PETERBILT 579 2018

Complete listing of complaints and recalls for this vehicle

12
Complaints
17
Recalls

Complaints & Recalls

12 Complaints 17 Recalls

Official Safety Recalls - Important!

17 Recalls

These are official manufacturer recalls ordered by NHTSA for safety defects. If you own this vehicle, contact your dealer immediately for free repairs.

Paccar Incorporated
NHTSA Campaign: 22V277000 SAFETY RECALL
17.6K Vehicles Affected
Recall Date: Apr 25, 2022
Safety Issue:

PACCAR Incorporated (PACCAR) is recalling certain 2018-2020 Kenworth T270, T370, T440, T470, T660, T680, T880, T800, W900, W990; and 2018-2020 Peterbilt 330, 337, 348, 365, 367, 389, 520, 567, and 579 vehicles. The Dana D-Series axle steer arm fasteners that attach the steering arm to the steering knuckle may fail.

Potential Risk:
Fastener failure can result in a loss of steering control, increasing the risk of a crash or injury.
FREE Recall Solution:
Dealers will replace and torque the steer arm fasteners, at no charge. Owner notification letters were mailed November 8, 2022. Owners may contact Kenworth customer service at 1-425-828-5888 and Peterbilt customer service at 1-940-591-4220. PACCAR's numbers for this recall are 22 PBB and 22 KWB.
Additional Details:

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.

Action Required: Contact your local PETERBILT dealer to schedule your FREE recall repair.
Manufacturer: PETERBILT
Mfg Campaign: 22 PBB and 22 KWB
Notice Date: Nov 8, 2022
Recall Date: Apr 25, 2022
Paccar Incorporated
NHTSA Campaign: 21V00N000 SAFETY RECALL
1.1K Vehicles Affected
Recall Date: Dec 29, 2021
Safety Issue:

PACCAR Incorporated (PACCAR) is recalling certain 2016-2022 Peterbilt 567, 579, 2021-2022 Peterbilt 536, 2017-2021 Kenworth T880, 2016-2022 Kenworth T680, 2018-2020 Kenworth T440, 2020 Kenworth T270, and 2021 Kenworth T280 vehicles. The methane detection system will not function if the system loses power.

Potential Risk:
The operator may be unaware of a system malfunction or the presence of excessive methane levels, increasing the risk of injury or fire.
FREE Recall Solution:
Dealers will re-wire the warning alarm, free of charge. Owner notification letters were mailed December 1, 2022. Owners may contact Peterbilt customer service at 1-940-591-4220, and Kenworth customer service at 1-425-828-5888. PACCAR's numbers for this recall are 21KWH and 21PBN.
Additional Details:

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.

Action Required: Contact your local PETERBILT dealer to schedule your FREE recall repair.
Manufacturer: PETERBILT
Mfg Campaign: 21KWH and 21PBN
Notice Date: Dec 1, 2022
Recall Date: Dec 29, 2021
Paccar Incorporated
NHTSA Campaign: 20V199000 SAFETY RECALL
460.5K Vehicles Affected
Recall Date: Apr 6, 2020
Safety Issue:

PACCAR Incorporated (PACCAR) is recalling certain 2008-2019 Peterbilt 330, 335, 337, 340, 348, 365, 367, 384, 386, 387, 388, 389, 567, 579 and 587 vehicles and 2008-2020 Kenworth T170, T270, T370, T660, T680, T800, T880, and W900 vehicles equipped with NAMUX Software. In the event that the Anti-lock Brake System (ABS) loses battery and/or ignition power to the controller, the dash warning light for the ABS may not illuminate to warn the driver of the loss of ABS. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 121, "Air Brake Systems," and 136, "Electronic Stability Control System on Heavy Vehicles."

Potential Risk:
If the driver unknowingly operates the vehicle without the ABS functioning, there would be an increased risk of a crash.
FREE Recall Solution:
PACCAR will notify owners, and dealers will update the NAMUX software within the cab control module, free of charge. PACCAR issued owners an interim notification on June 4, 2020. The recall began May 26, 2020. Owners may contact Kenworth customer service at 1-425-828-5888 or Peterbilt customer service at 1-940-591-4220. PACCAR's number for this recall is 20pbc AND 20KWB.
Additional Details:

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Action Required: Contact your local PETERBILT dealer to schedule your FREE recall repair.
Manufacturer: PETERBILT
Mfg Campaign: 20pbc AND 20KWB
Notice Date: May 26, 2020
Recall Date: Apr 6, 2020
Paccar Incorporated
NHTSA Campaign: 20V130000 SAFETY RECALL
35.7K Vehicles Affected
Recall Date: Mar 4, 2020
Safety Issue:

PACCAR Incorporated (PACCAR) is recalling certain 2015-2020 Peterbilt 365, 389, 567, and 579 vehicles equipped with a left-hand under hood jumper terminal (option code 2539410). The positive battery jumper terminal cable may be too long, allowing it to chafe against the left front suspension spring and result in an electrical short circuit.

Potential Risk:
An electrical short circuit can increase the risk of a fire.
FREE Recall Solution:
PACCAR will notify owners, and dealers will inspect the battery jumper terminal cables, and replace them as necessary, free of charge. The recall began April 30, 2020. Owners may contact PACCAR customer service at 1-940-591-4220. PACCAR's number for this recall is 20PBA.
Additional Details:

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Action Required: Contact your local PETERBILT dealer to schedule your FREE recall repair.
Manufacturer: PETERBILT
Mfg Campaign: 20PBA
Notice Date: Apr 30, 2020
Recall Date: Mar 4, 2020
Transportation Power, Inc.
NHTSA Campaign: 19V657000 SAFETY RECALL
12 Vehicles Affected
Recall Date: Sep 17, 2019
Safety Issue:

Transportation Power, Inc. (TransPower) is recalling certain 2017-2018 electric trucks built on Peterbilt 579 chassis. The vehicles do not have stabilization hardware and software that interacts with the braking system. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 136, "Electronic Stability Control Systems on Heavy Vehicles."

Potential Risk:
Without a Electronic Stability Control system, there is a greater chance of loss of stability control, which increases the risk of a crash.
FREE Recall Solution:
TransPower will notify owners, and dealers will install an Electronic Stability Control (ESC) system, free of charge. The recall began September 26, 2019. Owners may contact TransPower customer service at 1-858-248-4255.
Additional Details:

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Action Required: Contact your local PETERBILT dealer to schedule your FREE recall repair.
Manufacturer: PETERBILT
Notice Date: Sep 26, 2019
Recall Date: Sep 17, 2019
Paccar Incorporated
NHTSA Campaign: 18V931000 SAFETY RECALL
25.6K Vehicles Affected
Recall Date: Dec 21, 2018
Safety Issue:

PACCAR Incorporated (PACCAR) is recalling certain 2018-2019 Peterbilt 337, 348, 365, 367, 389, 567, 579 and 587 trucks and 2018-2019 Kenworth C500, T270, T370, T440, T660, T680, T800, T880 and W900 trucks equipped with automated manual transmissions. An internal component in the clutch assembly may fail, possibly resulting in unintended vehicle movement.

Potential Risk:
Unintended movement of a vehicle can increase the risk of a crash.
FREE Recall Solution:
PACCAR will notify owners, and dealers will update the transmission control module, free of charge. The recall began February 23, 2019. Owners may contact PACCAR customer service at 1-940-591-4220. PACCAR's numbers for this recall are 18PBE and 18KWH.
Additional Details:

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Action Required: Contact your local PETERBILT dealer to schedule your FREE recall repair.
Manufacturer: PETERBILT
Mfg Campaign: 18PBE; 18KWH
Notice Date: Feb 23, 2019
Recall Date: Dec 21, 2018
Paccar Incorporated
NHTSA Campaign: 18V870000 SAFETY RECALL
6.9K Vehicles Affected
Recall Date: Dec 7, 2018
Safety Issue:

PACCAR Incorporated (PACCAR) is recalling certain 2018 Kenworth T680 and T880, and Peterbilt 567 and 579 trucks. The seat belt buckle assemblies on these vehicles may have been glued and not sewn during manufacturing, possibly causing the assembly to come apart under load, such as in the event of a crash.

Potential Risk:
If the seat belt buckle assembly separates, it can prevent the occupant from being properly restrained in the event of a crash, increasing the risk of a crash.
FREE Recall Solution:
PACCAR will notify owners, and dealers will replace the seat belt buckle assemblies that were not sewn, free of charge. PACCAR issued owners an interim notification on February 4, 2019. The recall began February 28, 2019. Owners may contact PACCAR customer service at 1-918-259-3258. PACCAR's numbers for this recall is 18KWG, and 18PBD.
Additional Details:

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Action Required: Contact your local PETERBILT dealer to schedule your FREE recall repair.
Manufacturer: PETERBILT
Mfg Campaign: 18KWG and 18PBD
Notice Date: Feb 28, 2019
Recall Date: Dec 7, 2018
Paccar Incorporated
NHTSA Campaign: 18V816000 SAFETY RECALL
1.6K Vehicles Affected
Recall Date: Nov 16, 2018
Safety Issue:

PACCAR Incorporated (PACCAR) is recalling certain 2013-2019 Kenworth T680 and T880 and Peterbilt 579 trucks, greater than 30 feet long and equipped with side extender mounted intermediate marker lamp/turn signals that do not include a reflex reflector. Since both intermediate side marker lamps and reflex reflectors are required, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."

Potential Risk:
Missing reflex reflectors can reduce the vehicle's visibility to other drivers, increasing the risk of a crash.
FREE Recall Solution:
PACCAR will notify owners and dealers will install reflex reflective tape, free of charge. The recall began January 15, 2019. Owners may contact PACCAR customer service at 1-918-259-3258. PACCAR's number for this recall is 18KWF, and 18PBC.
Additional Details:

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Action Required: Contact your local PETERBILT dealer to schedule your FREE recall repair.
Manufacturer: PETERBILT
Mfg Campaign: 18KWF & 18PBC
Notice Date: Jan 15, 2019
Recall Date: Nov 16, 2018
Paccar Incorporated
NHTSA Campaign: 18V657000 SAFETY RECALL
48.9K Vehicles Affected
Recall Date: Sep 21, 2018
Safety Issue:

PACCAR Incorporated (PACCAR) is recalling certain 2017-2019 Kenworth C500, T600, T660, T680, T800, T880 and W900 trucks, as well as Peterbilt 367, 386, 389, 567, 579 and 587 trucks, equipped with Cummins ISX15 or X15 diesel engines. In certain driving conditions, such as on a long down-hill grade, the fuel line may burst if the fuel pump cooling circuit screen becomes restricted.

Potential Risk:
If the fuel line bursts, fuel may leak onto the road resulting in a roadway hazard for other motorists. The engine may also stall without warning, resulting in the vehicle's inability to restart, increasing the risk of a crash.
FREE Recall Solution:
Cummins will notify owners, and dealers will replace the suspect fuel pump cooling circuit screen, free of charge. The recall began November 21, 2018. Owners may contact PACCAR customer service at 1-940-591-4220. PACCAR's number for this recall is 18E081.
Additional Details:

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Action Required: Contact your local PETERBILT dealer to schedule your FREE recall repair.
Manufacturer: PETERBILT
Mfg Campaign: 18E081
Notice Date: Nov 21, 2018
Recall Date: Sep 21, 2018
Paccar Incorporated
NHTSA Campaign: 18V368000 SAFETY RECALL
85.6K Vehicles Affected
Recall Date: Jun 1, 2018
Safety Issue:

PACCAR Incorporated (PACCAR) is recalling certain 2017-2018 Peterbilt 567 and 579 trucks and 2015-2018 Kenworth T660, T680, T800, T880 and W900 trucks. In the event that the Anti-lock Brake System (ABS) loses battery and/or ignition power to the controller, the dash warning light for the ABS may not illuminate to warn the driver of the loss of ABS. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 121, "Air Brake Systems," and 136, "Electronic Stability Control System on Heavy Vehicles."

Potential Risk:
If the driver unknowingly operates the vehicle without the ABS functioning, there would be an increased risk of a crash.
FREE Recall Solution:
PACCAR will notify owners, and dealers will update the NAMUX software within the cab control module, free of charge. PACCAR issued owners an interim notification on July 30, 2018. Owners may contact Peterbilt customer service at 1-918-259-3258 or Kenworth customer service at 1-425-828-5000.
Additional Details:

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Action Required: Contact your local PETERBILT dealer to schedule your FREE recall repair.
Manufacturer: PETERBILT
Mfg Campaign: 18KWD;18PBB
Notice Date: May 21, 2020
Recall Date: Jun 1, 2018
Paccar Incorporated
NHTSA Campaign: 18V092000 SAFETY RECALL
1.9K Vehicles Affected
Recall Date: Feb 2, 2018
Safety Issue:

PACCAR Incorporated (PACCAR) is recalling certain 2017-2018 Kenworth T680 and T880 trucks, and Peterbilt 567 and 579 trucks, all equipped with an automated Eaton UltraShift Plus or Eaton Advantage Transmission with right hand stalk shifter. The display that indicates which transmission gear the driver selected may display incorrectly. The display can indicate 'N' when the shifter is set into 'D' or 'R', and the as a result, the truck will not move. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 102, "Transmission Shift Lever Sequence/Starter Interlock/Transmission Braking Effect," and number 101, "Control and Displays."

Potential Risk:
A truck that does not move as expected can increase the risk of a crash.
FREE Recall Solution:
PACCAR will notify owners, and dealers will install a transmission software update, free of charge. The recall began on March 9, 2018. Owners may contact Kenworth customer service at 1-425-828-5000 or Peterbilt customer service at 1-940-591-4220. PACCAR's numbers for this recall is 18KWA and 118-A.
Additional Details:

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Action Required: Contact your local PETERBILT dealer to schedule your FREE recall repair.
Manufacturer: PETERBILT
Mfg Campaign: 18KWA and 118-A
Notice Date: Mar 9, 2018
Recall Date: Feb 2, 2018
Paccar Incorporated
NHTSA Campaign: 17V840000 SAFETY RECALL
1.2K Vehicles Affected
Recall Date: Dec 22, 2017
Safety Issue:

PACCAR Incorporated (PACCAR) is recalling certain 2018 Peterbilt 567, 579, Kenworth T680, and T880 trucks, equipped with certain Eaton Endurant and PACCAR AMT transmissions. The transmission control module (TCM) may allow the engine to crank briefly even if the transmission shifter is not in neutral. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 102, "Transmission Shift Lever Sequence/Starter Interlock/Transmission Braking Effect."

Potential Risk:
If the transmission is not in neutral when the engine begins running, there may be unintended vehicle movement, increasing the risk of a crash.
FREE Recall Solution:
PACCAR will notify owners, and dealers will update the TCM software, free of charge. The recall began February 6, 2018. Owners may contact Peterbilt customer service at 1-940-591-4000, or Kenworth customer service at 1-425-828-5000. PACCAR's numbers for this recall are 1217F and 1717KWF.
Additional Details:

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Action Required: Contact your local PETERBILT dealer to schedule your FREE recall repair.
Manufacturer: PETERBILT
Mfg Campaign: 1217F and 17KWF
Notice Date: Feb 6, 2018
Recall Date: Dec 22, 2017
Paccar Incorporated
NHTSA Campaign: 17V443000 SAFETY RECALL
1.7K Vehicles Affected
Recall Date: Jul 13, 2017
Safety Issue:

PACCAR Incorporated (PACCAR) is recalling certain 2017-2018 Peterbilt 367, 389, 567, 579 and 587 trucks, and 2018 Kenworth C500, T680, T800, T880 and W900 trucks equipped with Cummins ISX 15L engines. These engines have a fuel pump whose drive gear could possibly slip on its drive shaft, causing a fuel pump function loss, resulting in an engine stall.

Potential Risk:
An engine stall can increase the risk of a crash.
FREE Recall Solution:
Cummins will notify the vehicle purchaser, and Cummins dealers will replace the fuel pumps, free of charge. The recall began July 1, 2017. Owners may contact Cummins customer service at 1-800-286-6467 or PACCAR customer service at 1-425-468-7400. PACCAR's number for this recall is C1909.
Additional Details:

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Action Required: Contact your local PETERBILT dealer to schedule your FREE recall repair.
Manufacturer: PETERBILT
Mfg Campaign: C1909
Notice Date: Jul 1, 2017
Recall Date: Jul 13, 2017
Paccar Incorporated
NHTSA Campaign: 17V103000 SAFETY RECALL
465 Vehicles Affected
Recall Date: Feb 15, 2017
Safety Issue:

PACCAR Incorporated (PACCAR) is recalling certain 2015-2018 Kenworth K370, T680, T880 and 2017-2018 Peterbilt 567 and 579 trucks. The plastic fuel tee fittings on these trucks may leak fuel.

Potential Risk:
A fuel leak in the presence of an ignition source can increase the risk of a fire.
FREE Recall Solution:
Kenworth and Peterbilt will notify owners, and dealers will replace the suspect fuel tees, free of charge. The recall began on April 13, 2017. Owners may contact Kenworth customer service at 1-425-828-5000 and Peterbilt customer service at 1-940-591-4000. PACCAR's numbers for this recall is 17KWA and 217-A.
Additional Details:

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Action Required: Contact your local PETERBILT dealer to schedule your FREE recall repair.
Manufacturer: PETERBILT
Mfg Campaign: 17KWA and 217-A
Notice Date: Apr 13, 2017
Recall Date: Feb 15, 2017

Consumer Complaints

12 Complaints
Paccar Incorporated
Campaign: 11659905 Other
May 9, 2025
Defect Description:

SERVICE BRAKES

Potential Consequences:

See attached document for complaint.

Corrective Action:

See attached document for complaint.

Additional Notes:

See attached document for complaint.

Manufacturer: PETERBILT
Mfg Campaign: 11659905
Notice Date: May 9, 2025
Recall Date: May 9, 2025
Paccar Incorporated
Campaign: 11659905 Other
May 9, 2025
Defect Description:

FIRERELATED

Potential Consequences:

See attached document for complaint.

Corrective Action:

See attached document for complaint.

Additional Notes:

See attached document for complaint.

Manufacturer: PETERBILT
Mfg Campaign: 11659905
Notice Date: May 9, 2025
Recall Date: May 9, 2025
Paccar Incorporated
Campaign: 11624162 Other
Nov 8, 2024
Defect Description:

SERVICE BRAKES

Potential Consequences:

This vehicle about 6-8 weeks ago started throwing codes for all systems above (over 100 codes). This issue affected all systems of the vehicle including but not limited to the speed and braking of the vehicle, plus the fuel system and adaptive driving systems. We took it to the dealer Performance Peterbilt in Tifton, GA. They cleared the codes and said they resolved it by replacing a NOX sensor. We left the repair shop and within 50-100 miles the exact same issue started up again. We took it back to the same shop, they worked with Paccar and determined it needed a new ECM (Computer), this was changed out and still did not resolve issue. They then changed out the main wire harness. This resolved some issues but not all issues. Now the repair dealer is stating it needs a dash wire harness. This vehicle has relatively low miles 500K and has only been serviced by Peterbilt dealers through it's life. This issue causes the vehicle to accelerate and brake randomly plus many other issues by stopping power in hauling. We have another IDENTICAL vehicle which is now doing the same thing but have not brought it into the shop yet until manufacturer can get this 1st truck fixed properly to ensure safety.

Corrective Action:

This vehicle about 6-8 weeks ago started throwing codes for all systems above (over 100 codes). This issue affected all systems of the vehicle including but not limited to the speed and braking of the vehicle, plus the fuel system and adaptive driving systems. We took it to the dealer Performance Peterbilt in Tifton, GA. They cleared the codes and said they resolved it by replacing a NOX sensor. We left the repair shop and within 50-100 miles the exact same issue started up again. We took it back to the same shop, they worked with Paccar and determined it needed a new ECM (Computer), this was changed out and still did not resolve issue. They then changed out the main wire harness. This resolved some issues but not all issues. Now the repair dealer is stating it needs a dash wire harness. This vehicle has relatively low miles 500K and has only been serviced by Peterbilt dealers through it's life. This issue causes the vehicle to accelerate and brake randomly plus many other issues by stopping power in hauling. We have another IDENTICAL vehicle which is now doing the same thing but have not brought it into the shop yet until manufacturer can get this 1st truck fixed properly to ensure safety.

Additional Notes:

This vehicle about 6-8 weeks ago started throwing codes for all systems above (over 100 codes). This issue affected all systems of the vehicle including but not limited to the speed and braking of the vehicle, plus the fuel system and adaptive driving systems. We took it to the dealer Performance Peterbilt in Tifton, GA. They cleared the codes and said they resolved it by replacing a NOX sensor. We left the repair shop and within 50-100 miles the exact same issue started up again. We took it back to the same shop, they worked with Paccar and determined it needed a new ECM (Computer), this was changed out and still did not resolve issue. They then changed out the main wire harness. This resolved some issues but not all issues. Now the repair dealer is stating it needs a dash wire harness. This vehicle has relatively low miles 500K and has only been serviced by Peterbilt dealers through it's life. This issue causes the vehicle to accelerate and brake randomly plus many other issues by stopping power in hauling. We have another IDENTICAL vehicle which is now doing the same thing but have not brought it into the shop yet until manufacturer can get this 1st truck fixed properly to ensure safety.

Manufacturer: PETERBILT
Mfg Campaign: 11624162
Notice Date: Nov 8, 2024
Recall Date: Nov 8, 2024
Paccar Incorporated
Campaign: 11624162 Other
Nov 8, 2024
Defect Description:

ENGINE

Potential Consequences:

This vehicle about 6-8 weeks ago started throwing codes for all systems above (over 100 codes). This issue affected all systems of the vehicle including but not limited to the speed and braking of the vehicle, plus the fuel system and adaptive driving systems. We took it to the dealer Performance Peterbilt in Tifton, GA. They cleared the codes and said they resolved it by replacing a NOX sensor. We left the repair shop and within 50-100 miles the exact same issue started up again. We took it back to the same shop, they worked with Paccar and determined it needed a new ECM (Computer), this was changed out and still did not resolve issue. They then changed out the main wire harness. This resolved some issues but not all issues. Now the repair dealer is stating it needs a dash wire harness. This vehicle has relatively low miles 500K and has only been serviced by Peterbilt dealers through it's life. This issue causes the vehicle to accelerate and brake randomly plus many other issues by stopping power in hauling. We have another IDENTICAL vehicle which is now doing the same thing but have not brought it into the shop yet until manufacturer can get this 1st truck fixed properly to ensure safety.

Corrective Action:

This vehicle about 6-8 weeks ago started throwing codes for all systems above (over 100 codes). This issue affected all systems of the vehicle including but not limited to the speed and braking of the vehicle, plus the fuel system and adaptive driving systems. We took it to the dealer Performance Peterbilt in Tifton, GA. They cleared the codes and said they resolved it by replacing a NOX sensor. We left the repair shop and within 50-100 miles the exact same issue started up again. We took it back to the same shop, they worked with Paccar and determined it needed a new ECM (Computer), this was changed out and still did not resolve issue. They then changed out the main wire harness. This resolved some issues but not all issues. Now the repair dealer is stating it needs a dash wire harness. This vehicle has relatively low miles 500K and has only been serviced by Peterbilt dealers through it's life. This issue causes the vehicle to accelerate and brake randomly plus many other issues by stopping power in hauling. We have another IDENTICAL vehicle which is now doing the same thing but have not brought it into the shop yet until manufacturer can get this 1st truck fixed properly to ensure safety.

Additional Notes:

This vehicle about 6-8 weeks ago started throwing codes for all systems above (over 100 codes). This issue affected all systems of the vehicle including but not limited to the speed and braking of the vehicle, plus the fuel system and adaptive driving systems. We took it to the dealer Performance Peterbilt in Tifton, GA. They cleared the codes and said they resolved it by replacing a NOX sensor. We left the repair shop and within 50-100 miles the exact same issue started up again. We took it back to the same shop, they worked with Paccar and determined it needed a new ECM (Computer), this was changed out and still did not resolve issue. They then changed out the main wire harness. This resolved some issues but not all issues. Now the repair dealer is stating it needs a dash wire harness. This vehicle has relatively low miles 500K and has only been serviced by Peterbilt dealers through it's life. This issue causes the vehicle to accelerate and brake randomly plus many other issues by stopping power in hauling. We have another IDENTICAL vehicle which is now doing the same thing but have not brought it into the shop yet until manufacturer can get this 1st truck fixed properly to ensure safety.

Manufacturer: PETERBILT
Mfg Campaign: 11624162
Notice Date: Nov 8, 2024
Recall Date: Nov 8, 2024
Paccar Incorporated
Campaign: 11624162 Other
Nov 8, 2024
Defect Description:

ELECTRICAL SYSTEM

Potential Consequences:

This vehicle about 6-8 weeks ago started throwing codes for all systems above (over 100 codes). This issue affected all systems of the vehicle including but not limited to the speed and braking of the vehicle, plus the fuel system and adaptive driving systems. We took it to the dealer Performance Peterbilt in Tifton, GA. They cleared the codes and said they resolved it by replacing a NOX sensor. We left the repair shop and within 50-100 miles the exact same issue started up again. We took it back to the same shop, they worked with Paccar and determined it needed a new ECM (Computer), this was changed out and still did not resolve issue. They then changed out the main wire harness. This resolved some issues but not all issues. Now the repair dealer is stating it needs a dash wire harness. This vehicle has relatively low miles 500K and has only been serviced by Peterbilt dealers through it's life. This issue causes the vehicle to accelerate and brake randomly plus many other issues by stopping power in hauling. We have another IDENTICAL vehicle which is now doing the same thing but have not brought it into the shop yet until manufacturer can get this 1st truck fixed properly to ensure safety.

Corrective Action:

This vehicle about 6-8 weeks ago started throwing codes for all systems above (over 100 codes). This issue affected all systems of the vehicle including but not limited to the speed and braking of the vehicle, plus the fuel system and adaptive driving systems. We took it to the dealer Performance Peterbilt in Tifton, GA. They cleared the codes and said they resolved it by replacing a NOX sensor. We left the repair shop and within 50-100 miles the exact same issue started up again. We took it back to the same shop, they worked with Paccar and determined it needed a new ECM (Computer), this was changed out and still did not resolve issue. They then changed out the main wire harness. This resolved some issues but not all issues. Now the repair dealer is stating it needs a dash wire harness. This vehicle has relatively low miles 500K and has only been serviced by Peterbilt dealers through it's life. This issue causes the vehicle to accelerate and brake randomly plus many other issues by stopping power in hauling. We have another IDENTICAL vehicle which is now doing the same thing but have not brought it into the shop yet until manufacturer can get this 1st truck fixed properly to ensure safety.

Additional Notes:

This vehicle about 6-8 weeks ago started throwing codes for all systems above (over 100 codes). This issue affected all systems of the vehicle including but not limited to the speed and braking of the vehicle, plus the fuel system and adaptive driving systems. We took it to the dealer Performance Peterbilt in Tifton, GA. They cleared the codes and said they resolved it by replacing a NOX sensor. We left the repair shop and within 50-100 miles the exact same issue started up again. We took it back to the same shop, they worked with Paccar and determined it needed a new ECM (Computer), this was changed out and still did not resolve issue. They then changed out the main wire harness. This resolved some issues but not all issues. Now the repair dealer is stating it needs a dash wire harness. This vehicle has relatively low miles 500K and has only been serviced by Peterbilt dealers through it's life. This issue causes the vehicle to accelerate and brake randomly plus many other issues by stopping power in hauling. We have another IDENTICAL vehicle which is now doing the same thing but have not brought it into the shop yet until manufacturer can get this 1st truck fixed properly to ensure safety.

Manufacturer: PETERBILT
Mfg Campaign: 11624162
Notice Date: Nov 8, 2024
Recall Date: Nov 8, 2024
Paccar Incorporated
Campaign: 11607883 Other
Aug 12, 2024
Defect Description:

ELECTRICAL SYSTEM

Potential Consequences:

On 8/10/2024 our sleeper berth hvac fans abruptly quit working. After checking fuses we noticed the fan control switch was hot. After removing the panel that the switch is held in we noticed the HVAC Fan Control switch (Part# 599-5000) was charred, upon removing the switch from the plug we observed the actual plug is melted, and one of the wires on the wire harness has charring of the plastic insulation. This could have very well caught fire. I am going to have to replace the wiring harness as re-pining the plug will not solve the issue of the wire being burned and the insulation being charred. There was no warning lamps, occasionally the fan would turn off then resume.

Corrective Action:

On 8/10/2024 our sleeper berth hvac fans abruptly quit working. After checking fuses we noticed the fan control switch was hot. After removing the panel that the switch is held in we noticed the HVAC Fan Control switch (Part# 599-5000) was charred, upon removing the switch from the plug we observed the actual plug is melted, and one of the wires on the wire harness has charring of the plastic insulation. This could have very well caught fire. I am going to have to replace the wiring harness as re-pining the plug will not solve the issue of the wire being burned and the insulation being charred. There was no warning lamps, occasionally the fan would turn off then resume.

Additional Notes:

On 8/10/2024 our sleeper berth hvac fans abruptly quit working. After checking fuses we noticed the fan control switch was hot. After removing the panel that the switch is held in we noticed the HVAC Fan Control switch (Part# 599-5000) was charred, upon removing the switch from the plug we observed the actual plug is melted, and one of the wires on the wire harness has charring of the plastic insulation. This could have very well caught fire. I am going to have to replace the wiring harness as re-pining the plug will not solve the issue of the wire being burned and the insulation being charred. There was no warning lamps, occasionally the fan would turn off then resume.

Manufacturer: PETERBILT
Mfg Campaign: 11607883
Notice Date: Aug 12, 2024
Recall Date: Aug 12, 2024
Paccar Incorporated
Campaign: 11522814 Other
May 19, 2023
Defect Description:

SUSPENSION

Potential Consequences:

Front axle begins popping and making metal to metal noises when hitting bumps and or turning. We took it to the shop and they found the nuts to the U-bolts that hold the leaf springs to the front axle had begun backing off and were out of torque spec. Upon receiving the truck back the front end no longer made this noise. Approximately 8 months later we are hearing the same metal on metal and popping noises that we heard previously. We have also noticed similar year Peterbilt 579's with this same noise and popping so this isn't specific to our vehicle.

Corrective Action:

Front axle begins popping and making metal to metal noises when hitting bumps and or turning. We took it to the shop and they found the nuts to the U-bolts that hold the leaf springs to the front axle had begun backing off and were out of torque spec. Upon receiving the truck back the front end no longer made this noise. Approximately 8 months later we are hearing the same metal on metal and popping noises that we heard previously. We have also noticed similar year Peterbilt 579's with this same noise and popping so this isn't specific to our vehicle.

Additional Notes:

Front axle begins popping and making metal to metal noises when hitting bumps and or turning. We took it to the shop and they found the nuts to the U-bolts that hold the leaf springs to the front axle had begun backing off and were out of torque spec. Upon receiving the truck back the front end no longer made this noise. Approximately 8 months later we are hearing the same metal on metal and popping noises that we heard previously. We have also noticed similar year Peterbilt 579's with this same noise and popping so this isn't specific to our vehicle.

Manufacturer: PETERBILT
Mfg Campaign: 11522814
Notice Date: May 19, 2023
Recall Date: May 19, 2023
Paccar Incorporated
Campaign: 11522814 Other
May 19, 2023
Defect Description:

STEERING

Potential Consequences:

Front axle begins popping and making metal to metal noises when hitting bumps and or turning. We took it to the shop and they found the nuts to the U-bolts that hold the leaf springs to the front axle had begun backing off and were out of torque spec. Upon receiving the truck back the front end no longer made this noise. Approximately 8 months later we are hearing the same metal on metal and popping noises that we heard previously. We have also noticed similar year Peterbilt 579's with this same noise and popping so this isn't specific to our vehicle.

Corrective Action:

Front axle begins popping and making metal to metal noises when hitting bumps and or turning. We took it to the shop and they found the nuts to the U-bolts that hold the leaf springs to the front axle had begun backing off and were out of torque spec. Upon receiving the truck back the front end no longer made this noise. Approximately 8 months later we are hearing the same metal on metal and popping noises that we heard previously. We have also noticed similar year Peterbilt 579's with this same noise and popping so this isn't specific to our vehicle.

Additional Notes:

Front axle begins popping and making metal to metal noises when hitting bumps and or turning. We took it to the shop and they found the nuts to the U-bolts that hold the leaf springs to the front axle had begun backing off and were out of torque spec. Upon receiving the truck back the front end no longer made this noise. Approximately 8 months later we are hearing the same metal on metal and popping noises that we heard previously. We have also noticed similar year Peterbilt 579's with this same noise and popping so this isn't specific to our vehicle.

Manufacturer: PETERBILT
Mfg Campaign: 11522814
Notice Date: May 19, 2023
Recall Date: May 19, 2023
Paccar Incorporated
Campaign: 11298970 Other
Jan 13, 2020
Defect Description:

ELECTRICAL SYSTEM

Potential Consequences:

TL* THE CONTACT OWNS A 2018 PETERBILT 579. THE CONTACT STATED THAT WHILE THE DRIVER WAS DRIVING, THE REAR BRAKES AND TURN SIGNALS FAILED TO FUNCTION. THE NEXT DAY THE RUNNING LIGHTS ON THE DRIVERS SIDE FAILED, THE PASSENGER SIDE OF THE TURN SIGNAL AND BRAKE ALSO FAILED TO FUNCTION. THE CONTACT STATED THAT THE MAIN ELECTRICAL HARNESS COMING OUT OF THE MAIN COMPUTER AND RUNNING THE ENTIRE SPAN UNDERNEATH THE CAB HAD LITTLE TO NO PROTECTIVE SHEATHING/ CORD WRAP/ ALUMINUM WRAP PROTECTING THE WIRES. THE HARNESS WAS ROUTED THROUGH A U-BOLT TYPE FLANGE AS WELL AS HANGS NEAR SEVERAL METAL PARTS THAT, WHILE IN MOTION, RUB AGAINST THE WIRE CAUSING THEM TO FRAY. AS A RESULT, SEVERAL ITEMS BEGAN TO SHORT OUT AND ALSO CAUSED NUMEROUS WIRES TO HEAT UP AND MELT. IT WAS DISCOVERED THAT THE RUNNING LIGHT BRAKE LIGHTS INTERN SIGNALS BEGAN TO FAIL. THE HARNESS COULD CAUSE FRAYING AND A POTENTIAL FIRE AS WELL AS SEVERAL MODULES TO FAIL. THE CONTACT CALLED NORTHERN OHIO PETERBILT DEALER, (1330 W TRENTON AVE, FINDLAY, OH 45840, (419) 423-3441) AND WAS INFORMED THAT THE VEHICLE WAS OVER THE ONE YEAR HUNDRED THOUSAND MILES FOR THE WARRANTY AND DID NOT ASSIST. THE VEHICLE WAS NOT TAKEN TO A DEALER AND WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 36,375.

Corrective Action:

TL* THE CONTACT OWNS A 2018 PETERBILT 579. THE CONTACT STATED THAT WHILE THE DRIVER WAS DRIVING, THE REAR BRAKES AND TURN SIGNALS FAILED TO FUNCTION. THE NEXT DAY THE RUNNING LIGHTS ON THE DRIVERS SIDE FAILED, THE PASSENGER SIDE OF THE TURN SIGNAL AND BRAKE ALSO FAILED TO FUNCTION. THE CONTACT STATED THAT THE MAIN ELECTRICAL HARNESS COMING OUT OF THE MAIN COMPUTER AND RUNNING THE ENTIRE SPAN UNDERNEATH THE CAB HAD LITTLE TO NO PROTECTIVE SHEATHING/ CORD WRAP/ ALUMINUM WRAP PROTECTING THE WIRES. THE HARNESS WAS ROUTED THROUGH A U-BOLT TYPE FLANGE AS WELL AS HANGS NEAR SEVERAL METAL PARTS THAT, WHILE IN MOTION, RUB AGAINST THE WIRE CAUSING THEM TO FRAY. AS A RESULT, SEVERAL ITEMS BEGAN TO SHORT OUT AND ALSO CAUSED NUMEROUS WIRES TO HEAT UP AND MELT. IT WAS DISCOVERED THAT THE RUNNING LIGHT BRAKE LIGHTS INTERN SIGNALS BEGAN TO FAIL. THE HARNESS COULD CAUSE FRAYING AND A POTENTIAL FIRE AS WELL AS SEVERAL MODULES TO FAIL. THE CONTACT CALLED NORTHERN OHIO PETERBILT DEALER, (1330 W TRENTON AVE, FINDLAY, OH 45840, (419) 423-3441) AND WAS INFORMED THAT THE VEHICLE WAS OVER THE ONE YEAR HUNDRED THOUSAND MILES FOR THE WARRANTY AND DID NOT ASSIST. THE VEHICLE WAS NOT TAKEN TO A DEALER AND WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 36,375.

Additional Notes:

TL* THE CONTACT OWNS A 2018 PETERBILT 579. THE CONTACT STATED THAT WHILE THE DRIVER WAS DRIVING, THE REAR BRAKES AND TURN SIGNALS FAILED TO FUNCTION. THE NEXT DAY THE RUNNING LIGHTS ON THE DRIVERS SIDE FAILED, THE PASSENGER SIDE OF THE TURN SIGNAL AND BRAKE ALSO FAILED TO FUNCTION. THE CONTACT STATED THAT THE MAIN ELECTRICAL HARNESS COMING OUT OF THE MAIN COMPUTER AND RUNNING THE ENTIRE SPAN UNDERNEATH THE CAB HAD LITTLE TO NO PROTECTIVE SHEATHING/ CORD WRAP/ ALUMINUM WRAP PROTECTING THE WIRES. THE HARNESS WAS ROUTED THROUGH A U-BOLT TYPE FLANGE AS WELL AS HANGS NEAR SEVERAL METAL PARTS THAT, WHILE IN MOTION, RUB AGAINST THE WIRE CAUSING THEM TO FRAY. AS A RESULT, SEVERAL ITEMS BEGAN TO SHORT OUT AND ALSO CAUSED NUMEROUS WIRES TO HEAT UP AND MELT. IT WAS DISCOVERED THAT THE RUNNING LIGHT BRAKE LIGHTS INTERN SIGNALS BEGAN TO FAIL. THE HARNESS COULD CAUSE FRAYING AND A POTENTIAL FIRE AS WELL AS SEVERAL MODULES TO FAIL. THE CONTACT CALLED NORTHERN OHIO PETERBILT DEALER, (1330 W TRENTON AVE, FINDLAY, OH 45840, (419) 423-3441) AND WAS INFORMED THAT THE VEHICLE WAS OVER THE ONE YEAR HUNDRED THOUSAND MILES FOR THE WARRANTY AND DID NOT ASSIST. THE VEHICLE WAS NOT TAKEN TO A DEALER AND WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 36,375.

Manufacturer: PETERBILT
Mfg Campaign: 11298970
Notice Date: Jan 13, 2020
Recall Date: Jan 13, 2020
Paccar Incorporated
Campaign: 11202730 Other
Apr 21, 2019
Defect Description:

SERVICE BRAKES

Potential Consequences:

BENDIX WINGMAN COLLISION MITIGATION SYSTEM, THIS SYSTEM AS AM TRYING TO BRAKE THE VEHICLE DETERMINED THAT THE VEHICLE IN FRONT WAS CLOSER THAN IT REALLY WAS AND LOCKED THE BRAKES AND STEERING, AT SUCH TIME THE DRIVER LOOSES CONTROL OF THE VEHICLE COMPLETELY, THIS WAS THE FOURTH TIME IT DID THIS, THE THIRD TIME IT LOCKED THE BRAKES I WAS TRYING TO BRAKE WHILE A CAR WAS DRIVING OUT OF A DRIVEWAY, SECOND TIME I WAS TRYING TO PASS A CAR AND IT DETECTED THE CAR TO CLOSE AND LOCKED THE BRAKES, FIRST TIME BUMPER TO BUMPER IT WAS RAINING, ON A HIGHWAY A VEHICLE CUT IN FRONT OF ME TRIED TO APPLY THE BRAKES AND THE SYSTEM LOCKED UP THE BRAKES AND STEERING, THERE WAS PLENTY OF ROOM FOR ME TO STOP WITHOUT THIS SYSTEM HAVING TO LOCK THE BRAKES UP ON ME

Corrective Action:

BENDIX WINGMAN COLLISION MITIGATION SYSTEM, THIS SYSTEM AS AM TRYING TO BRAKE THE VEHICLE DETERMINED THAT THE VEHICLE IN FRONT WAS CLOSER THAN IT REALLY WAS AND LOCKED THE BRAKES AND STEERING, AT SUCH TIME THE DRIVER LOOSES CONTROL OF THE VEHICLE COMPLETELY, THIS WAS THE FOURTH TIME IT DID THIS, THE THIRD TIME IT LOCKED THE BRAKES I WAS TRYING TO BRAKE WHILE A CAR WAS DRIVING OUT OF A DRIVEWAY, SECOND TIME I WAS TRYING TO PASS A CAR AND IT DETECTED THE CAR TO CLOSE AND LOCKED THE BRAKES, FIRST TIME BUMPER TO BUMPER IT WAS RAINING, ON A HIGHWAY A VEHICLE CUT IN FRONT OF ME TRIED TO APPLY THE BRAKES AND THE SYSTEM LOCKED UP THE BRAKES AND STEERING, THERE WAS PLENTY OF ROOM FOR ME TO STOP WITHOUT THIS SYSTEM HAVING TO LOCK THE BRAKES UP ON ME

Additional Notes:

BENDIX WINGMAN COLLISION MITIGATION SYSTEM, THIS SYSTEM AS AM TRYING TO BRAKE THE VEHICLE DETERMINED THAT THE VEHICLE IN FRONT WAS CLOSER THAN IT REALLY WAS AND LOCKED THE BRAKES AND STEERING, AT SUCH TIME THE DRIVER LOOSES CONTROL OF THE VEHICLE COMPLETELY, THIS WAS THE FOURTH TIME IT DID THIS, THE THIRD TIME IT LOCKED THE BRAKES I WAS TRYING TO BRAKE WHILE A CAR WAS DRIVING OUT OF A DRIVEWAY, SECOND TIME I WAS TRYING TO PASS A CAR AND IT DETECTED THE CAR TO CLOSE AND LOCKED THE BRAKES, FIRST TIME BUMPER TO BUMPER IT WAS RAINING, ON A HIGHWAY A VEHICLE CUT IN FRONT OF ME TRIED TO APPLY THE BRAKES AND THE SYSTEM LOCKED UP THE BRAKES AND STEERING, THERE WAS PLENTY OF ROOM FOR ME TO STOP WITHOUT THIS SYSTEM HAVING TO LOCK THE BRAKES UP ON ME

Manufacturer: PETERBILT
Mfg Campaign: 11202730
Notice Date: Apr 21, 2019
Recall Date: Apr 21, 2019
Paccar Incorporated
Campaign: 11202730 Other
Apr 21, 2019
Defect Description:

STEERING

Potential Consequences:

BENDIX WINGMAN COLLISION MITIGATION SYSTEM, THIS SYSTEM AS AM TRYING TO BRAKE THE VEHICLE DETERMINED THAT THE VEHICLE IN FRONT WAS CLOSER THAN IT REALLY WAS AND LOCKED THE BRAKES AND STEERING, AT SUCH TIME THE DRIVER LOOSES CONTROL OF THE VEHICLE COMPLETELY, THIS WAS THE FOURTH TIME IT DID THIS, THE THIRD TIME IT LOCKED THE BRAKES I WAS TRYING TO BRAKE WHILE A CAR WAS DRIVING OUT OF A DRIVEWAY, SECOND TIME I WAS TRYING TO PASS A CAR AND IT DETECTED THE CAR TO CLOSE AND LOCKED THE BRAKES, FIRST TIME BUMPER TO BUMPER IT WAS RAINING, ON A HIGHWAY A VEHICLE CUT IN FRONT OF ME TRIED TO APPLY THE BRAKES AND THE SYSTEM LOCKED UP THE BRAKES AND STEERING, THERE WAS PLENTY OF ROOM FOR ME TO STOP WITHOUT THIS SYSTEM HAVING TO LOCK THE BRAKES UP ON ME

Corrective Action:

BENDIX WINGMAN COLLISION MITIGATION SYSTEM, THIS SYSTEM AS AM TRYING TO BRAKE THE VEHICLE DETERMINED THAT THE VEHICLE IN FRONT WAS CLOSER THAN IT REALLY WAS AND LOCKED THE BRAKES AND STEERING, AT SUCH TIME THE DRIVER LOOSES CONTROL OF THE VEHICLE COMPLETELY, THIS WAS THE FOURTH TIME IT DID THIS, THE THIRD TIME IT LOCKED THE BRAKES I WAS TRYING TO BRAKE WHILE A CAR WAS DRIVING OUT OF A DRIVEWAY, SECOND TIME I WAS TRYING TO PASS A CAR AND IT DETECTED THE CAR TO CLOSE AND LOCKED THE BRAKES, FIRST TIME BUMPER TO BUMPER IT WAS RAINING, ON A HIGHWAY A VEHICLE CUT IN FRONT OF ME TRIED TO APPLY THE BRAKES AND THE SYSTEM LOCKED UP THE BRAKES AND STEERING, THERE WAS PLENTY OF ROOM FOR ME TO STOP WITHOUT THIS SYSTEM HAVING TO LOCK THE BRAKES UP ON ME

Additional Notes:

BENDIX WINGMAN COLLISION MITIGATION SYSTEM, THIS SYSTEM AS AM TRYING TO BRAKE THE VEHICLE DETERMINED THAT THE VEHICLE IN FRONT WAS CLOSER THAN IT REALLY WAS AND LOCKED THE BRAKES AND STEERING, AT SUCH TIME THE DRIVER LOOSES CONTROL OF THE VEHICLE COMPLETELY, THIS WAS THE FOURTH TIME IT DID THIS, THE THIRD TIME IT LOCKED THE BRAKES I WAS TRYING TO BRAKE WHILE A CAR WAS DRIVING OUT OF A DRIVEWAY, SECOND TIME I WAS TRYING TO PASS A CAR AND IT DETECTED THE CAR TO CLOSE AND LOCKED THE BRAKES, FIRST TIME BUMPER TO BUMPER IT WAS RAINING, ON A HIGHWAY A VEHICLE CUT IN FRONT OF ME TRIED TO APPLY THE BRAKES AND THE SYSTEM LOCKED UP THE BRAKES AND STEERING, THERE WAS PLENTY OF ROOM FOR ME TO STOP WITHOUT THIS SYSTEM HAVING TO LOCK THE BRAKES UP ON ME

Manufacturer: PETERBILT
Mfg Campaign: 11202730
Notice Date: Apr 21, 2019
Recall Date: Apr 21, 2019
Paccar Incorporated
Campaign: 11184671 Other
Mar 6, 2019
Defect Description:

ELECTRICAL SYSTEM

Potential Consequences:

THE MAIN ELECTRICAL HARNESS COMING OUT OF THE MAIN COMPUTER AND RUNNING THE ENTIRE SPAN UNDERNEATH THE CAB HAD LITTLE TO NO PROTECTIVE SHEATHING/CORD WRAP/ALUMINUM WRAP PROTECTING THE WIRES. THE HARNESS IS ROUTED THROUGH A U-BOLT TYPE FLANGE AS WELL AS HANGS NEAR SEVERAL METAL PARTS THAT, WHILE IN MOTION, RUB AGAINST THE WIRES CAUSING THEM TO FRAY. THIS IN TURN CAUSED SEVERAL ITEMS TO BEGIN TO SHORT OUT AND ALSO CAUSED NUMEROUS WIRES TO HEAT UP AND MELT. IT WAS DISCOVERED WHEN THE DRIVERS SIDE HEADLIGHT FAILED AND THE SAME SIDE RUNNING LIGHTS CAME ON AND STAYED ON. THIS ALSO CAUSED THE WASHER FLUID PUMP TO TURN ON AND RUN CONSTANTLY, HEATING IT TO THE POINT OF SCALDING TO THE TOUCH. NOT HAVING ANY TYPE OF PROTECTIVE WRAP AROUND THE HARNESS COULD CAUSE FRAYING AND A POTENTIAL FIRE AS WELL AS SEVERAL MODULES TO FAIL AS IT DID IN THIS CASE. *DT CONSUMER STATED PETERBILT WARRANTY(1 YEAR/100,000 MILES) WAS NOT COVERED UNDER WARRANTY.*JB

Corrective Action:

THE MAIN ELECTRICAL HARNESS COMING OUT OF THE MAIN COMPUTER AND RUNNING THE ENTIRE SPAN UNDERNEATH THE CAB HAD LITTLE TO NO PROTECTIVE SHEATHING/CORD WRAP/ALUMINUM WRAP PROTECTING THE WIRES. THE HARNESS IS ROUTED THROUGH A U-BOLT TYPE FLANGE AS WELL AS HANGS NEAR SEVERAL METAL PARTS THAT, WHILE IN MOTION, RUB AGAINST THE WIRES CAUSING THEM TO FRAY. THIS IN TURN CAUSED SEVERAL ITEMS TO BEGIN TO SHORT OUT AND ALSO CAUSED NUMEROUS WIRES TO HEAT UP AND MELT. IT WAS DISCOVERED WHEN THE DRIVERS SIDE HEADLIGHT FAILED AND THE SAME SIDE RUNNING LIGHTS CAME ON AND STAYED ON. THIS ALSO CAUSED THE WASHER FLUID PUMP TO TURN ON AND RUN CONSTANTLY, HEATING IT TO THE POINT OF SCALDING TO THE TOUCH. NOT HAVING ANY TYPE OF PROTECTIVE WRAP AROUND THE HARNESS COULD CAUSE FRAYING AND A POTENTIAL FIRE AS WELL AS SEVERAL MODULES TO FAIL AS IT DID IN THIS CASE. *DT CONSUMER STATED PETERBILT WARRANTY(1 YEAR/100,000 MILES) WAS NOT COVERED UNDER WARRANTY.*JB

Additional Notes:

THE MAIN ELECTRICAL HARNESS COMING OUT OF THE MAIN COMPUTER AND RUNNING THE ENTIRE SPAN UNDERNEATH THE CAB HAD LITTLE TO NO PROTECTIVE SHEATHING/CORD WRAP/ALUMINUM WRAP PROTECTING THE WIRES. THE HARNESS IS ROUTED THROUGH A U-BOLT TYPE FLANGE AS WELL AS HANGS NEAR SEVERAL METAL PARTS THAT, WHILE IN MOTION, RUB AGAINST THE WIRES CAUSING THEM TO FRAY. THIS IN TURN CAUSED SEVERAL ITEMS TO BEGIN TO SHORT OUT AND ALSO CAUSED NUMEROUS WIRES TO HEAT UP AND MELT. IT WAS DISCOVERED WHEN THE DRIVERS SIDE HEADLIGHT FAILED AND THE SAME SIDE RUNNING LIGHTS CAME ON AND STAYED ON. THIS ALSO CAUSED THE WASHER FLUID PUMP TO TURN ON AND RUN CONSTANTLY, HEATING IT TO THE POINT OF SCALDING TO THE TOUCH. NOT HAVING ANY TYPE OF PROTECTIVE WRAP AROUND THE HARNESS COULD CAUSE FRAYING AND A POTENTIAL FIRE AS WELL AS SEVERAL MODULES TO FAIL AS IT DID IN THIS CASE. *DT CONSUMER STATED PETERBILT WARRANTY(1 YEAR/100,000 MILES) WAS NOT COVERED UNDER WARRANTY.*JB

Manufacturer: PETERBILT
Mfg Campaign: 11184671
Notice Date: Mar 6, 2019
Recall Date: Mar 6, 2019

Need Legal Help?

Featured Attorneys
Barry Edzant

Edzant Price LLC

Valencia, CA • 36 yrs

Focus: Lemon Law, Personal Injury

Recent Articles
Jeep Grand Cherokee Head Restraint Problem

Chrysler (FCA US, LLC) has announced a safety issue affecting certain 2023–2024 Jeep Grand Ch ...

Aug 1, 2025
Fuel Injector Problem: 2021-2024 Ford Bronco Sport and 2020-2022 Ford Escape

If you own a 2021-2024 Ford Bronco Sport or 2020-2022 Ford Escape equipped with a 1.5L Dragon GTDI e ...

Jul 28, 2025
Airbag Problem Affects 2022-2025 Chrysler Pacifica and Voyager Vehicles

If you own a Chrysler Pacifica or Voyager, your vehicle may be equipped with defective side curtain ...

Jul 24, 2025