bmw r1200 cl 2004 Complaints

STRUCTURE:FRAME AND MEMBERS

dt: 2004 bmw r1200cl motorcycle, the frame is bending because of the weight pressure on the side stand, metal of frame of vehicle is too weak, causing the frame to bend and twist, consumer took the vehicle to the dealer to be repaired, and dealer replaced the frame, the problem recurred. the dealer was replacing the second frame. vehicle was still under warranty, the service technicians informed the consumer that there was a possibility that the frame metal could have been tempered incorrectly, the heavy weight of the vehicle caused the consumer to have muscle strain, this did not cause permanent injury or a visit to the doctor. consumer noticed that there were many other consumers with the same complaint online concerning the vehicle. *ak

Reported in: NORFOLK VA || Crash: N || VIN #: WB10496A34Z

OTHER

while riding consumers bike caught fire.*ts while riding in a parking lot flame started coming from the left side of the bike. the consumer had to drop the bike and extinguish the fire. it was determined that the oil level glass had melted, drained the oil which caused the fire. *nm

Reported in: SILVER SPRING MD || Crash: Y || VIN #: WB10496AX4Z

FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS

high pressure fuel connector broke. at 75 mph the bmw quickly disconnected, broke, and the 45 psi of fuel sprayed all over the right side of the motorcycle, my leg and the exhaust. it was this bmw part # 13317659119 that broke. *ak possible fire, burns, death.

Reported in: GRAND JUNCTION CO || Crash: N || VIN #: WB10319A04Z

FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS

tl*the contact owns a 2004 bmw r1200 cl motorcycle. while driving approximately 55 mph, the contact smelled a strong odor of gasoline coming from the vehicle. upon further inspection, he noticed gasoline leaking from the vehicle because the fuel line quick-disconnect couplings fractured. the manufacturer would not assist because the vehicle was excluded from nhtsa campaign id number 04v028000 (fuel system, gasoline:delivery:hoses, lines/piping, and fittings). the vehicle has not been repaired. the failure and current mileages were 8,000.

Reported in: GREENVILLE SC || Crash: N || VIN #: WB10496A14Z

FUEL SYSTEM, GASOLINE

the quick connect fuel line coupling on my 2004 bmw r1200clc motorcycle broke spilling gasoline on the exhuast, catalytic converter and rear disc brake while riding on the expressway in good weather. the bike stopped running, leaving me to negotiate a 825 lb. motorcycle to the side of the road with no power and a gasoline soaked rear disc brake. 40 years of cycling experience saved me from what was a dire and life threatening situation. there was a factory recall to replace the o-rings on this coupling, which i did. when i contacted the dealer from which i purchased the motorcycle new about this problem, they informed me that bmw had replaced this plastic part with a metal part in their replacement parts inventory. this part retails for $31.50 and is only for sale. it is also only half of the coupling, the other half still only avilable in plastic. there are two of these couplings in the fuel system. in my discussions with the dealer, i was told this is a common problem in all 2004 bmws, with this essential part failing often. i repaired the fuel line with a brass fuel line fitting. bmw is aware of this problem evidenced by the change in the material that this part now only available in. why has there been no recall on this potentially fatal defect issued by bmw? i still have the failed part. i have also experienced engine failure on this same vehicle when a short in the wiring harness to the fuel pump blows the fuse and the fuel pump stops. this was also described to me as an inherent problem in this motorcycle due to the wiring insulation deteriorating and cracking. this information was passed on to me by the dealer service rep who said he had seen that defect often. this problem has also left me riding a suddenly dead motoccyle several times in heavy traffic. when i contacted bmw about fixing the wiring harness, they were unresponsive to my complaint and dismissive to me personally. i have the e-mails. this motorcycle has 13,859 miles on it and is garage kept.

Reported in: SPICEWOOD TX || Crash: N || VIN #: WB10496A14Z

FUEL SYSTEM, GASOLINE

tl* the contact owns a 2004 bmw r1200 cl motorcycle. the contact stated that there was a defect in the quick connect fuel line, causing the fuel to leak from from the line. the manufacturer was contacted and requested that the contact take the vehicle to an authorized dealer for repair. the vehicle was not repaired. the failure and current mileage was 17,000. the vin was unavailable.

Reported in: ALTONA IL || Crash: N || VIN #:

FUEL SYSTEM, GASOLINE

tl* the contact owns a 2004 bmw r1200 cl motorcycle. the contact stated while driving fuel began to leak onto the exhaust pipe and the contact noticed there was smoke. the dealer diagnosed that the vehicle had the same symptoms as the nhtsa campaign id number: 04v028000 (fuel system, gasoline:delivery:hoses, lines/piping, and fittings) recall, but the vin was not associated. the manufacturer was notified and assisted the contact with the defect. the vehicle was repaired. the failure and current mileage was 11,784.

Reported in: WINSER CA || Crash: N || VIN #: WB10379A24Z

FUEL SYSTEM, GASOLINE

tl* the contact owns a 2004 bmw r1200 cl. the contact stated that he noticed an abnormal substance on the ground near the motorcycle. upon further inspection of the bike, he discovered that the fuel connector was fractured. the motorcycle was not taken to the dealer for inspection and was not repaired. the manufacturer was notified and stated that the vehicle was not included in any recall. the failure mileage was 4,200. the dealer informed the consumer there were numerous complaints because of the original quick disconnectors made of plastic. the consumer discovered a recall had been issued for the same problem he experienced. however, his vehicle identification number was not included. updated 02/06/13 updated 11/04/13

Reported in: APACHEJUNCTION AZ || Crash: N || VIN #: WB10319A24Z

FUEL/PROPULSION SYSTEM

my bike was sputtering & backfiring, i brought it into the local bmw dealer who diagnosed the problem as "throttle body system" he told me it was "this happens all the time of this year and model bike, even with the low mileage" i had just purchased the bike, if i had know about this common failure i would have not bought it. they want $1800 to repair it.

Reported in: TRINITY FL || Crash: N || VIN #: WB10496AXA4

ENGINE

my bike was sputtering & backfiring, i brought it into the local bmw dealer who diagnosed the problem as "throttle body system" he told me it was "this happens all the time of this year and model bike, even with the low mileage" i had just purchased the bike, if i had know about this common failure i would have not bought it. they want $1800 to repair it.

Reported in: TRINITY FL || Crash: N || VIN #: WB10496AXA4