GRAND DESIGN MOMENTUM 2025

Complete listing of complaints and recalls for this vehicle

1
Complaints
9
Recalls

Complaints & Recalls

1 Complaints 9 Recalls

Official Safety Recalls - Important!

9 Recalls

These are official manufacturer recalls ordered by NHTSA for safety defects. If you own this vehicle, contact your dealer immediately for free repairs.

Grand Design Rv, Llc
NHTSA Campaign: 25V281000 SAFETY RECALL
121 Vehicles Affected
Recall Date: Apr 30, 2025
Safety Issue:

Grand Design RV, LLC (Grand Design) is recalling certain 2024-2025 Momentum 320G, 325G, 344M, 250G, 351MS, 381MS, 392M, 395MS, 397THS, 398M, 399TH, 410TH, 414M, and 415G toy haulers, equipped with a removable step assembly. The clip-on bracket mounting bolts may come loose, allowing the steps to detach.

Potential Risk:
Steps that detach while in use increase the risk of injury.
FREE Recall Solution:
Dealers will inspect the clip-on bracket and make repairs as necessary, free of charge. Owner notification letters were mailed May 15, 2025. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910050.
Additional Details:

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1- 888-275-9171), or go to www.safercar.gov.

Action Required: Contact your local GRAND DESIGN dealer to schedule your FREE recall repair.
Manufacturer: GRAND DESIGN
Mfg Campaign: 910050
Notice Date: May 15, 2025
Recall Date: Apr 30, 2025
Grand Design Rv, Llc
NHTSA Campaign: 24V916000 SAFETY RECALL
508 Vehicles Affected
Recall Date: Dec 10, 2024
Safety Issue:

Grand Design RV, LLC (Grand Design) is recalling certain 2023-2025 Momentum fifth wheel trailers. The interior step base does not adequately support the step tread.

Potential Risk:
The tread may detach from the step, increasing the risk of a trip and fall injury.
FREE Recall Solution:
Dealers will replace the step riser and step treads, free of charge. Owner notification letters were mailed January 16, 2025. Owners may contact Grand Design customer service at 1-574-825-9679. Grand Design's number for this recall is 910047.
Additional Details:

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153) or go to nhtsa.gov.

Action Required: Contact your local GRAND DESIGN dealer to schedule your FREE recall repair.
Manufacturer: GRAND DESIGN
Mfg Campaign: 910047
Notice Date: Jan 16, 2025
Recall Date: Dec 10, 2024

Consumer Complaints

1 Complaint
Grand Design Rv, Llc
Campaign: 11671014 Other
Jul 3, 2025
Defect Description:

SERVICE BRAKES

Potential Consequences:

Sudden loss of trailer brakes nearly caused me to rear end vehicle in front of me. The more concerning part is when I went to an RV dealer to disgnose, they pulled the break away emergency brake to test if brakes applied. They did not apply, however about 1 minute after the breakway was pulled the switch began to melt, then almost immediately there was smoke coming from inside the battery compartment and a fire was started by the power wires melting due to a short. The fire then damaged a hydralic line and hydralic fluid was leaking right next to the flame. Luckily we had a fire extinguisher handy and quickly disconnected the battery. Grand Design had an investigator come on site to survey the damage and interview the dealer and myself. I was told that pulling the breakaway cable will cause the wires to overheat and could start a fire. I might agree if it was left for a long period of time, but not in 1 munute. If this would have been an actual emergency situation where the traler disconnected while driving, the brakes would not have applied and I am sure would have burned completely as it would have taken more time to get access to the fire location. Being told that this is expected behavior makes me very nervous to continue to use this trailier as I beleive it could happen again. A letter was sent to Grand Design and I have yet to get a response and having difficulty getting them to approve the repair and send parts

Corrective Action:

Sudden loss of trailer brakes nearly caused me to rear end vehicle in front of me. The more concerning part is when I went to an RV dealer to disgnose, they pulled the break away emergency brake to test if brakes applied. They did not apply, however about 1 minute after the breakway was pulled the switch began to melt, then almost immediately there was smoke coming from inside the battery compartment and a fire was started by the power wires melting due to a short. The fire then damaged a hydralic line and hydralic fluid was leaking right next to the flame. Luckily we had a fire extinguisher handy and quickly disconnected the battery. Grand Design had an investigator come on site to survey the damage and interview the dealer and myself. I was told that pulling the breakaway cable will cause the wires to overheat and could start a fire. I might agree if it was left for a long period of time, but not in 1 munute. If this would have been an actual emergency situation where the traler disconnected while driving, the brakes would not have applied and I am sure would have burned completely as it would have taken more time to get access to the fire location. Being told that this is expected behavior makes me very nervous to continue to use this trailier as I beleive it could happen again. A letter was sent to Grand Design and I have yet to get a response and having difficulty getting them to approve the repair and send parts

Additional Notes:

Sudden loss of trailer brakes nearly caused me to rear end vehicle in front of me. The more concerning part is when I went to an RV dealer to disgnose, they pulled the break away emergency brake to test if brakes applied. They did not apply, however about 1 minute after the breakway was pulled the switch began to melt, then almost immediately there was smoke coming from inside the battery compartment and a fire was started by the power wires melting due to a short. The fire then damaged a hydralic line and hydralic fluid was leaking right next to the flame. Luckily we had a fire extinguisher handy and quickly disconnected the battery. Grand Design had an investigator come on site to survey the damage and interview the dealer and myself. I was told that pulling the breakaway cable will cause the wires to overheat and could start a fire. I might agree if it was left for a long period of time, but not in 1 munute. If this would have been an actual emergency situation where the traler disconnected while driving, the brakes would not have applied and I am sure would have burned completely as it would have taken more time to get access to the fire location. Being told that this is expected behavior makes me very nervous to continue to use this trailier as I beleive it could happen again. A letter was sent to Grand Design and I have yet to get a response and having difficulty getting them to approve the repair and send parts

Manufacturer: GRAND DESIGN
Mfg Campaign: 11671014
Notice Date: Jul 3, 2025
Recall Date: Jul 3, 2025

Need Legal Help?

Featured Attorneys
Barry Edzant

Edzant Price LLC

Valencia, CA • 36 yrs

Focus: Lemon Law, Personal Injury

Recent Articles
Jeep Grand Cherokee Head Restraint Problem

Chrysler (FCA US, LLC) has announced a safety issue affecting certain 2023–2024 Jeep Grand Ch ...

Aug 1, 2025
Fuel Injector Problem: 2021-2024 Ford Bronco Sport and 2020-2022 Ford Escape

If you own a 2021-2024 Ford Bronco Sport or 2020-2022 Ford Escape equipped with a 1.5L Dragon GTDI e ...

Jul 28, 2025
Airbag Problem Affects 2022-2025 Chrysler Pacifica and Voyager Vehicles

If you own a Chrysler Pacifica or Voyager, your vehicle may be equipped with defective side curtain ...

Jul 24, 2025