false. I did not have any liquids nor should that be a reason why a car suddenly stops and becomes a piece of metal in the middle of the road. What's worse was that there is no emergency brake on this model. My life was in danger and I am lucky that I was not hit. A passenger got out of her car and stood next to mine in the middle of the road with oncoming traffic coming at my driver's side. Volvo dealership is claiming it's the starter switch and it must have shorted. There is a defect and safety problem requiring investigating.
Additional Notes:
While I was going down a small side street that is a hill, the air conditioning system suddenly went off and immediately the entire car's mechanisms ceased. The engine stopped and the car was unstearable and the brakes were not working. I had my foot on the brake and that was not responsive, the car slid with all electrical systems not working and the brake not holding the car or stopping the movement of the car. I could not start the car to get the engine going.I could not stop nor start the car that slid into a major street that is a thoroughfare for a hospital. I had no control of the car at all. I attempted at least 7 times to start the Volvo that requires keeping your foot on the brake and turning a small switch that is located right next to the cup holder. Nothing would work. I called Volvo On Call who instead of immediately helping told me to call 911 since the car slid into the middle of the major street and it was an emergency regarding my safetly . A police officer came after a few minutes and blocked the traffic. Meanwhile, I was suddenly able by the 9 or 10th time to start the car and move it to the side of the road. The police officer drove in back of me literally a block away from where the Volvo dealer just happened to be located. There were no warning messages prior to the car ceasing. The car is now in the Volvo dealership who upon receiving it said that I must have gotten the ignition switch wet. This is totally false. I did not have any liquids nor should that be a reason why a car suddenly stops and becomes a piece of metal in the middle of the road. What's worse was that there is no emergency brake on this model. My life was in danger and I am lucky that I was not hit. A passenger got out of her car and stood next to mine in the middle of the road with oncoming traffic coming at my driver's side. Volvo dealership is claiming it's the starter switch and it must have shorted. There is a defect and safety problem requiring investigating.
Mfg Campaign: 11418969
Recall Date: May 29, 2021
Volvo Car Usa, Llc
Defect Description:
STEERING
Potential Consequences:
While I was going down a small side street that is a hill, the air conditioning system suddenly went off and immediately the entire car's mechanisms ceased. The engine stopped and the car was unstearable and the brakes were not working. I had my foot on the brake and that was not responsive, the car slid with all electrical systems not working and the brake not holding the car or stopping the movement of the car. I could not start the car to get the engine going.I could not stop nor start the car that slid into a major street that is a thoroughfare for a hospital. I had no control of the car at all. I attempted at least 7 times to start the Volvo that requires keeping your foot on the brake and turning a small switch that is located right next to the cup holder. Nothing would work. I called Volvo On Call who instead of immediately helping told me to call 911 since the car slid into the middle of the major street and it was an emergency regarding my safetly . A police officer came after a few minutes and blocked the traffic. Meanwhile, I was suddenly able by the 9 or 10th time to start the car and move it to the side of the road. The police officer drove in back of me literally a block away from where the Volvo dealer just happened to be located. There were no warning messages prior to the car ceasing. The car is now in the Volvo dealership who upon receiving it said that I must have gotten the ignition switch wet. This is totally false. I did not have any liquids nor should that be a reason why a car suddenly stops and becomes a piece of metal in the middle of the road. What's worse was that there is no emergency brake on this model. My life was in danger and I am lucky that I was not hit. A passenger got out of her car and stood next to mine in the middle of the road with oncoming traffic coming at my driver's side. Volvo dealership is claiming it's the starter switch and it must have shorted. There is a defect and safety problem requiring investigating.
Corrective Action:
While I was going down a small side street that is a hill, the air conditioning system suddenly went off and immediately the entire car's mechanisms ceased. The engine stopped and the car was unstearable and the brakes were not working. I had my foot on the brake and that was not responsive, the car slid with all electrical systems not working and the brake not holding the car or stopping the movement of the car. I could not start the car to get the engine going.I could not stop nor start the car that slid into a major street that is a thoroughfare for a hospital. I had no control of the car at all. I attempted at least 7 times to start the Volvo that requires keeping your foot on the brake and turning a small switch that is located right next to the cup holder. Nothing would work. I called Volvo On Call who instead of immediately helping told me to call 911 since the car slid into the middle of the major street and it was an emergency regarding my safetly . A police officer came after a few minutes and blocked the traffic. Meanwhile, I was suddenly able by the 9 or 10th time to start the car and move it to the side of the road. The police officer drove in back of me literally a block away from where the Volvo dealer just happened to be located. There were no warning messages prior to the car ceasing. The car is now in the Volvo dealership who upon receiving it said that I must have gotten the ignition switch wet. This is totally false. I did not have any liquids nor should that be a reason why a car suddenly stops and becomes a piece of metal in the middle of the road. What's worse was that there is no emergency brake on this model. My life was in danger and I am lucky that I was not hit. A passenger got out of her car and stood next to mine in the middle of the road with oncoming traffic coming at my driver's side. Volvo dealership is claiming it's the starter switch and it must have shorted. There is a defect and safety problem requiring investigating.
Additional Notes:
While I was going down a small side street that is a hill, the air conditioning system suddenly went off and immediately the entire car's mechanisms ceased. The engine stopped and the car was unstearable and the brakes were not working. I had my foot on the brake and that was not responsive, the car slid with all electrical systems not working and the brake not holding the car or stopping the movement of the car. I could not start the car to get the engine going.I could not stop nor start the car that slid into a major street that is a thoroughfare for a hospital. I had no control of the car at all. I attempted at least 7 times to start the Volvo that requires keeping your foot on the brake and turning a small switch that is located right next to the cup holder. Nothing would work. I called Volvo On Call who instead of immediately helping told me to call 911 since the car slid into the middle of the major street and it was an emergency regarding my safetly . A police officer came after a few minutes and blocked the traffic. Meanwhile, I was suddenly able by the 9 or 10th time to start the car and move it to the side of the road. The police officer drove in back of me literally a block away from where the Volvo dealer just happened to be located. There were no warning messages prior to the car ceasing. The car is now in the Volvo dealership who upon receiving it said that I must have gotten the ignition switch wet. This is totally false. I did not have any liquids nor should that be a reason why a car suddenly stops and becomes a piece of metal in the middle of the road. What's worse was that there is no emergency brake on this model. My life was in danger and I am lucky that I was not hit. A passenger got out of her car and stood next to mine in the middle of the road with oncoming traffic coming at my driver's side. Volvo dealership is claiming it's the starter switch and it must have shorted. There is a defect and safety problem requiring investigating.
Mfg Campaign: 11418969
Recall Date: May 29, 2021
Need Legal Help?
Featured Attorneys
Barry Edzant
Edzant Price LLC
Valencia, CA • 36 yrs
Focus: Lemon Law, Personal Injury
Recent Articles
Jeep Grand Cherokee Head Restraint Problem
Chrysler (FCA US, LLC) has announced a safety issue affecting certain 2023–2024 Jeep Grand Ch ...
Aug 1, 2025Fuel Injector Problem: 2021-2024 Ford Bronco Sport and 2020-2022 Ford Escape
If you own a 2021-2024 Ford Bronco Sport or 2020-2022 Ford Escape equipped with a 1.5L Dragon GTDI e ...
Jul 28, 2025Airbag Problem Affects 2022-2025 Chrysler Pacifica and Voyager Vehicles
If you own a Chrysler Pacifica or Voyager, your vehicle may be equipped with defective side curtain ...
Jul 24, 2025