Complaints & Recalls
Official Safety Recalls - Important!
29 RecallsThese are official manufacturer recalls ordered by NHTSA for safety defects. If you own this vehicle, contact your dealer immediately for free repairs.
Paccar Incorporated
Safety Issue:
PACCAR Incorporated (PACCAR) is recalling certain 2021-2025 Peterbilt and Kenworth vehicles, equipped with Bendix EC80 Advanced Electronic Control Units (ECU). Please see the recall report for a complete list of models. Electrical noise and low signal to the power line carrier may cause the ECU to incorrectly process commands or stop functioning.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153) or go to nhtsa.gov.
Mfg Campaign: 24KWL, 24PBL
Recall Date: Dec 9, 2024
Paccar Incorporated
Safety Issue:
PACCAR Incorporated (PACCAR) is recalling certain 2021-2024 Peterbilt 365, 367, 389, 535, 536, 537, 548, 567, 579, and 2021-2025 Kenworth T180, T280, T380, T480, T680, T880 and W990 trucks. The right-hand gear shifter stalk connectors may have been improperly crimped, resulting in a loss of communication.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Mfg Campaign: 24PBE/24KWE
Paccar Incorporated
Safety Issue:
PACCAR Incorporated (PACCAR) is recalling certain 2009-2021 Kenworth C500, 2014-2015 Kenworth T440, 2009-2015 Kenworth T660, 2015-2024 Kenworth T680, 2009-2024 Kenworth T800, 2013-2023 Kenworth T880, 2016 Kenworth T470, and 2009-2019 Kenworth W900 vehicles. The air tanks have an insufficient volume of air for the brake system. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 121, "Air Brake Systems."
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Mfg Campaign: 24KWD
Recall Date: Feb 23, 2024
Paccar Incorporated
Safety Issue:
PACCAR Incorporated (PACCAR) is recalling certain 2016-2022 Peterbilt 567, 579, 2021-2022 Peterbilt 536, 2017-2021 Kenworth T880, 2016-2022 Kenworth T680, 2018-2020 Kenworth T440, 2020 Kenworth T270, and 2021 Kenworth T280 vehicles. The methane detection system will not function if the system loses power.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Mfg Campaign: 21KWH and 21PBN
Recall Date: Dec 29, 2021
Paccar Incorporated
Safety Issue:
PACCAR Incorporated (PACCAR) is recalling certain 2019-2022 Kenworth T880, W990, Peterbilt 567, 579, 389, and 2022 Peterbilt 536, 537 wrecker and auto hauler vehicles. The work brake (winch brake) may unintentionally disengage the service brakes during winching operations, causing the vehicle to roll.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Mfg Campaign: 21KWG and 21PBM
Recall Date: Nov 19, 2021
Paccar Incorporated
Safety Issue:
PACCAR Incorporated (PACCAR) is recalling certain 2018-2021 Peterbilt 337, 348, 365, 367, 520, 567, Kenworth T270, T370, T440, T470, T800 and T880 vehicles. The sealing washer may not seat correctly in the pilot bore holes, allowing the high pressure fuel rail assembly to leak.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Mfg Campaign: 21KWC, 21PBD
Recall Date: May 26, 2021
Paccar Incorporated
Safety Issue:
PACCAR Incorporated (PACCAR) is recalling certain 2021-2022 Kenworth T680, T880, W990, T800, W900 and Peterbilt 579, 567, 389, 367 vehicles equipped with a Cummins X15 engine. The capscrews that attach the flywheel to the crankshaft may have been improperly torqued, allowing the flywheel to detach.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Mfg Campaign: 21KWA / 21PBB
Recall Date: Feb 17, 2021
Paccar Incorporated
Safety Issue:
PACCAR Incorporated (PACCAR) is recalling certain 2020-2021 Peterbilt 348, 365, 367, 389, 520, 567 and Kenworth T800, T880, W900, W990 vehicles equipped with Watson and Chalin steerable lift axle suspension systems (model SL2065). The axles may have lower rear pivot bolts that are not long enough to sufficiently engage the locking feature of the corresponding nuts.
Potential Risk:
FREE Recall Solution:
Additional Details:
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Mfg Campaign: 20PBE and 20KWC
Recall Date: Aug 26, 2020
Consumer Complaints
1 ComplaintPaccar Incorporated
Defect Description:
SERVICE BRAKES
Potential Consequences:
TRACTOR ABS SYSTEM APPLIES THE BRAKES TO THE TRAILERS WHILE CORNERING CAUSING THE VEHICLE TO BECOME UNCONTROLLABLE. THIS USUALLY OCCURS WHILE ENTERING OR EXITING A HIGHWAY AT SPEEDS ABOVE 30 MPH. THE ABS SYSTEM LOCKS UP THE BRAKES UNTIL THE TRACTOR AND TRAILERS COME TO A COMPLETE STOP. THESE TRUCKS AND TRAILERS WEIGH APPROXIMATELY 155,000 LBS., AND LOSING CONTROL IS A SAFETY HAZARD FOR ANYONE ON THE ROAD. THESE TRUCKS ARE 2021 MODELS WITH BENDIX ABS SYSTEMS. THIS ISSUE HAS BEEN BROUGHT TO THE ATTENTION OF KENWORTH (THE VEHICLE MANUFACTURE) AND BENDIX (THE ABS SYSTEM MANUFACTURE). LITTLE HAS BEEN DONE TO RECTIFY THIS SAFETY ISSUE. THIS HAS BEEN HAPPENING SENSE THE TRACTORS WERE PUT INTO SERVICE APPROXIMATELY 8 MONTHS AGO. THERE IS NO WARNING BEFORE THE ABS SYSTEM LOCKS UP THE TRAILER BRAKES, AND THERE IS NOTHING THE DRIVER CAN DO TO CONTROL THE TRUCK WHILE THE BRAKES ARE LOCKED UP.
Corrective Action:
TRACTOR ABS SYSTEM APPLIES THE BRAKES TO THE TRAILERS WHILE CORNERING CAUSING THE VEHICLE TO BECOME UNCONTROLLABLE. THIS USUALLY OCCURS WHILE ENTERING OR EXITING A HIGHWAY AT SPEEDS ABOVE 30 MPH. THE ABS SYSTEM LOCKS UP THE BRAKES UNTIL THE TRACTOR AND TRAILERS COME TO A COMPLETE STOP. THESE TRUCKS AND TRAILERS WEIGH APPROXIMATELY 155,000 LBS., AND LOSING CONTROL IS A SAFETY HAZARD FOR ANYONE ON THE ROAD. THESE TRUCKS ARE 2021 MODELS WITH BENDIX ABS SYSTEMS. THIS ISSUE HAS BEEN BROUGHT TO THE ATTENTION OF KENWORTH (THE VEHICLE MANUFACTURE) AND BENDIX (THE ABS SYSTEM MANUFACTURE). LITTLE HAS BEEN DONE TO RECTIFY THIS SAFETY ISSUE. THIS HAS BEEN HAPPENING SENSE THE TRACTORS WERE PUT INTO SERVICE APPROXIMATELY 8 MONTHS AGO. THERE IS NO WARNING BEFORE THE ABS SYSTEM LOCKS UP THE TRAILER BRAKES, AND THERE IS NOTHING THE DRIVER CAN DO TO CONTROL THE TRUCK WHILE THE BRAKES ARE LOCKED UP.
Additional Notes:
TRACTOR ABS SYSTEM APPLIES THE BRAKES TO THE TRAILERS WHILE CORNERING CAUSING THE VEHICLE TO BECOME UNCONTROLLABLE. THIS USUALLY OCCURS WHILE ENTERING OR EXITING A HIGHWAY AT SPEEDS ABOVE 30 MPH. THE ABS SYSTEM LOCKS UP THE BRAKES UNTIL THE TRACTOR AND TRAILERS COME TO A COMPLETE STOP. THESE TRUCKS AND TRAILERS WEIGH APPROXIMATELY 155,000 LBS., AND LOSING CONTROL IS A SAFETY HAZARD FOR ANYONE ON THE ROAD. THESE TRUCKS ARE 2021 MODELS WITH BENDIX ABS SYSTEMS. THIS ISSUE HAS BEEN BROUGHT TO THE ATTENTION OF KENWORTH (THE VEHICLE MANUFACTURE) AND BENDIX (THE ABS SYSTEM MANUFACTURE). LITTLE HAS BEEN DONE TO RECTIFY THIS SAFETY ISSUE. THIS HAS BEEN HAPPENING SENSE THE TRACTORS WERE PUT INTO SERVICE APPROXIMATELY 8 MONTHS AGO. THERE IS NO WARNING BEFORE THE ABS SYSTEM LOCKS UP THE TRAILER BRAKES, AND THERE IS NOTHING THE DRIVER CAN DO TO CONTROL THE TRUCK WHILE THE BRAKES ARE LOCKED UP.
Mfg Campaign: 11388343
Recall Date: Jan 15, 2021
Need Legal Help?
Featured Attorneys
Barry Edzant
Edzant Price LLC
Valencia, CA • 36 yrs
Focus: Lemon Law, Personal Injury
Recent Articles
Jeep Grand Cherokee Head Restraint Problem
Chrysler (FCA US, LLC) has announced a safety issue affecting certain 2023–2024 Jeep Grand Ch ...
Aug 1, 2025Fuel Injector Problem: 2021-2024 Ford Bronco Sport and 2020-2022 Ford Escape
If you own a 2021-2024 Ford Bronco Sport or 2020-2022 Ford Escape equipped with a 1.5L Dragon GTDI e ...
Jul 28, 2025Airbag Problem Affects 2022-2025 Chrysler Pacifica and Voyager Vehicles
If you own a Chrysler Pacifica or Voyager, your vehicle may be equipped with defective side curtain ...
Jul 24, 2025