KAWASAKI ZX400 2023

Complete listing of complaints and recalls for this vehicle

3
Complaints
1
Recalls

Complaints & Recalls

3 Complaints 1 Recalls

Official Safety Recalls - Important!

1 Recall

These are official manufacturer recalls ordered by NHTSA for safety defects. If you own this vehicle, contact your dealer immediately for free repairs.

Kawasaki Motors Corp., U.s.a.
NHTSA Campaign: 23V515000 SAFETY RECALL
991 Vehicles Affected
Recall Date: Jul 26, 2023
Safety Issue:

Kawasaki Motors Corp., U.S.A. (KMC) is recalling certain 2023 ZX400SPFNL motorcycles. The alternator may fail due to a loose connection between the rotor and crank shaft, causing an engine stall.

Potential Risk:
An engine stall can increase the risk of a crash.
FREE Recall Solution:
Dealers will inspect and tighten the rotor bolt, as necessary, free of charge. Owner notification letters were mailed August 14, 2023. Owners may contact KMC customer service at 1-866-802-9381.
Additional Details:

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov. Please be reminded of the following requirements:You are required to submit a draft owner notification letter to this office no less than five days prior to mailing it to the customers.Also, copies of all notices, bulletins, dealer notifications, and other communications that relate to this recall, including a copy of the final owner notification letter and any subsequent owner follow-up notification letter(s), are required to be submitted to this office no later than 5 days after they are originally sent (if they are sent to more than one manufacturer, distributor, dealer, or purchaser/owner).Please be reminded that under 49 U.S.C. 30112(a)(3), it is illegal for a manufacturer, to sell, offer for sale, import, or introduce or deliver into interstate commerce, a motor vehicle or item of motor vehicle equipment that contains a safety defect once the manufacturer has notified NHTSA about that safety defect.This prohibition does not apply once the motor vehicle or motor vehicle equipment has been remedied according to the manufacturer's instructions.As stated in 49 U.S.C. 30118(f), submission of eight consecutive quarterly reports followed by three annual reports is required. As described in 573.7, submission of the first of eight consecutive quarterly status reports is required within one month after the close of the calendar quarter in which notification to purchasers occurs. Therefore, the first quarterly report will be due on, or before, 30 days after the close of the calendar quarter. The first of three consecutive annual status reports will be due on, or before, 1 year after the eighth quarterly report was submitted.

Action Required: Contact your local KAWASAKI dealer to schedule your FREE recall repair.
Manufacturer: KAWASAKI
Notice Date: Aug 14, 2023
Recall Date: Jul 26, 2023

Consumer Complaints

3 Complaints
Kawasaki Motors Corp., U.s.a.
Campaign: 11602735 Other
Jul 16, 2024
Defect Description:

ENGINE

Potential Consequences:

The contact owned a 2023 Kawasaki ZX400. The contact stated that while driving at an undisclosed speed, cylinder three started shuddering and misfiring. As a result, flames were noticed coming from the front area, near the engine compartment, causing the vehicle to be burned down. No one was injured during the fire. A race track fire crew arrived and extinguished the fire. A police and fire report was not filed. The vehicle was towed to a local dealer, where it remains, and the cause of the fire has not been determined yet. The manufacturer was notified of the failure. The failure mileage was approximately 5,000. 

Corrective Action:

The contact owned a 2023 Kawasaki ZX400. The contact stated that while driving at an undisclosed speed, cylinder three started shuddering and misfiring. As a result, flames were noticed coming from the front area, near the engine compartment, causing the vehicle to be burned down. No one was injured during the fire. A race track fire crew arrived and extinguished the fire. A police and fire report was not filed. The vehicle was towed to a local dealer, where it remains, and the cause of the fire has not been determined yet. The manufacturer was notified of the failure. The failure mileage was approximately 5,000. 

Additional Notes:

The contact owned a 2023 Kawasaki ZX400. The contact stated that while driving at an undisclosed speed, cylinder three started shuddering and misfiring. As a result, flames were noticed coming from the front area, near the engine compartment, causing the vehicle to be burned down. No one was injured during the fire. A race track fire crew arrived and extinguished the fire. A police and fire report was not filed. The vehicle was towed to a local dealer, where it remains, and the cause of the fire has not been determined yet. The manufacturer was notified of the failure. The failure mileage was approximately 5,000. 

Manufacturer: KAWASAKI
Mfg Campaign: 11602735
Notice Date: Jul 16, 2024
Recall Date: Jul 16, 2024
Kawasaki Motors Corp., U.s.a.
Campaign: 11602758 Other
Jul 16, 2024
Defect Description:

POWER TRAIN

Potential Consequences:

The contact owns a 2023 Kawasaki ZX400 Motorcycle. The contact state while riding approximately 65 MPH and in 6th gear, the motorcycle lost motive power. In addition, while downshifting into the lower gears, the motorcycle had reduced power until 4th gear. The engine seized and the contact grabbed the clutch to slow down and pull over. The contact stated the front of the crankcase had a hole. No warning light was illuminated. The motorcycle was towed to a local dealer where it was diagnosed but the result was not available. The manufacturer was made aware of the failure. The failure mileage was approximately 64,000.

Corrective Action:

The contact owns a 2023 Kawasaki ZX400 Motorcycle. The contact state while riding approximately 65 MPH and in 6th gear, the motorcycle lost motive power. In addition, while downshifting into the lower gears, the motorcycle had reduced power until 4th gear. The engine seized and the contact grabbed the clutch to slow down and pull over. The contact stated the front of the crankcase had a hole. No warning light was illuminated. The motorcycle was towed to a local dealer where it was diagnosed but the result was not available. The manufacturer was made aware of the failure. The failure mileage was approximately 64,000.

Additional Notes:

The contact owns a 2023 Kawasaki ZX400 Motorcycle. The contact state while riding approximately 65 MPH and in 6th gear, the motorcycle lost motive power. In addition, while downshifting into the lower gears, the motorcycle had reduced power until 4th gear. The engine seized and the contact grabbed the clutch to slow down and pull over. The contact stated the front of the crankcase had a hole. No warning light was illuminated. The motorcycle was towed to a local dealer where it was diagnosed but the result was not available. The manufacturer was made aware of the failure. The failure mileage was approximately 64,000.

Manufacturer: KAWASAKI
Mfg Campaign: 11602758
Notice Date: Jul 16, 2024
Recall Date: Jul 16, 2024
Kawasaki Motors Corp., U.s.a.
Campaign: 11536689 Other
1 Vehicles Affected
Aug 5, 2023
Defect Description:

ELECTRICAL SYSTEM

Potential Consequences:

I was leaving a stop light in road mode. I took off smoothly with no rapid acceleration. I was in second gear and was going roughly 20 mph, when suddenly the bike stalled and the rpms immediately dropped. I was jerked forward but stood on the bike. However, it caused me to drop it on my right side, causing the right side fairings, exhaust pipe, even frame and bar ends to be scratched. I did get injured with a fractured hand. Luckily there was no traffic around and no others were in danger. There was no warning lamps on the dash at the time, and it hasn't happened so far. I have not got the bike checked yet, but definitely plan on it after hearing of the recall.

Corrective Action:

I was leaving a stop light in road mode. I took off smoothly with no rapid acceleration. I was in second gear and was going roughly 20 mph, when suddenly the bike stalled and the rpms immediately dropped. I was jerked forward but stood on the bike. However, it caused me to drop it on my right side, causing the right side fairings, exhaust pipe, even frame and bar ends to be scratched. I did get injured with a fractured hand. Luckily there was no traffic around and no others were in danger. There was no warning lamps on the dash at the time, and it hasn't happened so far. I have not got the bike checked yet, but definitely plan on it after hearing of the recall.

Additional Notes:

I was leaving a stop light in road mode. I took off smoothly with no rapid acceleration. I was in second gear and was going roughly 20 mph, when suddenly the bike stalled and the rpms immediately dropped. I was jerked forward but stood on the bike. However, it caused me to drop it on my right side, causing the right side fairings, exhaust pipe, even frame and bar ends to be scratched. I did get injured with a fractured hand. Luckily there was no traffic around and no others were in danger. There was no warning lamps on the dash at the time, and it hasn't happened so far. I have not got the bike checked yet, but definitely plan on it after hearing of the recall.

Manufacturer: KAWASAKI
Mfg Campaign: 11536689
Notice Date: Aug 5, 2023
Recall Date: Aug 5, 2023

Need Legal Help?

Featured Attorneys
Barry Edzant

Edzant Price LLC

Valencia, CA • 36 yrs

Focus: Lemon Law, Personal Injury

Recent Articles
Jeep Grand Cherokee Head Restraint Problem

Chrysler (FCA US, LLC) has announced a safety issue affecting certain 2023–2024 Jeep Grand Ch ...

Aug 1, 2025
Fuel Injector Problem: 2021-2024 Ford Bronco Sport and 2020-2022 Ford Escape

If you own a 2021-2024 Ford Bronco Sport or 2020-2022 Ford Escape equipped with a 1.5L Dragon GTDI e ...

Jul 28, 2025
Airbag Problem Affects 2022-2025 Chrysler Pacifica and Voyager Vehicles

If you own a Chrysler Pacifica or Voyager, your vehicle may be equipped with defective side curtain ...

Jul 24, 2025