TESLA MODEL Y 2020

Complete listing of complaints and recalls for this vehicle

447
Complaints
45
Recalls

Complaints & Recalls

447 Complaints 45 Recalls

Official Safety Recalls - Important!

45 Recalls

These are official manufacturer recalls ordered by NHTSA for safety defects. If you own this vehicle, contact your dealer immediately for free repairs.

Tesla, Inc.
NHTSA Campaign: 24V935000 SAFETY RECALL
696.3K Vehicles Affected
Recall Date: Dec 17, 2024
Safety Issue:

Tesla, Inc. (Tesla) is recalling certain 2024 Cybertruck, 2017-2025 Model 3, and 2020-2025 Model Y vehicles. The tire pressure monitoring system (TPMS) warning light may not remain illuminated between drive cycles, failing to warn the driver of low tire pressure. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 138, "Tire Pressure Monitoring Systems."

Potential Risk:
Driving with improperly inflated tires increases the risk of a crash.
FREE Recall Solution:
Tesla released an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed February 15, 2025. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-018.
Additional Details:

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.

Action Required: Contact your local TESLA dealer to schedule your FREE recall repair.
Manufacturer: TESLA
Mfg Campaign: SB-24-00-018
Notice Date: Feb 15, 2025
Recall Date: Dec 17, 2024
Tesla, Inc.
NHTSA Campaign: 24V554000 SAFETY RECALL
1.8M Vehicles Affected
Recall Date: Jul 24, 2024
Safety Issue:

Tesla, Inc. (Tesla) is recalling certain 2021-2024 Model 3, Model S, Model X, and 2020-2024 Model Y vehicles. The hood latch assembly may fail to detect an unlatched hood condition after the hood has been opened.

Potential Risk:
An unlatched hood can fully open, obstructing the driver's view and increasing the risk of a crash.
FREE Recall Solution:
Tesla has released an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed September 24, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-012.
Additional Details:

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.

Action Required: Contact your local TESLA dealer to schedule your FREE recall repair.
Manufacturer: TESLA
Mfg Campaign: SB-24-00-012
Notice Date: Sep 22, 2024
Recall Date: Jul 24, 2024
Tesla, Inc.
NHTSA Campaign: 24V376000 SAFETY RECALL
125.2K Vehicles Affected
Recall Date: May 28, 2024
Safety Issue:

Tesla, Inc. (Tesla) is recalling certain 2012-2024 Model S, 2015-2024 Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles. In the event of an unbelted driver, the seat belt warning light and audible chime may not activate as intended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."

Potential Risk:
A seat belt warning system that fails to alert occupants of an unbelted seat belt can increase the risk of injury during a crash.
FREE Recall Solution:
Tesla will release an over-the-air (OTA) software update. Owner notification letters were mailed July 26, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-008.
Additional Details:

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.

Action Required: Contact your local TESLA dealer to schedule your FREE recall repair.
Manufacturer: TESLA
Mfg Campaign: SB-24-00-008
Notice Date: Jul 26, 2024
Recall Date: May 28, 2024
Tesla, Inc.
NHTSA Campaign: 24V153000 SAFETY RECALL
6.6K Vehicles Affected
Recall Date: Feb 27, 2024
Safety Issue:

Tesla, Inc. (Tesla) is recalling certain 2013, 2018-2021 Model S, 2020-2021 Model X, 2018-2022 Model 3, and 2020-2022 Model Y vehicles. A factory reset muted the Pedestrian Warning System (PWS) sounds. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 141, "Minimum Sound Requirements for Hybrid and Electric Vehicles."

Potential Risk:
Pedestrians may be unaware of an approaching vehicle if the PWS sounds are muted, increasing the risk of a crash.
FREE Recall Solution:
Tesla released an over-the-air (OTA) software update, release 2023.44.30.14, free of charge. Owner notification letters were mailed April 27, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-006.
Additional Details:

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.

Action Required: Contact your local TESLA dealer to schedule your FREE recall repair.
Manufacturer: TESLA
Mfg Campaign: SB-24-00-006
Notice Date: Apr 27, 2024
Recall Date: Feb 27, 2024
Tesla, Inc.
NHTSA Campaign: 24V051000 SAFETY RECALL
2.2M Vehicles Affected
Recall Date: Jan 30, 2024
Safety Issue:

Tesla, Inc. (Tesla) is recalling certain 2012-2023 Model S, 2016-2024 Model X, 2017-2023 Model 3, 2019-2024 Model Y, and 2024 Cybertruck vehicles. An incorrect font size is displayed on the instrument panel for the Brake, Park, and Antilock Brake System (ABS) warning lights. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 105, "Hydraulic and Electric Brake Systems" and 135, "Light Vehicle Brake Systems."

Potential Risk:
Warning lights with a smaller font size can make critical safety information on the instrument panel difficult to read, increasing the risk of a crash.
FREE Recall Solution:
Tesla began releasing an over-the-air (OTA) software update, free of charge. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-003.
Additional Details:

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.

Action Required: Contact your local TESLA dealer to schedule your FREE recall repair.
Manufacturer: TESLA
Mfg Campaign: SB-24-00-003
Notice Date: Feb 21, 2024
Recall Date: Jan 30, 2024
Tesla, Inc.
NHTSA Campaign: 23V838000 SAFETY RECALL
2M Vehicles Affected
Recall Date: Dec 12, 2023
Safety Issue:

Tesla, Inc. (Tesla) is recalling 2012-2023 Model S, 2016-2023 Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles equipped with all versions of Autosteer leading up to the version(s) that contains the recall remedy. In certain circumstances when Autosteer is engaged, the prominence and scope of the feature's controls may not be sufficient to prevent driver misuse of the SAE Level 2 advanced driver-assistance feature.

Potential Risk:
In certain circumstances when Autosteer is engaged, and the driver does not maintain responsibility for vehicle operation and is unprepared to intervene as necessary or fails to recognize when Autosteer is canceled or not engaged, there may be an increased risk of a crash.
FREE Recall Solution:
Tesla will release an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed February 10, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-23-00-008.
Additional Details:

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.

Action Required: Contact your local TESLA dealer to schedule your FREE recall repair.
Manufacturer: TESLA
Mfg Campaign: SB-23-00-008
Notice Date: Feb 10, 2024
Recall Date: Dec 12, 2023
Tesla, Inc.
NHTSA Campaign: 23V085000 SAFETY RECALL
362.8K Vehicles Affected
Recall Date: Feb 15, 2023
Safety Issue:

Tesla, Inc. (Tesla) is recalling certain 2016-2023 Model S, Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles equipped with Full Self-Driving Beta (FSD Beta) software or pending installation. The FSD Beta system may allow the vehicle to act unsafe around intersections, such as traveling straight through an intersection while in a turn-only lane, entering a stop sign-controlled intersection without coming to a complete stop, or proceeding into an intersection during a steady yellow traffic signal without due caution. In addition, the system may respond insufficiently to changes in posted speed limits or not adequately account for the driver's adjustment of the vehicle's speed to exceed posted speed limits.

Potential Risk:
FSD Beta software that allows a vehicle to exceed speed limits or travel through intersections in an unlawful or unpredictable manner increases the risk of a crash.
FREE Recall Solution:
Tesla will release an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed April 15, 2023. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-23-00-001.
Additional Details:

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.

Action Required: Contact your local TESLA dealer to schedule your FREE recall repair.
Manufacturer: TESLA
Mfg Campaign: SB-23-00-001
Notice Date: Apr 15, 2023
Recall Date: Feb 15, 2023
Tesla, Inc.
NHTSA Campaign: 22V844000 SAFETY RECALL
321.6K Vehicles Affected
Recall Date: Nov 15, 2022
Safety Issue:

Tesla, Inc. (Tesla) is recalling certain 2023 Model 3 and 2020-2023 Model Y vehicles. One or both taillights may intermittently fail to illuminate.

Potential Risk:
A taillight that fails to illuminate may reduce the visibility of the vehicle, increasing the risk of a crash.
FREE Recall Solution:
Tesla has released an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed January 14, 2023. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-016.
Additional Details:

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.

Action Required: Contact your local TESLA dealer to schedule your FREE recall repair.
Manufacturer: TESLA
Mfg Campaign: SB-22-00-016
Notice Date: Jan 14, 2023
Recall Date: Nov 15, 2022
Tesla, Inc.
NHTSA Campaign: 22V702000 SAFETY RECALL
1.1M Vehicles Affected
Recall Date: Sep 19, 2022
Safety Issue:

Tesla, Inc. (Tesla) is recalling certain 2017-2022 Model 3, 2020-2022 Model Y, and 2021-2022 Model S and Model X vehicles. The window automatic reversal system may not react correctly after detecting an obstruction. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 118, "Power-Operated Window Systems."

Potential Risk:
A closing window may exert excessive force by pinching a driver or passenger before retracting, increasing the risk of injury.
FREE Recall Solution:
Tesla will perform an over-the-air (OTA) software update of the automatic window reversal system, free of charge. Owner notification letters were mailed March 31, 2032. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-013.
Additional Details:

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.

Action Required: Contact your local TESLA dealer to schedule your FREE recall repair.
Manufacturer: TESLA
Mfg Campaign: SB-22-00-013
Notice Date: Mar 31, 2023
Recall Date: Sep 19, 2022
Tesla, Inc.
NHTSA Campaign: 22V235000 SAFETY RECALL
594.9K Vehicles Affected
Recall Date: Apr 12, 2022
Safety Issue:

Tesla, Inc. (Tesla) is recalling certain 2020-2022 Model Y, Model X, Model S, and 2017-2022 Model 3 vehicles. The Boombox function allows sounds to be played through an external speaker while the vehicle is in motion, which may obscure the Pedestrian Warning System (PWS) sounds. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 141, "Minimum Sound Requirements for Hybrid and Electric Vehicles."

Potential Risk:
Pedestrians may be unaware of an approaching vehicle if the PWS sounds are obscured, increasing the risk of a crash.
FREE Recall Solution:
Tesla will perform an over-the-air (OTA) software update that will disable the Boombox functionality when the vehicle is in Drive, Neutral and Reverse modes, including Summon and Smart Summon, free of charge. Owner notification letters were mailed June 6, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-003. Note: This recall supersedes recall 22V-063. Vehicles configured with Summon or Smart Summon and already remedied under 22V-063 will need to have the new remedy software installed.
Additional Details:

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.

Action Required: Contact your local TESLA dealer to schedule your FREE recall repair.
Manufacturer: TESLA
Mfg Campaign: SB-22-00-003
Notice Date: Jun 6, 2022
Recall Date: Apr 12, 2022
Tesla, Inc.
NHTSA Campaign: 22V063000 SAFETY RECALL
578.6K Vehicles Affected
Recall Date: Feb 4, 2022
Safety Issue:

Tesla, Inc. (Tesla) is recalling certain 2020-2022 Model S, Model X, Model Y, and 2017-2022 Model 3 vehicles. The Boombox function allows sounds to be played through an external speaker while the vehicle is in motion, which may obscure the Pedestrian Warning System (PWS) sounds. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 141, "Minimum Sound Requirements for Hybrid and Electric Vehicles."

Potential Risk:
Pedestrians may be unaware of an approaching vehicle if the PWS sounds are obscured, increasing the risk of a crash.
FREE Recall Solution:
Tesla will perform an over-the-air (OTA) software update that will disable the Boombox functionality when the vehicle is in Drive, Neutral and Reverse modes, free of charge. Owner notification letters are expected to be mailed April 5, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-003. Note: This recall has been superseded by Recall 22V-235. Tesla's number for the new recall is SB-22-00-003.
Additional Details:

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.

Action Required: Contact your local TESLA dealer to schedule your FREE recall repair.
Manufacturer: TESLA
Mfg Campaign: SB-22-00-003
Notice Date: Apr 12, 2022
Recall Date: Feb 4, 2022
Tesla, Inc.
NHTSA Campaign: 22V050000 SAFETY RECALL
26.7K Vehicles Affected
Recall Date: Feb 2, 2022
Safety Issue:

Tesla, Inc. (Tesla) is recalling certain 2021-2022 Model 3, Model S, Model X, and 2020-2022 Model Y vehicles. A software error may cause a valve in the heat pump to open unintentionally and trap the refrigerant inside the evaporator, resulting in decreased defrosting performance. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 103, "Windshield Defrosting and Defogging Systems."

Potential Risk:
Decreased defrosting performance may reduce the driver's visibility, increasing the risk of a crash.
FREE Recall Solution:
Tesla will perform an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed April 1, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-18-002.
Additional Details:

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.

Action Required: Contact your local TESLA dealer to schedule your FREE recall repair.
Manufacturer: TESLA
Mfg Campaign: SB-22-18-002
Notice Date: Apr 1, 2022
Recall Date: Feb 2, 2022
Tesla, Inc.
NHTSA Campaign: 22V045000 SAFETY RECALL
817.1K Vehicles Affected
Recall Date: Feb 1, 2022
Safety Issue:

Tesla, Inc. (Tesla) is recalling certain 2021-2022 Model S and Model X, 2017-2022 Model 3, and 2020-2022 Model Y vehicles. The audible chime may not activate when the vehicle starts and the driver has not buckled their seat belt. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."

Potential Risk:
The driver may be unaware that their seat belt is not fastened, increasing the risk of injury during a crash.
FREE Recall Solution:
Tesla will perform an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed April 1, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-002.
Additional Details:

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.

Action Required: Contact your local TESLA dealer to schedule your FREE recall repair.
Manufacturer: TESLA
Mfg Campaign: SB-22-00-002
Notice Date: Apr 1, 2022
Recall Date: Feb 1, 2022
Tesla, Inc.
NHTSA Campaign: 22V037000 SAFETY RECALL
53.8K Vehicles Affected
Recall Date: Jan 27, 2022
Safety Issue:

Tesla, Inc. (Tesla) is recalling certain 2016-2022 Model S and Model X, 2017-2022 Model 3, and 2020-2022 Model Y vehicles. The "rolling stop" functionality available as part of the Full Self-Driving (Beta) software may allow the vehicle to travel through an all-way stop intersection without first coming to a stop.

Potential Risk:
Failing to stop at a stop sign can increase the risk of a crash.
FREE Recall Solution:
Tesla will perform an over-the-air (OTA) software update that disables the "rolling stop" functionality, free of charge. Owner notification letters were mailed March 28, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-22-00-001.
Additional Details:

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.

Action Required: Contact your local TESLA dealer to schedule your FREE recall repair.
Manufacturer: TESLA
Mfg Campaign: SB-22-00-001
Notice Date: Mar 28, 2022
Recall Date: Jan 27, 2022
Tesla, Inc.
NHTSA Campaign: 21V912000 SAFETY RECALL
826 Vehicles Affected
Recall Date: Nov 21, 2021
Safety Issue:

Tesla, Inc. (Tesla) is recalling certain 2020-2022 Model Y vehicles. The front and rear suspension knuckles may fracture, causing the suspension links to separate.

Potential Risk:
Suspension links that separate can reduce vehicle stability and control, increasing the risk of a crash.
FREE Recall Solution:
Tesla Service will inspect and replace the knuckles as necessary, free of charge. Owner notification letters were mailed January 18, 2022. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-21-31-004.
Additional Details:

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.

Action Required: Contact your local TESLA dealer to schedule your FREE recall repair.
Manufacturer: TESLA
Mfg Campaign: SB-21-31-004
Notice Date: Jan 18, 2022
Recall Date: Nov 21, 2021
Tesla, Inc.
NHTSA Campaign: 21V846000 SAFETY RECALL
11.7K Vehicles Affected
Recall Date: Oct 29, 2021
Safety Issue:

Tesla, Inc. (Tesla) is recalling certain 2017-2021 Model S, Model 3, Model X, and 2020-2021 Model Y vehicles operating software version 2021.36.5.2. A communication error may cause false forward-collision warning (FCW) or unexpected activation of the automatic emergency brake (AEB) system.

Potential Risk:
Unexpected activation of the AEB system may cause the car to stop suddenly, increasing the risk of a crash.
FREE Recall Solution:
Tesla Service has released an over-the-air (OTA) software update, free of charge. The recall began October 25, 2021. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-21-00-004.
Additional Details:

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.

Action Required: Contact your local TESLA dealer to schedule your FREE recall repair.
Manufacturer: TESLA
Mfg Campaign: SB-21-00-004
Notice Date: Oct 25, 2021
Recall Date: Oct 29, 2021
Tesla, Inc.
NHTSA Campaign: 21V835000 SAFETY RECALL
2.8K Vehicles Affected
Recall Date: Oct 25, 2021
Safety Issue:

Tesla, Inc. (Tesla) is recalling certain 2020-2021 Model Y and 2019-2021 Model 3 vehicles. The front suspension lateral link fasteners may loosen, allowing the lateral link to separate from the sub-frame.

Potential Risk:
A lateral link separation could shift the wheel alignment, causing instability and increasing the risk of a crash.
FREE Recall Solution:
Tesla Service will tighten or replace the lateral link fasteners as necessary, free of charge. Owner notification letters were mailed December 20, 2021. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-21-31-003.
Additional Details:

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.

Action Required: Contact your local TESLA dealer to schedule your FREE recall repair.
Manufacturer: TESLA
Mfg Campaign: SB-21-31-003
Notice Date: Dec 20, 2021
Recall Date: Oct 25, 2021
Tesla, Inc.
NHTSA Campaign: 21V388000 SAFETY RECALL
2.2K Vehicles Affected
Recall Date: May 25, 2021
Safety Issue:

Tesla, Inc. (Tesla) is recalling certain 2019-2021 Model Y vehicles. One or both fasteners that secure the left and right second row seat belt retractors may not be properly attached.

Potential Risk:
Improperly attached fasteners may prevent the seat belt retention system from performing as designed, increasing the risk of injury.
FREE Recall Solution:
Tesla Service will inspect and replace both fasteners if necessary, free of charge. Owner notification letters were mailed July 23, 2021. Owners may contact Tesla customer service online by visiting www.tesla.com/support/contact or by calling 1-877-79-TESLA (or 1-877-798-3752). Tesla's number for this recall is SB-21-20-002.
Additional Details:

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Action Required: Contact your local TESLA dealer to schedule your FREE recall repair.
Manufacturer: TESLA
Mfg Campaign: SB-21-20-002
Notice Date: Jul 23, 2021
Recall Date: May 25, 2021
Tesla, Inc.
NHTSA Campaign: 21V387000 SAFETY RECALL
6K Vehicles Affected
Recall Date: May 25, 2021
Safety Issue:

Tesla, Inc. (Tesla) is recalling certain 2019-2021 Model 3 and 2020-2021 Model Y vehicles. The brake caliper bolts may be loose, allowing the brake caliper to separate and contact the wheel rim.

Potential Risk:
Contact with the rim may cause a loss of tire pressure, increasing the risk of a crash.
FREE Recall Solution:
Tesla Service will inspect and tighten, or replace the caliper bolts as necessary, free of charge. Owner notification letters were mailed July 23, 2021. Owners may contact Tesla customer service online by visiting www.tesla.com/support/contact or by calling 1-877-79-TESLA (or 1-877-798-3752). Tesla's number for this recall is SB-21-33-002.
Additional Details:

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Action Required: Contact your local TESLA dealer to schedule your FREE recall repair.
Manufacturer: TESLA
Mfg Campaign: SB-21-33-002
Notice Date: Jul 23, 2021
Recall Date: May 25, 2021
Tesla, Inc.
NHTSA Campaign: 21V389000 SAFETY RECALL
5.5K Vehicles Affected
Recall Date: May 25, 2021
Safety Issue:

Tesla, Inc. (Tesla) is recalling certain 2018-2020 Model 3 and 2019-2021 Model Y vehicles. One or both fasteners that secure the front seat shoulder belt to the b-pillar may not be properly attached.

Potential Risk:
An improperly attached fastener may prevent the seat belt system from performing as designed, increasing the risk of injury.
FREE Recall Solution:
Tesla Service will inspect and repair both fasteners if necessary, free of charge. Owner notification letters were mailed July 23, 2021. Owners may contact Tesla customer service online by visiting www.tesla.com/support/contact or by calling 1-877-79-TESLA (or 1-877-798-3752). Tesla's number for this recall is SB-21-20-001.
Additional Details:

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Action Required: Contact your local TESLA dealer to schedule your FREE recall repair.
Manufacturer: TESLA
Mfg Campaign: SB-21-20-001
Notice Date: Jul 23, 2021
Recall Date: May 25, 2021
Tesla, Inc.
NHTSA Campaign: 20V709000 SAFETY RECALL
401 Vehicles Affected
Recall Date: Nov 17, 2020
Safety Issue:

Tesla, Inc. (Tesla) is recalling certain 2020 Model Y vehicles. The bolts connecting the front upper control arm and steering knuckle may have not been properly tightened, allowing the upper control arm to detach from the steering knuckle.

Potential Risk:
A detached upper control arm can cause the wheels to lean in or out, decreasing the driver's ability to steer and increasing the risk of a crash.
FREE Recall Solution:
Tesla will notify owners, and dealers will inspect, and as necessary, tighten the bolts, free of charge. The recall began January 15, 2021. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-20-31-012.
Additional Details:

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Action Required: Contact your local TESLA dealer to schedule your FREE recall repair.
Manufacturer: TESLA
Mfg Campaign: SB-20-31-012
Notice Date: Jan 15, 2021
Recall Date: Nov 17, 2020
Tesla, Inc.
NHTSA Campaign: 20V609000 SAFETY RECALL
2.6K Vehicles Affected
Recall Date: Sep 30, 2020
Safety Issue:

Tesla, Inc. (Tesla) is recalling certain 2020 Model Y vehicles equipped with a global rear lamp and tow package configuration. A software error prevents the illumination of trailer brake lights. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."

Potential Risk:
Trailer brake lights that fail to illuminate during braking increase the risk of a crash.
FREE Recall Solution:
Tesla will notify owners, and has released the firmware update over-the-air (OTA) to vehicles as of September 23, 2020. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-20-00-002.
Additional Details:

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Action Required: Contact your local TESLA dealer to schedule your FREE recall repair.
Manufacturer: TESLA
Mfg Campaign: SB-20-00-002
Notice Date: Sep 23, 2020
Recall Date: Sep 30, 2020

Consumer Complaints

447 Complaints
Tesla, Inc.
Campaign: 11672036 Other
Jul 8, 2025
Defect Description:

VISIBILITY/WIPER

Potential Consequences:

Was driving in rain, had windshield wipers on, suddenly windshield wipers stopped working; could not see through windshield because of the rain; almost had collision before being able to move to the side of the road to safety. Cost $255 to have windshield wipers repaired.

Corrective Action:

Was driving in rain, had windshield wipers on, suddenly windshield wipers stopped working; could not see through windshield because of the rain; almost had collision before being able to move to the side of the road to safety. Cost $255 to have windshield wipers repaired.

Additional Notes:

Was driving in rain, had windshield wipers on, suddenly windshield wipers stopped working; could not see through windshield because of the rain; almost had collision before being able to move to the side of the road to safety. Cost $255 to have windshield wipers repaired.

Manufacturer: TESLA
Mfg Campaign: 11672036
Notice Date: Jul 8, 2025
Recall Date: Jul 8, 2025
Tesla, Inc.
Campaign: 11670914 Other
Jul 2, 2025
Defect Description:

ELECTRICAL SYSTEM

Potential Consequences:

My 2020 Tesla Model Y Long Range/AWD vehicle has 46,000 miles and can no longer recharge its battery (engine) with an approved charger (L2) due to a commonly failed part inside the battery. This part is called PCS (Power Conversion System). This device attached to the Tesla battery is used to convert power from a charger which is AC (household alternating current) into DC (Direct Current) the battery can understand. This error appeared for the first time on [XXX] at [XXX]. This critical part has failed in thousands of Tesla vehicles, some multiple times easily verified by thousands of customer complaints online. The PCS is NOT a consumable part - such as a tire, wiper blades, brake pads, etc. There is nothing the vehicle Owner can do to prevent the PCS failure. The Cost to repair/replace the PCS part(s) is ~ $3,000 and may fail again after replacement. As required by Tesla, I scheduled a service appointment through their phone app, and received an estimate of ~$280.00 to repair my vehicle on June 26, 2025 at the Irvine, CA Tesla Service Center 2801 Barranca Pkwy. After diagnosis, I was informed the cost to fix/repair the PCS part in my vehicle so that I could charge and drive it, would be ~$3,000. The Manager Ryan Sutherland (949) 404-2989, further stated the repair would not be covered under my Vehicle Tesla Warranty (Tesla battery or drive unit warranty that does not expire until [XXX]). I tried to contact Tesla corporate for assistance at resolutions@tesla.com and did not receive a response but instead was contacted by service manager Ryan Sutherland via email confirming Tesla's warranty position. Tesla is essentially the only service/repair resource available for these vehicles. This repair is obviously due to a faulty/defective PCS or faulty design by Tesla affecting thousands of vehicles and should covered under my vehicle warranty so that it can be driven. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Corrective Action:

My 2020 Tesla Model Y Long Range/AWD vehicle has 46,000 miles and can no longer recharge its battery (engine) with an approved charger (L2) due to a commonly failed part inside the battery. This part is called PCS (Power Conversion System). This device attached to the Tesla battery is used to convert power from a charger which is AC (household alternating current) into DC (Direct Current) the battery can understand. This error appeared for the first time on [XXX] at [XXX]. This critical part has failed in thousands of Tesla vehicles, some multiple times easily verified by thousands of customer complaints online. The PCS is NOT a consumable part - such as a tire, wiper blades, brake pads, etc. There is nothing the vehicle Owner can do to prevent the PCS failure. The Cost to repair/replace the PCS part(s) is ~ $3,000 and may fail again after replacement. As required by Tesla, I scheduled a service appointment through their phone app, and received an estimate of ~$280.00 to repair my vehicle on June 26, 2025 at the Irvine, CA Tesla Service Center 2801 Barranca Pkwy. After diagnosis, I was informed the cost to fix/repair the PCS part in my vehicle so that I could charge and drive it, would be ~$3,000. The Manager Ryan Sutherland (949) 404-2989, further stated the repair would not be covered under my Vehicle Tesla Warranty (Tesla battery or drive unit warranty that does not expire until [XXX]). I tried to contact Tesla corporate for assistance at resolutions@tesla.com and did not receive a response but instead was contacted by service manager Ryan Sutherland via email confirming Tesla's warranty position. Tesla is essentially the only service/repair resource available for these vehicles. This repair is obviously due to a faulty/defective PCS or faulty design by Tesla affecting thousands of vehicles and should covered under my vehicle warranty so that it can be driven. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Additional Notes:

My 2020 Tesla Model Y Long Range/AWD vehicle has 46,000 miles and can no longer recharge its battery (engine) with an approved charger (L2) due to a commonly failed part inside the battery. This part is called PCS (Power Conversion System). This device attached to the Tesla battery is used to convert power from a charger which is AC (household alternating current) into DC (Direct Current) the battery can understand. This error appeared for the first time on [XXX] at [XXX]. This critical part has failed in thousands of Tesla vehicles, some multiple times easily verified by thousands of customer complaints online. The PCS is NOT a consumable part - such as a tire, wiper blades, brake pads, etc. There is nothing the vehicle Owner can do to prevent the PCS failure. The Cost to repair/replace the PCS part(s) is ~ $3,000 and may fail again after replacement. As required by Tesla, I scheduled a service appointment through their phone app, and received an estimate of ~$280.00 to repair my vehicle on June 26, 2025 at the Irvine, CA Tesla Service Center 2801 Barranca Pkwy. After diagnosis, I was informed the cost to fix/repair the PCS part in my vehicle so that I could charge and drive it, would be ~$3,000. The Manager Ryan Sutherland (949) 404-2989, further stated the repair would not be covered under my Vehicle Tesla Warranty (Tesla battery or drive unit warranty that does not expire until [XXX]). I tried to contact Tesla corporate for assistance at resolutions@tesla.com and did not receive a response but instead was contacted by service manager Ryan Sutherland via email confirming Tesla's warranty position. Tesla is essentially the only service/repair resource available for these vehicles. This repair is obviously due to a faulty/defective PCS or faulty design by Tesla affecting thousands of vehicles and should covered under my vehicle warranty so that it can be driven. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Manufacturer: TESLA
Mfg Campaign: 11670914
Notice Date: Jul 2, 2025
Recall Date: Jul 2, 2025
Tesla, Inc.
Campaign: 11670914 Other
Jul 2, 2025
Defect Description:

ENGINE

Potential Consequences:

My 2020 Tesla Model Y Long Range/AWD vehicle has 46,000 miles and can no longer recharge its battery (engine) with an approved charger (L2) due to a commonly failed part inside the battery. This part is called PCS (Power Conversion System). This device attached to the Tesla battery is used to convert power from a charger which is AC (household alternating current) into DC (Direct Current) the battery can understand. This error appeared for the first time on [XXX] at [XXX]. This critical part has failed in thousands of Tesla vehicles, some multiple times easily verified by thousands of customer complaints online. The PCS is NOT a consumable part - such as a tire, wiper blades, brake pads, etc. There is nothing the vehicle Owner can do to prevent the PCS failure. The Cost to repair/replace the PCS part(s) is ~ $3,000 and may fail again after replacement. As required by Tesla, I scheduled a service appointment through their phone app, and received an estimate of ~$280.00 to repair my vehicle on June 26, 2025 at the Irvine, CA Tesla Service Center 2801 Barranca Pkwy. After diagnosis, I was informed the cost to fix/repair the PCS part in my vehicle so that I could charge and drive it, would be ~$3,000. The Manager Ryan Sutherland (949) 404-2989, further stated the repair would not be covered under my Vehicle Tesla Warranty (Tesla battery or drive unit warranty that does not expire until [XXX]). I tried to contact Tesla corporate for assistance at resolutions@tesla.com and did not receive a response but instead was contacted by service manager Ryan Sutherland via email confirming Tesla's warranty position. Tesla is essentially the only service/repair resource available for these vehicles. This repair is obviously due to a faulty/defective PCS or faulty design by Tesla affecting thousands of vehicles and should covered under my vehicle warranty so that it can be driven. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Corrective Action:

My 2020 Tesla Model Y Long Range/AWD vehicle has 46,000 miles and can no longer recharge its battery (engine) with an approved charger (L2) due to a commonly failed part inside the battery. This part is called PCS (Power Conversion System). This device attached to the Tesla battery is used to convert power from a charger which is AC (household alternating current) into DC (Direct Current) the battery can understand. This error appeared for the first time on [XXX] at [XXX]. This critical part has failed in thousands of Tesla vehicles, some multiple times easily verified by thousands of customer complaints online. The PCS is NOT a consumable part - such as a tire, wiper blades, brake pads, etc. There is nothing the vehicle Owner can do to prevent the PCS failure. The Cost to repair/replace the PCS part(s) is ~ $3,000 and may fail again after replacement. As required by Tesla, I scheduled a service appointment through their phone app, and received an estimate of ~$280.00 to repair my vehicle on June 26, 2025 at the Irvine, CA Tesla Service Center 2801 Barranca Pkwy. After diagnosis, I was informed the cost to fix/repair the PCS part in my vehicle so that I could charge and drive it, would be ~$3,000. The Manager Ryan Sutherland (949) 404-2989, further stated the repair would not be covered under my Vehicle Tesla Warranty (Tesla battery or drive unit warranty that does not expire until [XXX]). I tried to contact Tesla corporate for assistance at resolutions@tesla.com and did not receive a response but instead was contacted by service manager Ryan Sutherland via email confirming Tesla's warranty position. Tesla is essentially the only service/repair resource available for these vehicles. This repair is obviously due to a faulty/defective PCS or faulty design by Tesla affecting thousands of vehicles and should covered under my vehicle warranty so that it can be driven. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Additional Notes:

My 2020 Tesla Model Y Long Range/AWD vehicle has 46,000 miles and can no longer recharge its battery (engine) with an approved charger (L2) due to a commonly failed part inside the battery. This part is called PCS (Power Conversion System). This device attached to the Tesla battery is used to convert power from a charger which is AC (household alternating current) into DC (Direct Current) the battery can understand. This error appeared for the first time on [XXX] at [XXX]. This critical part has failed in thousands of Tesla vehicles, some multiple times easily verified by thousands of customer complaints online. The PCS is NOT a consumable part - such as a tire, wiper blades, brake pads, etc. There is nothing the vehicle Owner can do to prevent the PCS failure. The Cost to repair/replace the PCS part(s) is ~ $3,000 and may fail again after replacement. As required by Tesla, I scheduled a service appointment through their phone app, and received an estimate of ~$280.00 to repair my vehicle on June 26, 2025 at the Irvine, CA Tesla Service Center 2801 Barranca Pkwy. After diagnosis, I was informed the cost to fix/repair the PCS part in my vehicle so that I could charge and drive it, would be ~$3,000. The Manager Ryan Sutherland (949) 404-2989, further stated the repair would not be covered under my Vehicle Tesla Warranty (Tesla battery or drive unit warranty that does not expire until [XXX]). I tried to contact Tesla corporate for assistance at resolutions@tesla.com and did not receive a response but instead was contacted by service manager Ryan Sutherland via email confirming Tesla's warranty position. Tesla is essentially the only service/repair resource available for these vehicles. This repair is obviously due to a faulty/defective PCS or faulty design by Tesla affecting thousands of vehicles and should covered under my vehicle warranty so that it can be driven. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Manufacturer: TESLA
Mfg Campaign: 11670914
Notice Date: Jul 2, 2025
Recall Date: Jul 2, 2025
Tesla, Inc.
Campaign: 11668372 Other
Jun 21, 2025
Defect Description:

SEAT BELTS

Potential Consequences:

Subject: Complaint Regarding Faulty Seat Belt on Tesla Vehicle (VIN: [XXX] ) Dear NHTSA Vehicle Safety Hotline, I am writing to formally report a safety concern regarding my Tesla vehicle, VIN [XXX] . I have experienced issues with the seat belt system, which I believe are related to a known defect. Despite this, my vehicle was not included in the recent recall for faulty seat belts. The problem I am facing is consistent with the conditions described in the recall notice, and I am concerned about the safety implications of continuing to use this defective component. I believe that my vehicle shares the same defect as the recalled units, and I request that NHTSA review this matter to determine whether my VIN should be included in the recall or whether further investigation is warranted. Please advise on the next steps I should take, and whether Tesla should be required to address this issue for my vehicle. Safety is a top priority, and I appreciate your attention to this matter. Thank you for your assistance. Sincerely, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Corrective Action:

Subject: Complaint Regarding Faulty Seat Belt on Tesla Vehicle (VIN: [XXX] ) Dear NHTSA Vehicle Safety Hotline, I am writing to formally report a safety concern regarding my Tesla vehicle, VIN [XXX] . I have experienced issues with the seat belt system, which I believe are related to a known defect. Despite this, my vehicle was not included in the recent recall for faulty seat belts. The problem I am facing is consistent with the conditions described in the recall notice, and I am concerned about the safety implications of continuing to use this defective component. I believe that my vehicle shares the same defect as the recalled units, and I request that NHTSA review this matter to determine whether my VIN should be included in the recall or whether further investigation is warranted. Please advise on the next steps I should take, and whether Tesla should be required to address this issue for my vehicle. Safety is a top priority, and I appreciate your attention to this matter. Thank you for your assistance. Sincerely, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Additional Notes:

Subject: Complaint Regarding Faulty Seat Belt on Tesla Vehicle (VIN: [XXX] ) Dear NHTSA Vehicle Safety Hotline, I am writing to formally report a safety concern regarding my Tesla vehicle, VIN [XXX] . I have experienced issues with the seat belt system, which I believe are related to a known defect. Despite this, my vehicle was not included in the recent recall for faulty seat belts. The problem I am facing is consistent with the conditions described in the recall notice, and I am concerned about the safety implications of continuing to use this defective component. I believe that my vehicle shares the same defect as the recalled units, and I request that NHTSA review this matter to determine whether my VIN should be included in the recall or whether further investigation is warranted. Please advise on the next steps I should take, and whether Tesla should be required to address this issue for my vehicle. Safety is a top priority, and I appreciate your attention to this matter. Thank you for your assistance. Sincerely, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Manufacturer: TESLA
Mfg Campaign: 11668372
Notice Date: Jun 21, 2025
Recall Date: Jun 21, 2025
Tesla, Inc.
Campaign: 11660602 Other
May 13, 2025
Defect Description:

STEERING

Potential Consequences:

Steering became difficult to turn to the right with the wheel sticking to the right when trying to turn or drive the vehicle. Tesla claims we had some kind of a large impact. Maybe a pothole. Tesla claims well this is a heavy vehicle. Out of no where we had to replace the entire steering rack. I've never had to replace an entire steering rack for a pothole. Seems ridiculous.

Corrective Action:

Steering became difficult to turn to the right with the wheel sticking to the right when trying to turn or drive the vehicle. Tesla claims we had some kind of a large impact. Maybe a pothole. Tesla claims well this is a heavy vehicle. Out of no where we had to replace the entire steering rack. I've never had to replace an entire steering rack for a pothole. Seems ridiculous.

Additional Notes:

Steering became difficult to turn to the right with the wheel sticking to the right when trying to turn or drive the vehicle. Tesla claims we had some kind of a large impact. Maybe a pothole. Tesla claims well this is a heavy vehicle. Out of no where we had to replace the entire steering rack. I've never had to replace an entire steering rack for a pothole. Seems ridiculous.

Manufacturer: TESLA
Mfg Campaign: 11660602
Notice Date: May 13, 2025
Recall Date: May 13, 2025
Tesla, Inc.
Campaign: 11660602 Other
May 13, 2025
Defect Description:

SUSPENSION

Potential Consequences:

Steering became difficult to turn to the right with the wheel sticking to the right when trying to turn or drive the vehicle. Tesla claims we had some kind of a large impact. Maybe a pothole. Tesla claims well this is a heavy vehicle. Out of no where we had to replace the entire steering rack. I've never had to replace an entire steering rack for a pothole. Seems ridiculous.

Corrective Action:

Steering became difficult to turn to the right with the wheel sticking to the right when trying to turn or drive the vehicle. Tesla claims we had some kind of a large impact. Maybe a pothole. Tesla claims well this is a heavy vehicle. Out of no where we had to replace the entire steering rack. I've never had to replace an entire steering rack for a pothole. Seems ridiculous.

Additional Notes:

Steering became difficult to turn to the right with the wheel sticking to the right when trying to turn or drive the vehicle. Tesla claims we had some kind of a large impact. Maybe a pothole. Tesla claims well this is a heavy vehicle. Out of no where we had to replace the entire steering rack. I've never had to replace an entire steering rack for a pothole. Seems ridiculous.

Manufacturer: TESLA
Mfg Campaign: 11660602
Notice Date: May 13, 2025
Recall Date: May 13, 2025
Tesla, Inc.
Campaign: 11659665 Other
May 8, 2025
Defect Description:

WHEELS

Potential Consequences:

I am submitting this service request and formal incident report concerning a serious malfunction of the Full Self-Driving (FSD) system on my 2020 Tesla Model Y. While operating the vehicle on [insert road name or location] with FSD fully engaged, the system initiated a left-hand turn but failed to complete it properly. As a result, the vehicle mounted the sidewalk, causing a blowout of the rear tire and visible damage to the passenger-side rims. Following this incident, I had the tires and wheels replaced. However, the vehicle now exhibits the following ongoing issues: - Rubbing noise from the front passenger wheel well when turning - Multiple system alerts, including: - Autonomous Emergency Braking Disabled - Steering Alignment Issue - Stability Control and Traction Control Warnings

Corrective Action:

I am submitting this service request and formal incident report concerning a serious malfunction of the Full Self-Driving (FSD) system on my 2020 Tesla Model Y. While operating the vehicle on [insert road name or location] with FSD fully engaged, the system initiated a left-hand turn but failed to complete it properly. As a result, the vehicle mounted the sidewalk, causing a blowout of the rear tire and visible damage to the passenger-side rims. Following this incident, I had the tires and wheels replaced. However, the vehicle now exhibits the following ongoing issues: - Rubbing noise from the front passenger wheel well when turning - Multiple system alerts, including: - Autonomous Emergency Braking Disabled - Steering Alignment Issue - Stability Control and Traction Control Warnings

Additional Notes:

I am submitting this service request and formal incident report concerning a serious malfunction of the Full Self-Driving (FSD) system on my 2020 Tesla Model Y. While operating the vehicle on [insert road name or location] with FSD fully engaged, the system initiated a left-hand turn but failed to complete it properly. As a result, the vehicle mounted the sidewalk, causing a blowout of the rear tire and visible damage to the passenger-side rims. Following this incident, I had the tires and wheels replaced. However, the vehicle now exhibits the following ongoing issues: - Rubbing noise from the front passenger wheel well when turning - Multiple system alerts, including: - Autonomous Emergency Braking Disabled - Steering Alignment Issue - Stability Control and Traction Control Warnings

Manufacturer: TESLA
Mfg Campaign: 11659665
Notice Date: May 8, 2025
Recall Date: May 8, 2025
Tesla, Inc.
Campaign: 11659665 Other
May 8, 2025
Defect Description:

ELECTRICAL SYSTEM:ADAS

Potential Consequences:

I am submitting this service request and formal incident report concerning a serious malfunction of the Full Self-Driving (FSD) system on my 2020 Tesla Model Y. While operating the vehicle on [insert road name or location] with FSD fully engaged, the system initiated a left-hand turn but failed to complete it properly. As a result, the vehicle mounted the sidewalk, causing a blowout of the rear tire and visible damage to the passenger-side rims. Following this incident, I had the tires and wheels replaced. However, the vehicle now exhibits the following ongoing issues: - Rubbing noise from the front passenger wheel well when turning - Multiple system alerts, including: - Autonomous Emergency Braking Disabled - Steering Alignment Issue - Stability Control and Traction Control Warnings

Corrective Action:

I am submitting this service request and formal incident report concerning a serious malfunction of the Full Self-Driving (FSD) system on my 2020 Tesla Model Y. While operating the vehicle on [insert road name or location] with FSD fully engaged, the system initiated a left-hand turn but failed to complete it properly. As a result, the vehicle mounted the sidewalk, causing a blowout of the rear tire and visible damage to the passenger-side rims. Following this incident, I had the tires and wheels replaced. However, the vehicle now exhibits the following ongoing issues: - Rubbing noise from the front passenger wheel well when turning - Multiple system alerts, including: - Autonomous Emergency Braking Disabled - Steering Alignment Issue - Stability Control and Traction Control Warnings

Additional Notes:

I am submitting this service request and formal incident report concerning a serious malfunction of the Full Self-Driving (FSD) system on my 2020 Tesla Model Y. While operating the vehicle on [insert road name or location] with FSD fully engaged, the system initiated a left-hand turn but failed to complete it properly. As a result, the vehicle mounted the sidewalk, causing a blowout of the rear tire and visible damage to the passenger-side rims. Following this incident, I had the tires and wheels replaced. However, the vehicle now exhibits the following ongoing issues: - Rubbing noise from the front passenger wheel well when turning - Multiple system alerts, including: - Autonomous Emergency Braking Disabled - Steering Alignment Issue - Stability Control and Traction Control Warnings

Manufacturer: TESLA
Mfg Campaign: 11659665
Notice Date: May 8, 2025
Recall Date: May 8, 2025
Tesla, Inc.
Campaign: 11659331 Other
May 6, 2025
Defect Description:

VISIBILITY/WIPER

Potential Consequences:

I have a Tesla Model Y and a Model 3. Both of them 2020 year purchased. The miles on Model Y is 96K and 43K respectively. In Feb 2025, my Model Y windshield had cracked and I had made a Tesla Insurance claim and paid the 500$ deductible and got it replaced. Now, in May 1st week, the same Model Y's windshield is cracked. When I take to Tesla service center, they say that its because of an external impact and so, they can't consider a warranty claim and I have to make another payment for this. That's the first thing. Now, with my Model 3, there is a crack developing on the rear windshield. I understand from Tesla that it has to be replaced too. I had a chat with Safelite auto glass company technician and he said that Tesla's glasses are too thin to accmmodate sensors and thats why this is happening repeatedly.

Corrective Action:

I have a Tesla Model Y and a Model 3. Both of them 2020 year purchased. The miles on Model Y is 96K and 43K respectively. In Feb 2025, my Model Y windshield had cracked and I had made a Tesla Insurance claim and paid the 500$ deductible and got it replaced. Now, in May 1st week, the same Model Y's windshield is cracked. When I take to Tesla service center, they say that its because of an external impact and so, they can't consider a warranty claim and I have to make another payment for this. That's the first thing. Now, with my Model 3, there is a crack developing on the rear windshield. I understand from Tesla that it has to be replaced too. I had a chat with Safelite auto glass company technician and he said that Tesla's glasses are too thin to accmmodate sensors and thats why this is happening repeatedly.

Additional Notes:

I have a Tesla Model Y and a Model 3. Both of them 2020 year purchased. The miles on Model Y is 96K and 43K respectively. In Feb 2025, my Model Y windshield had cracked and I had made a Tesla Insurance claim and paid the 500$ deductible and got it replaced. Now, in May 1st week, the same Model Y's windshield is cracked. When I take to Tesla service center, they say that its because of an external impact and so, they can't consider a warranty claim and I have to make another payment for this. That's the first thing. Now, with my Model 3, there is a crack developing on the rear windshield. I understand from Tesla that it has to be replaced too. I had a chat with Safelite auto glass company technician and he said that Tesla's glasses are too thin to accmmodate sensors and thats why this is happening repeatedly.

Manufacturer: TESLA
Mfg Campaign: 11659331
Notice Date: May 6, 2025
Recall Date: May 6, 2025
Tesla, Inc.
Campaign: 11659331 Other
May 6, 2025
Defect Description:

UNKNOWN OR OTHER

Potential Consequences:

I have a Tesla Model Y and a Model 3. Both of them 2020 year purchased. The miles on Model Y is 96K and 43K respectively. In Feb 2025, my Model Y windshield had cracked and I had made a Tesla Insurance claim and paid the 500$ deductible and got it replaced. Now, in May 1st week, the same Model Y's windshield is cracked. When I take to Tesla service center, they say that its because of an external impact and so, they can't consider a warranty claim and I have to make another payment for this. That's the first thing. Now, with my Model 3, there is a crack developing on the rear windshield. I understand from Tesla that it has to be replaced too. I had a chat with Safelite auto glass company technician and he said that Tesla's glasses are too thin to accmmodate sensors and thats why this is happening repeatedly.

Corrective Action:

I have a Tesla Model Y and a Model 3. Both of them 2020 year purchased. The miles on Model Y is 96K and 43K respectively. In Feb 2025, my Model Y windshield had cracked and I had made a Tesla Insurance claim and paid the 500$ deductible and got it replaced. Now, in May 1st week, the same Model Y's windshield is cracked. When I take to Tesla service center, they say that its because of an external impact and so, they can't consider a warranty claim and I have to make another payment for this. That's the first thing. Now, with my Model 3, there is a crack developing on the rear windshield. I understand from Tesla that it has to be replaced too. I had a chat with Safelite auto glass company technician and he said that Tesla's glasses are too thin to accmmodate sensors and thats why this is happening repeatedly.

Additional Notes:

I have a Tesla Model Y and a Model 3. Both of them 2020 year purchased. The miles on Model Y is 96K and 43K respectively. In Feb 2025, my Model Y windshield had cracked and I had made a Tesla Insurance claim and paid the 500$ deductible and got it replaced. Now, in May 1st week, the same Model Y's windshield is cracked. When I take to Tesla service center, they say that its because of an external impact and so, they can't consider a warranty claim and I have to make another payment for this. That's the first thing. Now, with my Model 3, there is a crack developing on the rear windshield. I understand from Tesla that it has to be replaced too. I had a chat with Safelite auto glass company technician and he said that Tesla's glasses are too thin to accmmodate sensors and thats why this is happening repeatedly.

Manufacturer: TESLA
Mfg Campaign: 11659331
Notice Date: May 6, 2025
Recall Date: May 6, 2025
Tesla, Inc.
Campaign: 11657285 Other
Apr 28, 2025
Defect Description:

VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM

Potential Consequences:

Component or System Failure: The HVAC system, specifically the compressor and supermanifold, failed on my 2020 Tesla Model Y. Tesla retained the replaced components during service, so they are not available for inspection. Safety Risk: This failure caused a loss of cabin heating and prevented proper windshield/window defrosting during cold weather, severely impairing visibility and creating unsafe driving conditions. Critically, this system also regulates battery heating. Without it, battery performance in cold temperatures can be compromised, reducing driving range, impairing charging capability, and risking vehicle operability in freezing conditions. Problem Confirmation: Tesla service technicians diagnosed and confirmed failure of the compressor and supermanifold. Full replacement was required to restore proper HVAC and battery heating functions. Inspections Conducted: The vehicle was inspected by Tesla service both before and after the failure. Prior to my ownership, the vehicle had been brought in by a family member (prior owner) for HVAC performance concerns. HVAC issues reappeared around 28,000 miles, but I was unable to immediately schedule repairs due to the Tesla Service Center being approximately 1 hour and 15 minutes away and personal scheduling constraints. The vehicle was finally repaired on April 24, 2025, at 38,511 miles. Warning Indicators: Before the failure, HVAC symptoms included inconsistent heating, occasional HVAC warnings, and degraded cold weather performance. Additional Context: I was required to pay $2,992.89 for the repair out of pocket, as the vehicle was just outside of warranty. Due to this failure, I drove for an extended time without reliable cabin heat, defrosting, or proper battery heating in winter conditions, exposing me to serious safety risks. Tesla has acknowledged HVAC component contamination issues in official service bulletins, suggesting a known systemic problem.

Corrective Action:

Component or System Failure: The HVAC system, specifically the compressor and supermanifold, failed on my 2020 Tesla Model Y. Tesla retained the replaced components during service, so they are not available for inspection. Safety Risk: This failure caused a loss of cabin heating and prevented proper windshield/window defrosting during cold weather, severely impairing visibility and creating unsafe driving conditions. Critically, this system also regulates battery heating. Without it, battery performance in cold temperatures can be compromised, reducing driving range, impairing charging capability, and risking vehicle operability in freezing conditions. Problem Confirmation: Tesla service technicians diagnosed and confirmed failure of the compressor and supermanifold. Full replacement was required to restore proper HVAC and battery heating functions. Inspections Conducted: The vehicle was inspected by Tesla service both before and after the failure. Prior to my ownership, the vehicle had been brought in by a family member (prior owner) for HVAC performance concerns. HVAC issues reappeared around 28,000 miles, but I was unable to immediately schedule repairs due to the Tesla Service Center being approximately 1 hour and 15 minutes away and personal scheduling constraints. The vehicle was finally repaired on April 24, 2025, at 38,511 miles. Warning Indicators: Before the failure, HVAC symptoms included inconsistent heating, occasional HVAC warnings, and degraded cold weather performance. Additional Context: I was required to pay $2,992.89 for the repair out of pocket, as the vehicle was just outside of warranty. Due to this failure, I drove for an extended time without reliable cabin heat, defrosting, or proper battery heating in winter conditions, exposing me to serious safety risks. Tesla has acknowledged HVAC component contamination issues in official service bulletins, suggesting a known systemic problem.

Additional Notes:

Component or System Failure: The HVAC system, specifically the compressor and supermanifold, failed on my 2020 Tesla Model Y. Tesla retained the replaced components during service, so they are not available for inspection. Safety Risk: This failure caused a loss of cabin heating and prevented proper windshield/window defrosting during cold weather, severely impairing visibility and creating unsafe driving conditions. Critically, this system also regulates battery heating. Without it, battery performance in cold temperatures can be compromised, reducing driving range, impairing charging capability, and risking vehicle operability in freezing conditions. Problem Confirmation: Tesla service technicians diagnosed and confirmed failure of the compressor and supermanifold. Full replacement was required to restore proper HVAC and battery heating functions. Inspections Conducted: The vehicle was inspected by Tesla service both before and after the failure. Prior to my ownership, the vehicle had been brought in by a family member (prior owner) for HVAC performance concerns. HVAC issues reappeared around 28,000 miles, but I was unable to immediately schedule repairs due to the Tesla Service Center being approximately 1 hour and 15 minutes away and personal scheduling constraints. The vehicle was finally repaired on April 24, 2025, at 38,511 miles. Warning Indicators: Before the failure, HVAC symptoms included inconsistent heating, occasional HVAC warnings, and degraded cold weather performance. Additional Context: I was required to pay $2,992.89 for the repair out of pocket, as the vehicle was just outside of warranty. Due to this failure, I drove for an extended time without reliable cabin heat, defrosting, or proper battery heating in winter conditions, exposing me to serious safety risks. Tesla has acknowledged HVAC component contamination issues in official service bulletins, suggesting a known systemic problem.

Manufacturer: TESLA
Mfg Campaign: 11657285
Notice Date: Apr 28, 2025
Recall Date: Apr 28, 2025
Tesla, Inc.
Campaign: 11656833 Other
Apr 25, 2025
Defect Description:

FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING

Potential Consequences:

On Tuesday, [XXX], around [XXX] returning home and in my driveway when the following happened. Pulling into the left side of the driveway because a utility van was parked on the right side of the driveway with the rear door and driver’s side door opened with no one in the vicinity. There was not enough room to go forward into the garage. I was almost at a complete stop with the intention of getting out of the car to shut the drivers side door. That was when the car sped up at full speed and turned to the right into the van and continued in the right direction into the garage. The car was headed to the right back corner of the garage smashing into paint cans, a freezer, sink and cabinets. I had no control over the car from the time the car sped up and smashed into the back of the garage and it all happened in a matter of a few seconds. The vehicle has been totaled by the insurance company. This incident was recorded in the vehicle’s computer. The police department was called the same day and a police officer came to the house to record the incident. The car was towed to Gerber Collision & Glass, 10491 Corkscrew Commons Dr., Estero, FL 33928, phone (239) 947-6050. The car computer system should have recorded the event. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Corrective Action:

On Tuesday, [XXX], around [XXX] returning home and in my driveway when the following happened. Pulling into the left side of the driveway because a utility van was parked on the right side of the driveway with the rear door and driver’s side door opened with no one in the vicinity. There was not enough room to go forward into the garage. I was almost at a complete stop with the intention of getting out of the car to shut the drivers side door. That was when the car sped up at full speed and turned to the right into the van and continued in the right direction into the garage. The car was headed to the right back corner of the garage smashing into paint cans, a freezer, sink and cabinets. I had no control over the car from the time the car sped up and smashed into the back of the garage and it all happened in a matter of a few seconds. The vehicle has been totaled by the insurance company. This incident was recorded in the vehicle’s computer. The police department was called the same day and a police officer came to the house to record the incident. The car was towed to Gerber Collision & Glass, 10491 Corkscrew Commons Dr., Estero, FL 33928, phone (239) 947-6050. The car computer system should have recorded the event. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Additional Notes:

On Tuesday, [XXX], around [XXX] returning home and in my driveway when the following happened. Pulling into the left side of the driveway because a utility van was parked on the right side of the driveway with the rear door and driver’s side door opened with no one in the vicinity. There was not enough room to go forward into the garage. I was almost at a complete stop with the intention of getting out of the car to shut the drivers side door. That was when the car sped up at full speed and turned to the right into the van and continued in the right direction into the garage. The car was headed to the right back corner of the garage smashing into paint cans, a freezer, sink and cabinets. I had no control over the car from the time the car sped up and smashed into the back of the garage and it all happened in a matter of a few seconds. The vehicle has been totaled by the insurance company. This incident was recorded in the vehicle’s computer. The police department was called the same day and a police officer came to the house to record the incident. The car was towed to Gerber Collision & Glass, 10491 Corkscrew Commons Dr., Estero, FL 33928, phone (239) 947-6050. The car computer system should have recorded the event. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Manufacturer: TESLA
Mfg Campaign: 11656833
Notice Date: Apr 25, 2025
Recall Date: Apr 25, 2025
Tesla, Inc.
Campaign: 11656833 Other
Apr 25, 2025
Defect Description:

VEHICLE SPEED CONTROL

Potential Consequences:

On Tuesday, [XXX], around [XXX] returning home and in my driveway when the following happened. Pulling into the left side of the driveway because a utility van was parked on the right side of the driveway with the rear door and driver’s side door opened with no one in the vicinity. There was not enough room to go forward into the garage. I was almost at a complete stop with the intention of getting out of the car to shut the drivers side door. That was when the car sped up at full speed and turned to the right into the van and continued in the right direction into the garage. The car was headed to the right back corner of the garage smashing into paint cans, a freezer, sink and cabinets. I had no control over the car from the time the car sped up and smashed into the back of the garage and it all happened in a matter of a few seconds. The vehicle has been totaled by the insurance company. This incident was recorded in the vehicle’s computer. The police department was called the same day and a police officer came to the house to record the incident. The car was towed to Gerber Collision & Glass, 10491 Corkscrew Commons Dr., Estero, FL 33928, phone (239) 947-6050. The car computer system should have recorded the event. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Corrective Action:

On Tuesday, [XXX], around [XXX] returning home and in my driveway when the following happened. Pulling into the left side of the driveway because a utility van was parked on the right side of the driveway with the rear door and driver’s side door opened with no one in the vicinity. There was not enough room to go forward into the garage. I was almost at a complete stop with the intention of getting out of the car to shut the drivers side door. That was when the car sped up at full speed and turned to the right into the van and continued in the right direction into the garage. The car was headed to the right back corner of the garage smashing into paint cans, a freezer, sink and cabinets. I had no control over the car from the time the car sped up and smashed into the back of the garage and it all happened in a matter of a few seconds. The vehicle has been totaled by the insurance company. This incident was recorded in the vehicle’s computer. The police department was called the same day and a police officer came to the house to record the incident. The car was towed to Gerber Collision & Glass, 10491 Corkscrew Commons Dr., Estero, FL 33928, phone (239) 947-6050. The car computer system should have recorded the event. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Additional Notes:

On Tuesday, [XXX], around [XXX] returning home and in my driveway when the following happened. Pulling into the left side of the driveway because a utility van was parked on the right side of the driveway with the rear door and driver’s side door opened with no one in the vicinity. There was not enough room to go forward into the garage. I was almost at a complete stop with the intention of getting out of the car to shut the drivers side door. That was when the car sped up at full speed and turned to the right into the van and continued in the right direction into the garage. The car was headed to the right back corner of the garage smashing into paint cans, a freezer, sink and cabinets. I had no control over the car from the time the car sped up and smashed into the back of the garage and it all happened in a matter of a few seconds. The vehicle has been totaled by the insurance company. This incident was recorded in the vehicle’s computer. The police department was called the same day and a police officer came to the house to record the incident. The car was towed to Gerber Collision & Glass, 10491 Corkscrew Commons Dr., Estero, FL 33928, phone (239) 947-6050. The car computer system should have recorded the event. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Manufacturer: TESLA
Mfg Campaign: 11656833
Notice Date: Apr 25, 2025
Recall Date: Apr 25, 2025
Tesla, Inc.
Campaign: 11656833 Other
Apr 25, 2025
Defect Description:

FORWARD COLLISION AVOIDANCE: WARNINGS

Potential Consequences:

On Tuesday, [XXX], around [XXX] returning home and in my driveway when the following happened. Pulling into the left side of the driveway because a utility van was parked on the right side of the driveway with the rear door and driver’s side door opened with no one in the vicinity. There was not enough room to go forward into the garage. I was almost at a complete stop with the intention of getting out of the car to shut the drivers side door. That was when the car sped up at full speed and turned to the right into the van and continued in the right direction into the garage. The car was headed to the right back corner of the garage smashing into paint cans, a freezer, sink and cabinets. I had no control over the car from the time the car sped up and smashed into the back of the garage and it all happened in a matter of a few seconds. The vehicle has been totaled by the insurance company. This incident was recorded in the vehicle’s computer. The police department was called the same day and a police officer came to the house to record the incident. The car was towed to Gerber Collision & Glass, 10491 Corkscrew Commons Dr., Estero, FL 33928, phone (239) 947-6050. The car computer system should have recorded the event. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Corrective Action:

On Tuesday, [XXX], around [XXX] returning home and in my driveway when the following happened. Pulling into the left side of the driveway because a utility van was parked on the right side of the driveway with the rear door and driver’s side door opened with no one in the vicinity. There was not enough room to go forward into the garage. I was almost at a complete stop with the intention of getting out of the car to shut the drivers side door. That was when the car sped up at full speed and turned to the right into the van and continued in the right direction into the garage. The car was headed to the right back corner of the garage smashing into paint cans, a freezer, sink and cabinets. I had no control over the car from the time the car sped up and smashed into the back of the garage and it all happened in a matter of a few seconds. The vehicle has been totaled by the insurance company. This incident was recorded in the vehicle’s computer. The police department was called the same day and a police officer came to the house to record the incident. The car was towed to Gerber Collision & Glass, 10491 Corkscrew Commons Dr., Estero, FL 33928, phone (239) 947-6050. The car computer system should have recorded the event. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Additional Notes:

On Tuesday, [XXX], around [XXX] returning home and in my driveway when the following happened. Pulling into the left side of the driveway because a utility van was parked on the right side of the driveway with the rear door and driver’s side door opened with no one in the vicinity. There was not enough room to go forward into the garage. I was almost at a complete stop with the intention of getting out of the car to shut the drivers side door. That was when the car sped up at full speed and turned to the right into the van and continued in the right direction into the garage. The car was headed to the right back corner of the garage smashing into paint cans, a freezer, sink and cabinets. I had no control over the car from the time the car sped up and smashed into the back of the garage and it all happened in a matter of a few seconds. The vehicle has been totaled by the insurance company. This incident was recorded in the vehicle’s computer. The police department was called the same day and a police officer came to the house to record the incident. The car was towed to Gerber Collision & Glass, 10491 Corkscrew Commons Dr., Estero, FL 33928, phone (239) 947-6050. The car computer system should have recorded the event. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Manufacturer: TESLA
Mfg Campaign: 11656833
Notice Date: Apr 25, 2025
Recall Date: Apr 25, 2025
Tesla, Inc.
Campaign: 11649657 Other
Mar 21, 2025
Defect Description:

STRUCTURE:INTERIOR PANELS:DOOR

Potential Consequences:

On three separate occaisions the back left door panel has slipped from its position and caused the door to not be able to open either from the inside or outside. It requires repair each time. This is extremely dangerous for the back seat passengers as they are not able to exit the car AND it can't be forced open AND requires a technician. I have asked Tesla to fix it, but it appears to be a design flaw and it is a known flaw. There are no warning lights. The vehicle has been looked at each time and each technician has said that the clips pop out and they do a car each week or so.

Corrective Action:

On three separate occaisions the back left door panel has slipped from its position and caused the door to not be able to open either from the inside or outside. It requires repair each time. This is extremely dangerous for the back seat passengers as they are not able to exit the car AND it can't be forced open AND requires a technician. I have asked Tesla to fix it, but it appears to be a design flaw and it is a known flaw. There are no warning lights. The vehicle has been looked at each time and each technician has said that the clips pop out and they do a car each week or so.

Additional Notes:

On three separate occaisions the back left door panel has slipped from its position and caused the door to not be able to open either from the inside or outside. It requires repair each time. This is extremely dangerous for the back seat passengers as they are not able to exit the car AND it can't be forced open AND requires a technician. I have asked Tesla to fix it, but it appears to be a design flaw and it is a known flaw. There are no warning lights. The vehicle has been looked at each time and each technician has said that the clips pop out and they do a car each week or so.

Manufacturer: TESLA
Mfg Campaign: 11649657
Notice Date: Mar 21, 2025
Recall Date: Mar 21, 2025
Tesla, Inc.
Campaign: 11649532 Other
Mar 20, 2025
Defect Description:

STEERING

Potential Consequences:

The steering control arms were clicking and making noises when the steering wheel was turned. Reports on Reddit said dozens of people had this problem right before they completely busted and lost control of steering the vehicle. I took mine in to the service center and they acknowledged the problem and charged me over $750 to fix. This is a SAFETY ISSUE and should be recalled and fixed for free. I have owned cars for over 40 years and have NEVER had to replace steering control arms. They installed faulty parts.

Corrective Action:

The steering control arms were clicking and making noises when the steering wheel was turned. Reports on Reddit said dozens of people had this problem right before they completely busted and lost control of steering the vehicle. I took mine in to the service center and they acknowledged the problem and charged me over $750 to fix. This is a SAFETY ISSUE and should be recalled and fixed for free. I have owned cars for over 40 years and have NEVER had to replace steering control arms. They installed faulty parts.

Additional Notes:

The steering control arms were clicking and making noises when the steering wheel was turned. Reports on Reddit said dozens of people had this problem right before they completely busted and lost control of steering the vehicle. I took mine in to the service center and they acknowledged the problem and charged me over $750 to fix. This is a SAFETY ISSUE and should be recalled and fixed for free. I have owned cars for over 40 years and have NEVER had to replace steering control arms. They installed faulty parts.

Manufacturer: TESLA
Mfg Campaign: 11649532
Notice Date: Mar 20, 2025
Recall Date: Mar 20, 2025
Tesla, Inc.
Campaign: 11644775 Other
Feb 25, 2025
Defect Description:

LANE DEPARTURE: WARNING

Potential Consequences:

My Advance Driving assist (FSD for Tesla) stop working randomly. Adaptive Cruse control stoped working, forward collision stopped working. Backup camera randomly disconnect when parking. All of this happened right after a software update. I have contacted Tesla several times. They quoted me $2,666.96 to address the issue. Isn't this a Safety feature of the Car Specially when I paid $10,000.00 extra when I purchase the car to have FSD? All of the advanced driving assistance and collision warning stopped working as well.

Corrective Action:

My Advance Driving assist (FSD for Tesla) stop working randomly. Adaptive Cruse control stoped working, forward collision stopped working. Backup camera randomly disconnect when parking. All of this happened right after a software update. I have contacted Tesla several times. They quoted me $2,666.96 to address the issue. Isn't this a Safety feature of the Car Specially when I paid $10,000.00 extra when I purchase the car to have FSD? All of the advanced driving assistance and collision warning stopped working as well.

Additional Notes:

My Advance Driving assist (FSD for Tesla) stop working randomly. Adaptive Cruse control stoped working, forward collision stopped working. Backup camera randomly disconnect when parking. All of this happened right after a software update. I have contacted Tesla several times. They quoted me $2,666.96 to address the issue. Isn't this a Safety feature of the Car Specially when I paid $10,000.00 extra when I purchase the car to have FSD? All of the advanced driving assistance and collision warning stopped working as well.

Manufacturer: TESLA
Mfg Campaign: 11644775
Notice Date: Feb 25, 2025
Recall Date: Feb 25, 2025
Tesla, Inc.
Campaign: 11644775 Other
Feb 25, 2025
Defect Description:

FORWARD COLLISION AVOIDANCE: WARNINGS

Potential Consequences:

My Advance Driving assist (FSD for Tesla) stop working randomly. Adaptive Cruse control stoped working, forward collision stopped working. Backup camera randomly disconnect when parking. All of this happened right after a software update. I have contacted Tesla several times. They quoted me $2,666.96 to address the issue. Isn't this a Safety feature of the Car Specially when I paid $10,000.00 extra when I purchase the car to have FSD? All of the advanced driving assistance and collision warning stopped working as well.

Corrective Action:

My Advance Driving assist (FSD for Tesla) stop working randomly. Adaptive Cruse control stoped working, forward collision stopped working. Backup camera randomly disconnect when parking. All of this happened right after a software update. I have contacted Tesla several times. They quoted me $2,666.96 to address the issue. Isn't this a Safety feature of the Car Specially when I paid $10,000.00 extra when I purchase the car to have FSD? All of the advanced driving assistance and collision warning stopped working as well.

Additional Notes:

My Advance Driving assist (FSD for Tesla) stop working randomly. Adaptive Cruse control stoped working, forward collision stopped working. Backup camera randomly disconnect when parking. All of this happened right after a software update. I have contacted Tesla several times. They quoted me $2,666.96 to address the issue. Isn't this a Safety feature of the Car Specially when I paid $10,000.00 extra when I purchase the car to have FSD? All of the advanced driving assistance and collision warning stopped working as well.

Manufacturer: TESLA
Mfg Campaign: 11644775
Notice Date: Feb 25, 2025
Recall Date: Feb 25, 2025
Tesla, Inc.
Campaign: 11644775 Other
Feb 25, 2025
Defect Description:

FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL

Potential Consequences:

My Advance Driving assist (FSD for Tesla) stop working randomly. Adaptive Cruse control stoped working, forward collision stopped working. Backup camera randomly disconnect when parking. All of this happened right after a software update. I have contacted Tesla several times. They quoted me $2,666.96 to address the issue. Isn't this a Safety feature of the Car Specially when I paid $10,000.00 extra when I purchase the car to have FSD? All of the advanced driving assistance and collision warning stopped working as well.

Corrective Action:

My Advance Driving assist (FSD for Tesla) stop working randomly. Adaptive Cruse control stoped working, forward collision stopped working. Backup camera randomly disconnect when parking. All of this happened right after a software update. I have contacted Tesla several times. They quoted me $2,666.96 to address the issue. Isn't this a Safety feature of the Car Specially when I paid $10,000.00 extra when I purchase the car to have FSD? All of the advanced driving assistance and collision warning stopped working as well.

Additional Notes:

My Advance Driving assist (FSD for Tesla) stop working randomly. Adaptive Cruse control stoped working, forward collision stopped working. Backup camera randomly disconnect when parking. All of this happened right after a software update. I have contacted Tesla several times. They quoted me $2,666.96 to address the issue. Isn't this a Safety feature of the Car Specially when I paid $10,000.00 extra when I purchase the car to have FSD? All of the advanced driving assistance and collision warning stopped working as well.

Manufacturer: TESLA
Mfg Campaign: 11644775
Notice Date: Feb 25, 2025
Recall Date: Feb 25, 2025
Tesla, Inc.
Campaign: 11642358 Other
Feb 12, 2025
Defect Description:

VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM

Potential Consequences:

Heat and A/C. VCFront_a447 code Can't defrost windshield / can't drive in the cold

Corrective Action:

Heat and A/C. VCFront_a447 code Can't defrost windshield / can't drive in the cold

Additional Notes:

Heat and A/C. VCFront_a447 code Can't defrost windshield / can't drive in the cold

Manufacturer: TESLA
Mfg Campaign: 11642358
Notice Date: Feb 12, 2025
Recall Date: Feb 12, 2025

Need Legal Help?

Featured Attorneys
Barry Edzant

Edzant Price LLC

Valencia, CA • 36 yrs

Focus: Lemon Law, Personal Injury

Recent Articles
Jeep Grand Cherokee Head Restraint Problem

Chrysler (FCA US, LLC) has announced a safety issue affecting certain 2023–2024 Jeep Grand Ch ...

Aug 1, 2025
Fuel Injector Problem: 2021-2024 Ford Bronco Sport and 2020-2022 Ford Escape

If you own a 2021-2024 Ford Bronco Sport or 2020-2022 Ford Escape equipped with a 1.5L Dragon GTDI e ...

Jul 28, 2025
Airbag Problem Affects 2022-2025 Chrysler Pacifica and Voyager Vehicles

If you own a Chrysler Pacifica or Voyager, your vehicle may be equipped with defective side curtain ...

Jul 24, 2025