Complaints & Recalls
Official Safety Recalls - Important!
5 RecallsThese are official manufacturer recalls ordered by NHTSA for safety defects. If you own this vehicle, contact your dealer immediately for free repairs.
Tiffin Motorhomes, Inc.
Safety Issue:
Tiffin Motorhomes, Inc. (Tiffin) is recalling certain 2018-2022 Allegro Breeze, Allegro Red, Allegro, Allegro Bus, Phaeton, and 2018-2021 Zephyr recreational vehicles. The sofa seat belts may not have been installed correctly, which could result in unsecured passengers. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 210, "Seat Belt Assembly Anchorages."
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Mfg Campaign: TIF-118
Recall Date: Sep 1, 2021
Tiffin Motorhomes, Inc.
Safety Issue:
Tiffin Motorhomes, Inc. (Tiffin) is recalling certain 2017-2021 Bus and Phaeton vehicles. The sealing washer may not seat correctly in the pilot bore, allowing the high pressure fuel rail assembly to leak.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Mfg Campaign: TIF-116
Recall Date: Apr 30, 2021
Tiffin Motorhomes, Inc.
Safety Issue:
Tiffin Motorhomes, Inc. (Tiffin) is recalling certain 2018-2019 Phaeton, Allegro Bus, and Zephyr motorhomes. The alternating current electrical wires may have been improperly secured in the Energy Management Module, causing increased electrical resistance.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Mfg Campaign: TIFF-111
Recall Date: Mar 22, 2019
Tiffin Motorhomes, Inc.
Safety Issue:
Tiffin Motorhomes, Inc. (Tiffin) is recalling certain 2018-2019 Tiffin Allegro RED, Allegro Open Road, Breeze, Bus, Phaeton, and Zephyr motorhomes. The entry door on these vehicles may have been improperly assembled, allowing the door to open while the vehicle is moving.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Mfg Campaign: TIF-110
Recall Date: May 25, 2018
Tiffin Motorhomes, Inc.
Safety Issue:
Tiffin Motorhomes, Inc. (Tiffin) is recalling certain 2009-2018 Allegro and Allegro RED, Bus and Phaeton vehicles, 2009-2010 Bay vehicles, 2011-2018 Breeze vehicles, and 2009-2015, and 2017-2018 Zephyr vehicles. These motorhomes are equipped with Kidde Plastic-Handle or Push Button 'Pindicator' Fire Extinguishers that may become clogged, preventing the extinguisher from discharging as expected or excessive force may be needed to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Recall Date: Dec 22, 2017
Consumer Complaints
3 ComplaintsTiffin Motorhomes, Inc.
Defect Description:
TIRES:SIDEWALL
Potential Consequences:
tire size 275/80/22.5 Driving down highway 301, driver side steer tire’s side wall blew out with no warning. My motor home made a hard left, luckily no one was in that fast lane. I managed to recover control and started to head to the shoulder of the road. Before I could reach the shoulder the rim cut the tire and threw it off the rim and into the highway. This put my life , my wife and anyone on the highway’s life in severe danger!!! I called michelin and their rep inspected the tire and felt the tire was run low. I completely disagree. All tires were checked that day and if this steer tire was low it would have pulled to the left!!
Corrective Action:
tire size 275/80/22.5 Driving down highway 301, driver side steer tire’s side wall blew out with no warning. My motor home made a hard left, luckily no one was in that fast lane. I managed to recover control and started to head to the shoulder of the road. Before I could reach the shoulder the rim cut the tire and threw it off the rim and into the highway. This put my life , my wife and anyone on the highway’s life in severe danger!!! I called michelin and their rep inspected the tire and felt the tire was run low. I completely disagree. All tires were checked that day and if this steer tire was low it would have pulled to the left!!
Additional Notes:
tire size 275/80/22.5 Driving down highway 301, driver side steer tire’s side wall blew out with no warning. My motor home made a hard left, luckily no one was in that fast lane. I managed to recover control and started to head to the shoulder of the road. Before I could reach the shoulder the rim cut the tire and threw it off the rim and into the highway. This put my life , my wife and anyone on the highway’s life in severe danger!!! I called michelin and their rep inspected the tire and felt the tire was run low. I completely disagree. All tires were checked that day and if this steer tire was low it would have pulled to the left!!
Mfg Campaign: 11513495
Recall Date: Mar 23, 2023
Tiffin Motorhomes, Inc.
Defect Description:
ENGINE AND ENGINE COOLING
Potential Consequences:
The contact owns a 2018 Tiffin Phaeton RV. The contact stated that while driving approximately 60 MPH, the dashboard instrument cluster lights suddenly began to flash off and on and the Diesel Emission Fluid (DEF) sensor light remained illuminated before the vehicles decelerated independently to 5 MPH. The vehicle was driven to a nearby service center(unknown) and the Diesel Emission Fluid sensor was replaced, and the failure was remedied. The manufacturer was notified of the failure. The local dealer was not contacted. The failure mileage was 22,000.
Corrective Action:
The contact owns a 2018 Tiffin Phaeton RV. The contact stated that while driving approximately 60 MPH, the dashboard instrument cluster lights suddenly began to flash off and on and the Diesel Emission Fluid (DEF) sensor light remained illuminated before the vehicles decelerated independently to 5 MPH. The vehicle was driven to a nearby service center(unknown) and the Diesel Emission Fluid sensor was replaced, and the failure was remedied. The manufacturer was notified of the failure. The local dealer was not contacted. The failure mileage was 22,000.
Additional Notes:
The contact owns a 2018 Tiffin Phaeton RV. The contact stated that while driving approximately 60 MPH, the dashboard instrument cluster lights suddenly began to flash off and on and the Diesel Emission Fluid (DEF) sensor light remained illuminated before the vehicles decelerated independently to 5 MPH. The vehicle was driven to a nearby service center(unknown) and the Diesel Emission Fluid sensor was replaced, and the failure was remedied. The manufacturer was notified of the failure. The local dealer was not contacted. The failure mileage was 22,000.
Mfg Campaign: 11431608
Recall Date: Sep 3, 2021
Tiffin Motorhomes, Inc.
Defect Description:
WHEELS
Potential Consequences:
I SAW A POST ON THE TIFFIN RV FORUM REGARDING THE VALVE STEM STABILIZERS THAT FREIGHTLINER PROVIDED ON RECENT RV CHASSIS EQUIPPED WITH A NEW STYLE RIM. I HAVE A 2018 TIFFIN COACH AND HAD THE SAME ISSUE SOON AFTER I PURCHASED IT. I NOTICED THAT THE VALVE STEM WAS RUBBING ON THE CHROME WHEEL AND IN FACT HAD RUBBED OFF THE CHROME DOWN TO BARE METAL. I TOOK IT TO BAY DIESEL IN RED BAY, AL. AND THEY REPLACE THE VALVE STEMS. THEY SHOWED ME ON ONE WHERE IT HAD ALMOST RUBBED THROUGH AND THERE WOULD HAVE BEEN AN AIR LEAK IF I HAD DRIVEN IT MANY MORE MILES. I WAS TOLD IT WAS NOT WARRANTABLE AND I PAID FOR THE REPLACEMENT STEMS. IT HAPPENED AGAIN SOON AFTER AND WHEN I CALLED FREIGHTLINER, THE PERSON I TALKED TO SAID THEY KNOW ABOUT THE PROBLEM BUT HAVE NOT COME UP WITH A CORRECTION AS YET. MFR BUILD DATE WAS 4/1/2018.
Corrective Action:
I SAW A POST ON THE TIFFIN RV FORUM REGARDING THE VALVE STEM STABILIZERS THAT FREIGHTLINER PROVIDED ON RECENT RV CHASSIS EQUIPPED WITH A NEW STYLE RIM. I HAVE A 2018 TIFFIN COACH AND HAD THE SAME ISSUE SOON AFTER I PURCHASED IT. I NOTICED THAT THE VALVE STEM WAS RUBBING ON THE CHROME WHEEL AND IN FACT HAD RUBBED OFF THE CHROME DOWN TO BARE METAL. I TOOK IT TO BAY DIESEL IN RED BAY, AL. AND THEY REPLACE THE VALVE STEMS. THEY SHOWED ME ON ONE WHERE IT HAD ALMOST RUBBED THROUGH AND THERE WOULD HAVE BEEN AN AIR LEAK IF I HAD DRIVEN IT MANY MORE MILES. I WAS TOLD IT WAS NOT WARRANTABLE AND I PAID FOR THE REPLACEMENT STEMS. IT HAPPENED AGAIN SOON AFTER AND WHEN I CALLED FREIGHTLINER, THE PERSON I TALKED TO SAID THEY KNOW ABOUT THE PROBLEM BUT HAVE NOT COME UP WITH A CORRECTION AS YET. MFR BUILD DATE WAS 4/1/2018.
Additional Notes:
I SAW A POST ON THE TIFFIN RV FORUM REGARDING THE VALVE STEM STABILIZERS THAT FREIGHTLINER PROVIDED ON RECENT RV CHASSIS EQUIPPED WITH A NEW STYLE RIM. I HAVE A 2018 TIFFIN COACH AND HAD THE SAME ISSUE SOON AFTER I PURCHASED IT. I NOTICED THAT THE VALVE STEM WAS RUBBING ON THE CHROME WHEEL AND IN FACT HAD RUBBED OFF THE CHROME DOWN TO BARE METAL. I TOOK IT TO BAY DIESEL IN RED BAY, AL. AND THEY REPLACE THE VALVE STEMS. THEY SHOWED ME ON ONE WHERE IT HAD ALMOST RUBBED THROUGH AND THERE WOULD HAVE BEEN AN AIR LEAK IF I HAD DRIVEN IT MANY MORE MILES. I WAS TOLD IT WAS NOT WARRANTABLE AND I PAID FOR THE REPLACEMENT STEMS. IT HAPPENED AGAIN SOON AFTER AND WHEN I CALLED FREIGHTLINER, THE PERSON I TALKED TO SAID THEY KNOW ABOUT THE PROBLEM BUT HAVE NOT COME UP WITH A CORRECTION AS YET. MFR BUILD DATE WAS 4/1/2018.
Mfg Campaign: 11307150
Recall Date: Jan 31, 2020
Need Legal Help?
Featured Attorneys
Barry Edzant
Edzant Price LLC
Valencia, CA • 36 yrs
Focus: Lemon Law, Personal Injury
Recent Articles
Jeep Grand Cherokee Head Restraint Problem
Chrysler (FCA US, LLC) has announced a safety issue affecting certain 2023–2024 Jeep Grand Ch ...
Aug 1, 2025Fuel Injector Problem: 2021-2024 Ford Bronco Sport and 2020-2022 Ford Escape
If you own a 2021-2024 Ford Bronco Sport or 2020-2022 Ford Escape equipped with a 1.5L Dragon GTDI e ...
Jul 28, 2025Airbag Problem Affects 2022-2025 Chrysler Pacifica and Voyager Vehicles
If you own a Chrysler Pacifica or Voyager, your vehicle may be equipped with defective side curtain ...
Jul 24, 2025